NHTSA owner reports · September 18, 2026 snapshot.
Fuel System, Gasoline complaints
30 reportsClear category filterMileage unknown · Oct 1, 2014
EquipmentFuel System, GasolineService Brakes, Hydraulic
1998 CHEVROLET MALIBU. CONSUMER WRITES TO EXPRESS DISCONTENT WITH LOCAL DEALERSHIP. *TGW THE CONSUMER STATED THE BRAKE WAS SPONGY, THE ABS LIGHT ILLUMINATED AND THE AC WORKED ERRATICALLY, DEPENDING ON THE BLOWER SPEED AND WOULD SOMETIMES QUIT BLOWING COLD AIR AND WOULD START TO BLOW WARM AIR. THE CONSUMER STATED THE BRAKE FLUI…
Read full complaint
1998 CHEVROLET MALIBU. CONSUMER WRITES TO EXPRESS DISCONTENT WITH LOCAL DEALERSHIP. *TGW THE CONSUMER STATED THE BRAKE WAS SPONGY, THE ABS LIGHT ILLUMINATED AND THE AC WORKED ERRATICALLY, DEPENDING ON THE BLOWER SPEED AND WOULD SOMETIMES QUIT BLOWING COLD AIR AND WOULD START TO BLOW WARM AIR. THE CONSUMER STATED THE BRAKE FLUID WAS VERY LOW. THE DEALER WAS UNABLE TO FIND ANY BRAKE FLUID LEAKS. HOWEVER, TWO MONTHS LATER WHILE DRIVING, THE BRAKE PEDAL WENT TO THE FLOOR, BECAUSE THE FLUID HAD LEAKED OUT AGAIN. THE BRAKE LINES WERE REPLACED. IN ADDITION, TO THE BRAKE LINE ISSUE, THE SWAY BAR WAS BROKEN, A FUEL LINE WAS LEAKING AND THE LEFT REAR STRUT HAD FAILED. *JB
NHTSA ODI #10639977
200,000 miles · Apr 24, 2009
Fuel System, Gasoline
SOMETHING IS WRONG WITH HOW THE FUEL IS BEING RECEIVED. WHEN ITS IN NEUTRAL IT RECEIVES THE FUEL JUST FINE BUT IN REVERSE OR DRIVE IT TRIES TO STALL OUT OR DIE. WE USUALLY HAVE TO TAKE IT ON A DRIVE JUST TO GET THE FUEL PUMPING THROUGH. IT'S CRAZY AND SCARY BECAUSE WHEN YOU NEED TO PULL AND GO IT WILL JERK AND STALL AND THAT NOT…
Read full complaint
SOMETHING IS WRONG WITH HOW THE FUEL IS BEING RECEIVED. WHEN ITS IN NEUTRAL IT RECEIVES THE FUEL JUST FINE BUT IN REVERSE OR DRIVE IT TRIES TO STALL OUT OR DIE. WE USUALLY HAVE TO TAKE IT ON A DRIVE JUST TO GET THE FUEL PUMPING THROUGH. IT'S CRAZY AND SCARY BECAUSE WHEN YOU NEED TO PULL AND GO IT WILL JERK AND STALL AND THAT NOT A GOOD THING. *TR
NHTSA ODI #10266622
120,000 miles · Oct 2, 2008
Electrical SystemFuel System, Gasoline
PASSLOCK SYSTEM FAILURE. HAPPENS VERY FREQUENTLY (THREE TO FOUR TIMES A WEEK) AND CAR CANNOT BE STARTED FOR AT LEAST 10 MINUTES WHILE THE SYSTEM RESETS ITSELF. THIS PROBLEM WAS MISDIAGNOSED SEVERAL TIMES BY DIFFERENT (WELL-QUALIFIED) MECHANICS AND WOUND UP COSTING OVER 1500 DOLLARS IN UNNEEDED REPAIRS TO THE FUEL PUMP AND FUEL …
Read full complaint
PASSLOCK SYSTEM FAILURE. HAPPENS VERY FREQUENTLY (THREE TO FOUR TIMES A WEEK) AND CAR CANNOT BE STARTED FOR AT LEAST 10 MINUTES WHILE THE SYSTEM RESETS ITSELF. THIS PROBLEM WAS MISDIAGNOSED SEVERAL TIMES BY DIFFERENT (WELL-QUALIFIED) MECHANICS AND WOUND UP COSTING OVER 1500 DOLLARS IN UNNEEDED REPAIRS TO THE FUEL PUMP AND FUEL LINE SEVERAL TIMES. GM IS AWARE OF THIS PROBLEM AND REFUSES TO DO A RECALL. *TR
NHTSA ODI #10244259
Mileage unknown · Dec 1, 2007
Engine And Engine CoolingFuel System, Gasoline
1998 CHEVY MALIBU: FAULTY INTAKE MANIFOLD GASKET RESULTING IN COOLANT LEAK IN ENGINE. RESULTED IN ENGINE NEEDING TO BE REPLACED AND UPPER INTAKE GASKET CHANGED AT $2000 CANADIAN. TWO MONTHS LATER,AND LESS TAN 5,000 KMS LATER, FUEL TANK NEEDS TO BE REPLACED. LESS THAN 30 DAYS LATER, UPPER INTAKE GASKET AND FRONT BRAKES NEED T…
Read full complaint
1998 CHEVY MALIBU: FAULTY INTAKE MANIFOLD GASKET RESULTING IN COOLANT LEAK IN ENGINE. RESULTED IN ENGINE NEEDING TO BE REPLACED AND UPPER INTAKE GASKET CHANGED AT $2000 CANADIAN. TWO MONTHS LATER,AND LESS TAN 5,000 KMS LATER, FUEL TANK NEEDS TO BE REPLACED. LESS THAN 30 DAYS LATER, UPPER INTAKE GASKET AND FRONT BRAKES NEED TO BE CHANGED AT COST OF $1500 CANADIAN. *TR
NHTSA ODI #10210441
171,000 miles · Apr 5, 2006
Fuel System, GasolineSuspension
REPLACED WHEEL BEARINGS (COMMON GM PROBLEM, NO GREASE NIPPLE). HAVING FUEL PROBLEM (GETTING TOO MUCH). NOISE COMING FROM THE FRONT END (SOUNDS LIKE COIL SPRING). *JB
NHTSA ODI #10154643
Mileage unknown · Aug 16, 2005
Electrical SystemEngine And Engine CoolingExterior Lighting
I PURCHASED MY 1998 MALIBU, IT'S HAD NOTHING BUT PROBLEMS. SINCE I BOUGHT THIS CAR IN NOVEMBER OF 2001 WITH IN LESS THAN A WEEK OF PURCHASING I HAD TO TAKE THE CAR BACK TO DEALER AND HAVE THEM FIX A PROBLEM BECAUSE CHECK ENGINE LIGHT WAS ON, I AM UNSURE OF THE EXACT PROBLEM BUT I DO KNOW THE CAR DID NOT PASS EMISSIONS AND IF I H…
Read full complaint
I PURCHASED MY 1998 MALIBU, IT'S HAD NOTHING BUT PROBLEMS. SINCE I BOUGHT THIS CAR IN NOVEMBER OF 2001 WITH IN LESS THAN A WEEK OF PURCHASING I HAD TO TAKE THE CAR BACK TO DEALER AND HAVE THEM FIX A PROBLEM BECAUSE CHECK ENGINE LIGHT WAS ON, I AM UNSURE OF THE EXACT PROBLEM BUT I DO KNOW THE CAR DID NOT PASS EMISSIONS AND IF I HAD TO PAY FOR IT, IT WOULD HAVE COST ME OVER 500 DOLLARS, I HAVE REPLACED MY FRONT BRAKES ON 3 OCCASIONS, I HAVE FIXED THE LEAKING TRANSMISSION 2X, I HAVE REPLACED THE TAIL LIGHT BULBS ABOUT 4X, I REPLACED THE ALTERNATOR AND THE LINING IS COMING OFF THE TRUNK. THESE ARE ALL PROBLEMS I HAD IN LESS THEN 2 YEARS OF OWNING THE VEHICLE. SINCE MARCH 2004 I HAVE BEEN UNABLE TO DRIVE MY VEHICLE. I HAVE REPLACED THE FUEL PUMP, WATER PUMP, 2 OF THE INJECTORS AND THERE HAVE BEEN OTHER SMALL REPAIRS HERE AND THERE. EVERY TIME I FIX SOMETHING WITHIN LESS THEN A WEEK OF DRIVING IT THERE IS SOMETHING ELSE WRONG I AM UNABLE TO REPAIR IT UNTIL I CAN SAVE ENOUGH MONEY TO PUT MORE INTO IT. I AM CURRENTLY REPLACING THE INJECTORS WHICH I HAVE ALREADY PAID 600 DOLLARS AND HAVE 4 MORE TO GO. I AM WORRIED THAT AFTER I PUT THIS MONEY INTO IT I WILL STILL HAVE MORE PROBLEMS, I HAVE BEEN TOLD THAT THERE IS SOME ELECTRICAL PROBLEM IN THE DASH BUT THEY ARE UNSURE EXACTLY WHAT IT IS BECAUSE THE CAR WILL NOT RUN LONG ENOUGH TO FIGURE OUT. NOBODY CAN TELL ME EVERYTHING THAT IS WRONG WITH BECAUSE I NEED TO FIX ONE PROBLEM BEFORE THEY CAN BE SURE OF THE NEXT. THIS CAR WAS THE WORST PURCHASE I HAVE MADE. I WAS UNABLE TO REGISTER MY VEHICLE LAST YEAR DUE TO ALL THE PROBLEMS. I HAVE BEEN ON SEVERAL WEB SITES AND ABOUT THIS CAR AND EVERYONE IS HAVING SIMILAR PROBLEMS AND PUTTING OUT THOUSANDS OF DOLLARS IN REPAIRS. *NM
NHTSA ODI #10132979
Mileage unknown · May 5, 2005
Fuel System, Gasoline
WHILE DRIVING,THE VEHICLE STALLED. THIS PROBLEM OCCURRED MORE THAN ONCE AND HAD NOT BEEN RESOLVED. VEHICLE WAS TOWED TO THE DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT THE FUEL PUMP NEEDED TO BE REPLACED. *AK THE FUEL PUMP HAS BEEN FIXED FOUR TIMES BUT THEY CONTINUE TO FAIL. *BF *NM
NHTSA ODI #10117566
Mileage unknown · Mar 20, 2005
Engine And Engine CoolingFuel System, Gasoline
FUEL PUMP, DISCONTINUED, BUT NOT RECALLED. *AK
NHTSA ODI #10114356
56,770 miles · Nov 8, 2004
Fuel System, Gasoline
CLOGGED FUIL INJECTORS P0300 CODE A VERY COMMON PROBLEM WITH GM CARS GM CAME OUT WITH A BULLETIN TO CLEAN THE INJECTORS SHORT TERM FIX I HAVE SEEN MANY VEHICLES DAILY WITH THIS PROBLEM MANY INJECTORS REPLACED.SOME GM CARS DONT HAVE THIS PROBLEM CORVETTE PRIZM BOTH CARS USE A DIFFERENT STYLE INJECTOR THEY DONT CLOGGE GM SAYS G…
Read full complaint
CLOGGED FUIL INJECTORS P0300 CODE A VERY COMMON PROBLEM WITH GM CARS GM CAME OUT WITH A BULLETIN TO CLEAN THE INJECTORS SHORT TERM FIX I HAVE SEEN MANY VEHICLES DAILY WITH THIS PROBLEM MANY INJECTORS REPLACED.SOME GM CARS DONT HAVE THIS PROBLEM CORVETTE PRIZM BOTH CARS USE A DIFFERENT STYLE INJECTOR THEY DONT CLOGGE GM SAYS GAS IS THE PROBLEM WELL CORVETTE AND PRIZM USES THE SAME GAS.THIS IS SUCH A COMMON PROBLEM GM NEEDS TO STEP UP AND COME OUT WITH A BETTER INJECTOR AND RECALL THE CARS.I HAD MY INJECTORS CLEAND MANY TIMES AND ALL THE INJECTORS REPLACED.*AK
NHTSA ODI #10098432
Mileage unknown · May 26, 2004
Fuel System, Gasoline
GAS GAUGE IN DASH SET DOES NOT REGISTER AND THE ENTIRE DASH COMPONENT MUST BE REPLACED. TANK IS FULL, BUT GAUGE REGISTERS E, SENDING UNIT ALRIGHT, PROBLEM IS IN THE DASH SET UP. *NM
NHTSA ODI #10073215
Official recalls
3Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Dec 11, 2003
CERTAIN PASSENGER VEHICLES HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE RETAINERS COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR PONTIAC AT 1-800-620-7668.
Mar 8, 2001
ON CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE "SALT BELT" STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, AND WYOMING. IF A BUILDUP OF SNOW OR ICE RESTRICTS THE MOVEMENT OF THE PASSENGER SIDE WINDSHIELD WIPER ARM, THE PIVOT HOUSING CAN CRACK AND THE WIPERS WILL NOT OPERATE.
Consequence & remedy
Consequence: REDUCED VISIBILITY IN INCLEMENT WEATHER COULD LEAD TO A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE PASSENGER SIDE WINDSHIELD WIPER PIVOT HOUSING. OWNER NOTIFICATION BEGAN AUGUST 14, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR OLDSMOBILE AT 1-800-442-6537.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6RQ04006 · Windshield Wiper Failure
Opened Jul 7, 2004 · Closed Jan 13, 2005
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:linkages
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
Additional source detail variants (2)
Visibility:windshield Wiper/washer
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
Visibility:windshield Wiper/washer:linkages
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
RQ03001 · Power Rack And Pinion Steering Failure
Opened Jan 2, 2003 · Closed Sep 15, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Additional source detail variants (2)
Steering
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
EA00019 · Windshield Wiper
Opened Jul 12, 2000 · Closed Mar 6, 2001
Status: closed (inferred from source dates) · Visibility
ON FEBRUARY 22, 2000, THE OFFICE OF DEFECTS INVESTIGATION (ODI) INITIATED PE00-009 BASED ON SEVEN REPORTS OF WINDSHIELD WIPER FAILURE IN CERTAIN MODEL YEAR (MY) 1997 & 1998 CHEVROLET MALIBU & OLDSMOBILE CUTLASS VEHICLES.THE INVESTIGATION WAS UPGRADED TO EA00-019 ON JULY 12, 2000.DURING THE COURSE OF THE INVESTIGATION, IT WAS FOUND THAT THE FAILURES WERE THE RESULT OF FRACTURE OF THE PASSENGER-SIDE WINDSHIELD WIPER PIVOT HOUSING (SUBJECT COMPONENT).SUCH A FRACTURE LED TO AN IMMEDIATE AND IRRECOVERABLE LOSS OF WINDSHIELD WIPER FUNCTION.GMREPORTED THAT THE MATERIAL COMPOSITION (50% GLASS-REINFORCED ACETAL) OF THE SUBJECT COMPONENT WAS INSUFFICIENT TO WITHSTAND STRESSES IMPOSED BY CERTAIN FROZEN PRECIPITIATION ACCUMULATIONS.THE SUBJECT COMPONENT MATERIAL WAS CHANGED TO THE STRONGER 50% GLASS-REINFORCEDNYLON-6, EFFECTIVE JANUARY 98.OBSOLETE SERVICE PART WERE DISCARDED.GM WILL REPLACE THE SUBJECT COMPONENTS IN 129,427 SUBJECT VEHICLES FOUND IN 28 STATES (AK, CO, CT, DE, ID, IL, IN, IA ME, MD, MA, MI, MN, MT, NE, NH, NJ, NY, ND, OH, PA, RI, SD, UT, VT, WV, WI, WY), THE DISTRICT OF COLUMBIA, AND ALL CANADIAN PROVINCES.THESE STATES ACCOUNTED FOR 91% OF THE CONSUMER COMPLAINTS IDENTIFIED ABOVE.ODI WILL MONITOR THIS COMPAIGN FOR ADEQUATE EFFCTIVENESS AND, IF NECESSARY, TAKE FURTHER ACTION IN THE FUTURE.FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS MATTER IS UNJUSTIFIED AT THIS TIME.THE ENGINEERING ANALYSIS IS CLOSED.
EA00010 · Stop Lamp Assembly Overheat
Opened Mar 27, 2000 · Closed Aug 9, 2001
Status: closed (inferred from source dates) · Exterior Lighting
There is no summary currently available
PE00009 · Windshield Wiper
Opened Feb 22, 2000 · Closed Jul 12, 2000
Status: closed (inferred from source dates) · Visibility
There is no summary currently available
PE99071 · Stop Lamp
Opened Nov 17, 1999 · Closed Mar 27, 2000
Status: closed (inferred from source dates) · Exterior Lighting
There is no summary currently available
Illustration