NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
443 reports142,200 miles · Jan 4, 2013
Visibility/wiper
TL* THE CONTACT OWNS A 1997 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING IN RAINY WEATHER, THE WINDSHIELD WIPERS FAILED. THE CONTACT STATED THAT THE WIPERS CROSSED OVER EACH OTHER AND STOPPED WORKING. THE CONTACT THEN MOVED OFF THE ROADWAY AND MANUALLY DISLODGED THE WIPERS HOWEVER, THEY WOULD NOT MOVE. THE VEHICLE WAS…
Read full complaint
TL* THE CONTACT OWNS A 1997 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING IN RAINY WEATHER, THE WINDSHIELD WIPERS FAILED. THE CONTACT STATED THAT THE WIPERS CROSSED OVER EACH OTHER AND STOPPED WORKING. THE CONTACT THEN MOVED OFF THE ROADWAY AND MANUALLY DISLODGED THE WIPERS HOWEVER, THEY WOULD NOT MOVE. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION WHERE THEY STATED THAT THE LINKAGES NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THE VEHICLE WAS NOT INCLUDED IN ANY RECALL. THE FAILURE MILEAGE WAS 142,200.
NHTSA ODI #10491459
Mileage unknown · Oct 26, 2012
Electrical SystemEngineFuel/propulsion System
CAR GOES INTO LOCKDOWN FREQUENTLY BECAUSE OF THE THEFT ALERT SYSTEM AND YOU HAVE TO WAIT 10 MINUTES BEFORE THE CAR WILL START. I BELIEVE THIS IS A SAFETY CONCERN AND POTENTIAL HAZARD TO ANYONE IS OPERATING THIS VEHICLE. I CALLED DEALERSHIP TO DISCUSS THIS PROBLEM AND THERE REPLY IS "WELL THE CAR IS OLD AND YOU NEED TO SEE ABOU…
Read full complaint
CAR GOES INTO LOCKDOWN FREQUENTLY BECAUSE OF THE THEFT ALERT SYSTEM AND YOU HAVE TO WAIT 10 MINUTES BEFORE THE CAR WILL START. I BELIEVE THIS IS A SAFETY CONCERN AND POTENTIAL HAZARD TO ANYONE IS OPERATING THIS VEHICLE. I CALLED DEALERSHIP TO DISCUSS THIS PROBLEM AND THERE REPLY IS "WELL THE CAR IS OLD AND YOU NEED TO SEE ABOUT PURCHASING ANOTHER ONE". I GOT THIS REPLY IN 2007. I HAVE ALSO RESEARCHED IT ON THE INTERNET AND FOUND THAT THIS IS A COMMON PROBLEM IN CHEVY MALIBU'S, WHICH TO ME CONSTITUTES A MANUFACTURING DEFECT AS WELL AS A SAFETY CONCERN. *TR
NHTSA ODI #10482296
126,930 miles · Jan 6, 2012
Electrical System
TL* THE CONTACT OWNS A 1997 CHEVROLET MALIBU. THE CONTACT WAS HAVING THE VEHICLE SERVICED AND WHEN THE BATTERY WAS DISCONNECTED, THE FUEL GAUGE NEEDLE BECAME STUCK. THE FAILURE OCCURRED TWICE. A PRIVATE MECHANIC WAS ABLE TO REPAIR THE VEHICLE AFTER THE FIRST FAILURE. THE DEALER WAS CONTACTED ABOUT THE FAILURE AND ADVISED THE CON…
Read full complaint
TL* THE CONTACT OWNS A 1997 CHEVROLET MALIBU. THE CONTACT WAS HAVING THE VEHICLE SERVICED AND WHEN THE BATTERY WAS DISCONNECTED, THE FUEL GAUGE NEEDLE BECAME STUCK. THE FAILURE OCCURRED TWICE. A PRIVATE MECHANIC WAS ABLE TO REPAIR THE VEHICLE AFTER THE FIRST FAILURE. THE DEALER WAS CONTACTED ABOUT THE FAILURE AND ADVISED THE CONTACT THAT THE FAILURE COULD HAVE HAPPENED DUE TO A SPIKE IN VOLTAGE WHEN THE BATTERY WAS RECONNECTED WITH THE KEY LEFT IN THE RUN POSITION. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 126,930.
NHTSA ODI #10442659
115,000 miles · May 3, 2011
Electrical System
ANTI THEFT SYSTEM ARMS AND DISARMS RANDOMLY, CAUSING THE CAR TO NOT START OR STALL OUT. *TR
NHTSA ODI #10398827
146,534 miles · Dec 8, 2010
Engine And Engine CoolingSteering
INTAKE MANIFOLD ON MY 1997 CHEVY MALIBU HAS STARTED TO GO BAD I KNOW ITS THE LOWER GASKET I CALLED CHEVY AFTER SEEING SO MANY OTHER PEOPLE WITH THE SAME PROBLEM I WAS TOLD CHEVY WOULD NOT REPLACE IT DUE TO IT BEING OVER TEN YEARS OLD WELL IT SEEMS LIKE WITH WAS A PROBLEM WAITING TO HAPPEN AS SOON AS THEY SEALED THE MANIFOLD AT T…
Read full complaint
INTAKE MANIFOLD ON MY 1997 CHEVY MALIBU HAS STARTED TO GO BAD I KNOW ITS THE LOWER GASKET I CALLED CHEVY AFTER SEEING SO MANY OTHER PEOPLE WITH THE SAME PROBLEM I WAS TOLD CHEVY WOULD NOT REPLACE IT DUE TO IT BEING OVER TEN YEARS OLD WELL IT SEEMS LIKE WITH WAS A PROBLEM WAITING TO HAPPEN AS SOON AS THEY SEALED THE MANIFOLD AT THE FACTORY I THINK GM SHOULD REPLACE THIS ITEM ONCE FREE OF CHARGE PER CAR ALSO MY RACK AND PINION SEEMS TO STICK ON MY LEFT SIDE I'VE REPLACED THE POWER STEERING PUMP AND CHECKED THE RACK AND PINION SEEMS THE BALL BEARING WANTING TO COME OUT OR IS GONE I TOLD GM I DON'T THINK THEY REPLACED IT WHEN THEY RECALLED IT AND THEY TOLD ME THE FIRST OWNER DID BUT WONT SEND ME PAPERWORK ON THE REPAIR OR THE DEALERSHIP THAT DID THE WORK. *TR
NHTSA ODI #10369571
159,598 miles · Oct 19, 2010
Tires
TL*THE CONTACT OWNS A 1997 CHEVROLET MALIBU. WHILE DRIVING 60 MPH THE VEHICLE WAS SHAKING AND VIBRATING ON THE REAR DRIVER SIDE. THE VEHICLE WAS TAKEN TO A DEALER TIRE SHOP AND AFTER INSPECTING IT THEY FOUND THAT THE REAR DRIVER SIDE TIRE WAS WARPED AND HAD TREAD SEPARATION. THE BRAND NAME WAS LARAMIE, MODEL, PERFORMER HP, SIZE…
Read full complaint
TL*THE CONTACT OWNS A 1997 CHEVROLET MALIBU. WHILE DRIVING 60 MPH THE VEHICLE WAS SHAKING AND VIBRATING ON THE REAR DRIVER SIDE. THE VEHICLE WAS TAKEN TO A DEALER TIRE SHOP AND AFTER INSPECTING IT THEY FOUND THAT THE REAR DRIVER SIDE TIRE WAS WARPED AND HAD TREAD SEPARATION. THE BRAND NAME WAS LARAMIE, MODEL, PERFORMER HP, SIZE 235/60R15. THE DEALER WHERE THE TIRE WAS PURCHASE WAS NOT NOTIFIED. THE MANUFACTURER WAS CALLED AND CONFIRMED BASED ON THE DOT NUMBER THAT THE TIRE WAS NOT ON RECALL. THE FAILURE MILEAGE WAS 159,598.
NHTSA ODI #10361180
150,000 miles · Jul 8, 2010
Equipment
TL*THE CONTACT OWNS A 1997 CHEVROLET MALIBU. THE CONTACT WAS DRIVING APPROXIMATELY BETWEEN 5 TO 10 MPH AND ENCOUNTERED SEVERAL SPEED BUMPS IN THE ROADWAY. IMMEDIATELY AFTER DRIVING OVER THE SPEED BUMPS THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE WOULD NOT RESTART AND WAS TOWED TO HIS RESIDENCE. THE CONTACT STATED THAT THE FA…
Read full complaint
TL*THE CONTACT OWNS A 1997 CHEVROLET MALIBU. THE CONTACT WAS DRIVING APPROXIMATELY BETWEEN 5 TO 10 MPH AND ENCOUNTERED SEVERAL SPEED BUMPS IN THE ROADWAY. IMMEDIATELY AFTER DRIVING OVER THE SPEED BUMPS THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE WOULD NOT RESTART AND WAS TOWED TO HIS RESIDENCE. THE CONTACT STATED THAT THE FAILURE WAS CONTRIBUTED TO THE ANTI-THEFT PATH LOCK. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED WHEN THE COMPLAINT WAS FILED. THE FAILURE MILEAGE WAS 150,000.
NHTSA ODI #10341948
135,000 miles · Feb 22, 2010
Electrical System
I HAVE A 1997 CHEVY MALIBU. RECENTLY, THE ANTI-THEFT LIGHT HAS BEEN COMING ON AND DISABLING THE ENGINE. THERE IS NO FIX FOR THIS PROBLEM PER THE DEALERSHIP AND THE ONLY OPTION I HAVE IS TO DISCONNECT THE BATTERY AND RECONNECT IT. THIS ISN'T EVER CONVENIENT AND IS A MAJOR SAFETY ISSUE. *TR
NHTSA ODI #10312785
75,000 miles · Aug 8, 2009
Engine And Engine Cooling
CAR ENGINE OVERHEATING NOT DUE TO THERMOSTAT OR WATER PUMP. *TR
NHTSA ODI #10279791
53,900 miles · Apr 17, 2009
Engine And Engine Cooling
I HAVE A 1997 CHEVY MALIBU (54,000) MILES THAT SEIZED UP IN TRAFFIC DUE TO ANTIFREEZE IN THE OIL. I HAVE RECENTLY LEARNED THAT THE ANTIFREEZE (DEXA-COOL) USE BY GM HAS A LONG HISTORY OF CAUSING PREMATURE ENGINE FAILURES BY EATING AWAY THE GASKETS, WATER PUMPS AND OTHER ASSOCIATED ENGINE COOLING COMPONENTS. I?M NOT ABLE TO TAKE A…
Read full complaint
I HAVE A 1997 CHEVY MALIBU (54,000) MILES THAT SEIZED UP IN TRAFFIC DUE TO ANTIFREEZE IN THE OIL. I HAVE RECENTLY LEARNED THAT THE ANTIFREEZE (DEXA-COOL) USE BY GM HAS A LONG HISTORY OF CAUSING PREMATURE ENGINE FAILURES BY EATING AWAY THE GASKETS, WATER PUMPS AND OTHER ASSOCIATED ENGINE COOLING COMPONENTS. I?M NOT ABLE TO TAKE ADVANTAGE OF THE CLASS ACTION LAW SUIT SINCE MY PROBLEM HAPPENED LONG AFTER THE CLOSING DATE. I FEEL A NATIONAL RECALL SHOULD BE INITIATED BY NHTSA. *TR
NHTSA ODI #10265876
Official recalls
4Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Dec 11, 2003
CERTAIN PASSENGER VEHICLES HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE RETAINERS COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR PONTIAC AT 1-800-620-7668.
Mar 8, 2001
ON CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE "SALT BELT" STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, AND WYOMING. IF A BUILDUP OF SNOW OR ICE RESTRICTS THE MOVEMENT OF THE PASSENGER SIDE WINDSHIELD WIPER ARM, THE PIVOT HOUSING CAN CRACK AND THE WIPERS WILL NOT OPERATE.
Consequence & remedy
Consequence: REDUCED VISIBILITY IN INCLEMENT WEATHER COULD LEAD TO A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE PASSENGER SIDE WINDSHIELD WIPER PIVOT HOUSING. OWNER NOTIFICATION BEGAN AUGUST 14, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR OLDSMOBILE AT 1-800-442-6537.
Jun 28, 1997
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE FASTENERS THAT SECURE THE PASSENGER AIR BAG MODULE TO THE INSTRUMENT PANEL TIE BAR WERE OMITTED.
Consequence & remedy
Consequence: IF THE AIR BAG DEPLOYS, THE MODULE COULD SEPARATE FROM THE INSTRUMENT PANEL STRIKING AND INJURING AN OCCUPANT.
Remedy: DEALERS WILL INSPECT THE AIR BAG MODULE FOR THE PRESENCE OF THE FASTENERS AND, IF NECESSARY, INSTALL ANY FASTENERS THAT MAY HAVE BEEN OMITTED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7RQ04006 · Windshield Wiper Failure
Opened Jul 7, 2004 · Closed Jan 13, 2005
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:linkages
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
Additional source detail variants (2)
Visibility:windshield Wiper/washer
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
Visibility:windshield Wiper/washer:linkages
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
RQ03001 · Power Rack And Pinion Steering Failure
Opened Jan 2, 2003 · Closed Sep 15, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Additional source detail variants (2)
Steering
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
EA02003 · Power Rack And Pinion Steering Failure
Opened Apr 4, 2002 · Closed Dec 10, 2002
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
THE LOWER PINION BEARING IN THE RACK AND PINION STEERING ASSEMBLY MAY FAIL.GM WILL RECALL 1997-98 GRAND PRIX BUILT BETWEEN 1-MAR-96 AND 31-OCT-97; AND 1996-98 U-VANS/J-CARS BUILT BETWEEN 1-JAN-96 AND 31-OCT-97.SEE ATTACHED SUMMARY.
Additional source detail variants (2)
Steering
THE LOWER PINION BEARING IN THE RACK AND PINION STEERING ASSEMBLY MAY FAIL.GM WILL RECALL 1997-98 GRAND PRIX BUILT BETWEEN 1-MAR-96 AND 31-OCT-97; AND 1996-98 U-VANS/J-CARS BUILT BETWEEN 1-JAN-96 AND 31-OCT-97.SEE ATTACHED SUMMARY.
Steering:rack And Pinion
THE LOWER PINION BEARING IN THE RACK AND PINION STEERING ASSEMBLY MAY FAIL.GM WILL RECALL 1997-98 GRAND PRIX BUILT BETWEEN 1-MAR-96 AND 31-OCT-97; AND 1996-98 U-VANS/J-CARS BUILT BETWEEN 1-JAN-96 AND 31-OCT-97.SEE ATTACHED SUMMARY.
PE01038 · Steering Rack And Pinion
Opened Nov 14, 2001 · Closed Apr 4, 2002
Status: closed (inferred from source dates) · Steering
ODI HAS RECEIVED 200 COMPLAINTS FROMT CONSUMERS AND 1,238 FROM GM ALLEGING FAILURE OR LOCKUP OF THE STEERING RACK AND PINION UNIT (R&P).THIS ALLEGED CONDITION CAN RESULT IN THE LOSS OF STEERING CONTROL OF THE VEHICLE AND A CRASH CAN RESULT.GM HAS REPORTED SIX CRASHES IN WHICH EIGHT PEOPLE HAVE SUSTAINED INJURIES RANGING FROM BRUISES, AIRBAG BURN, SEAT BELT ABRASION, FACIAL INJURY, NECK AND BACK PAIN.ALL CRASHES WERE SINGLE VEHICLE CRASHES.GM STATES THAT ONE POSSIBLE FAILURE MODE IS FAILURE OF THE LOWER PINION BEARING IN THE R&P.AN ENGINEERING ANALYSIS HAS BEEN OPENED TO DETERMINE IF A SAFETY DEFECT TREND EXISTS.
EA00019 · Windshield Wiper
Opened Jul 12, 2000 · Closed Mar 6, 2001
Status: closed (inferred from source dates) · Visibility
ON FEBRUARY 22, 2000, THE OFFICE OF DEFECTS INVESTIGATION (ODI) INITIATED PE00-009 BASED ON SEVEN REPORTS OF WINDSHIELD WIPER FAILURE IN CERTAIN MODEL YEAR (MY) 1997 & 1998 CHEVROLET MALIBU & OLDSMOBILE CUTLASS VEHICLES.THE INVESTIGATION WAS UPGRADED TO EA00-019 ON JULY 12, 2000.DURING THE COURSE OF THE INVESTIGATION, IT WAS FOUND THAT THE FAILURES WERE THE RESULT OF FRACTURE OF THE PASSENGER-SIDE WINDSHIELD WIPER PIVOT HOUSING (SUBJECT COMPONENT).SUCH A FRACTURE LED TO AN IMMEDIATE AND IRRECOVERABLE LOSS OF WINDSHIELD WIPER FUNCTION.GMREPORTED THAT THE MATERIAL COMPOSITION (50% GLASS-REINFORCED ACETAL) OF THE SUBJECT COMPONENT WAS INSUFFICIENT TO WITHSTAND STRESSES IMPOSED BY CERTAIN FROZEN PRECIPITIATION ACCUMULATIONS.THE SUBJECT COMPONENT MATERIAL WAS CHANGED TO THE STRONGER 50% GLASS-REINFORCEDNYLON-6, EFFECTIVE JANUARY 98.OBSOLETE SERVICE PART WERE DISCARDED.GM WILL REPLACE THE SUBJECT COMPONENTS IN 129,427 SUBJECT VEHICLES FOUND IN 28 STATES (AK, CO, CT, DE, ID, IL, IN, IA ME, MD, MA, MI, MN, MT, NE, NH, NJ, NY, ND, OH, PA, RI, SD, UT, VT, WV, WI, WY), THE DISTRICT OF COLUMBIA, AND ALL CANADIAN PROVINCES.THESE STATES ACCOUNTED FOR 91% OF THE CONSUMER COMPLAINTS IDENTIFIED ABOVE.ODI WILL MONITOR THIS COMPAIGN FOR ADEQUATE EFFCTIVENESS AND, IF NECESSARY, TAKE FURTHER ACTION IN THE FUTURE.FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS MATTER IS UNJUSTIFIED AT THIS TIME.THE ENGINEERING ANALYSIS IS CLOSED.
EA00010 · Stop Lamp Assembly Overheat
Opened Mar 27, 2000 · Closed Aug 9, 2001
Status: closed (inferred from source dates) · Exterior Lighting
There is no summary currently available
PE00009 · Windshield Wiper
Opened Feb 22, 2000 · Closed Jul 12, 2000
Status: closed (inferred from source dates) · Visibility
There is no summary currently available
Illustration