Steering. Review the 768 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 368 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electronic Stability Control (esc). Review the 255 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

41 crash reports9 fire reports31 injury reports

Latches/locks/linkages complaints

56 reports

Clear category filter

45,000 miles · Apr 7, 2014

Electrical SystemLatches/locks/linkages

WHILE DRIVING DOOR LOCKS CONTINUALLY GO UP AND DOWN AND WHILE PARKED DOOR LOCKS OPEN AND CLOSE UNTIL WE TOOK FUSE OUT TO STOP. THIS IS A SAFETY HAZARD CAN'T OPEN DOOR WHILE ITS DOING THIS AND CAN'T LOCK DOORS, BECAUSE THEY START GOING UP AND DOWN AGAIN, AFRAID WILL DRAIN BATTERY OR CAUSE AN ACCIDENT BECAUSE OF THIS DISTRACTION. …

Read full complaint

NHTSA ODI #10578126

40,000 miles · Apr 7, 2014

Latches/locks/linkages

TL* THE CONTACT OWNS A 2009 CHEVROLET MALIBU. THE CONTACT STATED THE REAR PASSENGER AND REAR DRIVERS SIDE DOOR DO NOT LOCK OR UNLOCK PROPERLY. SPORADICALLY THE DOORS WOULD NOT RESPOND WHEN THE CONTACTS VEHICLE WAS IN THE PARK POSITION. THE DEALER WAS NOT MADE AWARE OF THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE A…

Read full complaint

NHTSA ODI #10577977

27,610 miles · Mar 26, 2014

Electrical SystemLatches/locks/linkages

Read full complaint

REAR RIGHT DOOR (REAR PASSENGER) LOCK FAILING TO OPEN. STARTED TO RANDOMLY OPEN AND NOW IT'S TOTALLY DEAD. IF THE DOOR FAILS TO OPEN GETTING MY KID OUT OF THE CAR IN AN EMERGENCY CAN BE IMPOSSIBLE EVEN FOR OTHER PASSENGERS SITTING ON THE BACK. THIS NEEDS AN URGENT INVESTIGATION. A LOT OF OWNERS HAVE THE SAME ISSUE AND SURPRISED TO SEE A LOT OF COMPLAINTS HERE AS WELL REGARDING THE LOCKS/ACTUATORS. GM IS AWARE OF THE ISSUE ABOUT ACTUATORS FAILING CONSISTENTLY TOO, IN SOME OCCASIONS THEY HAVE MADE THE REPLACEMENTS FREE OF CHARGE OR AT A DISCOUNTED PRICE. *TR

NHTSA ODI #10574929

35,000 miles · Mar 21, 2014

Electrical SystemLatches/locks/linkages

Read full complaint

TO THE NHTSA PERSON REVIEWING THIS: PLEASE ASSIST ON THIS ISSUE, WE DEPEND ON YOU ESCALATING THIS ISSUE. THE PROBLEM CONTAINED HERE IS A MAJOR SAFETY ISSUE POTENTIALLY CATASTROPHIC CONDITION WAITING TO HAPPEN. WE (OWNERS OF CHEVY MALIBUS OF YEARS 2008-09, AND 10') NEED AN INVESTIGATION TO BE INITIATED. SUMMARY OF PROBLEM: THE CHEVROLET MALIBU 2008,2009, AND 2010 HAS A MANUFACTURING PROBLEM WITH THE DOOR LOCK ACTUATORS (WHICH OPEN AND CLOSE THE LOCKS ON THE DOORS). FOR THE MALIBU YEAR 2009, AT APPROXIMATELY 35K MILE MARK ALL POWER LOCKS OF ALL FOUR DOORS RANDOMLY OPEN AND LOCK AT ANY VEHICLE FORWARD SPEED AT RANDOM TIMES. AN UNPRECEDENTED AMOUNT OF LACK OF SAFETY CONCERNS HAVE BEEN BROUGHT UP FROM COUNTLESS CUSTOMERS THROUGH DIFFERENT WEBSITES AND ARE BEGINNING TO COME IN A MORE FORMAL MANNER SUCH AS THIS PUBLIC TOOL. SAFETY FLAW: SINCE THE OPENING AN CLOSING OF THE LOCKS ON DOORS IS OF RANDOM MANNER AND OF RAPID FREQUENCY (OPENS AND CLOSES VERY FAST) IT POSES ALL OCCUPANTS TO REMAIN INSIDE THE VEHICLE UNABLE TO ESCAPE IN THE EVENT OF A FIRE, VEHICLE CRASH, OR ANY OTHER EMERGENCY. LIKEWISE, WHEN THE INTENT IS TO HAVE THE DOORS LOCKED IT POSES THE ISSUE THAT THE DOOR LOCKS WILL BECOME OPEN AT UNEXPECTED TIMES. SOLUTION: AVOID CASUALTIES, INCIDENTS, AND KEEP THE SAFETY OF OUR LOVED ONES IN MIND. WE NEED THE NHTSA TO LAUNCH AN INVESTIGATION ON THIS ISSUE. *TR

NHTSA ODI #10574050

57,000 miles · Mar 16, 2014

Latches/locks/linkagesStructure

Read full complaint

THE DRIVER'S SIDE DOOR LATCH FAILED TO OPEN. NEITHER THE INSIDE NOR OUTSIDE HANDLES WORKED. THERE WAS NO ACCIDENT, ABUSE OR INDICATION OF IMMINENT FAILURE. IT WAS EXTREMELY DIFFICULT TO EXIT THE VEHICLE; MY DAUGHTER NEEDED TO CRAWL ACROSS THE CONSOLE. WOULD BE EVEN MORE DIFFICULT (PERHAPS IMPOSSIBLE) IN AN EMERGENCY SITUATION. I SEARCHED THE CHEVROLET OWNER FORUMS ON THE INTERNET AND FOUND MANY PEOPLE WITH THE SAME PROBLEM GOING BACK YEARS. DEALER SERVICE PERSONNEL KNEW OF THE PROBLEM; OFFERED TO WAIVE USUAL $108 DIAGNOSTIC FEE FOR REPAIR. CHEVROLET CUSTOMER ASSISTANCE AGREED TO PAY $37 TOWARDS NECESSARY CORRECTION IF I PAID THE FIRST $200. *TR

NHTSA ODI #10572653

82,000 miles · Feb 25, 2014

Electrical SystemLatches/locks/linkages

Read full complaint

LEFT REAR DOOR LOCK ACTUATOR FAILED TO OPERATE. THIS IS THE 3RD REAR DOOR LOCK ACTUATOR TO FAIL ON THIS CAR. ORIGINAL OWNER, REPLACED 2 LOCKS UNDER WARRANTY, NOW A 3RD ACTUATOR FAILURE. THIS DOOR IS THE PRIMARY DOOR USED FOR ENTRY/EGRESS BY CHILDREN. THIS IS A SERIOUS SAFETY CONCERN DUE EITHER THE INABILITY TO SAFELY REMOVE A CHILD IN AN EMERGENCY, OR LEAVE THE DOOR UNLOCKED WHILE DRIVING. THERE ARE MANY, MANY COMPLAINTS OF THE SAME PROBLEM ON THIS VEHICLE NATION WIDE OVER THE LAST 5 YEARS. PLEASE INITIATE AN INVESTIGATION INTO THIS SAFETY ISSUE. *TR

NHTSA ODI #10565829

72,000 miles · Oct 30, 2013

Electrical SystemLatches/locks/linkages

Read full complaint

THE MALIBU MY WIFE AND I OWN HAVE HAD PROBLEM WITH THE LEFT PASSENGER DOOR LOCK NOT BEING ACTUATED WHEN COMMANDED. FOR EXAMPLE, WHEN THE DOOR WAS COMMANDED TO LOCK, IT WOULD STAY UNLOCKED. BUT MORE SERIOUSLY, IT WOULD STAY LOCKED WHEN COMMANDED TO UNLOCK. I TOOK IT TO NEUVILLE MOTORS IN WAUPACA, WI, A GM/CHEVY DEALER, TO HAVE IT FIXED. ACCORDING TO A SERVICE MANAGER AT THE DEALERSHIP, DOOR LOCK ACTUATOR MALFUNCTIONS IN MALIBUS FROM THAT MODEL YEAR IS COMMON AND HE SEES MANY OF THEM COME IN WITH EXACT SAME PROBLEM AS MY CAR'S. I BELIEVE A DOOR STAYING LOCKED WHEN COMMANDED TO OPEN IS A SERIOUS SAFETY HAZARD IF A RAPID EVACUATION OUT OF THE VEHICLE BECOMES NECESSARY. ALSO, IF THE VEHICLE ROLLS ON THE SIDE OF THE OPPOSITE SIDE OF MALFUNCTIONING DOOR, EVACUATING PASSENGERS OCCUPYING REAR SEATS CAN BE A CHALLENGE AS THE ONLY DOOR AVAILABLE MAY STAY LOCKED WHEN COMMANDED TO UNLOCK. I HAVE CONTACTED GM, BUT THEY INSISTED THAT THEY ARE NOT RESPONSIBLE AS THE VEHICLE IS OUT OF WARRANTY AND A RECALL WAS NOT ISSUED BY YOUR ADMINISTRATION. THE REFERENCE NUMBER OF MY COMPLAINT WITH GM IS [XXX]. I BELIEVE THIS IS A SERIOUS SAFETY ISSUE IF CHILDREN/ELDERLY/PETS ARE OCCUPYING THE REAR SEAT, OR THE PASSENGER IN THE BACK SEAT BECOMES UNCONSCIOUS IN CASE OF A CRASH. PLEASE CONSIDER ISSUING A RECALL IF THE PROBLEM IS A COMMON ONE. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ODI #10550275

51,000 miles · Jul 16, 2013

Latches/locks/linkages

IN THESE CHEVROLET MALIBUS, WHEN THE CAR IS PUT INTO DRIVE THE DOORS LOCK AUTOMATICALLY, WHEN PLACED INTO PARK THE DOORS UNLOCK. WITHOUT WARNING THE DOOR LOCK ACTUATORS QUIT WORKING AND LEAVE YOUR CAR EITHER LOCKED OR UNLOCKED. IN CASE OF EMERGENCY YOU WILL BE SCRAMBLING TO UNLOCK THE DOOR MANUALLY. *TR

NHTSA ODI #10525162

50,000 miles · Jul 10, 2013

Latches/locks/linkagesStructure

THE DOOR LOCK ACTUATOR ON BOTH REAR DOORS FAIL TO UNLOCK THE DOOR. APPARENTLY THIS IS VERY COMMON IN 2008 AND 2009 MALIBU'S. CONSIDERING THAT MY CHILDREN (AS I AM SURE MANY OTHERS), IT IS UNSAFE TO HAVE VEHICLES DOORS UNLOCK FROM THE OUTSIDE. FURTHER, GIVEN THE PLACEMENT OF THE PHYSICAL NOBS (IN THE FAR REAR) IT IS IMPRACTICA…

Read full complaint

NHTSA ODI #10524197

78,000 miles · Jul 3, 2013

Latches/locks/linkages

Read full complaint

I HAVE A CHEVY MALIBU 2009 LAST YEAR ONE BACK PASSENGER DOOR STARTED NOT LOCKING OR UNLOCKING, LATER AFTER THAT ANOTHER ONE AND NOW NONE OF THE DOORS LOCK/UNLOCK AUTOMATICALLY. I DID A SEARCH THIS ONLINE AND IT LOOKS LIKE THEY ARE THOUSANDS OF COMPLAINS OF THIS SAME ISSUE. I CONTACTED THE CHEVY SERVICE DEPARTMENT AND THEY STATED THAT THIS IS NOT SOMETHING THAT IS COVER UNDER WARRANTY NOR THEY HAVE THE RESPONSIBILITY OF REPAIRING IT BECAUSE IS NOT A HAZARDOUS OR A SAFETY ISSUE. FOR ME I BELIEVE THAT IS A SAFETY ISSUE. THE CAR IS SUPPOSE TO AUTOMATICALLY LOCK THE DOORS WHEN YOU MOVE INTO DRIVE AND UNLOCK WHEN IS MOVED BACK TO PARK, ALSO IF A CAR IS EQUIP WITH A SECURITY SYSTEM AND I PRESS THE LOCK BUTTON ALL DOORS SHOULD LOCK. CHEVY SERVICE DEPARTMENT CHARGERS $300.00 PER ACTUATOR PLUS THE COST OF LABOR THIS IS A HEAVY PRICE TO PAY, I UNDERSTAND IF ONE GOES BAD BUT HAVING ALL 4 DOORS GO BAD WITHIN MONTHS OF EACH OTHER FOR ME THIS IS A MANUFACTURE DEFECT. *TR

NHTSA ODI #10523042

Official recalls

14V252000 · Electrical System:wiring; Electronic Stability Control (esc); Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Vehicle Speed Control:cruise Control

May 14, 2014

General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.

Consequence & remedy

Consequence: Any of the above failure conditions increases the risk of a crash.

Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.

Additional source detail variants (5)

Electronic Stability Control (esc)

Consequence: Any of the above failure conditions increases the risk of a crash.

Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.

Vehicle Speed Control:cruise Control

Consequence: Any of the above failure conditions increases the risk of a crash.

Exterior Lighting:brake Lights:switch

Consequence: Any of the above failure conditions increases the risk of a crash.

Exterior Lighting:brake Lights

Consequence: Any of the above failure conditions increases the risk of a crash.

Electrical System:wiring

Consequence: Any of the above failure conditions increases the risk of a crash.

14V153000 · Steering:electric Power Assist System

Mar 31, 2014

General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.

Consequence & remedy

Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.

Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.

12V460000 · Power Train:automatic Transmission:gear Position Indication (prndl)

Sep 18, 2012

General Motors (GM) is recalling certain model year 2007-2010 Saturn Aura and model year 2008-2010 Chevrolet Malibu and Pontiac G6 vehicles, equipped with a 4-speed automatic transmission. On these vehicles, the tabs on the transmission shift cable end may fracture and separate.

Consequence & remedy

Consequence: If the tabs were to fracture and separate, the shift lever and the actual position of the transmission gear may not match. The driver would be able to move the shifter to 'PARK' and remove the ignition key, but the transmission gear may not be in 'PARK.' The vehicle may not be able to be restarted and the vehicle could roll away after the driver has exited the vehicle, resulting in a possible crash without prior warning.

Remedy: GM will notify owners, and dealers will install a retainer over the cable end or replace the shift cable as necessary. This service will be performed free of charge. Notification to owners began on on November 9, 2012. Owners were instructed to not bring their vehicles for repair until January 2013. Owners may contact General Motors at 1-800-521-7300.

09V073000 · Power Train:automatic Transmission:lever And Linkage:column Shift

Mar 6, 2009

GENERAL MOTORS IS RECALLING 276,729 MY 2009 BUICK ENCLAVE, CHEVROLET COBALT, HHR, MALIBU, TRAVERSE, GMC ACADIA, PONTIAC G5, G6 AND SATURN AURA AND OUTLOOK PASSENGER VEHICLES. THESE VEHICLES FAIL TO COMPLY WITH FEDERAL MOTOR VEHICLES SAFETY STANDARD 102, "TRANSMISSION SHIFT POSITION SEQUENCE, STARTER INTERLOCK, AND TRANSMISSION BRAKING EFFECT", AND FMVSS 114, "THEFT PROTECTION AND ROLLAWAY PREVENTION". ON SOME OF THESE VEHICLES, THE TRANSMISSION SHIFT CABLE ADJUSTMENT CLIP MAY NOT BE FULLY ENGAGED. IF THE CLIP IS NOT FULLY ENGAGED, THE SHIFT LEVER AND THE ACTUAL POSITION OF THE TRANSMISSION GEAR MAY NOT MATCH. WITH THIS CONDITION, THE DRIVE COULD MOVE THE SHIFTER TO "PARK" AND REMOVE THE IGNITION KEY, BUT THE TRANSMISSION GEAR MAY NOT BE IN "PARK".

Consequence & remedy

Consequence: THE DRIVER MAY NOT BE ABLE TO RESTART THE VEHICLE AND THE VEHICLE COULD ROLL AWAY AFTER THE DRIVER HAS EXITED THE VEHICLE, RESULTING IN A POSSIBLE CRASH WITHOUT PRIOR WARNING.

Remedy: DEALERS WILL INSPECT AND ENSURE THAT THE SHIFT CABLE ADJUSTMENT CLIP IS FULLY ENGAGED. IN THE EVENT THAT THE CLIP DOES NOT ENGAGE, THE SHIFT CABLE WILL BE REPLACED FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE MARCH 24, 2009. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668 AND SATURN AT 1-800-972-8876 OR AT WWW.GMOWNERCENTER.COM.

08V634000 · Visibility:defroster/defogger/hvac System

Dec 2, 2008

GM IS RECALLING 77 MY 2009 CHEVROLET MALIBU HYBRID VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 103, "WINDSHIELD DEFROSTING AND DEFOGGING SYSTEM." THE HEATING, VENTILATION, AND AIRCONDITIONING (HVAC) SYSTEM MAY BECOME INOPERATIVE. IF THIS WERE TO OCCUR, THE BLOWER WOULD NOT FUNCTION PROPERLY AND THE MODE SELECTOR WOULD REMAIN IN THE LAST KNOWN SETTING.

Consequence & remedy

Consequence: IF THE WINDSHIELD BEGAN TO FOG OR FROST, THERE MAY NOT BE ENOUGH AIRFLOW TO CLEAR THE WINDSHIELD, RESULTING IN REDUCED DRIVER VISIBILITY AND A POSSIBLE CRASH WITHOUT PRIOR WARNING.

Remedy: DEALERS WILL REPROGRAM THE HVAC CONTROL HEAD MODULE. THE RECALL IS EXPECTED TO BEGIN ON DECEMBER 17, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

AQ10001 · Fleet Vehicle Recall Completion Audit

Opened Nov 18, 2010 · Closed Dec 28, 2015

Status: closed (inferred from source dates) · Unknown Or Other

On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.