Engine And Engine Cooling. Review the 41 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes, Hydraulic. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 8 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

9 crash reports4 fire reports8 injury reports

Tires complaints

4 reports

Clear category filter

25,000 miles · Feb 17, 2016

Tires

Read full complaint

DRIVING AT 70MPH THERE WAS A THERE WAS A LARGE INCREASE IN NOISE AND VIBRATION FOR A MINUTE FOLLOWED BY A LOUD BANG. INSPECTION REVEALED THAT AN EXPLOSIVE TIRE FAILURE HAD OCCURRED. SEVERAL PLACES ON THE SIDEWALL WERE TORN AND THE TREAD HAD BULGES ON IT. THE DEFECTIVE TIRE WAS REPLACED. 2 MONTHS LATER THE SAME BRAND AND MODEL TIRE ON THE OTHER SIDE OF THE CAR STARTED TO RUMBLE - FORTUNATELY AT ONLY 45 MPH IN TOWN. INSPECTION REVEALED THAT THERE WAS A BULGE ON THE TREAD SO THE TIRE WAS REPLACED. SINCE 2 PRIMEWELL TIRES ON THE SAME AXLE FAILED WITHIN 2 MONTHS OF EACH OTHER, I BELIEVE THIS IS MANUFACTURERS DEFECT - NOT JUST A SIMPLE COINCIDENCE.

NHTSA ODI #10836662

Mileage unknown · Jan 19, 2006

Tires

ON AUGUST 28, 2005 THE LEFT FRONT TIRE ON MY VEHICLE SUFFERED A MAJOR TREAD SEPARATION. THE ONGOING ATTEMPT TO RESOLVE THIS PROBLEM WITH THE COOPER TIRE AND RUBBER COMPANY OF FINDLAY, OHIO, IS DISTURBING TO SAY THE LEAST. IT IS MY UNDERSTANDING THAT YOUR AGENCY WISHES TO KNOW OF THESE SITUATIONS. *NM

NHTSA ODI #10144076

Mileage unknown · May 21, 2001

Engine And Engine CoolingService Brakes, HydraulicTires

Read full complaint

CAR WAS PURCHASED ON 4/23/01, UP UNTIL TODAYS DATE 5/21, I HAVE HAD THESE PROBLEMS OCCUR: 4/25 UPON BRAKING CAR WOULD SHAKE, IT WAS DETERMINED THE ROTORS WERE WARPED. 4/28, DRIVING OUT OF TOWN FRONT TIRE BLEW OUT, HAD TO REPLACE BOTH FRONT TIRES WITHIN TWO DAYSOF EACH OTHER ALONG WITH NOISE AND VIBRATION FROM BRAKING. WHILE DRIVING ON INTERSTATE LOUD ROAR AND VIBRATION NOISE COMING FROM REAR TIRES, CAR PULLING ALL OVER HIGHWAY AT SPEED OF 60MPH. 5/11 COMPLAINED TO DEALERSHIP, THEY PERFORM ALIGNMENT. CLEANING ASHTRAY, UPON REPLACING BACK PIECE BROKE. NOISE COMING FROM AC, WHEN I ACCELERATE, IT BECAME LOUDER, TURN OFF AC, NOISE WENT AWAY. CALLED CHEVROLET DEALERSHIP, FAN MOTOR NEEDED TO BE REPLACED. ROAR COMING FROM TIRES, HE STATED TIRES NEEDED TO BE REPLACED, NOT TO SURE, TREAD WEAR STILL IN GOOD SHAPE. WINDSHIELD WASHER DOES NOT WORK ON PASSENGER SIDE. WHILE SITTING AT TRAFFIC LIGHT OR STOP POSITION, CAR SEEMS AS IF IT WANTS TO SHUT OFF. THIS PAST WEEKEND 5/19, I SMELL GAS FUMES. ALSO, AFTER HAVING BRAKE INSPECTION PERFORMED, IT WAS DETERMINED THAT BRAKE PADS WERE NEEDED, HONDA SAID THEY WERE NOT, BUT TIL THIS DAY, WHEN BRAKING I HEARING SCRUBBING OR RUBBING NOISE WHEN BRAKING, AND TURNING EITHER RIGHT OR LEFT. PLEASE NOTE, I WAS NOT ABLE TO RECORD ALL THIS INFORMATION IN THE "FAILED COMPONENT PARTS" SECTION.. *AK

NHTSA ODI #745575

Mileage unknown · Nov 23, 1999

Power TrainTires

THE VEHICLE DOES NOT SEEM SAFE, THE TIRES HAVE A LOUD ROAR, AND THE CAR IS HARD TO KEEP IN THE ROAD. SOMEONE FROM ANOTHER DEALERSHIP TOLD US IT SEEMED LIKE THE WHEEL BEARINGS. COLES KNOWS THERE IS A PROBLEM WITH THE TIRES BUT SAYS THERE IS NOTHING THEY CAN DO. IT HAS BEEN CHECKED SEVERAL TIMES. I FEEL THAT THIS CAR NEEDS TO BE F…

Read full complaint

NHTSA ODI #715159

Official recalls

15V701000 · Engine And Engine Cooling:engine; Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe

Oct 26, 2015

General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.

Consequence & remedy

Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.

Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.

Additional source detail variants (2)

Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe

Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.

Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.

Engine And Engine Cooling:engine

Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.

09V116000 · Engine And Engine Cooling

Apr 8, 2009

GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.

Consequence & remedy

Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.

Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

EA02030 · Engine Compartment Fires

Opened Oct 22, 2002 · Closed Mar 9, 2004

Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.

Additional source detail variants (3)

Fuel System, Gasoline:delivery

Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

Fuel System, Gasoline