NHTSA owner reports · September 18, 2026 snapshot.
Visibility complaints
41 reportsClear category filter93,986 miles · Dec 30, 2008
Visibility
TL*THE CONTACT OWNS A 1997 CHEVROLET MALIBU. WHILE DRIVING APPROXIMATELY 40 MPH IN INCLEMENT WEATHER CONDITIONS, THE PIVOT HOUSING FRACTURED AND CAUSED THE WIPERS TO FAIL. AS A CONSEQUENCE, THE CONTACT'S VISIBILITY WAS SIGNIFICANTLY REDUCED AND THE RISK OF A CRASH WAS INCREASED. THE DEALER STATED THAT HIS VIN WAS EXCLUDED FRO…
Read full complaint
TL*THE CONTACT OWNS A 1997 CHEVROLET MALIBU. WHILE DRIVING APPROXIMATELY 40 MPH IN INCLEMENT WEATHER CONDITIONS, THE PIVOT HOUSING FRACTURED AND CAUSED THE WIPERS TO FAIL. AS A CONSEQUENCE, THE CONTACT'S VISIBILITY WAS SIGNIFICANTLY REDUCED AND THE RISK OF A CRASH WAS INCREASED. THE DEALER STATED THAT HIS VIN WAS EXCLUDED FROM NHTSA CAMPAIGN ID NUMBER 01V068000 (VISIBILITY:WINDSHIELD WIPER/WASHER:LINKAGES). THE CONTACT PAID $380.68 TO REPLACE THE WINDSHIELD WIPER PIVOT HOUSING. THE MANUFACTURER DID NOT ASSIST. THE FAILURE AND CURRENT MILEAGES WERE 93,986. UPDATED 1/26/09 *CN UPDATED 01/26/09. *JB
NHTSA ODI #10253189
Mileage unknown · Mar 13, 2007
Electrical SystemSteeringVisibility
MY FIANCE AND I HAVE HAD A 1997 CHEVY MALIBU FOR A YEAR AND A HALF. ABOUT A MONTH AFTER PURCHASING IT, THE VEHICLE STARTED HAVING PROBLEMS WITH THE PASSLOCK THEFT SYSTEM THAT WOULD LEAVE US STRANDED FOR 10 MINUTES BECAUSE THE CAR WOULDN'T CRANK. GRADUALLY IT STARTED DOING IT MORE AND MORE. WE'VE HAD INCIDENTS WHERE THE THEFT SYS…
Read full complaint
MY FIANCE AND I HAVE HAD A 1997 CHEVY MALIBU FOR A YEAR AND A HALF. ABOUT A MONTH AFTER PURCHASING IT, THE VEHICLE STARTED HAVING PROBLEMS WITH THE PASSLOCK THEFT SYSTEM THAT WOULD LEAVE US STRANDED FOR 10 MINUTES BECAUSE THE CAR WOULDN'T CRANK. GRADUALLY IT STARTED DOING IT MORE AND MORE. WE'VE HAD INCIDENTS WHERE THE THEFT SYSTEM LIGHT WOULD GO OFF AFTER 10 MINUTES BUT WHEN TRYING TO START IT AGAIN; IT WOULD DO THE SAME THING. I'VE ACTUALLY HAD TIMES OF BEING STRANDED FOR 2 HOURS BECAUSE IT WOULD KEEP DOING IT! RIGHT NOW OUR CAR IS AT MY FIANCE'S WORK BECAUSE IT WON'T CRANK AND WE GOT TIRED OF TRYING AFTER 3 HOURS. THIS IS SO ANNOYING! CHEVROLET SHOULD BE ASHAMED OF THEMSELVES! I KNOW A LOT OF PEOPLE THAT HAVE HAD THIS SAME PROBLEM(NOT COUNTING ALL THE OTHER PROBLEMS LIKE THE BRAKES AND WINDSHIELD WIPERS). WITH SO MANY PEOPLE HAVING THE SAME PROBLEM..THAT MEANS THEY SHOULD RECALL IT AND FIX IT. WE DON'T HAVE MONEY LIKE THEY DO AND CAN'T AFFORD TO KEEP PUTTING IT IN THE SHOP TO BE WORKED ON. I'M CURRENTLY A COLLEGE PELL GRANT RECIPIENT THAT IS GOING TO LOSE MY GRANTS BECAUSE OF THIS LEMON CAR! I WAS ADOPTED BY MY GRANDPARENTS THAT ARE ON SSI AND DISABILITY AND THEY CAN'T AFFORD TO SEND ME TO SCHOOL. I HOPE THE PEOPLE AT CHEVROLET ARE HAPPY WITH RUINING MY FUTURE! PLEASE HELP ME!!!I NEED MY CAR FIXED BEFORE IT'S TOO LATE!*JB
NHTSA ODI #10185005
162,300 miles · Jan 19, 2007
Visibility
I AM THE OWNER OF A 1997 CHEVY MALIBU. ONE DAY WHILE I WAS DRIVING AROUND TOWN, IT WAS RAINING, AND MY WINDSHIELD WIPER ARM FLEW OFF OF THE CAR. I LOOKED UP RECALLS ON YOUR SITE AND FOUND THAT THERE IS A RECALL FOR THE PROBLEM I HAVE. I CONTACTED CHEVROLET AND THEY TOLD ME THAT THERE IS NO SUCH RECALL FOR MY CAR. I DON'T FEEL I …
Read full complaint
I AM THE OWNER OF A 1997 CHEVY MALIBU. ONE DAY WHILE I WAS DRIVING AROUND TOWN, IT WAS RAINING, AND MY WINDSHIELD WIPER ARM FLEW OFF OF THE CAR. I LOOKED UP RECALLS ON YOUR SITE AND FOUND THAT THERE IS A RECALL FOR THE PROBLEM I HAVE. I CONTACTED CHEVROLET AND THEY TOLD ME THAT THERE IS NO SUCH RECALL FOR MY CAR. I DON'T FEEL I SHOULD HAVE TO PAY FOR REPLACEMENT PARTS IF THERE IS A RECALL ON DEFECTIVE PARTS. THE NHTSA CAMPAIGN ID # IS 01V068000
NHTSA ODI #10179121
Mileage unknown · Mar 26, 2005
Visibility
THERE IS A RECALL ON MY 1997 CHEVY MALIBU FOR THE WINDSHIELD WIPERS AND I HAVE HAD THEM BREAK DO TO THE RECALL BUT THE DEALER IN MY TOWN WILL NOT COVER THE RECALL BECAUSE I DO NOT HAVE THE VIN NUMBER THAT IS LISTED IN THE RECALLS AND I LIVE IN THE STATE OF MISSOURI. JUST BECAUSE SOMEONE HAS NOT REPORTED IT FROM MISSOURI ABOUT TH…
Read full complaint
THERE IS A RECALL ON MY 1997 CHEVY MALIBU FOR THE WINDSHIELD WIPERS AND I HAVE HAD THEM BREAK DO TO THE RECALL BUT THE DEALER IN MY TOWN WILL NOT COVER THE RECALL BECAUSE I DO NOT HAVE THE VIN NUMBER THAT IS LISTED IN THE RECALLS AND I LIVE IN THE STATE OF MISSOURI. JUST BECAUSE SOMEONE HAS NOT REPORTED IT FROM MISSOURI ABOUT THIS HAPPENING DOES NOT MEAN IT SHOULD NOT BE COVERED. THE EXACT THING THAT IS SAID TO HAPPEN TO THE WIPERS ON THE RECALL HAS HAPPENED TO MINE AND IT WILL COST ME 150.00 TO REPLACE THE WHOLE SYSTEM THAT BROKE. I WANT THIS PROBLEM FIXED SO I CAN GET MY CAR FIXED. PLEASE AD MISSOURI TO THE LIST AND ALSO ALL CHEVY MALIBUS IN 1997 SHOULD BE COVERED UNDER THIS RECALL AS IT HAS HAPPENED TO ME.!!!*AK
NHTSA ODI #10114784
96,000 miles · Mar 18, 2005
Visibility
RECALL 01V068000 CONCERNING WINDSHIELD WIPER ARM. FRONT WINDSHIELD WIPERS STOPPED OPERATING DURING INCLEMENT CONDITIONS. DEALER WAS NOTIFIED, BUT DEALER INFORMED THE CONSUMER THAT THIS VEHICLE WAS NOT COVERED UNDER THE RECALL DUE TO VIN. *AK *NM
NHTSA ODI #10107008
Mileage unknown · Nov 24, 2004
Visibility
1997 CHEVROLET MALIBU WIPERS THE PART BROKE FROM THE ARM CALLED CHEVROLET PLACE IN BOAZ ALABAMA TO CHECK IF THEY HAD A RECALL HE CHECKED AND SAID NO. *NM
NHTSA ODI #10100458
Mileage unknown · May 25, 2004
Electrical SystemEngine And Engine CoolingExterior Lighting
MY FIRST ISSUE IS WITH THE LIGHTS ON THE MALIBU. MY LIGHT DEVELOPED CONDENSATION IN THEM WHICH IN THE REAR CAUSED THE LIGHT TO GLOW DIM, AND CAUSED E TO GET PULLED OVER ON A NUMBER OF TIMES. IN THE FRONT IT HAS CAUSED THE GLASS SHIELD TO FOG CAUSING ME TO FAIL VEHICLE INSPECTION. THERE HAVE ARE MANY OTHER ELECTRICAL MALFUNCTIONS…
Read full complaint
MY FIRST ISSUE IS WITH THE LIGHTS ON THE MALIBU. MY LIGHT DEVELOPED CONDENSATION IN THEM WHICH IN THE REAR CAUSED THE LIGHT TO GLOW DIM, AND CAUSED E TO GET PULLED OVER ON A NUMBER OF TIMES. IN THE FRONT IT HAS CAUSED THE GLASS SHIELD TO FOG CAUSING ME TO FAIL VEHICLE INSPECTION. THERE HAVE ARE MANY OTHER ELECTRICAL MALFUNCTIONS ON MY CAR SUCH AS THE THEFT LOCK SYSTEM, THE POWER MOON ROOF, THE MANUFACTURER'S CD PLAYER, THE HEADLIGHT CONTROL SWITCH. THEN IT HAS A PROBLEM WITH EMISSIONS. THE HEADLINER IS FALLING OFF THE CEILING. *NM
NHTSA ODI #10073144
Mileage unknown · Apr 20, 2004
Visibility
WHILE DRIVING IN INCLEMENT WEATHER, THE WINDSHIELD WIPERS STOPPED WORKING ON THEIR OWN. THE CONSUMER DROVE THE VEHICLE TO THE DEALER FOR AN INSPECTION,AND THE MECHANIC INFORMED THE DRIVER THAT THIS VEHICLE WAS NOT COVERED UNDER THE RECALL. *AK THE WIPERS ARE INOPERATIVE. *SC *JB
NHTSA ODI #10063324
109,482 miles · Mar 17, 2004
Visibility
WHILE TRAVELING ON A BUSY INTERSTATE IN VERY HEAVY RAINS AND RUSH HOUR TRAFFIC, I HEARD A LOUD NOISE AND THEN MY WIPERS WERE STOPPED & CRISS-CROSSED IN FRONT OF ME. I FELT EXTREMELY LUCKY TO GET OFF THE HIGHWAY, WITHOUT CAUSING A WRECK. LATER, I FOUND OUT THAT THERE WAS A KNOW DEFECT ON THE WIPER PIVOTS FOR MY MODEL CAR. BU…
Read full complaint
WHILE TRAVELING ON A BUSY INTERSTATE IN VERY HEAVY RAINS AND RUSH HOUR TRAFFIC, I HEARD A LOUD NOISE AND THEN MY WIPERS WERE STOPPED & CRISS-CROSSED IN FRONT OF ME. I FELT EXTREMELY LUCKY TO GET OFF THE HIGHWAY, WITHOUT CAUSING A WRECK. LATER, I FOUND OUT THAT THERE WAS A KNOW DEFECT ON THE WIPER PIVOTS FOR MY MODEL CAR. BUT REGARDLESS, THE RECALL WASN'T ANY GOOD FOR MY STATE. I DON'T UNDERSTAND THE LOGIC BEHIND THIS... IF A PART IS DEFECTIVE- IT IS DEFECTIVE. THE RECALL WAS ONLY EFFECTIVE FOR CERTAIN 'SALT-BELT' STATES, OF WHICH MY STATE ISN'T INCLUDED. I DID HOWEVER LIVE IN ONE OF THESE SALT-BELT STATES FOR SEVERAL YEARS (WITH THIS CAR). BUT WHETHER YOUR CAR IS REGISTERED IN ONE OF THOSE STATES OR NOT YOU COULD HAVE A LOT OF USE OF THE WIPERS. BETWEEN HURRICANE SEASON AND THE RAINY SEASON IN FLORIDA, WIPERS GET A WHOLE LOT OF USE DOWN HERE TOO. *NM
NHTSA ODI #10062439
91,000 miles · Feb 26, 2004
Visibility
THE WINDSHIELD WIPER LINKAGE FAILED. A RECALL HAS BEEN ISSUED HOWEVER, THE VEHICLE IDENTIFICATION NUMBER WAS NOT INCLUDED.*AK *SC *JB
NHTSA ODI #10059840
Official recalls
4Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Dec 11, 2003
CERTAIN PASSENGER VEHICLES HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE RETAINERS COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR PONTIAC AT 1-800-620-7668.
Mar 8, 2001
ON CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE "SALT BELT" STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, AND WYOMING. IF A BUILDUP OF SNOW OR ICE RESTRICTS THE MOVEMENT OF THE PASSENGER SIDE WINDSHIELD WIPER ARM, THE PIVOT HOUSING CAN CRACK AND THE WIPERS WILL NOT OPERATE.
Consequence & remedy
Consequence: REDUCED VISIBILITY IN INCLEMENT WEATHER COULD LEAD TO A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE PASSENGER SIDE WINDSHIELD WIPER PIVOT HOUSING. OWNER NOTIFICATION BEGAN AUGUST 14, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR OLDSMOBILE AT 1-800-442-6537.
Jun 28, 1997
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE FASTENERS THAT SECURE THE PASSENGER AIR BAG MODULE TO THE INSTRUMENT PANEL TIE BAR WERE OMITTED.
Consequence & remedy
Consequence: IF THE AIR BAG DEPLOYS, THE MODULE COULD SEPARATE FROM THE INSTRUMENT PANEL STRIKING AND INJURING AN OCCUPANT.
Remedy: DEALERS WILL INSPECT THE AIR BAG MODULE FOR THE PRESENCE OF THE FASTENERS AND, IF NECESSARY, INSTALL ANY FASTENERS THAT MAY HAVE BEEN OMITTED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7RQ04006 · Windshield Wiper Failure
Opened Jul 7, 2004 · Closed Jan 13, 2005
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:linkages
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
Additional source detail variants (2)
Visibility:windshield Wiper/washer
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
Visibility:windshield Wiper/washer:linkages
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
RQ03001 · Power Rack And Pinion Steering Failure
Opened Jan 2, 2003 · Closed Sep 15, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Additional source detail variants (2)
Steering
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
EA02003 · Power Rack And Pinion Steering Failure
Opened Apr 4, 2002 · Closed Dec 10, 2002
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
THE LOWER PINION BEARING IN THE RACK AND PINION STEERING ASSEMBLY MAY FAIL.GM WILL RECALL 1997-98 GRAND PRIX BUILT BETWEEN 1-MAR-96 AND 31-OCT-97; AND 1996-98 U-VANS/J-CARS BUILT BETWEEN 1-JAN-96 AND 31-OCT-97.SEE ATTACHED SUMMARY.
Additional source detail variants (2)
Steering
THE LOWER PINION BEARING IN THE RACK AND PINION STEERING ASSEMBLY MAY FAIL.GM WILL RECALL 1997-98 GRAND PRIX BUILT BETWEEN 1-MAR-96 AND 31-OCT-97; AND 1996-98 U-VANS/J-CARS BUILT BETWEEN 1-JAN-96 AND 31-OCT-97.SEE ATTACHED SUMMARY.
Steering:rack And Pinion
THE LOWER PINION BEARING IN THE RACK AND PINION STEERING ASSEMBLY MAY FAIL.GM WILL RECALL 1997-98 GRAND PRIX BUILT BETWEEN 1-MAR-96 AND 31-OCT-97; AND 1996-98 U-VANS/J-CARS BUILT BETWEEN 1-JAN-96 AND 31-OCT-97.SEE ATTACHED SUMMARY.
PE01038 · Steering Rack And Pinion
Opened Nov 14, 2001 · Closed Apr 4, 2002
Status: closed (inferred from source dates) · Steering
ODI HAS RECEIVED 200 COMPLAINTS FROMT CONSUMERS AND 1,238 FROM GM ALLEGING FAILURE OR LOCKUP OF THE STEERING RACK AND PINION UNIT (R&P).THIS ALLEGED CONDITION CAN RESULT IN THE LOSS OF STEERING CONTROL OF THE VEHICLE AND A CRASH CAN RESULT.GM HAS REPORTED SIX CRASHES IN WHICH EIGHT PEOPLE HAVE SUSTAINED INJURIES RANGING FROM BRUISES, AIRBAG BURN, SEAT BELT ABRASION, FACIAL INJURY, NECK AND BACK PAIN.ALL CRASHES WERE SINGLE VEHICLE CRASHES.GM STATES THAT ONE POSSIBLE FAILURE MODE IS FAILURE OF THE LOWER PINION BEARING IN THE R&P.AN ENGINEERING ANALYSIS HAS BEEN OPENED TO DETERMINE IF A SAFETY DEFECT TREND EXISTS.
EA00019 · Windshield Wiper
Opened Jul 12, 2000 · Closed Mar 6, 2001
Status: closed (inferred from source dates) · Visibility
ON FEBRUARY 22, 2000, THE OFFICE OF DEFECTS INVESTIGATION (ODI) INITIATED PE00-009 BASED ON SEVEN REPORTS OF WINDSHIELD WIPER FAILURE IN CERTAIN MODEL YEAR (MY) 1997 & 1998 CHEVROLET MALIBU & OLDSMOBILE CUTLASS VEHICLES.THE INVESTIGATION WAS UPGRADED TO EA00-019 ON JULY 12, 2000.DURING THE COURSE OF THE INVESTIGATION, IT WAS FOUND THAT THE FAILURES WERE THE RESULT OF FRACTURE OF THE PASSENGER-SIDE WINDSHIELD WIPER PIVOT HOUSING (SUBJECT COMPONENT).SUCH A FRACTURE LED TO AN IMMEDIATE AND IRRECOVERABLE LOSS OF WINDSHIELD WIPER FUNCTION.GMREPORTED THAT THE MATERIAL COMPOSITION (50% GLASS-REINFORCED ACETAL) OF THE SUBJECT COMPONENT WAS INSUFFICIENT TO WITHSTAND STRESSES IMPOSED BY CERTAIN FROZEN PRECIPITIATION ACCUMULATIONS.THE SUBJECT COMPONENT MATERIAL WAS CHANGED TO THE STRONGER 50% GLASS-REINFORCEDNYLON-6, EFFECTIVE JANUARY 98.OBSOLETE SERVICE PART WERE DISCARDED.GM WILL REPLACE THE SUBJECT COMPONENTS IN 129,427 SUBJECT VEHICLES FOUND IN 28 STATES (AK, CO, CT, DE, ID, IL, IN, IA ME, MD, MA, MI, MN, MT, NE, NH, NJ, NY, ND, OH, PA, RI, SD, UT, VT, WV, WI, WY), THE DISTRICT OF COLUMBIA, AND ALL CANADIAN PROVINCES.THESE STATES ACCOUNTED FOR 91% OF THE CONSUMER COMPLAINTS IDENTIFIED ABOVE.ODI WILL MONITOR THIS COMPAIGN FOR ADEQUATE EFFCTIVENESS AND, IF NECESSARY, TAKE FURTHER ACTION IN THE FUTURE.FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS MATTER IS UNJUSTIFIED AT THIS TIME.THE ENGINEERING ANALYSIS IS CLOSED.
EA00010 · Stop Lamp Assembly Overheat
Opened Mar 27, 2000 · Closed Aug 9, 2001
Status: closed (inferred from source dates) · Exterior Lighting
There is no summary currently available
PE00009 · Windshield Wiper
Opened Feb 22, 2000 · Closed Jul 12, 2000
Status: closed (inferred from source dates) · Visibility
There is no summary currently available
Illustration