NHTSA owner reports · September 18, 2026 snapshot.
Air Bags complaints
25 reportsClear category filter83,501 miles · Dec 17, 2019
Air BagsInjury
I WAS DRIVING ON A RESIDENTIAL STREET AND REALIZED I WAS GOING THE WRONG WAY. I TURNED LEFT TO MAKE A U-TURN AND DROVE ONTO THE EASEMENT (DIRT). WHEN I TURNED THE STEERING WHEEL TO THE LEFT ALL THE WAY, BOTH AIRBAGS DEPLOYED. I WAS BURNED BY THE CHEMICALS OVER THE LEFT SIDE OF MY NECK AND CHEST, LEFT EAR AND INSIDE LEFT WRIST. I…
Read full complaint
I WAS DRIVING ON A RESIDENTIAL STREET AND REALIZED I WAS GOING THE WRONG WAY. I TURNED LEFT TO MAKE A U-TURN AND DROVE ONTO THE EASEMENT (DIRT). WHEN I TURNED THE STEERING WHEEL TO THE LEFT ALL THE WAY, BOTH AIRBAGS DEPLOYED. I WAS BURNED BY THE CHEMICALS OVER THE LEFT SIDE OF MY NECK AND CHEST, LEFT EAR AND INSIDE LEFT WRIST. I WAS TRAVELING LESS THAN 5 MPH WHILE MAKING THIS TURN. THE PASSENGER AIRBAG KNOCKED MY WINDOW CAMERA OFF AND BROKE IT AND SENT PART OF A HANDHELD FAN CLIPPED TO THE PASSENGERS VISOR, INTO MY HEAD AND ENDED UP IN THE BACKSEAT. I DID NOT HIT ANYTHING AS IT WAS JUST DIRT.
NHTSA ODI #11289715
107,000 miles · Mar 2, 2015
Air BagsSeat BeltsCrashInjury
SWERVED TO AVOID A DEER AND STRUCK A GUARD RAIL, HEAD ON. AIR BAGS DIDN'T DEPLOY AND SEAT BELT DIDN'T LOCK UP. POLICE, FIRE, AMBULANCE AND TOW TRUCK DRIVER COULDN'T BELIEVE THE BAGS AND SEAT BELT FAILED. DAUGHTER WAS DRIVING AND RECEIVE A CONCUSSION, A V SHAPE CUT IN SCALP REQUIRING 17 STITCHES TO CLOSE AND SEVERE BRUISING AL…
Read full complaint
SWERVED TO AVOID A DEER AND STRUCK A GUARD RAIL, HEAD ON. AIR BAGS DIDN'T DEPLOY AND SEAT BELT DIDN'T LOCK UP. POLICE, FIRE, AMBULANCE AND TOW TRUCK DRIVER COULDN'T BELIEVE THE BAGS AND SEAT BELT FAILED. DAUGHTER WAS DRIVING AND RECEIVE A CONCUSSION, A V SHAPE CUT IN SCALP REQUIRING 17 STITCHES TO CLOSE AND SEVERE BRUISING ALL OVER. POLICE THINKS HER HEAD STRUCK THE STEERING WHEEL OR POSSIBLY THE REAR VIEW MIRROR. SLACK IN SEAT BELT ALLOWED TOO MUCH BODY MOVEMENT AND THE AIR BAGS FAILURE CAUSE THE HEAD TRAUMA. ENTIRE FRONT END OF CAR IS DESTROYED SO SENSORS SHOULD HAVE ACTIVATE. *TR
NHTSA ODI #10691665
50,000 miles · Sep 29, 2014
Air BagsStructureSuspensionCrashInjury
TL* THE CONTACT OWNS A 1997 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 50 MPH, THE FRAME SEPARATED FROM THE VEHICLE CAUSING IT TO FLIP AND CRASH INTO A TREE. THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS NOT FILED. THE CONTACT SUSTAINED HEAD AND NECK INJURIES WHICH REQUIRED MEDICAL ATTENTION. THE …
Read full complaint
TL* THE CONTACT OWNS A 1997 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 50 MPH, THE FRAME SEPARATED FROM THE VEHICLE CAUSING IT TO FLIP AND CRASH INTO A TREE. THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS NOT FILED. THE CONTACT SUSTAINED HEAD AND NECK INJURIES WHICH REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE FAILURE MILEAGE WAS 50,000.
NHTSA ODI #10639799
167,000 miles · Apr 21, 2008
Air BagsCrash
SITTING AT A RED LIGHT IN A COMPLETE STOPPED POSITION THE CAR ROLLED FORWARD WITH THE BRAKE STILL BEING DEPRESSED AND COMPLETELY WENT TO THE FLOOR AS I QUICKLY TRIED TO PUMP THE BRAKES TO STOP AND AN ONCOMING VEHICLE STRUCK ME. TROOPERS AND OTHER PERSONAL CHECKED MY BRAKES AT THE TIME OF THE ACCIDENT AND SAID THAT THERE WASN'T …
Read full complaint
SITTING AT A RED LIGHT IN A COMPLETE STOPPED POSITION THE CAR ROLLED FORWARD WITH THE BRAKE STILL BEING DEPRESSED AND COMPLETELY WENT TO THE FLOOR AS I QUICKLY TRIED TO PUMP THE BRAKES TO STOP AND AN ONCOMING VEHICLE STRUCK ME. TROOPERS AND OTHER PERSONAL CHECKED MY BRAKES AT THE TIME OF THE ACCIDENT AND SAID THAT THERE WASN'T ANY BRAKES. NO BRAKE PROBLEMS HAD BEEN EXPERIENCED PRIOR TO THIS. I WAS SEVERELY STRUCK BY THE OTHER VEHICLE WHICH COMPLETELY TURNED THE DIRECTION OF MY VEHICLE AND CAUSED TOTAL DAMAGE RESULTING IN A TOTAL LOSS. THE IMPACT WAS SO HARD, THE OTHER DRIVE WAS CITED FOR HIS HIGH-SPEED HIT TO MY VEHICLE. THE AIRBAGS NEVER DEPLOYED AND IS A GREAT CONCERN OF MINE AT THIS POINT IN TIME AS WELL AS THE BRAKE FAILURE. I RECEIVED NOTICE IN DECEMBER 2007 FROM GM THAT THERE WAS A SETTLEMENT OF A PENDING DISTRICT COURT CASE (DELMAS FORD, EL AL. V. GENERAL MOTORS CORPORATION, CASE NO. CJ-2002-424) WHICH MEANT THAT MY VEHICLE HAD TO BE SEAN BY A AUTHORIZED CHEVY DEALER TO HAVE THE 1997 CHEVY MALIBU'S SENSING AND DIAGNOSTIC MODULE REPROGRAMMED. THIS REFERRED TO TSB #07-09-41-006 DATED AUGUST 2007. I HAD THE VEHICLE SEEN AS SOON AS THERE WAS AN OPEN APPOINTMENT ON JANUARY 7, 2008 AT RANDY MARION CHEVROLET PONTIAC BUICK. SO, UPON THIS ACCIDENT TODAY, I AM WITHOUT A VEHICLE DUE TO BRAKE FAILURE AFTER ALREADY HAVE THEM REPLACED WITHIN THE LAST FOUR MONTHS AS WELL AS FAILURE OF THE AIRBAGS TO DEPLOY. I AM ALSO CONTACTING AN ATTORNEY IN REGARD TO THIS MATTER. I UNDERSTAND THERE WERE OTHER ACCIDENTS INVOLVING THIS ISSUE OF THE AIRBAGS DEPLOYING AT ODD TIMES. AFTER A NOTICE OF SETTLEMENT OF THIS CASE AND HAVING THE VEHICLE AIRBAGS CHECKED AND FIXED AS INDICATED, I AM A FEARFUL AND CONCERNED CONSUMER OF THIS INCIDENT AS I HAVE TOTAL VEHICLE LOSS AND SUFFICIENT DAMAGES. YOU WOULD THINK THAT THE AIRBAGS WOULD DEFINITELY WORK.......THEY DIDN'T DEPLOY AT ALL AS WELL AS THE BRAKES LETTING GO MID STOPLIGHT. *TR
NHTSA ODI #10225297
112,000 miles · Jun 19, 2006
Air Bags
DT*: THE CONTACT STATED THE FRONTAL AIRBAG DEPLOYED WHILE PULLING THE VEHICLE INTO THE DRIVEWAY AT 5MPH. THERE WAS NO IMPACT OR WARNING PRIOR TO THE DEPLOYMENT. THE VEHICLE HAS NOT BEEN INSPECTED AND MANUFACTURER HAS NOT BEEN ALERTED.
NHTSA ODI #10160139
62,000 miles · Sep 6, 2005
Air BagsCrash
DT: ON 07/19/2005 THE CONTACT'S VEHICLE WAS HIT FROM BEHIND WHICH CAUSED IT TO NOSE DIVE INTO A DITCH. UPON IMPACT THE AIR BAGS DID NOT DEPLOY. THERE WERE NO LIGHTS ILLUMINATED ON THE DASH PRIOR TO THE ACCIDENT. THE CONTACT DID NOT KNOW HOW FAST THE OTHER VEHICLE WAS TRAVELING AT THE TIME OF IMPACT. THE IMPACT OF THE CRASH …
Read full complaint
DT: ON 07/19/2005 THE CONTACT'S VEHICLE WAS HIT FROM BEHIND WHICH CAUSED IT TO NOSE DIVE INTO A DITCH. UPON IMPACT THE AIR BAGS DID NOT DEPLOY. THERE WERE NO LIGHTS ILLUMINATED ON THE DASH PRIOR TO THE ACCIDENT. THE CONTACT DID NOT KNOW HOW FAST THE OTHER VEHICLE WAS TRAVELING AT THE TIME OF IMPACT. THE IMPACT OF THE CRASH BENT THE VEHICLE'S DOORS AND BUSTED HE WINDSHIELD. *AK *NM
NHTSA ODI #10131099
17,026 miles · Mar 22, 2004
Air Bags
CONSUMER COMPLAINED ABOUT AN AIR BAG PROBLEM. AIR BAG LIGHT CAME ON. DEALER REPLACED THE SENSORS, AND AIR BAGS WON'T DEPLOY. DEALER WAS CHARGING $425.00 TO REPAIR THE AIR BAGS. *AK
NHTSA ODI #10064647
Mileage unknown · Feb 11, 2004
Air BagsCrash
WHILE DRIVING 20 CONSUMER CRASHED HEAD ON INTO A POLE. UPON IMPACT, AIR BAGS DID NOT DEPLOY. *AK
NHTSA ODI #10057896
100,000 miles · Oct 12, 2003
Air BagsCrashInjury
WHILE DRIVING AT 35 MPH, THE CONSUMER HIT A POT HOLE AND THEN SHE LOST CONTROL OF THE VEHICLE. THE FRONT END OF THE VEHICLE IMPACTED A DITCH AND THEN THE VEHICLE BOUNCED ONTO A FIELD. NONE OF THE FRONT AIR BAGS DEPLOYED UPON IMPACT. CONSUMER FRACTURED HER BACK. *AK *SCC
NHTSA ODI #10033728
Mileage unknown · Nov 3, 2002
Air BagsSeat BeltsCrashInjury
NO SUMMARY. DT
NHTSA ODI #769222
Official recalls
4Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Dec 11, 2003
CERTAIN PASSENGER VEHICLES HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE RETAINERS COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR PONTIAC AT 1-800-620-7668.
Mar 8, 2001
ON CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE "SALT BELT" STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, AND WYOMING. IF A BUILDUP OF SNOW OR ICE RESTRICTS THE MOVEMENT OF THE PASSENGER SIDE WINDSHIELD WIPER ARM, THE PIVOT HOUSING CAN CRACK AND THE WIPERS WILL NOT OPERATE.
Consequence & remedy
Consequence: REDUCED VISIBILITY IN INCLEMENT WEATHER COULD LEAD TO A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE PASSENGER SIDE WINDSHIELD WIPER PIVOT HOUSING. OWNER NOTIFICATION BEGAN AUGUST 14, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR OLDSMOBILE AT 1-800-442-6537.
Jun 28, 1997
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE FASTENERS THAT SECURE THE PASSENGER AIR BAG MODULE TO THE INSTRUMENT PANEL TIE BAR WERE OMITTED.
Consequence & remedy
Consequence: IF THE AIR BAG DEPLOYS, THE MODULE COULD SEPARATE FROM THE INSTRUMENT PANEL STRIKING AND INJURING AN OCCUPANT.
Remedy: DEALERS WILL INSPECT THE AIR BAG MODULE FOR THE PRESENCE OF THE FASTENERS AND, IF NECESSARY, INSTALL ANY FASTENERS THAT MAY HAVE BEEN OMITTED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7RQ04006 · Windshield Wiper Failure
Opened Jul 7, 2004 · Closed Jan 13, 2005
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:linkages
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
Additional source detail variants (2)
Visibility:windshield Wiper/washer
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
Visibility:windshield Wiper/washer:linkages
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
RQ03001 · Power Rack And Pinion Steering Failure
Opened Jan 2, 2003 · Closed Sep 15, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Additional source detail variants (2)
Steering
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
EA02003 · Power Rack And Pinion Steering Failure
Opened Apr 4, 2002 · Closed Dec 10, 2002
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
THE LOWER PINION BEARING IN THE RACK AND PINION STEERING ASSEMBLY MAY FAIL.GM WILL RECALL 1997-98 GRAND PRIX BUILT BETWEEN 1-MAR-96 AND 31-OCT-97; AND 1996-98 U-VANS/J-CARS BUILT BETWEEN 1-JAN-96 AND 31-OCT-97.SEE ATTACHED SUMMARY.
Additional source detail variants (2)
Steering
THE LOWER PINION BEARING IN THE RACK AND PINION STEERING ASSEMBLY MAY FAIL.GM WILL RECALL 1997-98 GRAND PRIX BUILT BETWEEN 1-MAR-96 AND 31-OCT-97; AND 1996-98 U-VANS/J-CARS BUILT BETWEEN 1-JAN-96 AND 31-OCT-97.SEE ATTACHED SUMMARY.
Steering:rack And Pinion
THE LOWER PINION BEARING IN THE RACK AND PINION STEERING ASSEMBLY MAY FAIL.GM WILL RECALL 1997-98 GRAND PRIX BUILT BETWEEN 1-MAR-96 AND 31-OCT-97; AND 1996-98 U-VANS/J-CARS BUILT BETWEEN 1-JAN-96 AND 31-OCT-97.SEE ATTACHED SUMMARY.
PE01038 · Steering Rack And Pinion
Opened Nov 14, 2001 · Closed Apr 4, 2002
Status: closed (inferred from source dates) · Steering
ODI HAS RECEIVED 200 COMPLAINTS FROMT CONSUMERS AND 1,238 FROM GM ALLEGING FAILURE OR LOCKUP OF THE STEERING RACK AND PINION UNIT (R&P).THIS ALLEGED CONDITION CAN RESULT IN THE LOSS OF STEERING CONTROL OF THE VEHICLE AND A CRASH CAN RESULT.GM HAS REPORTED SIX CRASHES IN WHICH EIGHT PEOPLE HAVE SUSTAINED INJURIES RANGING FROM BRUISES, AIRBAG BURN, SEAT BELT ABRASION, FACIAL INJURY, NECK AND BACK PAIN.ALL CRASHES WERE SINGLE VEHICLE CRASHES.GM STATES THAT ONE POSSIBLE FAILURE MODE IS FAILURE OF THE LOWER PINION BEARING IN THE R&P.AN ENGINEERING ANALYSIS HAS BEEN OPENED TO DETERMINE IF A SAFETY DEFECT TREND EXISTS.
EA00019 · Windshield Wiper
Opened Jul 12, 2000 · Closed Mar 6, 2001
Status: closed (inferred from source dates) · Visibility
ON FEBRUARY 22, 2000, THE OFFICE OF DEFECTS INVESTIGATION (ODI) INITIATED PE00-009 BASED ON SEVEN REPORTS OF WINDSHIELD WIPER FAILURE IN CERTAIN MODEL YEAR (MY) 1997 & 1998 CHEVROLET MALIBU & OLDSMOBILE CUTLASS VEHICLES.THE INVESTIGATION WAS UPGRADED TO EA00-019 ON JULY 12, 2000.DURING THE COURSE OF THE INVESTIGATION, IT WAS FOUND THAT THE FAILURES WERE THE RESULT OF FRACTURE OF THE PASSENGER-SIDE WINDSHIELD WIPER PIVOT HOUSING (SUBJECT COMPONENT).SUCH A FRACTURE LED TO AN IMMEDIATE AND IRRECOVERABLE LOSS OF WINDSHIELD WIPER FUNCTION.GMREPORTED THAT THE MATERIAL COMPOSITION (50% GLASS-REINFORCED ACETAL) OF THE SUBJECT COMPONENT WAS INSUFFICIENT TO WITHSTAND STRESSES IMPOSED BY CERTAIN FROZEN PRECIPITIATION ACCUMULATIONS.THE SUBJECT COMPONENT MATERIAL WAS CHANGED TO THE STRONGER 50% GLASS-REINFORCEDNYLON-6, EFFECTIVE JANUARY 98.OBSOLETE SERVICE PART WERE DISCARDED.GM WILL REPLACE THE SUBJECT COMPONENTS IN 129,427 SUBJECT VEHICLES FOUND IN 28 STATES (AK, CO, CT, DE, ID, IL, IN, IA ME, MD, MA, MI, MN, MT, NE, NH, NJ, NY, ND, OH, PA, RI, SD, UT, VT, WV, WI, WY), THE DISTRICT OF COLUMBIA, AND ALL CANADIAN PROVINCES.THESE STATES ACCOUNTED FOR 91% OF THE CONSUMER COMPLAINTS IDENTIFIED ABOVE.ODI WILL MONITOR THIS COMPAIGN FOR ADEQUATE EFFCTIVENESS AND, IF NECESSARY, TAKE FURTHER ACTION IN THE FUTURE.FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS MATTER IS UNJUSTIFIED AT THIS TIME.THE ENGINEERING ANALYSIS IS CLOSED.
EA00010 · Stop Lamp Assembly Overheat
Opened Mar 27, 2000 · Closed Aug 9, 2001
Status: closed (inferred from source dates) · Exterior Lighting
There is no summary currently available
PE00009 · Windshield Wiper
Opened Feb 22, 2000 · Closed Jul 12, 2000
Status: closed (inferred from source dates) · Visibility
There is no summary currently available
Illustration