IllustrationPASSLOCK SENSOR ACTIVATES FOR NO APPARENT REASON WHILE DRIVING THE VEHICLE AND PREVENTS THE CAR FROM BEING STARTED FOR 10 MINUTES. THIS IS A SAFETY HAZARD AND COULD PUT SOMEONE'S LIFE AT RISK. *TR
2002 Chevrolet Malibu
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2002 Chevrolet Malibu do not stand out strongly from the model-year median of 310.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Malibu years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
380–25K
8225–50K
10250–75K
7175–100K
73100–150K
25150K+
391 reports with mileage · 176 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 259 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 143 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 63 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
18 crash reports1 fire reports13 injury reports
Electrical System complaints
259 reportsCAR REFUSED TO START. LEFT ME STRANDED IN A PARKING LOT IN NASHVILLE AND HAD TO BE TOWED, TWICE. IT TOOK 2 TRIPS TO THE MECHANIC BEFORE THEY REALIZED IT WAS A DEFECT WITH THE ANTI THEFT SYSTEM,. IT LOCKED UP THE IGNITION FOR THIRTY MINUTES. THEY SAID THERE WAS NO FIX FOR THIS PROBLEM EXCEPT TO WAIT UNTIL THE CAR DECIDED TO LET M…
Read full complaint
CAR REFUSED TO START. LEFT ME STRANDED IN A PARKING LOT IN NASHVILLE AND HAD TO BE TOWED, TWICE. IT TOOK 2 TRIPS TO THE MECHANIC BEFORE THEY REALIZED IT WAS A DEFECT WITH THE ANTI THEFT SYSTEM,. IT LOCKED UP THE IGNITION FOR THIRTY MINUTES. THEY SAID THERE WAS NO FIX FOR THIS PROBLEM EXCEPT TO WAIT UNTIL THE CAR DECIDED TO LET ME START IT. *TR
MY 2002 CHEVY MALIBU'S THEFT SYSTEM SPORADICALLY, BUT FREQUENTLY WILL START FLASHING AND MY CAR WON'T START. I HAVE TO TURN THE KEY ON FOR 10 MINUTES AND WAIT FOR THE THEFT LIGHT TO TURN OFF. I TURN THE KEY OFF FOR 5 SECONDS AND THE CAR STARTS. VERY DANGEROUS FOR MY WIFE AND KIDS BEING STRANDED FOR 10 MINUTES - ANYWHERE. *TR
CAR WILL NOT START DO TO ANTI THEFT SYSTEM. YOU MUST WAIT TEN MIN FOR THE LIGHT TO TURN OFF THEN RESTART THE CAR. *TR
VEHICLE PREVENTED FROM STARTING DUE TO DEFECTIVE "THEFT DETERRENT" SYSTEM KNOWN AS PASS LOCK. *TR
1. NORMAL USAGE OF CAR 2. ANTI THEFT SYSTEM ENGAGES ARBITRARILY CAUSING CAR NOT TO START FOR 10 MINUTES UNTIL YOU DO A RESET PROCEDURE. NOTIFIED IT IS A PROBLEM WITH THE IGNITION LOCK CYLINDER. IT SEEMS THIS IS A WIDESPREAD DEFECT AND THE REPAIR IS EXPENSIVE. ALSO, REPORTS SHOW THE NEW PART WILL HAVE THE SAME PROBLEM. IT IS…
Read full complaint
1. NORMAL USAGE OF CAR 2. ANTI THEFT SYSTEM ENGAGES ARBITRARILY CAUSING CAR NOT TO START FOR 10 MINUTES UNTIL YOU DO A RESET PROCEDURE. NOTIFIED IT IS A PROBLEM WITH THE IGNITION LOCK CYLINDER. IT SEEMS THIS IS A WIDESPREAD DEFECT AND THE REPAIR IS EXPENSIVE. ALSO, REPORTS SHOW THE NEW PART WILL HAVE THE SAME PROBLEM. IT IS A FUNDAMENTAL DEFECT. 3. NOTHING, TO EXPENSIVE, SHOULD BE COVERED AS A DEFECT. *TR
2002 CHEVROLET MALIBU 37,000MI. THE VEHICLE ANTI THEFT SYSTEM( PASSLOCK SYSTEM),FAILURE. VEHICLE WON'T START. RECENTLY GOT THE CAR STARTED BUT NOW THE ANTI THEFT SYSTEM LIGHT STAYS ON PERMANENTLY. *TR
TL*THE CONTACT OWNS A 2002 CHEVROLET MALIBU. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. THERE WERE NO WARNING LIGHTS PRESENT, HOWEVER, THE THEFT DETERRENT LIGHT ILLUMINATED. THE VEHICLE TOOK TEN MINUTES TO FINALLY START. ONCE THE VEHICLE STARTED, THE THEFT LIGHT DIMMED. THE FAILURE OCCURRED TWICE BEFORE. THE CURR…
Read full complaint
TL*THE CONTACT OWNS A 2002 CHEVROLET MALIBU. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. THERE WERE NO WARNING LIGHTS PRESENT, HOWEVER, THE THEFT DETERRENT LIGHT ILLUMINATED. THE VEHICLE TOOK TEN MINUTES TO FINALLY START. ONCE THE VEHICLE STARTED, THE THEFT LIGHT DIMMED. THE FAILURE OCCURRED TWICE BEFORE. THE CURRENT MILEAGE WAS 69,000 AND FAILURE MILEAGE WAS 68,900. UPDATED 02-01-08 *BF UPDATED 02/01/08 *TR
CAR FAILS TO START DUE TO FAULTY ANTI THEFT DETERRENT SYSTEM. COMPONENTS OF SYSTEM INCLUDING IGNITION LOCK CYLINDER AND HOUSING, BODY CONTROL MODULE, AND KEY REPLACED IN 11/06. SAME SYMPTOMS RECURRED IN 07/07. *AK
I HAVE HAD A PROBLEM WITH THE ANTI-THEFT DEVICE IN THE COMPUTER. I REPLACED THE COMPUTER 11 MONTHS AGO AND ALREADY I HAVE TO REPLACE IT AGAIN. THE ANTI-THEFT DEVICE TRICKS THE COMPUTER AND DISABLES THE ENGINE FROM IGNITING. *TR
Official recalls
214V400000 · Electrical System:ignition
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
02V107000 · Exterior Lighting:headlights
Apr 10, 2002
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." SOME OF THESE VEHICLES WERE PRODUCED WITH A LEFT LOW-BEAM HEADLAMP THAT DOES NOT MEET THE PHOTOMETRIC PERFORMANCE REQUIREMENTS OF THE STANDARD.
Consequence & remedy
Consequence: LIGHT INTENSITIES BELOW THE MINIMUM INTENSITY REQUIREMENTS CAUSE REDUCTION IN VISIBILITY DOWN THE ROAD FOR THE DRIVER OF THE VEHICLE AND INTENSITIES ABOVE THE MAXIMUM INTENSITY REQUIREMENTS CAUSE INCREASE IN GLARE FOR DRIVERS AHEAD OF, OR APPROACHING, THE VEHICLE.
Remedy: DEALERS WILL INSPECT THE LEFT LOW-BEAM HEADLAMP AND REPLACE IT IF IT DOES NOT MEET REQUIREMENTS. OWNER NOTIFICATION BEGAN MAY 23, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE05055 · Turn Signal Failures
Opened Sep 27, 2005 · Closed Jan 13, 2006
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal:switch
IN DECEMBER 2004, GM ISSUED A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327. THE POLICY COVERED TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURRED FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH. GM SENT LETTERS TO OWNERS STARTING DECEMBER 30, 2004.IN JANUARY 2006, GM WILL UPDATE THE SPECIAL POLICY TO INCLUDE MY 2002 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V-327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING LATE APRIL 2006.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
IN DECEMBER 2004, GM ISSUED A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327. THE POLICY COVERED TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURRED FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH. GM SENT LETTERS TO OWNERS STARTING DECEMBER 30, 2004.IN JANUARY 2006, GM WILL UPDATE THE SPECIAL POLICY TO INCLUDE MY 2002 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V-327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING LATE APRIL 2006.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:turn Signal:switch
IN DECEMBER 2004, GM ISSUED A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327. THE POLICY COVERED TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURRED FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH. GM SENT LETTERS TO OWNERS STARTING DECEMBER 30, 2004.IN JANUARY 2006, GM WILL UPDATE THE SPECIAL POLICY TO INCLUDE MY 2002 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V-327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING LATE APRIL 2006.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.