NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
976 reports56,523 miles · Jan 6, 2006
Suspension
THE DRIVER SIDE FRONT COIL SPRING BROKE WHILE I WAS BACKING UP ON MY DRIVEWAY. I TOOK IT TO A TRUSTED LOCAL MECHANIC WHO REPLACED BOTH FRONT SUSPENSION UNITS WHICH INCLUDED THE STRUT, COIL SPRING AND MOUNTING PLATE. ACCORDING TO THE MECHANIC, IT'S SAFER TO REPLACE BOTH SIDES AT THE SAME TIME. I AGREED WITH HIM, WHO KNOWS IF …
Read full complaint
THE DRIVER SIDE FRONT COIL SPRING BROKE WHILE I WAS BACKING UP ON MY DRIVEWAY. I TOOK IT TO A TRUSTED LOCAL MECHANIC WHO REPLACED BOTH FRONT SUSPENSION UNITS WHICH INCLUDED THE STRUT, COIL SPRING AND MOUNTING PLATE. ACCORDING TO THE MECHANIC, IT'S SAFER TO REPLACE BOTH SIDES AT THE SAME TIME. I AGREED WITH HIM, WHO KNOWS IF I DID NOT REPLACE THE RIGHT SIDE IT COULD HAVE BROKEN WHILE DRIVING DOWN THE HIGHWAY CAUSING A SERIOUS ACCIDENT. THE RESULTS COULD BE DETRIMENTAL TO THE DRIVER AND OTHERS. MY 1998 CHEVROLET MALIBU HAS LESS THAN 57,000 MILES ON IT AND THE COIL SPRING SHOULD NOT BREAK IN HALF IN SUCH LOW MILEAGE. THAT SAID, I AM THINKING IF THERE''S ANY DEFECT IN THE DESIGN AND/OR BUILD MATERIAL OF THE COIL SPRING. I SPENT $634 TO FIX IT AND IT COULD HAVE COST MUCH MORE, INCLUDING MY LIFE, LOVED ONES AND OTHERS. I STRONGLY URGE NHTSA TO TAKE ACTIONS, INFORM GM AND BEGIN A RECALL CAMPAIGN IMMEDIATELY BEFORE SOMEONE GETS KILLED. REGARDS, SCOTT SHYU SHYUSCOTT@AOL.COM. *NM
NHTSA ODI #10147083
2,800 miles · Nov 22, 2005
Service Brakes, HydraulicVehicle Speed Control
DT: THE CONTACT STATED EVERY TIME SHE USED THE CRUISE CONTROL IT DEACTIVATED ON ITS OWN. THIS STARTED APPROXIMATELY ONE MONTH AFTER PURCHASING THE VEHICLE. THE VEHICLE HAS BEEN TO THE DEALERSHIP MULTIPLE TIMES FOR CRUISE CONTROL PROBLEMS, BUT THEY WERE UNABLE TO DUPLICATE THE PROBLEM. THERE HAVE BEEN NO REPAIRS TO THE VEHICL…
Read full complaint
DT: THE CONTACT STATED EVERY TIME SHE USED THE CRUISE CONTROL IT DEACTIVATED ON ITS OWN. THIS STARTED APPROXIMATELY ONE MONTH AFTER PURCHASING THE VEHICLE. THE VEHICLE HAS BEEN TO THE DEALERSHIP MULTIPLE TIMES FOR CRUISE CONTROL PROBLEMS, BUT THEY WERE UNABLE TO DUPLICATE THE PROBLEM. THERE HAVE BEEN NO REPAIRS TO THE VEHICLE AT THIS TIME. *AK UPDATED 2/7/2006 - THE BRALKES FAILED AT LESS THAN 2800 MILES. THE DEALER REPLACED THE BRAKES AND ROTORS. *NM
NHTSA ODI #10143477
133,657 miles · Nov 1, 2005
Engine And Engine Cooling
1998 CHEVY MALIBU: FAULTY INTAKE MANIFOLD GASKET RESULTING IN COOLANT LEAK, GASKET HAS BEEN REPLACED TWICE WITHIN 100,000 MILES (MAY BE RELATED TO MANDATED USAGE OF DEXCOOL ANTIFREEZE IN VEHICLE PER MANUFACTURER). *NM
NHTSA ODI #10141476
57,500 miles · Oct 17, 2005
Engine And Engine CoolingFire
THE OIL LIGHT CAME ON ONE MINUTE THE NEXT MINUTE THE CAR CUT OFF. I HAD THE CAR TOWED TO CURTIS CHEVROLET IN WASHINGTON, DC AND WAS TOLD THAT THE ENGINE SEIZED DUE TO THE OIL REGULATOR AND FILTER EXPLODED. THE CAR HAS ONLY 57500 ORIGINAL MILES, SERVICED MAINLY BY CURTIS CHEVROLET...OIL RECENTLY CHANGED BY CURTIS YET I WAS TOLD…
Read full complaint
THE OIL LIGHT CAME ON ONE MINUTE THE NEXT MINUTE THE CAR CUT OFF. I HAD THE CAR TOWED TO CURTIS CHEVROLET IN WASHINGTON, DC AND WAS TOLD THAT THE ENGINE SEIZED DUE TO THE OIL REGULATOR AND FILTER EXPLODED. THE CAR HAS ONLY 57500 ORIGINAL MILES, SERVICED MAINLY BY CURTIS CHEVROLET...OIL RECENTLY CHANGED BY CURTIS YET I WAS TOLD THAT TO REPLACE THE ENGINE WOULD BE $6,000. THE CAR IS CURRENTLY CONSIDERED TOTALED. *JB
NHTSA ODI #10140043
108,755 miles · Oct 10, 2005
Suspension
FRONT PASSENGER COIL STRUT BROKE WHILE DRIVING. RUBBED UP AGAINST TIRE. LEFT MY CAR IN THE PARKING LOT UNTIL I COULD AFFORD TO REPLACE IT. I TOOK THE CAR TO A TRUSTED LOCAL MECHANIC WHO FIXED MY CAR. FRONT PASSENGER COIL WAS REPLACED AS WELL AS THE TWO FRONT STRUTS. ALSO TWO NEW TIRES WERE REPLACED UP FRONT. *NM
NHTSA ODI #10139226
119,000 miles · Sep 30, 2005
Electrical SystemExterior LightingFire
ON AUG. 10,2005 MY 1998 CHEVY MALIBU, WHILE PARKED WITH IGNITION OFF CAUGHT FIRE. WHILE EXITING CAR BEFORE THE FIRE, I SMELLED NO SMOKE OR "HOT" SMELLS, I STOOD THERE APPROX. 3 MIN. WHILE TALKING TO MY DAUGHTER. 10 MIN. LATER THE LEBANON, TENNESSEE FIRE DEPT. WAS THERE EXTINGUISHING A FIRE THAT WAS MOSTLY CONTAINED TO THE DRIVE…
Read full complaint
ON AUG. 10,2005 MY 1998 CHEVY MALIBU, WHILE PARKED WITH IGNITION OFF CAUGHT FIRE. WHILE EXITING CAR BEFORE THE FIRE, I SMELLED NO SMOKE OR "HOT" SMELLS, I STOOD THERE APPROX. 3 MIN. WHILE TALKING TO MY DAUGHTER. 10 MIN. LATER THE LEBANON, TENNESSEE FIRE DEPT. WAS THERE EXTINGUISHING A FIRE THAT WAS MOSTLY CONTAINED TO THE DRIVERS SIDE FRONT HEADLIGHT AREA, THEY DEEMED THE CAR "TOTALED" . I CONTACTED GM THE SAME DAY, AND AFTER SEVERAL PHONE CONVERSATIONS , ON SEPT.13, 2005, I RECEIVED A LETTER FROM MR. MIKE DEMARE, CUSTOMER RELATIONSHIP MANAGER, THAT "GENERAL MOTORS IS UNABLE TO ASSUME RESPONSIBILITY FOR DAMAGES AND WE SUGGEST THAT YOU RESOLVE THIS MATTER THROUGH YOUR INSURANCE CARRIER." SO I AM STILL WITHOUT A CAR, AND I AM DISABLED, WITH A MINOR CHILD LIVING WITH ME. I CAN NOT AFFORD FULL COVERAGE , AND ONLY HAD LIABILITY ON THE VEHICLE. *NM SEPT.
NHTSA ODI #10138279
11,300 miles · Sep 16, 2005
Suspension
DT: ONE OF THE COIL SPRINGS ON FRONT DRIVER' S SIDE PUNCTURED THE TIRE. THE CONSUMER DID NOT CONTACT THE DEALER OR THE MANUFACTURER. THERE WAS A BIG BOOM SOUND. THIS HAPPENED ON JUNE 14, 2005. *AK THE CONSUMER DID CONTACT THE MANUFACTURER, HOWEVER IT WAS NOT THE RESPONSE SHE HOPED FOR. *JB
NHTSA ODI #10131960
Mileage unknown · Sep 14, 2005
Service Brakes, Hydraulic
REPEATED FAILURE OF FRONT ABS WHEEL SPEED SENSORS CAUSING ERRATIC ABS AND BRAKE OPERATION. *JB
NHTSA ODI #10136465
Mileage unknown · Sep 14, 2005
Suspension
SUDDEN FAILURE OF RIGHT FRONT SPRING CAUSING PUNCTURED TIRE SIDEWALL AND SUDDEN DEFLATION OF TIRE. *JB
NHTSA ODI #10136456
Mileage unknown · Sep 4, 2005
Engine And Engine Cooling
1. I CHECKED THE COOLANT LEVEL IN THE RESERVOIR AND NOTICED COOLANT WAS NEEDED. I PUT WATER INTO THE RESERVOIR (CAR WAS ON) AND EVERYTHING SEEMED TO BE FINE. I DROVE THE CAR ABOUT 10 MILES. I STOPPED TO PUT GAS IN AND NOTICED WATER/COOLANT COMING FROM UNDER THE CAR. I REPLACED THE WATER AND DROVE TO A MECHANIC. THE MECHANIC…
Read full complaint
1. I CHECKED THE COOLANT LEVEL IN THE RESERVOIR AND NOTICED COOLANT WAS NEEDED. I PUT WATER INTO THE RESERVOIR (CAR WAS ON) AND EVERYTHING SEEMED TO BE FINE. I DROVE THE CAR ABOUT 10 MILES. I STOPPED TO PUT GAS IN AND NOTICED WATER/COOLANT COMING FROM UNDER THE CAR. I REPLACED THE WATER AND DROVE TO A MECHANIC. THE MECHANIC TOLD ME THAT MY INTAKE GASKET NEEDED TO BE REPLACED; HE SHOWED ME THE LEAKAGE COMING FROM THE SIDE OF THE ENGINE. HE ALSO STATED, THIS IS A COMMON PROBLEM WITH THIS TYPE OF CAR. SIMILAR COMMENTS HAD BEEN MADE TO ME IN THE PAST IN REGARDS TO THE INTAKE GASKET; MECHANICS, AUTO PART SALES MEN AND THE DEALER WHERE I GET MY CAR SERVICED HAD ALL BEEN CONCERNED IN THE PAST FOR THIS AREA OF MY CAR, BUT UNTIL NOW EVERYTHING HAD BEEN FINE; 2. FAILURE OF THE INTAKE GASKET PREVENTED THE ENGINE COOLANT FROM MAINTAINING THE PROPER COOLANT LEVEL, THE CONSEQUENCE WAS THAT I NEEDED TO TAKE TIME OUT OF MY DAY TO INQUIRE ABOUT THIS MATTER AND SEEK ADVICE IN PREVENTING FURTHER DAMAGE; 3. I HAVE AN APPOINTMENT TO FIX THE PROBLEM ON TUESDAY (9/6/05). I WILL NOT HAVE MY CAR FOR A FULL DAY DUE TO THIS PROBLEM AND THE ESTIMATE TO FIX THE CAR WAS 550.00 TO 600.00 DOLLARS. *JB
NHTSA ODI #10135300
Official recalls
3Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Dec 11, 2003
CERTAIN PASSENGER VEHICLES HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE RETAINERS COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR PONTIAC AT 1-800-620-7668.
Mar 8, 2001
ON CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE "SALT BELT" STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, AND WYOMING. IF A BUILDUP OF SNOW OR ICE RESTRICTS THE MOVEMENT OF THE PASSENGER SIDE WINDSHIELD WIPER ARM, THE PIVOT HOUSING CAN CRACK AND THE WIPERS WILL NOT OPERATE.
Consequence & remedy
Consequence: REDUCED VISIBILITY IN INCLEMENT WEATHER COULD LEAD TO A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE PASSENGER SIDE WINDSHIELD WIPER PIVOT HOUSING. OWNER NOTIFICATION BEGAN AUGUST 14, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR OLDSMOBILE AT 1-800-442-6537.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6RQ04006 · Windshield Wiper Failure
Opened Jul 7, 2004 · Closed Jan 13, 2005
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:linkages
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
Additional source detail variants (2)
Visibility:windshield Wiper/washer
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
Visibility:windshield Wiper/washer:linkages
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
RQ03001 · Power Rack And Pinion Steering Failure
Opened Jan 2, 2003 · Closed Sep 15, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Additional source detail variants (2)
Steering
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
EA00019 · Windshield Wiper
Opened Jul 12, 2000 · Closed Mar 6, 2001
Status: closed (inferred from source dates) · Visibility
ON FEBRUARY 22, 2000, THE OFFICE OF DEFECTS INVESTIGATION (ODI) INITIATED PE00-009 BASED ON SEVEN REPORTS OF WINDSHIELD WIPER FAILURE IN CERTAIN MODEL YEAR (MY) 1997 & 1998 CHEVROLET MALIBU & OLDSMOBILE CUTLASS VEHICLES.THE INVESTIGATION WAS UPGRADED TO EA00-019 ON JULY 12, 2000.DURING THE COURSE OF THE INVESTIGATION, IT WAS FOUND THAT THE FAILURES WERE THE RESULT OF FRACTURE OF THE PASSENGER-SIDE WINDSHIELD WIPER PIVOT HOUSING (SUBJECT COMPONENT).SUCH A FRACTURE LED TO AN IMMEDIATE AND IRRECOVERABLE LOSS OF WINDSHIELD WIPER FUNCTION.GMREPORTED THAT THE MATERIAL COMPOSITION (50% GLASS-REINFORCED ACETAL) OF THE SUBJECT COMPONENT WAS INSUFFICIENT TO WITHSTAND STRESSES IMPOSED BY CERTAIN FROZEN PRECIPITIATION ACCUMULATIONS.THE SUBJECT COMPONENT MATERIAL WAS CHANGED TO THE STRONGER 50% GLASS-REINFORCEDNYLON-6, EFFECTIVE JANUARY 98.OBSOLETE SERVICE PART WERE DISCARDED.GM WILL REPLACE THE SUBJECT COMPONENTS IN 129,427 SUBJECT VEHICLES FOUND IN 28 STATES (AK, CO, CT, DE, ID, IL, IN, IA ME, MD, MA, MI, MN, MT, NE, NH, NJ, NY, ND, OH, PA, RI, SD, UT, VT, WV, WI, WY), THE DISTRICT OF COLUMBIA, AND ALL CANADIAN PROVINCES.THESE STATES ACCOUNTED FOR 91% OF THE CONSUMER COMPLAINTS IDENTIFIED ABOVE.ODI WILL MONITOR THIS COMPAIGN FOR ADEQUATE EFFCTIVENESS AND, IF NECESSARY, TAKE FURTHER ACTION IN THE FUTURE.FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS MATTER IS UNJUSTIFIED AT THIS TIME.THE ENGINEERING ANALYSIS IS CLOSED.
EA00010 · Stop Lamp Assembly Overheat
Opened Mar 27, 2000 · Closed Aug 9, 2001
Status: closed (inferred from source dates) · Exterior Lighting
There is no summary currently available
PE00009 · Windshield Wiper
Opened Feb 22, 2000 · Closed Jul 12, 2000
Status: closed (inferred from source dates) · Visibility
There is no summary currently available
PE99071 · Stop Lamp
Opened Nov 17, 1999 · Closed Mar 27, 2000
Status: closed (inferred from source dates) · Exterior Lighting
There is no summary currently available
Illustration