IllustrationSteering has become increasingly stiff and harder to turn, as if the power steering doesn't work. My granddaughter hit a curb in a tight turning entrance to a 4 lane highway and broke the wheel and other component parts.
2009 Chevrolet Malibu
Owner reports · Recalls · Investigations
More warning signs than most Malibu years
Owner complaints for the 2009 Chevrolet Malibu are substantially higher than the model-year median of 310.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Malibu years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
870–25K
9825–50K
19350–75K
21775–100K
373100–150K
232150K+
1,200 reports with mileage · 309 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 768 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 368 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electronic Stability Control (esc). Review the 255 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
41 crash reports9 fire reports31 injury reports
Suspension complaints
11 reportsWHEN GOING OVER ANY BUMP OR TURNING THE FRONT END SHAKES AND MAKES A CLACKING NOISE. ESC IS OFF. TRACTION CONTROL IS ALWAYS OFF. ERROR CODES READ P0010 P0449 P0013 P0722 P0011
WHILE DRIVING DOWN THE HIGHWAY THERE WAS A SUDDEN LOSS OF ELECTRIC POWER STEERING. JUST AS DESCRIBED IN BULLETIN 114116, MAKING IT HARD FOR ME TO TURN THE STEERING WHEEL WHICH CAUSED THE CAR TO SHAKE TERRIBLY.
POWER STEERING WORKS RANDOMLY BUT MOSTLY NOT AT ALL. POWER STEERING, SERVICE TRACTION CONTROL LIGHT. ABS LIGHT AND ESC FLASH ON DASH DISPLAY ALL IN ONE WEEK. DRIVING TO WORK MADE A LEFT HAND TURN AND POWER STEERING WENT OUT CAUSING ME TO DRIVE OFF THE ROAD. POWER STEERING CAME BACK ON AND THEN OUT AGAIN. AND HAS BEEN OFF SINCE
CAR BEGAN TO MAKE A RANDOM CLUNK WHEN TURNING. TOOK THE VEHICLE TO THE DEALER AS SOON AS THEY WERE OPEN. ALIGNMENT BEGAN TO PULL. FRONT END STARTED TO HUM. DEALER SERVICE MANAGER SAID WHEEL BEARINGS FAILING IN FRONT END. STRUT ASSEMBLIES IN FRONT NEED REPLACEMENT, KNUCKLES THAT HOLD THE STRUT ASSEMBLIES TO THE FRAME WERE ORIGINA…
Read full complaint
CAR BEGAN TO MAKE A RANDOM CLUNK WHEN TURNING. TOOK THE VEHICLE TO THE DEALER AS SOON AS THEY WERE OPEN. ALIGNMENT BEGAN TO PULL. FRONT END STARTED TO HUM. DEALER SERVICE MANAGER SAID WHEEL BEARINGS FAILING IN FRONT END. STRUT ASSEMBLIES IN FRONT NEED REPLACEMENT, KNUCKLES THAT HOLD THE STRUT ASSEMBLIES TO THE FRAME WERE ORIGINAL, MADE OUT OF ALUMINUM, AND ARE NOW ROTTED OUT AND REQUIRE REPLACEMENT. INTERMEDIATE STEERING COLUMN FAILING. THE VEHICLE HASN'T REACHED 90K MILES YET. THE COST OF REPAIRING THE VEHICLE IS NEARING HALF OF ITS RETAIL VALUE. ALLEGEDLY NO OPEN RECALLS, DESPITE A RECALL BY DORMAN FOR THE INTERMEDIATE STEERING SHAFT. ALUMINUM KNUCKLES TO HOLD STRUTS TO THE FRAME? AND THAT'S NOT A DESIGN FLAW? THE REPLACEMENT KNUCKLE PARTS ARE $1200 NOT INCLUDING LABOR. WHEEL BEARINGS ARE ABOUT $762, THE INTERMEDIATE STEERING SHAFT IS $290. STRUT ASSEMBLIES ARE ABOUT $600 FOR BOTH.
PURCHASED THIS VEHICLE BRAND NEW FROM DEALER IN JUNE OF 2009. 1ST TIME I HEARD CLUNKING NOISE FROM FRONT SUSPENSION ONLY WHEN THE TEMPS DROP BELOW 50 DEGREES. ONCE CAR WARMED UP, THE NOISE WOULD GO AWAY. SOUNDED LIKE A BROKEN STABILIZER LINK. RETURNED CAR TO DEALER AND HAD TO LEAVE OVERNIGHT SO THEY CAN HEAR THE NOISE, ONLY PROB…
Read full complaint
PURCHASED THIS VEHICLE BRAND NEW FROM DEALER IN JUNE OF 2009. 1ST TIME I HEARD CLUNKING NOISE FROM FRONT SUSPENSION ONLY WHEN THE TEMPS DROP BELOW 50 DEGREES. ONCE CAR WARMED UP, THE NOISE WOULD GO AWAY. SOUNDED LIKE A BROKEN STABILIZER LINK. RETURNED CAR TO DEALER AND HAD TO LEAVE OVERNIGHT SO THEY CAN HEAR THE NOISE, ONLY PROBLEM WAS THAT THE DEALER COULD HEAR THE NOISE WHEN COLD, BUT SOUND NOISE WOULD BE GONE BY THE TIME THEY GOT THE CAR ON THE LIFT. ONCE THE SOUND WAS GONE THEY HAD NO CLUE AS TO WHERE THE NOISE STARTED FROM. RETURNED TO THE DEALER ROUGHLY 7 TIMES OVER 3 YEAR PERIOD, NOW THE WARRANTY IS OVER. DEALER DID REPLACE LINKS, STRUTS, STEERING RACK, STEERING INTERMEDIATE SHAFT AND A SLEW OF OTHER PARTS WHICH I HAVE DOCUMENTED. NOW I HAVE THE CAR FOR 5 YEARS AND YES THE NOISE IS STILL THERE EACH WINTER MORNING BELOW 50 DEGREES. ONCE THE WARMER WEATHER ARRIVES, IT NEVER MAKES A SOUND. MY UNDERSTANDING IS THAT A LOT OF GM CARS ALL HAVE THE SAME "CLUNKING" SOUND IN FRONT SUSPENSION. ONLY THING I CAN THINK OF IS THAT THE DEALER PARTS ARE ALL DEFECTIVE AND MAYBE AN AFTERMARKET PART MAY BE UPGRADED TO HELP ELIMINATE THE NOISE. AS FOR NOW, I JUST LIVE WITH IT AS I FEEL NO WOBBLY EFFECTS OR UNSAFE CONDITION. *TR
ODOR FROM LEAKING COOLING SYSTEM. CAR PULLS TO LEFT. DRIVER DOES SEAT NOT ADJUST WITH THE CONTROL. FRONT TIRES ARE WORN DOWN CORDS SHOWING. BOUGHT CAR AT OURISMAN CHEV. CAR DEALER (34,523 MILES) WITH PLATINUM COVERAGE. CAR CURRENT (49,512 MILES). THEY INSISTED THAT I SHOULD PAY FOR NEW TIRES$295. TRANSMISSION FLUSH $249.00. FU…
Read full complaint
ODOR FROM LEAKING COOLING SYSTEM. CAR PULLS TO LEFT. DRIVER DOES SEAT NOT ADJUST WITH THE CONTROL. FRONT TIRES ARE WORN DOWN CORDS SHOWING. BOUGHT CAR AT OURISMAN CHEV. CAR DEALER (34,523 MILES) WITH PLATINUM COVERAGE. CAR CURRENT (49,512 MILES). THEY INSISTED THAT I SHOULD PAY FOR NEW TIRES$295. TRANSMISSION FLUSH $249.00. FUEL INDUCTION SERVICE $179. COOLANT HOSE$10. THAT MY PLAN ONLY COVER SURGE TANK WHICH I HAVE TO PAY $100.00 DEDUCTIBLE. I BROUGHT THE CAR 5/17/12. READING THROUGH COMPLAINTS 2009 MALIBU HAVE SIMILAR CAR PROBLEM. I DON'T HAVE THE FUNDS FOR ALL THESE PROBLEM FOR A CAR THAT OWN FOR THIS SHORT PERIOD OF TIME. *TR
AT 15,237 MILES THE RIGHT FRONT HUB BEARING WAS REPLACED. MFG PART # 20907865 AT 24,079 MILES THE LEFT FRONT HUB BEARING WAS REPLACED. MFG PART # 20907865 AT 24,079 MILES THE RIGHT FRONT HUB BEARING WILL HAVE TO BE REPLACED. MFG PART # 20907865 THIS 2009 CHEV. MALIBU HAS NEVER BEEN IN SALT OR ANY OTHER CORROSIVES EX…
Read full complaint
AT 15,237 MILES THE RIGHT FRONT HUB BEARING WAS REPLACED. MFG PART # 20907865 AT 24,079 MILES THE LEFT FRONT HUB BEARING WAS REPLACED. MFG PART # 20907865 AT 24,079 MILES THE RIGHT FRONT HUB BEARING WILL HAVE TO BE REPLACED. MFG PART # 20907865 THIS 2009 CHEV. MALIBU HAS NEVER BEEN IN SALT OR ANY OTHER CORROSIVES EXCEPT WHAT IS IN THE NORMAL DRIVING ENVIRONMENT. THIS CAR HAS THE V- 6 ENGINE. I HAVE OWNED SINCE NEW. *TR
THE EVENT LEADING UP TO : TURNING RIGHT FROM SIDE STREET THE CAR LUNGES INTO THE LEFT LANE WHEN ACCELERATING . THE FAILURE OCCURS EVERY TIME WHEN THE CAR TAKES OFF FROM A STOP TO ENTER INTO FREEWAY. STEERING WHEEL ROTATES WITH FAST ACTION CLOCK WISE 360 DEGREES.WHAT WAS DONE TOOK CAR TO 4 DEALERS ALL SAID IT MEETS THE SPECIFICAT…
Read full complaint
THE EVENT LEADING UP TO : TURNING RIGHT FROM SIDE STREET THE CAR LUNGES INTO THE LEFT LANE WHEN ACCELERATING . THE FAILURE OCCURS EVERY TIME WHEN THE CAR TAKES OFF FROM A STOP TO ENTER INTO FREEWAY. STEERING WHEEL ROTATES WITH FAST ACTION CLOCK WISE 360 DEGREES.WHAT WAS DONE TOOK CAR TO 4 DEALERS ALL SAID IT MEETS THE SPECIFICATIONS OF THE CAR. CAR DEALER SAID IT WAS A GLITCH CORPORATE SAID THERE WAS NOTHING THEY CAN DO. UPDATED 10/05/10 *BF THE CONSUMER STATED THE VEHICLE PULL TO THE RIGHT. UPDATED 10/07/10 *TR
STEERING SUSPENSION, 29NOV09 REPLACED RIGHT SWAY BAR LINK. 25JAN20 REPLACED SWAY BAR BUSHINGS AT THE FRAME. 10MAR10 REPLACED SWAY BAR INSULATORS AT THE FRAME. 04MAY10 REPLACED SWAY BAR LINKS AGAIN ONLY AFTER 6 MONTHS FROM LAST REPLACEMENT. THERE IS OBVIOUSLY A QUALITY ISSUE HERE. *TR
Official recalls
514V252000 · Electrical System:wiring; Electronic Stability Control (esc); Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Vehicle Speed Control:cruise Control
May 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence & remedy
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Additional source detail variants (5)
Electronic Stability Control (esc)
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Vehicle Speed Control:cruise Control
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights:switch
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Electrical System:wiring
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
14V153000 · Steering:electric Power Assist System
Mar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
12V460000 · Power Train:automatic Transmission:gear Position Indication (prndl)
Sep 18, 2012
General Motors (GM) is recalling certain model year 2007-2010 Saturn Aura and model year 2008-2010 Chevrolet Malibu and Pontiac G6 vehicles, equipped with a 4-speed automatic transmission. On these vehicles, the tabs on the transmission shift cable end may fracture and separate.
Consequence & remedy
Consequence: If the tabs were to fracture and separate, the shift lever and the actual position of the transmission gear may not match. The driver would be able to move the shifter to 'PARK' and remove the ignition key, but the transmission gear may not be in 'PARK.' The vehicle may not be able to be restarted and the vehicle could roll away after the driver has exited the vehicle, resulting in a possible crash without prior warning.
Remedy: GM will notify owners, and dealers will install a retainer over the cable end or replace the shift cable as necessary. This service will be performed free of charge. Notification to owners began on on November 9, 2012. Owners were instructed to not bring their vehicles for repair until January 2013. Owners may contact General Motors at 1-800-521-7300.
09V073000 · Power Train:automatic Transmission:lever And Linkage:column Shift
Mar 6, 2009
GENERAL MOTORS IS RECALLING 276,729 MY 2009 BUICK ENCLAVE, CHEVROLET COBALT, HHR, MALIBU, TRAVERSE, GMC ACADIA, PONTIAC G5, G6 AND SATURN AURA AND OUTLOOK PASSENGER VEHICLES. THESE VEHICLES FAIL TO COMPLY WITH FEDERAL MOTOR VEHICLES SAFETY STANDARD 102, "TRANSMISSION SHIFT POSITION SEQUENCE, STARTER INTERLOCK, AND TRANSMISSION BRAKING EFFECT", AND FMVSS 114, "THEFT PROTECTION AND ROLLAWAY PREVENTION". ON SOME OF THESE VEHICLES, THE TRANSMISSION SHIFT CABLE ADJUSTMENT CLIP MAY NOT BE FULLY ENGAGED. IF THE CLIP IS NOT FULLY ENGAGED, THE SHIFT LEVER AND THE ACTUAL POSITION OF THE TRANSMISSION GEAR MAY NOT MATCH. WITH THIS CONDITION, THE DRIVE COULD MOVE THE SHIFTER TO "PARK" AND REMOVE THE IGNITION KEY, BUT THE TRANSMISSION GEAR MAY NOT BE IN "PARK".
Consequence & remedy
Consequence: THE DRIVER MAY NOT BE ABLE TO RESTART THE VEHICLE AND THE VEHICLE COULD ROLL AWAY AFTER THE DRIVER HAS EXITED THE VEHICLE, RESULTING IN A POSSIBLE CRASH WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL INSPECT AND ENSURE THAT THE SHIFT CABLE ADJUSTMENT CLIP IS FULLY ENGAGED. IN THE EVENT THAT THE CLIP DOES NOT ENGAGE, THE SHIFT CABLE WILL BE REPLACED FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE MARCH 24, 2009. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668 AND SATURN AT 1-800-972-8876 OR AT WWW.GMOWNERCENTER.COM.
08V634000 · Visibility:defroster/defogger/hvac System
Dec 2, 2008
GM IS RECALLING 77 MY 2009 CHEVROLET MALIBU HYBRID VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 103, "WINDSHIELD DEFROSTING AND DEFOGGING SYSTEM." THE HEATING, VENTILATION, AND AIRCONDITIONING (HVAC) SYSTEM MAY BECOME INOPERATIVE. IF THIS WERE TO OCCUR, THE BLOWER WOULD NOT FUNCTION PROPERLY AND THE MODE SELECTOR WOULD REMAIN IN THE LAST KNOWN SETTING.
Consequence & remedy
Consequence: IF THE WINDSHIELD BEGAN TO FOG OR FROST, THERE MAY NOT BE ENOUGH AIRFLOW TO CLEAR THE WINDSHIELD, RESULTING IN REDUCED DRIVER VISIBILITY AND A POSSIBLE CRASH WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPROGRAM THE HVAC CONTROL HEAD MODULE. THE RECALL IS EXPECTED TO BEGIN ON DECEMBER 17, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.