NHTSA owner reports · September 18, 2026 snapshot.
Suspension complaints
108 reportsClear category filterMileage unknown · Oct 1, 2014
EquipmentFuel System, GasolineService Brakes, Hydraulic
1998 CHEVROLET MALIBU. CONSUMER WRITES TO EXPRESS DISCONTENT WITH LOCAL DEALERSHIP. *TGW THE CONSUMER STATED THE BRAKE WAS SPONGY, THE ABS LIGHT ILLUMINATED AND THE AC WORKED ERRATICALLY, DEPENDING ON THE BLOWER SPEED AND WOULD SOMETIMES QUIT BLOWING COLD AIR AND WOULD START TO BLOW WARM AIR. THE CONSUMER STATED THE BRAKE FLUI…
Read full complaint
1998 CHEVROLET MALIBU. CONSUMER WRITES TO EXPRESS DISCONTENT WITH LOCAL DEALERSHIP. *TGW THE CONSUMER STATED THE BRAKE WAS SPONGY, THE ABS LIGHT ILLUMINATED AND THE AC WORKED ERRATICALLY, DEPENDING ON THE BLOWER SPEED AND WOULD SOMETIMES QUIT BLOWING COLD AIR AND WOULD START TO BLOW WARM AIR. THE CONSUMER STATED THE BRAKE FLUID WAS VERY LOW. THE DEALER WAS UNABLE TO FIND ANY BRAKE FLUID LEAKS. HOWEVER, TWO MONTHS LATER WHILE DRIVING, THE BRAKE PEDAL WENT TO THE FLOOR, BECAUSE THE FLUID HAD LEAKED OUT AGAIN. THE BRAKE LINES WERE REPLACED. IN ADDITION, TO THE BRAKE LINE ISSUE, THE SWAY BAR WAS BROKEN, A FUEL LINE WAS LEAKING AND THE LEFT REAR STRUT HAD FAILED. *JB
NHTSA ODI #10639977
76,900 miles · Dec 27, 2012
SteeringSuspension
I WAS PARKING THE CAR IN MY DRIVE WAY AND ALL OF SUDDEN A LOUD NOISE COMES FROM UNDERNEATH AND THE CAR STEERS BY ITSELF IN THE WRONG DIRECTION WHERE THE OTHER CAR WAS ALREADY PARKED. I MANAGED TO STEER DUE TO THE SLOW SPEED THE CAR WAS MOVING BUT I REALIZED HOW BAD THIS COULD HAVE BEEN WHILE DRIVING THE CAR IN TRAFFIC AND AT …
Read full complaint
I WAS PARKING THE CAR IN MY DRIVE WAY AND ALL OF SUDDEN A LOUD NOISE COMES FROM UNDERNEATH AND THE CAR STEERS BY ITSELF IN THE WRONG DIRECTION WHERE THE OTHER CAR WAS ALREADY PARKED. I MANAGED TO STEER DUE TO THE SLOW SPEED THE CAR WAS MOVING BUT I REALIZED HOW BAD THIS COULD HAVE BEEN WHILE DRIVING THE CAR IN TRAFFIC AND AT HIGH SPEED RATES. WHEN I CHECKED WHAT HAPPENED, I NOTICED THAT THE FRONT END CRADLE THAT THE STEERING RACK MOUNTS TO, HAS RUSTED OUT AND THE WHOLE RACK AND PINION BECAME LOSE IN ONE OF THE MOUNTING POINTS. I AM VERY DISAPPOINTED WITH THE QUALITY AND WORKMANSHIP THEY PUT IN ONE OF THE MOST IMPORTANT PARTS OF THE CAR, WHERE STEERING, SUSPENSION, IN FACT THE WHOLE POWER TRAIN SEATS ON AND IT FAILED SO EASY. THE MANUFACTURE WAS TRYING TO SAVE SOME DOLLARS AT THE COST OF PEOPLES LIVES. *TR
NHTSA ODI #10490238
53,924 miles · Jun 22, 2012
Suspension
TL* THE CONTACT OWNS A 1998 CHEVROLET MALIBU. THE CONTACT STATED THAT THE FRONT DRIVER SIDE SPRING FAILED AND CAUSED DAMAGE TO THE FRONT DRIVER SIDE TIRE AND WHEEL. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND THE CURRENT MILEAGE WAS 53,924.
NHTSA ODI #10462684
160,000 miles · Jul 20, 2010
Suspension
I HAVE A 1998 CHEVY MALIBU, AND THE SPRING STRUT SNAPPED IN HALF AND POPPED A HOLE IN MY TIRE, I HAD NO CONTROL OF THE VEHICLE AND ALMOST HAD A HEAD ON COLLISION WITH ANOTHER CAR GOING 45 MPH. LUCKILY THE CAR MOVED JUST IN TIME, I AM VERY SCARED FOR OTHER PEOPLE WHO OWN THIS CAR. IT JUST HAPPENED TONIGHT, SO I AM NOT QUITE SURE …
Read full complaint
I HAVE A 1998 CHEVY MALIBU, AND THE SPRING STRUT SNAPPED IN HALF AND POPPED A HOLE IN MY TIRE, I HAD NO CONTROL OF THE VEHICLE AND ALMOST HAD A HEAD ON COLLISION WITH ANOTHER CAR GOING 45 MPH. LUCKILY THE CAR MOVED JUST IN TIME, I AM VERY SCARED FOR OTHER PEOPLE WHO OWN THIS CAR. IT JUST HAPPENED TONIGHT, SO I AM NOT QUITE SURE WHAT IS GOING TO BE DONE ABOUT THE CAR, BUT IM BEGGING YOU TO PLEASE MAKE THIS ISSUE PUBLIC! SOMETHING NEEDS TO BE DONE ABOUT THIS ISSUE, PEOPLE NEED TO KNOW BECAUSE IT CAN COST LIVES BY NOT SAYING ANYTHING. *TR
NHTSA ODI #10344135
81,000 miles · Aug 17, 2008
Suspension
CAR WAS PARKED IN DRIVEWAY, I WENT INTO CAR TO GET SOMETHING OUT OF THE GLOVE COMPARTMENT ALL OF A SUDDEN THIS LOUD BANG! I WALKED AROUND THE CAR TO TRY TO FIND OUT WHAT CAUSED THIS, COULD NOT SEE ANYTHING OUT OF THE ORDINARY. I THEN SAT IN CAR AND TURNED THE STEERING WHEEL TO ONE SIDE, WENT OUT TO CHECK TIRES, BOTH TIRES TURNE…
Read full complaint
CAR WAS PARKED IN DRIVEWAY, I WENT INTO CAR TO GET SOMETHING OUT OF THE GLOVE COMPARTMENT ALL OF A SUDDEN THIS LOUD BANG! I WALKED AROUND THE CAR TO TRY TO FIND OUT WHAT CAUSED THIS, COULD NOT SEE ANYTHING OUT OF THE ORDINARY. I THEN SAT IN CAR AND TURNED THE STEERING WHEEL TO ONE SIDE, WENT OUT TO CHECK TIRES, BOTH TIRES TURNED. DID THE SAME FOR THE OTHER SIDE, ALL OKAY. GOT IN CAR, BACKED OUT OF DRIVEWAY AND THEN ANOTHER LOUD BANG. BACKED THE CAR UP INTO THE DRIVEWAY. HAD IT FLAT BEDDED TO THE REPAIR SHOP. AS THE OTHER COMPLAINTS ARE NOTED IT WAS THE SPRING - THE REPAIR MAN SAID THANK GOD YOU WEREN'T DRIVING THE CAR IT COULD HAVE CAUSED A SERIOUS ACCIDENT. HAD TO HAVE SPRING, STRUTS AND STRUT MOUNTS REPLACED. AT THAT POINT I WAS SO SCARED TO DRIVE THIS VEHICLE AND POSSIBLY HAVE THE SAME THING HAPPEN TO THE OTHER SIDE, I ASKED THEM TO REPLACE BOTH. I CALLED CHEVROLET HEADQUARTERS TO ASK IF THIS IS ON A RECALL OR IF THERE HAVE BEEN ANY OTHER COMPLAINTS LIKE THIS FILED, THE REPRESENTATIVE SAID THEY HAVE NO RECALLS AND NOTHING ON RECORD OF THIS PROBLEM WITH OTHER CHEVROLET MALIBU OWNERS. *TR
NHTSA ODI #10238554
112,222 miles · Jul 31, 2008
Suspension
THE FRONT LEFT, DRIVER SIDE, SPRING BROKE WHILE DRIVING AT APPROXIMATELY 5 MILES PER HOUR ON A SMOOTH PAVED ROAD. THIS WAS THE 2ND TIME THIS HAS HAPPENED ON THE SAME CAR. THE FIRST TIME WAS THE RIGHT FRONT SIDE. I WAS DRIVING SLOWER SO THE TIRE DID NOT BLOW FROM THE SHARP BROKEN SPRING END RUBBING ON IT. THE SPRING WAS REPLACED …
Read full complaint
THE FRONT LEFT, DRIVER SIDE, SPRING BROKE WHILE DRIVING AT APPROXIMATELY 5 MILES PER HOUR ON A SMOOTH PAVED ROAD. THIS WAS THE 2ND TIME THIS HAS HAPPENED ON THE SAME CAR. THE FIRST TIME WAS THE RIGHT FRONT SIDE. I WAS DRIVING SLOWER SO THE TIRE DID NOT BLOW FROM THE SHARP BROKEN SPRING END RUBBING ON IT. THE SPRING WAS REPLACED WITH NO OTHER DAMAGE. AFTER READING ABOUT MANY OTHERS HAVING THE SAME PROBLEM I DECIDED TO SUMIT COMPLAINTS HOPING WE CAN PREVENT ANY INJURIES OR DEATHS. I CAN NOT UNDERSTAND WHY GM HAS NOT RECALLED THESE CARS AND HOW MANY ACCIDENTS GO UNREPORTED WITH THIS THE CAUSE. *TR
NHTSA ODI #10236497
102,619 miles · Jul 31, 2008
Suspension
DRIVING AT APPROXIMATELY 10 MPH ON A SMOOTH DRY ROAD SUDDENLY THE FRONT RIGHT SIDE SPRING BROKE DAMAGING THE STRUT AND TIRE. THANKFULLY, THIS WAS AT A SLOW SPEED OR SOMEONE COULD HAVE BEEN KILLED. THE TIRE, SPRING AND STRUT WERE REPLACED. *TR
NHTSA ODI #10236489
131,000 miles · Jul 14, 2008
Suspension
THE COIL SPRING ON THE PASSENGER SIDE STRUT SNAPPED INTO CAUSING A LARGE GOUGE IN THE TIRE DEFLATING IT IMMEDIATELY. LUCKILY, I HAD PULLED OFF INTERSTATE I-77 AND WAS IN A LARGE LEVEL PARKING SPACE. MY WIFE GOT IN THE CAR TO PULL UP AND PICK ME UP. AS THE CAR WENT LESS THAN A FOOT FORWARD A LARGE BANG WAS HEARD AND JOURNEY BEGAN…
Read full complaint
THE COIL SPRING ON THE PASSENGER SIDE STRUT SNAPPED INTO CAUSING A LARGE GOUGE IN THE TIRE DEFLATING IT IMMEDIATELY. LUCKILY, I HAD PULLED OFF INTERSTATE I-77 AND WAS IN A LARGE LEVEL PARKING SPACE. MY WIFE GOT IN THE CAR TO PULL UP AND PICK ME UP. AS THE CAR WENT LESS THAN A FOOT FORWARD A LARGE BANG WAS HEARD AND JOURNEY BEGAN TO GET HELP. TO AVOID RANDOM DETAILS OF 88 DEGREE HEAT AND HARDSHIP EVENTS, THE RESULT WAS A NEW TIRE, A NEW SPARE TIRE (DONUT), AN OVERNIGHT STAY AND EXPENSES AND A REPAIR BILL. THE STRUT WAS REPLACED WITH A USED ONE DUE TO THE FACT THAT WE WERE STRANDED AWAY FROM HOME AND HAD NO TIME TO WAIT FOR A NEW ONE TO BE ORDERED. WHAT REALLY DREW MY ATTENTION TO THE POSSIBLE SEVERITY OF THE PROBLEM WAS THAT IN A SMALL REPAIR SHOP WITH ONLY 4 BAYS (SHEPARD'S REPAIR, PARKERSBURG, WV) THERE SAT ANOTHER MALIBU OF POSSIBLY THE EXACT MODEL WAITING FOR A NEW STRUT TO BE SHIPPED IN. THE ODDS ARE RATHER STAGGERING THAT THIS EVENT COULD BE SO RANDOM AS TO NOT IN SOME WAY POINT TO A MUCH LARGER SCALED PROBLEM WITH THESE COILS. BOTH SNAPPED IN APPROXIMATELY THE SAME PLACE (EXCEPT HIS WAS THE DRIVER'S SIDE) AND NEITHER OF THE STRUTS THEMSELVES WERE LEAKING OR WEAK. NOW HOW DO I TRUST THE CAR FOR FEAR THE OTHER STRUT WILL BREAK OR EVEN THE REPLACEMENT FOR WHICH I KNOW NOT WHAT MODEL CAR IT WAS DISASSEMBLED FROM. *TR
NHTSA ODI #10234213
124,830 miles · Feb 29, 2008
Suspension
WHILE MOVING THE CAR FROM THE GARAGE HEARD A LOUD BANG FROM THE LEFT FRONT SUSPENSION. I FOUND THAT THE SPRING HAD BROKEN AND WAS JAMBED AGAINST THE TIRE. I HAD THE CAR TOWED TO THE REPAIR SHOP. I WAS INFORMED THAT THE SPRING HAD BROKEN AND WE WERE LUCKY WE WERE NOT TRAVELING FAST ASUREDLY WE WOULD HAVE LOST CONTROL OF THE CAR A…
Read full complaint
WHILE MOVING THE CAR FROM THE GARAGE HEARD A LOUD BANG FROM THE LEFT FRONT SUSPENSION. I FOUND THAT THE SPRING HAD BROKEN AND WAS JAMBED AGAINST THE TIRE. I HAD THE CAR TOWED TO THE REPAIR SHOP. I WAS INFORMED THAT THE SPRING HAD BROKEN AND WE WERE LUCKY WE WERE NOT TRAVELING FAST ASUREDLY WE WOULD HAVE LOST CONTROL OF THE CAR AND WOULD HAVE BEEN FORCED INTO ONCOMOING TRAFFIC. THE SERVICE MANAGER TOLD ME THAT HE HAS HAD A RASH OF SPRING FAILURES WITH MANY GM MODEL CARS HE ATIBUTES IT TO POOR QUALITY MATERIAL IN THE SPRINGS. HE HAD TO REPLACE BOTH SPRINGS AND BOTH SHOCK STRUTS. I HAPPENED TO DROP BY THE DEALER WHERE I PURCHASED THE CAR AND HE ASKED HOW IT WAS WORKING I INFORMED HIM ABOUT WHAT HAD HAPPENED, HE WAS VERY SURPISED, AND THEN TOLD ME HE HAD A 2000 CHEV MALIBU ON THE LOT THAT HAD THE SAME THING HAPPEN WHILE STANDING. OF COURSE HE COULD NOT DO ANYTHING FOR ME. OUT OF WARRANTY. THE COST FOR THE REPAIR WAS $847.59 BUT WE ARE GLAD TO BE ALIVE. NO MORE GM CARS MADE WITH INFERIOR CHINESE METAL. AMERICANS TAKE HEED. *TR
NHTSA ODI #10219711
135,000 miles · Jan 24, 2008
Suspension
THE COIL SPRING SNAPPED IN HALF WHILE I WAS IN MY CAR AND POPPED MY TIRE. I WAS TRAVELING AT EXTREMELY LOW SPEEDS, OTHERWISE IT COULD HAVE BEEN TERRIBLE. I REPLACED IT WITH A JUNK YARD SPRING AND STRUT SINCE I HAVE NEVER HEARD OF THIS TYPE OF FAILURE. SEVERAL WEEKS BEFORE THE FAILURE THERE WAS A LOW SQUEAK OR RUB COMING FRO…
Read full complaint
THE COIL SPRING SNAPPED IN HALF WHILE I WAS IN MY CAR AND POPPED MY TIRE. I WAS TRAVELING AT EXTREMELY LOW SPEEDS, OTHERWISE IT COULD HAVE BEEN TERRIBLE. I REPLACED IT WITH A JUNK YARD SPRING AND STRUT SINCE I HAVE NEVER HEARD OF THIS TYPE OF FAILURE. SEVERAL WEEKS BEFORE THE FAILURE THERE WAS A LOW SQUEAK OR RUB COMING FROM THE FRONT WHEEL WELL. I THOUGHT AT THE TIME THAT IT WAS SNOW BUILD UP, BUT NOW I KNOW BETTER. *TR
NHTSA ODI #10215875
Official recalls
3Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Dec 11, 2003
CERTAIN PASSENGER VEHICLES HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE RETAINERS COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR PONTIAC AT 1-800-620-7668.
Mar 8, 2001
ON CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE "SALT BELT" STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, AND WYOMING. IF A BUILDUP OF SNOW OR ICE RESTRICTS THE MOVEMENT OF THE PASSENGER SIDE WINDSHIELD WIPER ARM, THE PIVOT HOUSING CAN CRACK AND THE WIPERS WILL NOT OPERATE.
Consequence & remedy
Consequence: REDUCED VISIBILITY IN INCLEMENT WEATHER COULD LEAD TO A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE PASSENGER SIDE WINDSHIELD WIPER PIVOT HOUSING. OWNER NOTIFICATION BEGAN AUGUST 14, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR OLDSMOBILE AT 1-800-442-6537.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6RQ04006 · Windshield Wiper Failure
Opened Jul 7, 2004 · Closed Jan 13, 2005
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:linkages
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
Additional source detail variants (2)
Visibility:windshield Wiper/washer
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
Visibility:windshield Wiper/washer:linkages
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
RQ03001 · Power Rack And Pinion Steering Failure
Opened Jan 2, 2003 · Closed Sep 15, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Additional source detail variants (2)
Steering
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
EA00019 · Windshield Wiper
Opened Jul 12, 2000 · Closed Mar 6, 2001
Status: closed (inferred from source dates) · Visibility
ON FEBRUARY 22, 2000, THE OFFICE OF DEFECTS INVESTIGATION (ODI) INITIATED PE00-009 BASED ON SEVEN REPORTS OF WINDSHIELD WIPER FAILURE IN CERTAIN MODEL YEAR (MY) 1997 & 1998 CHEVROLET MALIBU & OLDSMOBILE CUTLASS VEHICLES.THE INVESTIGATION WAS UPGRADED TO EA00-019 ON JULY 12, 2000.DURING THE COURSE OF THE INVESTIGATION, IT WAS FOUND THAT THE FAILURES WERE THE RESULT OF FRACTURE OF THE PASSENGER-SIDE WINDSHIELD WIPER PIVOT HOUSING (SUBJECT COMPONENT).SUCH A FRACTURE LED TO AN IMMEDIATE AND IRRECOVERABLE LOSS OF WINDSHIELD WIPER FUNCTION.GMREPORTED THAT THE MATERIAL COMPOSITION (50% GLASS-REINFORCED ACETAL) OF THE SUBJECT COMPONENT WAS INSUFFICIENT TO WITHSTAND STRESSES IMPOSED BY CERTAIN FROZEN PRECIPITIATION ACCUMULATIONS.THE SUBJECT COMPONENT MATERIAL WAS CHANGED TO THE STRONGER 50% GLASS-REINFORCEDNYLON-6, EFFECTIVE JANUARY 98.OBSOLETE SERVICE PART WERE DISCARDED.GM WILL REPLACE THE SUBJECT COMPONENTS IN 129,427 SUBJECT VEHICLES FOUND IN 28 STATES (AK, CO, CT, DE, ID, IL, IN, IA ME, MD, MA, MI, MN, MT, NE, NH, NJ, NY, ND, OH, PA, RI, SD, UT, VT, WV, WI, WY), THE DISTRICT OF COLUMBIA, AND ALL CANADIAN PROVINCES.THESE STATES ACCOUNTED FOR 91% OF THE CONSUMER COMPLAINTS IDENTIFIED ABOVE.ODI WILL MONITOR THIS COMPAIGN FOR ADEQUATE EFFCTIVENESS AND, IF NECESSARY, TAKE FURTHER ACTION IN THE FUTURE.FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS MATTER IS UNJUSTIFIED AT THIS TIME.THE ENGINEERING ANALYSIS IS CLOSED.
EA00010 · Stop Lamp Assembly Overheat
Opened Mar 27, 2000 · Closed Aug 9, 2001
Status: closed (inferred from source dates) · Exterior Lighting
There is no summary currently available
PE00009 · Windshield Wiper
Opened Feb 22, 2000 · Closed Jul 12, 2000
Status: closed (inferred from source dates) · Visibility
There is no summary currently available
PE99071 · Stop Lamp
Opened Nov 17, 1999 · Closed Mar 27, 2000
Status: closed (inferred from source dates) · Exterior Lighting
There is no summary currently available
Illustration