NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
976 reportsMileage unknown · Jun 20, 2005
Power TrainSuspension
DT: THE CONTACT OWNS A 1998 CHEVROLET, MALIBU. THE FRONT COIL SPRING BROKE. THERE WAS NO SHIELD GUARD, AND IT CAUSED THE RIGHT FRONT CV SHAFT TO BREAK. ALSO, HAD TO DO OTHER REPAIRS. ACCORDING TO THE MECHANIC VEHICLE COULD HAVE BEEN INVOLVED IN SERIOUS ACCIDENT IF SHE DROVE THE VEHICLE AFTER THE COIL SPRING BROKE. THE COIL …
Read full complaint
DT: THE CONTACT OWNS A 1998 CHEVROLET, MALIBU. THE FRONT COIL SPRING BROKE. THERE WAS NO SHIELD GUARD, AND IT CAUSED THE RIGHT FRONT CV SHAFT TO BREAK. ALSO, HAD TO DO OTHER REPAIRS. ACCORDING TO THE MECHANIC VEHICLE COULD HAVE BEEN INVOLVED IN SERIOUS ACCIDENT IF SHE DROVE THE VEHICLE AFTER THE COIL SPRING BROKE. THE COIL SPRING COULD HAVE GONE THROUGH THE FRONT TIRE, CAUSING CONSUMER TO LOSE CONTROL OF THE VEHICLE. *AK
NHTSA ODI #10125964
32,000 miles · Jun 2, 2005
Electrical System
MY THEFT LIGHT CAME ON AS I WAS DRIVING THE CAR. I BROUGHT IT INTO VILLAGE CHEVROLET AND THEY SWITCHED OUT THE IGNITION SWITCH. (THIS HAS HAPPENED AT LEAST 12 TO 15 TIMES). THEY HAVE REPLACED THE IGINITION SWITCH AT LEAST 4 TIMES, THE BODY CONTROL MODULE ONCE. AT LEAST FIVE OF THOSE 12 TO 15 TIMES, I WASN'T DRIVING ANYWHERE …
Read full complaint
MY THEFT LIGHT CAME ON AS I WAS DRIVING THE CAR. I BROUGHT IT INTO VILLAGE CHEVROLET AND THEY SWITCHED OUT THE IGNITION SWITCH. (THIS HAS HAPPENED AT LEAST 12 TO 15 TIMES). THEY HAVE REPLACED THE IGINITION SWITCH AT LEAST 4 TIMES, THE BODY CONTROL MODULE ONCE. AT LEAST FIVE OF THOSE 12 TO 15 TIMES, I WASN'T DRIVING ANYWHERE AND I WAS USING THE ORIGINAL KEY THAT I GOT WHEN I PURCHASED THE CAR BRAND NEW, I WAS ATTEMPTING TO START THE CAR AND THE THEFT LIGHT CAME ON SOLID. I CALLED GM, AND THEY TOLD ME TO PUT THE KEY IN THE ON POSITION FOR 15 TO 20 MINUTES TO RESET ITSELF. I LIVE IN MN, AND THIS IS TOTALLY UNACCEPTABLE SINCE WE HAVE WEATHER EXTREMES AND I AM A SINGLE WOMAN, AND THIS IS MY ONLY MODE OF TRANSPORTATION. THE LAST TIME THAT I BROUGHT IT IN FOR THIS, THEY CUT A NEW KEY FROM MY VIN TO SEE IF THAT WOULD HELP SOLVE THE PROBLEM. IT HAS HAPPENED AT LEAST 2 MORE TIMES SINCE THAT. I HAVE CALLED GM REPEATEDLY, AND THEY TELL ME THAT THERE IS NOTHING THAT THEY CAN DO. I AM PRETTY SURE THAT THERE IS A SHORT BETWEEN THE IGNITION SWITCH AND THE STARTER. IS THERE ANYTHING THAT CAN BE DONE???
NHTSA ODI #10123999
Mileage unknown · May 30, 2005
Suspension
I PULLED OUT INTO THE STREET WHEN I HEARD A POP. THINKING IT WAS MY POWER STEERING I DROVE ON AND WITHIN A MILE MY TIRE BLEW. UPON REMOVAL OF THE TIRE, THE COIL SPRING ON THE FRONT RIGHT SIDE HAD SNAPPED. THERE WAS NO RUST, ONLY A COMPLETE BREAK IN THE COIL SPRING.
NHTSA ODI #10122441
Mileage unknown · May 20, 2005
Suspension
BOTH COIL SPRINGS FAILED WITHIN A 2 MONTH PERIOD.
NHTSA ODI #10121657
79,303 miles · May 13, 2005
Suspension
DT CONSUMER STATED HER SON WAS DRIVING THE VEHICLE WHEN HE HEARD A GRINDING NOISE COMING FROM THE RIGHT FRONT OF THE VEHICLE. THERE WAS A LOUD BANG. WHEN THE VEHICLE WAS INSPECTED IT WAS FOUND THAT THE COIL SPRING SNAPPED, THE FRONT RIGHT STRUT BROKE AND CAUSED THE COIL SPRING TO SLIT THE TIRE WHICH LEAD TO A BLOW OUT OF THE …
Read full complaint
DT CONSUMER STATED HER SON WAS DRIVING THE VEHICLE WHEN HE HEARD A GRINDING NOISE COMING FROM THE RIGHT FRONT OF THE VEHICLE. THERE WAS A LOUD BANG. WHEN THE VEHICLE WAS INSPECTED IT WAS FOUND THAT THE COIL SPRING SNAPPED, THE FRONT RIGHT STRUT BROKE AND CAUSED THE COIL SPRING TO SLIT THE TIRE WHICH LEAD TO A BLOW OUT OF THE TIRE. *JB
NHTSA ODI #10120885
84,400 miles · May 12, 2005
Engine And Engine Cooling
IN MARCH OF '05 TOOK CAR IN FOR SEVICE ENGINE WAS TICKING WHILE IDLE AT ONE POINT ONCE CAR WAS WARMED UP THE TICKING STOPED BUT NOW THE TICKING IS STILL HEARD WHILE DRIVING AND AT ACCELEARTION. TOOK CAR IN THE BOB MCGUIRE CHEVROLET IN BORDENTOWN, NJ WAS TOLD THAT I HAD A HEAD GASKET LEAK THAT HAD ALREADY MIXED WITH THE ENGINE O…
Read full complaint
IN MARCH OF '05 TOOK CAR IN FOR SEVICE ENGINE WAS TICKING WHILE IDLE AT ONE POINT ONCE CAR WAS WARMED UP THE TICKING STOPED BUT NOW THE TICKING IS STILL HEARD WHILE DRIVING AND AT ACCELEARTION. TOOK CAR IN THE BOB MCGUIRE CHEVROLET IN BORDENTOWN, NJ WAS TOLD THAT I HAD A HEAD GASKET LEAK THAT HAD ALREADY MIXED WITH THE ENGINE OIL. HAD EVERYTHING FIXED AND THEY EVEN PUT IN HEAVY DUTY LIFTER CLEANER TO CLEAN THE LIFTERS ACCORDING TO MECANIC THAT WAS WERE THE TICK WAS COMING FROM BUT WHEN I PICKED UP THE CAR THE ENGINE WAS STILL TICKING WHEN IDLE AND THE NOISE HAD GOTTEN WORSE. WHEN I ASKED WHAT IT WOULD TAKE TO FIX THE TICKING I WAS TOLD THAT THE WHOLE JOB THAT WAS JUST PERFORMED ON THE CAR HAD TO BE PERFORMED AGAIN IN ORDER TO FIX THE LIFTERS THAT IS CAUSING THE TICKING.
NHTSA ODI #10120784
Mileage unknown · May 5, 2005
Suspension
DT: THE CONSUMER INDICATED THAT HE HEARD A LOUD THUD WHILE DRIVING ABOUT 20 MPH. A COUPLE MINUTES LATER AFTER GOING PROBABLY 50 FT HE HEARD SOMETHING ROLLING UNDER HIS VEHICLE. HE PULLED OVER AND EXITED THE VEHICLE. HE SAW WHAT LOOKED LIKE A PIECE OF COIL SPRING AND PICKED IT UP. HE LOOKED UNDER THE CAR AND SAW WERE THE CO…
Read full complaint
DT: THE CONSUMER INDICATED THAT HE HEARD A LOUD THUD WHILE DRIVING ABOUT 20 MPH. A COUPLE MINUTES LATER AFTER GOING PROBABLY 50 FT HE HEARD SOMETHING ROLLING UNDER HIS VEHICLE. HE PULLED OVER AND EXITED THE VEHICLE. HE SAW WHAT LOOKED LIKE A PIECE OF COIL SPRING AND PICKED IT UP. HE LOOKED UNDER THE CAR AND SAW WERE THE COIL SPRING SLIPPED OFF FROM THE DRIVERS SIDE OF THE VEHICLE. HE CALLED THE MECHANIC BUT HAS NOT HAD ANY WORK DONE TO THE VEHICLE. HE ALSO TOOK THE ACTUAL PIECE OF THE COIL SPRING TO HIS DEALER. THE DEALER INDICATED THAT HE HAD SOLD SEVERAL COIL SPRINGS TO DIFFERENT PEOPLE. THE ROAD WAS BRICK PAVED ROAD AND THERE WAS NO WARNING PRIOR TO THE FAILURE EXCEPT FOR THE NOISE. *NM
NHTSA ODI #10120023
Mileage unknown · May 5, 2005
Fuel System, Gasoline
WHILE DRIVING,THE VEHICLE STALLED. THIS PROBLEM OCCURRED MORE THAN ONCE AND HAD NOT BEEN RESOLVED. VEHICLE WAS TOWED TO THE DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT THE FUEL PUMP NEEDED TO BE REPLACED. *AK THE FUEL PUMP HAS BEEN FIXED FOUR TIMES BUT THEY CONTINUE TO FAIL. *BF *NM
NHTSA ODI #10117566
83,000 miles · Apr 27, 2005
Suspension
CONSUMER HAS TWO SEPARATE ISSUES WHICH INVOLVED BOTH FRONT COIL SPRINGS BREAKING. THE FIRST TIME CONSUMER NOTICED A RUBBING NOISE COMING FROM THE FRONT WHEEL. VEHICLE WAS TAKEN TO A REPAIR SHOP, AND MECHANIC DETERMINED THAT THE LEFT FRONT COIL SPRING BROKE, AND RUBBED AGAINST THE TIRE. THE SECOND TIME WAS AFTER THE CONSUMER…
Read full complaint
CONSUMER HAS TWO SEPARATE ISSUES WHICH INVOLVED BOTH FRONT COIL SPRINGS BREAKING. THE FIRST TIME CONSUMER NOTICED A RUBBING NOISE COMING FROM THE FRONT WHEEL. VEHICLE WAS TAKEN TO A REPAIR SHOP, AND MECHANIC DETERMINED THAT THE LEFT FRONT COIL SPRING BROKE, AND RUBBED AGAINST THE TIRE. THE SECOND TIME WAS AFTER THE CONSUMER DROVE 50 MILES TO TAKE A FRIEND TO THE LOCAL HOSPITAL. AFTER GETTING INTO THE VEHICLE TO RETURN HOME CONSUMER FELT TENSION ON THE RIGHT TIRE. VEHICLE WAS TOWED TO THE REPAIR SHOP, AND MECHANIC DETERMINED FOUND THAT RIGHT COIL SPRING BROKE. DEALER WAS NOTIFIED, AND INFORMED CONSUMER THAT VEHICLE WAS NOT COVERED UNDER A RECALL.*AK
NHTSA ODI #10119234
139,400 miles · Apr 20, 2005
EquipmentPower Train
1) NORMAL DRIVING CONDITIONS, MOSTLY HIGHWAY. 2) FAILURE OF THE HUB ASSEMBLY. VERY NOISY, REDUCED NOISE AROUND CORNERS. 3) THIS HUB HAS BEEN REPLACED THREE TIMES AND IT NEEDS TO BE REPLACED AGAIN. I HAVE SEARCHED FOR ANY RECALLS ON THIS AND COULD NOT FIND ANY. IT HAS BEEN 25000 MILES SINCE IT WAS REPLACED LAST AND THIS IS TOTA…
Read full complaint
1) NORMAL DRIVING CONDITIONS, MOSTLY HIGHWAY. 2) FAILURE OF THE HUB ASSEMBLY. VERY NOISY, REDUCED NOISE AROUND CORNERS. 3) THIS HUB HAS BEEN REPLACED THREE TIMES AND IT NEEDS TO BE REPLACED AGAIN. I HAVE SEARCHED FOR ANY RECALLS ON THIS AND COULD NOT FIND ANY. IT HAS BEEN 25000 MILES SINCE IT WAS REPLACED LAST AND THIS IS TOTALLY UNACCEPTABLE AND EXPENSIVE. WAS TOLD THAT CONTINUED DRIVING COULD CAUSE MORE DAMAGE INCLUDING ABS SYSTEM. INCIDENT DATE BELOW CORRESPONDS TO THE LASTEST TIME HUB FAILED. HAVE NOT HAD IT REPLACED YET, SO PART IS STILL AVAILABLE.*AK
NHTSA ODI #10118160
Official recalls
3Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Dec 11, 2003
CERTAIN PASSENGER VEHICLES HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE RETAINERS COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR PONTIAC AT 1-800-620-7668.
Mar 8, 2001
ON CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE "SALT BELT" STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, AND WYOMING. IF A BUILDUP OF SNOW OR ICE RESTRICTS THE MOVEMENT OF THE PASSENGER SIDE WINDSHIELD WIPER ARM, THE PIVOT HOUSING CAN CRACK AND THE WIPERS WILL NOT OPERATE.
Consequence & remedy
Consequence: REDUCED VISIBILITY IN INCLEMENT WEATHER COULD LEAD TO A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE PASSENGER SIDE WINDSHIELD WIPER PIVOT HOUSING. OWNER NOTIFICATION BEGAN AUGUST 14, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR OLDSMOBILE AT 1-800-442-6537.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6RQ04006 · Windshield Wiper Failure
Opened Jul 7, 2004 · Closed Jan 13, 2005
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:linkages
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
Additional source detail variants (2)
Visibility:windshield Wiper/washer
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
Visibility:windshield Wiper/washer:linkages
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
RQ03001 · Power Rack And Pinion Steering Failure
Opened Jan 2, 2003 · Closed Sep 15, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Additional source detail variants (2)
Steering
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
EA00019 · Windshield Wiper
Opened Jul 12, 2000 · Closed Mar 6, 2001
Status: closed (inferred from source dates) · Visibility
ON FEBRUARY 22, 2000, THE OFFICE OF DEFECTS INVESTIGATION (ODI) INITIATED PE00-009 BASED ON SEVEN REPORTS OF WINDSHIELD WIPER FAILURE IN CERTAIN MODEL YEAR (MY) 1997 & 1998 CHEVROLET MALIBU & OLDSMOBILE CUTLASS VEHICLES.THE INVESTIGATION WAS UPGRADED TO EA00-019 ON JULY 12, 2000.DURING THE COURSE OF THE INVESTIGATION, IT WAS FOUND THAT THE FAILURES WERE THE RESULT OF FRACTURE OF THE PASSENGER-SIDE WINDSHIELD WIPER PIVOT HOUSING (SUBJECT COMPONENT).SUCH A FRACTURE LED TO AN IMMEDIATE AND IRRECOVERABLE LOSS OF WINDSHIELD WIPER FUNCTION.GMREPORTED THAT THE MATERIAL COMPOSITION (50% GLASS-REINFORCED ACETAL) OF THE SUBJECT COMPONENT WAS INSUFFICIENT TO WITHSTAND STRESSES IMPOSED BY CERTAIN FROZEN PRECIPITIATION ACCUMULATIONS.THE SUBJECT COMPONENT MATERIAL WAS CHANGED TO THE STRONGER 50% GLASS-REINFORCEDNYLON-6, EFFECTIVE JANUARY 98.OBSOLETE SERVICE PART WERE DISCARDED.GM WILL REPLACE THE SUBJECT COMPONENTS IN 129,427 SUBJECT VEHICLES FOUND IN 28 STATES (AK, CO, CT, DE, ID, IL, IN, IA ME, MD, MA, MI, MN, MT, NE, NH, NJ, NY, ND, OH, PA, RI, SD, UT, VT, WV, WI, WY), THE DISTRICT OF COLUMBIA, AND ALL CANADIAN PROVINCES.THESE STATES ACCOUNTED FOR 91% OF THE CONSUMER COMPLAINTS IDENTIFIED ABOVE.ODI WILL MONITOR THIS COMPAIGN FOR ADEQUATE EFFCTIVENESS AND, IF NECESSARY, TAKE FURTHER ACTION IN THE FUTURE.FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS MATTER IS UNJUSTIFIED AT THIS TIME.THE ENGINEERING ANALYSIS IS CLOSED.
EA00010 · Stop Lamp Assembly Overheat
Opened Mar 27, 2000 · Closed Aug 9, 2001
Status: closed (inferred from source dates) · Exterior Lighting
There is no summary currently available
PE00009 · Windshield Wiper
Opened Feb 22, 2000 · Closed Jul 12, 2000
Status: closed (inferred from source dates) · Visibility
There is no summary currently available
PE99071 · Stop Lamp
Opened Nov 17, 1999 · Closed Mar 27, 2000
Status: closed (inferred from source dates) · Exterior Lighting
There is no summary currently available
Illustration