IllustrationHORN INOPERABLE. ENTIRE AIRBAG ASSEMBLY REPLACED AND HORN STILL HAS PROBLEMS.
1998 Chevrolet Malibu
Owner reports · Recalls · Investigations
More warning signs than most Malibu years
Owner complaints for the 1998 Chevrolet Malibu are substantially higher than the model-year median of 310.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Malibu years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 223 of 976 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 347 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 144 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 130 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
34 crash reports5 fire reports18 injury reports
Electrical System complaints
130 reportsWHEN I AM DRIVING THE CAR, ALL THE LIGHTS ON THE DASH(PANEL) LIGHT UP AND THE SPEEDOMETER STARTS GOING CRAZY. ONE MINUTE IT SHOWS THAT I AM TRAVELING 10 MILES AN HOURS THEN IN A SPLIT SECOND IT SHOWS THAT I AM GOING 110 MILES AN HOUR. ALL THE OTHER GAUGES START GOING BACK AND FORTH AS WELL. I HAVE NO IDEA HOW FAST I AM GOING …
Read full complaint
WHEN I AM DRIVING THE CAR, ALL THE LIGHTS ON THE DASH(PANEL) LIGHT UP AND THE SPEEDOMETER STARTS GOING CRAZY. ONE MINUTE IT SHOWS THAT I AM TRAVELING 10 MILES AN HOURS THEN IN A SPLIT SECOND IT SHOWS THAT I AM GOING 110 MILES AN HOUR. ALL THE OTHER GAUGES START GOING BACK AND FORTH AS WELL. I HAVE NO IDEA HOW FAST I AM GOING OR IF MY CAR IS ABOUT TO JUST QUIT COMPLETELY. WHEN I FIRST BROUGHT MY CAR, ABOUT A YEAR LATER OR SO (AND I AM JUST ESTIMATING) THE DASH BOARD STARTED ACTING CRAZY BUT I JUST BLUE IT OFF. THEN I WAS TRAVELING TO DALLAS TO LOOK FOR A PLACE TO LIVE AND THE LIGHTS ALL COME ON AND THE SPEED WENT CRAZY THEN THE CAR STARTED TO DIE. I MADE IT TO THE DEALERSHIP BEFORE IT DIED. THEY STATED IT WAS THE ALTNERATOR, THAT WAS REPLACED. IT WORKED FINE FOR A WHILE THEN IT HAPPENED AGAIN. I TOOK IT TO THE DEALERSHIP IN SAN ANGELO AND THEY SAID THERE WAS AN ELECTRICAL SHORT. THAT WAS FIXED AND IT DIDN'T HAPPEN FOR A WHILE THEN IT HAPPENED AGAIN YESTERDAY (10/3/99). I AM A SINGLE PARENT AND I TRAVEL A LOT BACK AND FORTH FROM DALLAS TO SAN ANGELO. I AM ABSOLUTELY A NEVEROUS WRECK WHEN DRIVING MY CAR. I NEVER KNOW WHEN IT'S GOING TO ACT UP AND LEAVE MY DAUGTHER AND I STRANDED ALONG THE HIGHWAY. PLEAS HELP ME....... HAS THIS HAPPENED TO OTHER MALIBU OWNERS???????
WHEN IGNITION TURNED TO ACCESSORY POSITION, THE SHIFT LEVER CAN BE MOVED TO ANY GEAR WITHOUT PUSHING THE BRAKE PEDAL AND THE BRAKE LOCKS UP WHEN THE CAR ROLLS BACKWARDS. THE CAR ROLLED BACKWARDS ALMOST HITTING A CAR. THIS IS DANGEROUS AND COULD BE A TRAGIC SITUATION FOR SMALL CHILDREN IF UNATTENDED OR SENIOR CITIZENS UNAWARE THI…
Read full complaint
WHEN IGNITION TURNED TO ACCESSORY POSITION, THE SHIFT LEVER CAN BE MOVED TO ANY GEAR WITHOUT PUSHING THE BRAKE PEDAL AND THE BRAKE LOCKS UP WHEN THE CAR ROLLS BACKWARDS. THE CAR ROLLED BACKWARDS ALMOST HITTING A CAR. THIS IS DANGEROUS AND COULD BE A TRAGIC SITUATION FOR SMALL CHILDREN IF UNATTENDED OR SENIOR CITIZENS UNAWARE THIS COULD HAPPEN. *AK
IT SEEMS AS THOUGH SOONER I GET ONE THING FIXED AND ANOTHER GOES WRONG. I WANT GM TO PURCHASE THE CAR BACK. IT IS TO THE POINT I AM AFAID TO EVEN GET INTO THE CAR ANYMORE. *AK
MY VEHICLE'S BRAKE LIGHT STOPPED WORKING WHILE I WAS DRIVING. MY EMERGENCY BRAKE WARNING LIGHT WOULD NOT WORK ON MY DASH BOARD. MY IGNITION SWITCH ON MY VEHICLE WOULD NOT WORK SOMETIMES.
PURCHASE 07/24/98 CASH PAYMENT $18,239.24...CAR HAD 152 MILES AT THAT TIME..WITHING A FEW DAYS OF OWING THE CAR BRAKE PEDAL WAS MAKING CONSTANT NOISE WHEN APPLYING...I TOOK IT IN TO THE GARAGE AND THEY OILED IT AND IT CONTINUED 8-7-98 LUBRICATED BRAKE HAD RENT A CAR AND THEY ORDERED NEW ASSEMBLY..8-11-98 NEW ASSEMBLEY INSTALLED …
Read full complaint
PURCHASE 07/24/98 CASH PAYMENT $18,239.24...CAR HAD 152 MILES AT THAT TIME..WITHING A FEW DAYS OF OWING THE CAR BRAKE PEDAL WAS MAKING CONSTANT NOISE WHEN APPLYING...I TOOK IT IN TO THE GARAGE AND THEY OILED IT AND IT CONTINUED 8-7-98 LUBRICATED BRAKE HAD RENT A CAR AND THEY ORDERED NEW ASSEMBLY..8-11-98 NEW ASSEMBLEY INSTALLED AND THE BRAKE STILL MADE THE NOISE...FINALLY RENT A CAR AGAIN THEY FOUND OUT 8-18-98 THAT MASTER CYLINDER LEAKING..HAD TO REPLACE POWER BOASTER AND MASTER CYLINDER AND LUBED FRONT CALIPERS AND ADJUSTED THE BRAKES....ALSO I HAVE CONSTANT SQUEAL NOISE AND PULLING OF BRAKES IN THE BACK WHEN APPLY AND MUSHING SOUND...THEY ADJUSTED AND CLEANED AND STILL DOES IT COLD WET WARM DOES NOT MATTER...THE MANAGER CALLED AND SAID THAT THERE WASN'T MUCH ELSE THEY COULD DO FOR IT. BETWEEN ALL THIS THE DASH BOARD WAS WARPPED AND REPLACED, BACK TAIL GASKET KEPT COMING OFF AFTER SEVERAL VISITS TO THE CHEV. PLACE THEY ORDERD AND REPLACED THE WARP GASKET....THEN THE GASKET SEAL AROUND THE BACK WINDOW WAS COMING OFF...HE GLUED IT DOWN...I HAVE MENTIONED TO THEM IT STARTED FUNNY AT TIMES AND HE SAID COUNT TO 15 SECONDS AND THAT WOULD BE NORMAL...SO EVERYTIME I GET INTO THE CAR I AM CONCERNED IS IT GOING TO START OR NOT..FINALLY 3/12/99 I GOT INTO THE CAR TO DO MY ERRANDS AND IT WOULD NOT CRANK OVER AND START AFTER SEVERAL TRIES IT FINALLY STARTED AND I CALLED AND THE CAR IS AGAIN IN THE GARAGE I NOW HAVE A RENT A CAR AGAIN AND WILL NOT KNOW WHAT THE PROBLEM IS UNTIL NEXT WEEK. ALSO THE WIRE THAT HOLDS THE GAS CAP WHEN YOU PUMP GAS BROKE OFF. THE FIRST FEW MONTHS OF OWNING THE CAR AND TRYING TO REPAIR THE PROBLEMS AND GET TO WORK AND RENT A CAR AND CONTINUE ON WITH LIFE HAVE BEEN DISRUPTED. ALL I WANTED TO DO WAS BUY A NEW CAR BE ABLE TO TRUST IT AND NOT END UP GOING EVERY OTHER WEEK IN FOR THIS OR THAT. I HAVE TALKED TO THE MANAGER AND HAVE FILED A CLAIM 980 503 718 TO GET A REFUND. I HATE THE CAR ITS JUNK.
1.}FRONT BRAKES ARE PREMATURLEY WEARING OUT WITHIN 20 MILES. 2.}TRANAXLE SHAFT SEAL IS LEAKING OIL,PART WAS REPLACED. 3.}RADIATOR COOLANT RESERVOIR BUSTED, CAUSING THE COOLANT TO LEAK. 4.}INTAKE MANIFOLD IS LEAKING. 5.}IGINTION WIRING HAD TO REPLACED. 6.}AIR DISTRUBUTOR COMPLETELY FAILED WHICH IS NOT PULLING IN AIR. *AK
WIRING HARNESS CHIME SWITCH FAILED. YH
PCM FAILED. YH
IGNITION SWITCH FAILED. YH
Official recalls
314V400000 · Electrical System:ignition
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
03V527000 · Steering:rack And Pinion
Dec 11, 2003
CERTAIN PASSENGER VEHICLES HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE RETAINERS COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR PONTIAC AT 1-800-620-7668.
01V068000 · Visibility:windshield Wiper/washer:linkages
Mar 8, 2001
ON CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE "SALT BELT" STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, AND WYOMING. IF A BUILDUP OF SNOW OR ICE RESTRICTS THE MOVEMENT OF THE PASSENGER SIDE WINDSHIELD WIPER ARM, THE PIVOT HOUSING CAN CRACK AND THE WIPERS WILL NOT OPERATE.
Consequence & remedy
Consequence: REDUCED VISIBILITY IN INCLEMENT WEATHER COULD LEAD TO A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE PASSENGER SIDE WINDSHIELD WIPER PIVOT HOUSING. OWNER NOTIFICATION BEGAN AUGUST 14, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR OLDSMOBILE AT 1-800-442-6537.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6RQ04006 · Windshield Wiper Failure
Opened Jul 7, 2004 · Closed Jan 13, 2005
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:linkages
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
Additional source detail variants (2)
Visibility:windshield Wiper/washer
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
Visibility:windshield Wiper/washer:linkages
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
RQ03001 · Power Rack And Pinion Steering Failure
Opened Jan 2, 2003 · Closed Sep 15, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Additional source detail variants (2)
Steering
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
EA00019 · Windshield Wiper
Opened Jul 12, 2000 · Closed Mar 6, 2001
Status: closed (inferred from source dates) · Visibility
ON FEBRUARY 22, 2000, THE OFFICE OF DEFECTS INVESTIGATION (ODI) INITIATED PE00-009 BASED ON SEVEN REPORTS OF WINDSHIELD WIPER FAILURE IN CERTAIN MODEL YEAR (MY) 1997 & 1998 CHEVROLET MALIBU & OLDSMOBILE CUTLASS VEHICLES.THE INVESTIGATION WAS UPGRADED TO EA00-019 ON JULY 12, 2000.DURING THE COURSE OF THE INVESTIGATION, IT WAS FOUND THAT THE FAILURES WERE THE RESULT OF FRACTURE OF THE PASSENGER-SIDE WINDSHIELD WIPER PIVOT HOUSING (SUBJECT COMPONENT).SUCH A FRACTURE LED TO AN IMMEDIATE AND IRRECOVERABLE LOSS OF WINDSHIELD WIPER FUNCTION.GMREPORTED THAT THE MATERIAL COMPOSITION (50% GLASS-REINFORCED ACETAL) OF THE SUBJECT COMPONENT WAS INSUFFICIENT TO WITHSTAND STRESSES IMPOSED BY CERTAIN FROZEN PRECIPITIATION ACCUMULATIONS.THE SUBJECT COMPONENT MATERIAL WAS CHANGED TO THE STRONGER 50% GLASS-REINFORCEDNYLON-6, EFFECTIVE JANUARY 98.OBSOLETE SERVICE PART WERE DISCARDED.GM WILL REPLACE THE SUBJECT COMPONENTS IN 129,427 SUBJECT VEHICLES FOUND IN 28 STATES (AK, CO, CT, DE, ID, IL, IN, IA ME, MD, MA, MI, MN, MT, NE, NH, NJ, NY, ND, OH, PA, RI, SD, UT, VT, WV, WI, WY), THE DISTRICT OF COLUMBIA, AND ALL CANADIAN PROVINCES.THESE STATES ACCOUNTED FOR 91% OF THE CONSUMER COMPLAINTS IDENTIFIED ABOVE.ODI WILL MONITOR THIS COMPAIGN FOR ADEQUATE EFFCTIVENESS AND, IF NECESSARY, TAKE FURTHER ACTION IN THE FUTURE.FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS MATTER IS UNJUSTIFIED AT THIS TIME.THE ENGINEERING ANALYSIS IS CLOSED.
EA00010 · Stop Lamp Assembly Overheat
Opened Mar 27, 2000 · Closed Aug 9, 2001
Status: closed (inferred from source dates) · Exterior Lighting
There is no summary currently available
PE00009 · Windshield Wiper
Opened Feb 22, 2000 · Closed Jul 12, 2000
Status: closed (inferred from source dates) · Visibility
There is no summary currently available
PE99071 · Stop Lamp
Opened Nov 17, 1999 · Closed Mar 27, 2000
Status: closed (inferred from source dates) · Exterior Lighting
There is no summary currently available