NHTSA owner reports · September 18, 2026 snapshot.
Equipment complaints
37 reportsClear category filterMileage unknown · Oct 1, 2014
EquipmentFuel System, GasolineService Brakes, Hydraulic
1998 CHEVROLET MALIBU. CONSUMER WRITES TO EXPRESS DISCONTENT WITH LOCAL DEALERSHIP. *TGW THE CONSUMER STATED THE BRAKE WAS SPONGY, THE ABS LIGHT ILLUMINATED AND THE AC WORKED ERRATICALLY, DEPENDING ON THE BLOWER SPEED AND WOULD SOMETIMES QUIT BLOWING COLD AIR AND WOULD START TO BLOW WARM AIR. THE CONSUMER STATED THE BRAKE FLUI…
Read full complaint
1998 CHEVROLET MALIBU. CONSUMER WRITES TO EXPRESS DISCONTENT WITH LOCAL DEALERSHIP. *TGW THE CONSUMER STATED THE BRAKE WAS SPONGY, THE ABS LIGHT ILLUMINATED AND THE AC WORKED ERRATICALLY, DEPENDING ON THE BLOWER SPEED AND WOULD SOMETIMES QUIT BLOWING COLD AIR AND WOULD START TO BLOW WARM AIR. THE CONSUMER STATED THE BRAKE FLUID WAS VERY LOW. THE DEALER WAS UNABLE TO FIND ANY BRAKE FLUID LEAKS. HOWEVER, TWO MONTHS LATER WHILE DRIVING, THE BRAKE PEDAL WENT TO THE FLOOR, BECAUSE THE FLUID HAD LEAKED OUT AGAIN. THE BRAKE LINES WERE REPLACED. IN ADDITION, TO THE BRAKE LINE ISSUE, THE SWAY BAR WAS BROKEN, A FUEL LINE WAS LEAKING AND THE LEFT REAR STRUT HAD FAILED. *JB
NHTSA ODI #10639977
75,000 miles · Aug 16, 2009
Equipment
THE AC CONTROL KEEPS ON JUMPING FRONT INSIDE AIR TO OUTSIDE AIR, AND THESE CAUSED THE COMPRESSOR TO CYCLE ON AND OFF, BOUGHT A NEW ONE FROM THE DEALER COST 150.00 NO WARRANTY STILL KEEPS ON DOING THE SAME THING, GOT ANOTHER ONE FROM THE JUNK YARD STILL DOES THE SAME THING, SPENT 200.00 DOLLARS ON AC COMPRESSOR BUT AC DOES NOT WO…
Read full complaint
THE AC CONTROL KEEPS ON JUMPING FRONT INSIDE AIR TO OUTSIDE AIR, AND THESE CAUSED THE COMPRESSOR TO CYCLE ON AND OFF, BOUGHT A NEW ONE FROM THE DEALER COST 150.00 NO WARRANTY STILL KEEPS ON DOING THE SAME THING, GOT ANOTHER ONE FROM THE JUNK YARD STILL DOES THE SAME THING, SPENT 200.00 DOLLARS ON AC COMPRESSOR BUT AC DOES NOT WORK BECAUSE OF THESE PROBLEM , DO NOT KNOW WHAT TO DO, I NEED HELP! *TR
NHTSA ODI #10280582
65,000 miles · Jul 1, 2005
EquipmentEquipment Adaptive/mobilityService Brakes, Hydraulic
AT THE BEGINNING OF THIS YEAR, I BOUGHT A 1998 CHEVY MALIBU, 2.4 L, 4 CYL, SEDAN. SHORTLY AFTER PURCHASING THE VEHICLE I BEGAN HAVING A PROBLEM WITH THE ABS LIGHT COMMMING ON AND MY BRAKES WERE GRINDING REALLY BAD. I TOOK THE VEHICLE BACK TO THE DEALER THAT I BOUGHT IT FROM THE DAY MY WARRENTY WAS TO RUN OUT. THEY SUPPOSIDLY RES…
Read full complaint
AT THE BEGINNING OF THIS YEAR, I BOUGHT A 1998 CHEVY MALIBU, 2.4 L, 4 CYL, SEDAN. SHORTLY AFTER PURCHASING THE VEHICLE I BEGAN HAVING A PROBLEM WITH THE ABS LIGHT COMMMING ON AND MY BRAKES WERE GRINDING REALLY BAD. I TOOK THE VEHICLE BACK TO THE DEALER THAT I BOUGHT IT FROM THE DAY MY WARRENTY WAS TO RUN OUT. THEY SUPPOSIDLY RESET THE ABS SYSTEM BECAUSE IT DID THROW THEM A CODE. THE FOLLOWING DAY THE SAME PROBLEM OCCURED. I HAVE HAD NOTHING BUT PROBLEMS WITH THE ABS SINCE I PURCHASED THE VEHICLE. I'VE ALSO BEEN HAVING A PROBLEM WITH THE AIR COMPRESSOR. IT MAKES AN AWFUL NOISE. THE DEALER I PURCHASED THE VEHICLE FROM ALSO SUPPOSIDLY REPLACED THE COMPRESSOR WITH A USED ONE. THE COMPRESSOR IS STILL MAKING THE SAME NOISE AS IF THEY NEVER REPLACED IT. BUT THESE REPAIRS WERE DONE ON MY LAST DAY OF MY WARRENTY SO THE DEALER WILL NOT HAVE ANYTHING TO DO WITH THE PROBLEMS ANYMORE. I LOVE MY VEHICLE, IT IS PERFECT FOR THE SIZE FAMILY THAT I HAVE AND IT IS A VERY BEAUTIFUL VEHICLE BUT THE ISSUES I AM HAVING WITH IT ARE ALMOST NOT WORTH DEALING WITH. SOMETHING NEEDS TO BE DONE.
NHTSA ODI #10127305
139,400 miles · Apr 20, 2005
EquipmentPower Train
1) NORMAL DRIVING CONDITIONS, MOSTLY HIGHWAY. 2) FAILURE OF THE HUB ASSEMBLY. VERY NOISY, REDUCED NOISE AROUND CORNERS. 3) THIS HUB HAS BEEN REPLACED THREE TIMES AND IT NEEDS TO BE REPLACED AGAIN. I HAVE SEARCHED FOR ANY RECALLS ON THIS AND COULD NOT FIND ANY. IT HAS BEEN 25000 MILES SINCE IT WAS REPLACED LAST AND THIS IS TOTA…
Read full complaint
1) NORMAL DRIVING CONDITIONS, MOSTLY HIGHWAY. 2) FAILURE OF THE HUB ASSEMBLY. VERY NOISY, REDUCED NOISE AROUND CORNERS. 3) THIS HUB HAS BEEN REPLACED THREE TIMES AND IT NEEDS TO BE REPLACED AGAIN. I HAVE SEARCHED FOR ANY RECALLS ON THIS AND COULD NOT FIND ANY. IT HAS BEEN 25000 MILES SINCE IT WAS REPLACED LAST AND THIS IS TOTALLY UNACCEPTABLE AND EXPENSIVE. WAS TOLD THAT CONTINUED DRIVING COULD CAUSE MORE DAMAGE INCLUDING ABS SYSTEM. INCIDENT DATE BELOW CORRESPONDS TO THE LASTEST TIME HUB FAILED. HAVE NOT HAD IT REPLACED YET, SO PART IS STILL AVAILABLE.*AK
NHTSA ODI #10118160
Mileage unknown · Apr 20, 2004
Electrical SystemEquipmentExterior Lighting
WHEN THE GAS TANK WAS FULL THE GAS GAUGE READ EMPTY AND WHEN THE GAS TANK WAS EMPTY THE GAS GAUGE READ FULL. *AK THE STEERING WHEEL MADE NOISES, THE A/C LIGHT DID NOT STAY ON AND THE A/C BLEW HOT AIR WHEN THE BUTTON WAS NOT ACTIVATED, THE KEY WOULD COME OUT OF THE IGNITION AND WOULD NOT STAY IN AND THE VEHICLE WOULD STILL DR…
Read full complaint
WHEN THE GAS TANK WAS FULL THE GAS GAUGE READ EMPTY AND WHEN THE GAS TANK WAS EMPTY THE GAS GAUGE READ FULL. *AK THE STEERING WHEEL MADE NOISES, THE A/C LIGHT DID NOT STAY ON AND THE A/C BLEW HOT AIR WHEN THE BUTTON WAS NOT ACTIVATED, THE KEY WOULD COME OUT OF THE IGNITION AND WOULD NOT STAY IN AND THE VEHICLE WOULD STILL DRIVE WITHOUT THE KEY IN THE IGNITION. THE BRAKES WOULD HAVE TO BE REPLACED AT LEAST TWICE A YEAR, THE ANTENNA DID NOT PICK UP AN ADEQUATE NUMBER OF STATIONS, (CASE EFFICIENCY DECREASED FROM 350 TO 250 TO REFILL THE CAN), WHEN TWO BATTERIES WERE REPLACED, THE GAS GAUGE DID NOT WORK, AND CONDENSATION WOULD SET IN THE REAR LIGHTS AND BURNED THEM OUT. *SC *JB
NHTSA ODI #10053978
93,000 miles · Mar 30, 2004
EquipmentService Brakes, Hydraulic
ABS LIGHT ILLUMINATED, AND THE BRAKE PEDAL HAD TO BE PRESSED DOWN TO THE FLOOR FOR THE VEHICLE TO STOP. ALSO, AIR CONDITIONER TURNED ON/OFF ON ITS OWN. *AK
NHTSA ODI #10065255
40,000 miles · Mar 23, 2004
EquipmentPower TrainSteering
AUTOMATIC TRANSMISSION, POWER STEERING, AND A/C CONTROLS. *AK
NHTSA ODI #10063708
Mileage unknown · Jan 26, 2004
Equipment
THE HEATER ONLY BLOWS ON SETTING 5. RESEARCH INDICATES THE POSSIBILITY OF MELTED RESISTOR. SEEMS TO BE A COMMON, RECURRING PROBLEM WITH MALIBUS. *LA
NHTSA ODI #10054931
Mileage unknown · Nov 7, 2003
EquipmentService Brakes, Hydraulic
FACTORY ALARM SYSTEM MODULE FAILS CONSTANTLY CAUSES FUEL INJECTORS TO QUIT FOR ABOUT 10-20 MIN. "THEFT SYSTEM" LIGHT BLINKS, ONCE IT'S DONE BLINKING IT MIGHT START THE CAR, OR IT MIGHT FAIL AGAIN CAUSING ANOTHER 10-20 MIN. LAG PERIOD. A/C ALSO BLOWS COLD AIR WHEN OFF, AND HOT AIR WHEN ON AT TIMES. A/C ALSO TURNS IT'S SELF OFF AN…
Read full complaint
FACTORY ALARM SYSTEM MODULE FAILS CONSTANTLY CAUSES FUEL INJECTORS TO QUIT FOR ABOUT 10-20 MIN. "THEFT SYSTEM" LIGHT BLINKS, ONCE IT'S DONE BLINKING IT MIGHT START THE CAR, OR IT MIGHT FAIL AGAIN CAUSING ANOTHER 10-20 MIN. LAG PERIOD. A/C ALSO BLOWS COLD AIR WHEN OFF, AND HOT AIR WHEN ON AT TIMES. A/C ALSO TURNS IT'S SELF OFF AND ON FROM TIME TO TIME. BRAKES SEEM TO GIVE OUT IN THE MIDDLE OF BRAKING. ALMOST HAD AN ACCIDENT BECAUSE OF IT. *LA
NHTSA ODI #10045707
68,719 miles · Oct 23, 2003
Engine And Engine CoolingEquipmentSteering
I HAD TO HAVE THE RACK & PINION SYSTEM REPLACED ON MY 1998 MALIBU ALONG WITH THE POWER STEERING PUMP PULLEY DUE TO BEING WORN THRU AND UNSAFE TO DRIVE BY THE SERVICE TECHINICIANS RECOMMENDATION. THIS WAS DONE AT 68719 MILES. I ALSO HAD THE INTAKE VALVES REPLACED 2 MONTHS AGO FOR THE SECOND TIME DUE TO LEAKAGE OF LOTS OF OIL INT…
Read full complaint
I HAD TO HAVE THE RACK & PINION SYSTEM REPLACED ON MY 1998 MALIBU ALONG WITH THE POWER STEERING PUMP PULLEY DUE TO BEING WORN THRU AND UNSAFE TO DRIVE BY THE SERVICE TECHINICIANS RECOMMENDATION. THIS WAS DONE AT 68719 MILES. I ALSO HAD THE INTAKE VALVES REPLACED 2 MONTHS AGO FOR THE SECOND TIME DUE TO LEAKAGE OF LOTS OF OIL INTO THE ENGINE, ALSO PER THE SERVICE TECHNICIANS RECOMMENDATION. THIS WAS ONLY 14 MONTHS AFTER IT WAS DONE THE LAST TIME. I HAVE MY SERVICE DONE AT A CHEVROLET DEALERSHIP AND I THINK THAT 68719 MILES IS LOW MILEAGE TO HAVE TO REPLACE THE RACK & PINION SYSTEM. I ALSO THINK THAT I WAS GIVEN FAULTY INTAKE VALVES ON THE ORIGINAL ENGINE AND ALSO ON THE FIRST REPLACEMENT. I AM ALSO TAKING MY CAR BACK FOR THE 3RD VISIT TO TRY AND FIX THE CHIRPING SOUND THAT IS COMING FROM THE ENGINE. I ALSO REPLACED THE SERPENTINE BELT AND BEARINGS 2 MONTHS AGO WHEN THE INTAKE VALVES WERE DONE. *LA
NHTSA ODI #10043404
Official recalls
3Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Dec 11, 2003
CERTAIN PASSENGER VEHICLES HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE RETAINERS COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR PONTIAC AT 1-800-620-7668.
Mar 8, 2001
ON CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE "SALT BELT" STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, AND WYOMING. IF A BUILDUP OF SNOW OR ICE RESTRICTS THE MOVEMENT OF THE PASSENGER SIDE WINDSHIELD WIPER ARM, THE PIVOT HOUSING CAN CRACK AND THE WIPERS WILL NOT OPERATE.
Consequence & remedy
Consequence: REDUCED VISIBILITY IN INCLEMENT WEATHER COULD LEAD TO A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE PASSENGER SIDE WINDSHIELD WIPER PIVOT HOUSING. OWNER NOTIFICATION BEGAN AUGUST 14, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR OLDSMOBILE AT 1-800-442-6537.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6RQ04006 · Windshield Wiper Failure
Opened Jul 7, 2004 · Closed Jan 13, 2005
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:linkages
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
Additional source detail variants (2)
Visibility:windshield Wiper/washer
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
Visibility:windshield Wiper/washer:linkages
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
RQ03001 · Power Rack And Pinion Steering Failure
Opened Jan 2, 2003 · Closed Sep 15, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Additional source detail variants (2)
Steering
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
EA00019 · Windshield Wiper
Opened Jul 12, 2000 · Closed Mar 6, 2001
Status: closed (inferred from source dates) · Visibility
ON FEBRUARY 22, 2000, THE OFFICE OF DEFECTS INVESTIGATION (ODI) INITIATED PE00-009 BASED ON SEVEN REPORTS OF WINDSHIELD WIPER FAILURE IN CERTAIN MODEL YEAR (MY) 1997 & 1998 CHEVROLET MALIBU & OLDSMOBILE CUTLASS VEHICLES.THE INVESTIGATION WAS UPGRADED TO EA00-019 ON JULY 12, 2000.DURING THE COURSE OF THE INVESTIGATION, IT WAS FOUND THAT THE FAILURES WERE THE RESULT OF FRACTURE OF THE PASSENGER-SIDE WINDSHIELD WIPER PIVOT HOUSING (SUBJECT COMPONENT).SUCH A FRACTURE LED TO AN IMMEDIATE AND IRRECOVERABLE LOSS OF WINDSHIELD WIPER FUNCTION.GMREPORTED THAT THE MATERIAL COMPOSITION (50% GLASS-REINFORCED ACETAL) OF THE SUBJECT COMPONENT WAS INSUFFICIENT TO WITHSTAND STRESSES IMPOSED BY CERTAIN FROZEN PRECIPITIATION ACCUMULATIONS.THE SUBJECT COMPONENT MATERIAL WAS CHANGED TO THE STRONGER 50% GLASS-REINFORCEDNYLON-6, EFFECTIVE JANUARY 98.OBSOLETE SERVICE PART WERE DISCARDED.GM WILL REPLACE THE SUBJECT COMPONENTS IN 129,427 SUBJECT VEHICLES FOUND IN 28 STATES (AK, CO, CT, DE, ID, IL, IN, IA ME, MD, MA, MI, MN, MT, NE, NH, NJ, NY, ND, OH, PA, RI, SD, UT, VT, WV, WI, WY), THE DISTRICT OF COLUMBIA, AND ALL CANADIAN PROVINCES.THESE STATES ACCOUNTED FOR 91% OF THE CONSUMER COMPLAINTS IDENTIFIED ABOVE.ODI WILL MONITOR THIS COMPAIGN FOR ADEQUATE EFFCTIVENESS AND, IF NECESSARY, TAKE FURTHER ACTION IN THE FUTURE.FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS MATTER IS UNJUSTIFIED AT THIS TIME.THE ENGINEERING ANALYSIS IS CLOSED.
EA00010 · Stop Lamp Assembly Overheat
Opened Mar 27, 2000 · Closed Aug 9, 2001
Status: closed (inferred from source dates) · Exterior Lighting
There is no summary currently available
PE00009 · Windshield Wiper
Opened Feb 22, 2000 · Closed Jul 12, 2000
Status: closed (inferred from source dates) · Visibility
There is no summary currently available
PE99071 · Stop Lamp
Opened Nov 17, 1999 · Closed Mar 27, 2000
Status: closed (inferred from source dates) · Exterior Lighting
There is no summary currently available
Illustration