TL* THE CONTACT OWNS A 2002 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE FUEL SYSTEM, TRANSMISSION, COOLING SYSTEM AND POWER STEERING NEEDED TO BE FLUSHED. THE SPARK PLUGS, FU…
Read full complaint
TL* THE CONTACT OWNS A 2002 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE FUEL SYSTEM, TRANSMISSION, COOLING SYSTEM AND POWER STEERING NEEDED TO BE FLUSHED. THE SPARK PLUGS, FUEL FILTERS, AND HUB KIT WERE REPLACED. HOWEVER, THE FAILURE PERSISTED. THE VEHICLE WAS RETURNED TO THE INDEPENDENT MECHANIC WHO REPLACED THE IGNITION SWITCH. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000. UPDATED 01/06/15
I WALKED OUT THE DOOR READY TO GO TO WORK GOT IN THE CAR TURNED THE KEY IT WOULD NOT START. SO FIRST I HAD TO WAKE SOMEONE UP WITH A PHONE CALL BECAUSE THIS IS OUR ONLY CAR. GOT A RIDE TO WORK LATE AND CALLED THE PLACE WHERE I AM BUYING THIS CAR FOR THEM TO TOW IT TWO MILES TO THERE SHOP AND CHARGE ME SEVENTY EIGHT DOLLARS. I GE…
Read full complaint
I WALKED OUT THE DOOR READY TO GO TO WORK GOT IN THE CAR TURNED THE KEY IT WOULD NOT START. SO FIRST I HAD TO WAKE SOMEONE UP WITH A PHONE CALL BECAUSE THIS IS OUR ONLY CAR. GOT A RIDE TO WORK LATE AND CALLED THE PLACE WHERE I AM BUYING THIS CAR FOR THEM TO TOW IT TWO MILES TO THERE SHOP AND CHARGE ME SEVENTY EIGHT DOLLARS. I GET THE CALL FROM THEM SAYING ITS THE FUEL PUMP(ANOTHER COMMON UNNECESSARY FIX THAT YOU HERE REPEAT OVER AND OVER. HE ALSO SAID THE ANTITHEFT LIGHT WAS ON AND THAT I SOMEHOW DEMAGNITIZED THE KEY(WASN'T POSSIBLE BECAUSE I WAS GIVEN A ALL SILVER KEY NO CHIP IN IT) SO THAT COST ALMOST A EXTRA HUNDRED FOR THE KEY.SO AFTER IM RIDING ALMOST FINE TORQUE COULD BE MORE V6ISH BUT I DIGRESS TUESDAY SEP 4 2012 NOT A MONTH LATER IT DOESN'T START AGAIN, AND AGAIN ON MY WAY TO WORK. THIS TIME I HAD IT TOWED AND BY THE TIME IT MADE IT TO THE MECHANIC ITS WAS STARTING FINE. I DON'T MAKE ENOUGH MONEY TO CONTINUOUSLY WORRY ABOUT THIS OBVIOUS WIDESPREAD PROBLEM WITH GM VEHICLES MADE FROM 99-05. IF WHOEVER READS THIS TYPES IN MY CAR WONT START 2002 CHEVY MALIBU, AND JUST READ THE DIFFERENT PEOPLES STORY'S AND SEE VIDEOS. IN CONCLUSION GM MUST RECALL THESE VEHICLES AND FIX THESE PROBLEMS. IM A LONG TIME GM SUPPORTER OF THERE AMERICAN MADE CARS AND TRUCKS. I'VE OWNED A 1989 CADILLAC BIARITZ, 1999 CHEVY SURBURBAN,AND NOW THIS 2002 CHEVEY MALIBU.IVE BEEN LUCKY I READ ABOUT A GUY WHOSE ANTITHEFT ACTED UP WHILE HE WAS DRIVING WITH HIS CHILD. RECALL AND SAVE LIVES AND HEADACHES. *TR
NHTSA ODI #10474322
Mileage unknown · Jun 1, 2004
Power Train
WHILE DECREASING THE SPEED VEHICLE STALLED. CONSUMER TRIED TO START THE VEHICLE NUMEROUS TIME BUT WAS UNABLE TO DO SO. VEHICLE WAS TOWED TO THE DEALER FOR INSPECTION, AND MECHANIC WAS UNABLE TO DUPLICATE THE PROBLEM. *AK
NHTSA ODI #10075513
Mileage unknown · Jun 11, 2003
Power TrainVehicle Speed Control
WHILE TRAVELING RPMS WOULD IDLE HIGH, RESULTING IN VEHICLE NOT TO GAINING SPEED OR CHANGING INTO PASSING GEAR. VEHICLE HAS BEEN SERVICED SIX TIMES FOR PROBLEM. *AK
NHTSA ODI #10022841
Mileage unknown · Mar 5, 2003
Engine And Engine CoolingEquipmentFuel System, Gasoline
AT 15,000 MILES I HAD A PISTON KNOCK DEVELOP. PISTONS WERE REPLACED AND WAS TOLD THIS WAS A COMMON PROBLEM WITH THIS ENGINE. GAS CAP SEAL BAD AT SAME TIME. DECK LID NOT PROPERLY ADJUSTED AT TIME OF PURCHASE. AT 25,000 THE REAR LEFT SPEAKER WAS REPLACED DUE NOT WORKING AND THE TORQUE CLUTCH CONVERTER WAS COMING APART AND STUCK…
Read full complaint
AT 15,000 MILES I HAD A PISTON KNOCK DEVELOP. PISTONS WERE REPLACED AND WAS TOLD THIS WAS A COMMON PROBLEM WITH THIS ENGINE. GAS CAP SEAL BAD AT SAME TIME. DECK LID NOT PROPERLY ADJUSTED AT TIME OF PURCHASE. AT 25,000 THE REAR LEFT SPEAKER WAS REPLACED DUE NOT WORKING AND THE TORQUE CLUTCH CONVERTER WAS COMING APART AND STUCK IN THE OFF POSITION. FIRST PROBLEM WAS NOTED IN 2002.*JB
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." SOME OF THESE VEHICLES WERE PRODUCED WITH A LEFT LOW-BEAM HEADLAMP THAT DOES NOT MEET THE PHOTOMETRIC PERFORMANCE REQUIREMENTS OF THE STANDARD.
Consequence & remedy
Consequence: LIGHT INTENSITIES BELOW THE MINIMUM INTENSITY REQUIREMENTS CAUSE REDUCTION IN VISIBILITY DOWN THE ROAD FOR THE DRIVER OF THE VEHICLE AND INTENSITIES ABOVE THE MAXIMUM INTENSITY REQUIREMENTS CAUSE INCREASE IN GLARE FOR DRIVERS AHEAD OF, OR APPROACHING, THE VEHICLE.
Remedy: DEALERS WILL INSPECT THE LEFT LOW-BEAM HEADLAMP AND REPLACE IT IF IT DOES NOT MEET REQUIREMENTS. OWNER NOTIFICATION BEGAN MAY 23, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
IN DECEMBER 2004, GM ISSUED A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327. THE POLICY COVERED TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURRED FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH. GM SENT LETTERS TO OWNERS STARTING DECEMBER 30, 2004.IN JANUARY 2006, GM WILL UPDATE THE SPECIAL POLICY TO INCLUDE MY 2002 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V-327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING LATE APRIL 2006.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
IN DECEMBER 2004, GM ISSUED A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327. THE POLICY COVERED TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURRED FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH. GM SENT LETTERS TO OWNERS STARTING DECEMBER 30, 2004.IN JANUARY 2006, GM WILL UPDATE THE SPECIAL POLICY TO INCLUDE MY 2002 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V-327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING LATE APRIL 2006.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:turn Signal:switch
IN DECEMBER 2004, GM ISSUED A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327. THE POLICY COVERED TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURRED FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH. GM SENT LETTERS TO OWNERS STARTING DECEMBER 30, 2004.IN JANUARY 2006, GM WILL UPDATE THE SPECIAL POLICY TO INCLUDE MY 2002 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V-327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING LATE APRIL 2006.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
2002 Chevrolet Malibu Problems, Complaints & Recalls | Skip That Year
Illustration