IllustrationCONSUMER IS IN THE PROCESS OF REPLACING BRAKES FOR THIRD TIME. CALIPERS ARE RUBBING ON THE TIRES, AND THE BRAKE PADS ARE WARPED. *AK
1998 Chevrolet Lumina
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1998 Chevrolet Lumina do not stand out strongly from the model-year median of 126.
About this comparison →How this year compares
Owner complaints by model year
Compare all Lumina years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
20–25K
825–50K
1350–75K
1675–100K
21100–150K
12150K+
72 reports with mileage · 151 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 56 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 33 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 33 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
8 crash reports6 fire reports6 injury reports
What owners actually said
223 reportsNO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
WHEN VEHICLE IS ON AN INCLINE TRUNK WILL CLOSE DOWN HARD, HITTING OCCUPANT. TRUNK SHOULD HAVE SOME TYPE OF A RESTRAINT, SUCH AS SHOCK ABSORBER ORA HOLD LATCH, TO PREVENT INJURY WHEN CAR IS AN INCLINE. *AK
AIRBAG MALFUNCTIONED ON DRIVER SIDE CAUSED OPERATOR TO LOSE CONTROL OF VEHICLE WHICH WENT AIRBORNE AND CRASHED. *AK
THE EVENFLO ON MY WAY INFANT CAR SEAT WAS NOT VERY SAFE ONCE INSTALLED IN ANY VEHICLE. MY INFANT SON WAS ABLE TO KICK OUT THE SEAT BELT FROM THE TOP THREAD. WE WERE UNABLE TO USE THE BASE ATTACHED TO IT SINCE IT WOULD NOT FIT IN MY CAR. ANOTHER PROBLEM THAT MAKES ME VERY FURIOUS. EVERYBODY IS SO CONCERNED IN SAFETY OF THE CAR…
Read full complaint
THE EVENFLO ON MY WAY INFANT CAR SEAT WAS NOT VERY SAFE ONCE INSTALLED IN ANY VEHICLE. MY INFANT SON WAS ABLE TO KICK OUT THE SEAT BELT FROM THE TOP THREAD. WE WERE UNABLE TO USE THE BASE ATTACHED TO IT SINCE IT WOULD NOT FIT IN MY CAR. ANOTHER PROBLEM THAT MAKES ME VERY FURIOUS. EVERYBODY IS SO CONCERNED IN SAFETY OF THE CAR SEAT ITSELF, BUT DID THEY EVER INSTALL ONE OF THESE THINGS. MOST PARENTS PREFER THE CAR SEAT TO BE INSTALLED IN THE REAR CENTER, BUT ARE UNABLE TO DO THAT BECAUSE OF THE DESIGN OF THIS SEATBELT. IS IT POSSIBLE TO MAKE THIS SEATBELT COMPLY WITH THE CAR SEAT INSTALLATIONS. FOR INSTANCE, MAKE ALL REAR CENTER SEATS A STANDARD BELT AND LATCH THAT CONFORM TO ALL CAR SEATS? *AK
IT'S DIFFICULT TO DEPRESS AND SOUND THE HORN. DEALER HAS INSPECTED THE VEHICLE SEVERAL TIMES. *AK *ML
CAR EXPLODED IN OUR GARAGE CAUSING LOSS OF TWO VEHICLES, OUR TOWNHOUSE AND OUR LIVE AS WE KNEW IT. WE HAD LESS THAN 60 SECONDS TO ESCAPE WITH OUR LIVES. THE LAST 8 MO.S OF OUR LIVES HAVE BEEN "HELL" AND IS NOT OVER YET! WE BOTH HAVE INCURRED SERIOUS MEDICAL, FINANCIAL, EMOTIONAL, QUALITY-OF LIFE AND TRAUMA/LOSSES AS A RESULT O…
Read full complaint
CAR EXPLODED IN OUR GARAGE CAUSING LOSS OF TWO VEHICLES, OUR TOWNHOUSE AND OUR LIVE AS WE KNEW IT. WE HAD LESS THAN 60 SECONDS TO ESCAPE WITH OUR LIVES. THE LAST 8 MO.S OF OUR LIVES HAVE BEEN "HELL" AND IS NOT OVER YET! WE BOTH HAVE INCURRED SERIOUS MEDICAL, FINANCIAL, EMOTIONAL, QUALITY-OF LIFE AND TRAUMA/LOSSES AS A RESULT OF THIS EVENT. IN LESS THAN 60 SECONDS OUR LIVES WERE THROWN BACK 40 YEARS! WE DO NOT WANT ANYONE ELSE TO HAVE TO THROUGH THIS NIGHTMARE THAT WE EXPERIENCING. *AK REFERENCED IN EA02-030
EXTREME PRESSURE IS REQUIRED WHEN APPLYING THE HORN WHICH COULD BECOME DANGEROUS IN EMERGENCY TRAFFIC SITUATIONS, CAUSE UNKNOWN. PLEASE GIVE ANY FURTHER DETAILS. *AK
CAR ROLLS BACKWARDS WHEN STOPPED ON SLIGHT INCLINES UNLESS THE BRAKE IS FULLY DEPRESSED. IT HAS CAUGHT ME BY SURPRISE A FEW TIMES. I WILL MENTION IT TO DEALER ON MY NEXT VISIT AS I THOUGHT THIS WAS A NORMAL THING FOR BIG CAR. STEERING COLUMN GIVES A LOUD CLUNK WHEN TURNING; IT SOUNDS LIKE IT IS NOT PROPERLY LOCKED IN THE ADJU…
Read full complaint
CAR ROLLS BACKWARDS WHEN STOPPED ON SLIGHT INCLINES UNLESS THE BRAKE IS FULLY DEPRESSED. IT HAS CAUGHT ME BY SURPRISE A FEW TIMES. I WILL MENTION IT TO DEALER ON MY NEXT VISIT AS I THOUGHT THIS WAS A NORMAL THING FOR BIG CAR. STEERING COLUMN GIVES A LOUD CLUNK WHEN TURNING; IT SOUNDS LIKE IT IS NOT PROPERLY LOCKED IN THE ADJUSTMENT POSITION. I HAVE HAD IT CHECKED AND "NOTHING WRONG" WAS FOUND. I HAVE ONLY CHANGED THE STEERING WHEEL POSITION ONCE IN 1-1/2 YRS. YET IT STILL DOES IT CONSTANTLY AND IT IS SUCH A HARD CLICK THAT I FEEL LIKE THE STEERING WHEEL IS GOING TO DROP INTO ANOTHER POSITION. I WILL REPORT IT TO THE DEALER AGAIN.
THIS PROBLEM WAS ADDRESSED PROPERLY BY THE DEALERSHIP, BUT THE PROBLEM STILL EXISTS. I WOULD APPRECIATE AN OPPORTUNITY TO DISCUSS THE PROBLEM IN DEPTH WITH A NHTSA REPRESENTATIVE DUE TO THE PROBLEM DATING BACK TO A 1993 LUMINA, A 1995 LUMINA AND NOW THE 1998 LUMINA. I HAVE HAD A LOT OF EXPERIENCE WITH BRAKE SYSTEMS AND FEEL TH…
Read full complaint
THIS PROBLEM WAS ADDRESSED PROPERLY BY THE DEALERSHIP, BUT THE PROBLEM STILL EXISTS. I WOULD APPRECIATE AN OPPORTUNITY TO DISCUSS THE PROBLEM IN DEPTH WITH A NHTSA REPRESENTATIVE DUE TO THE PROBLEM DATING BACK TO A 1993 LUMINA, A 1995 LUMINA AND NOW THE 1998 LUMINA. I HAVE HAD A LOT OF EXPERIENCE WITH BRAKE SYSTEMS AND FEEL THAT I CAN POSSIBILITY HELP TO ANSWER SOME OF THE COMPLAINTS OF DRIVERS STATING THAT THEIR BRAKE PEDAL WENT TO THE FLOOR BOARD. WHEN I HAD MY CAR SERVICED, THE SERVICEMAN STATED THAT HE HAD COMPARED MY VEHICLE BRAKES AND FOUND THEM TO BE ALMOST THE SAME AS ON THE NEW VEHICLES. I DO AGREE THAT SOME OF THE NEW VEHICLES HAVE THE SAME BLEED DOWN PROBLEM AS MY VEHICLE AND THAT IS MY CONCERN. THE SERVICE MANAGER AGREED THAT HE WAS CONCERNED ABOUT THE OPERATION OF MY BRAKES AND DECIDED TO REPLACE THE MASTER CYLINDER AND ARRANGED FOR ME TO HAVE A CAR TO KEEP ME FROM DRIVING THE CAR HOME . ALTHOUGH THE PROBLEM WAS ONLY AN UNUSUALLY FAST PEDAL BLEED DOWN THE MANAGER STATED THAT HE TOO, HAS A CONCERN ABOUT THE BRAKE PROBLEM AND HAD ORDERED A BRAKE MASTER CYLINDER. THE NEW CLYLINDER DID REDUCE THE REQUIRED BRAKING EFFORT BUT THERE IS STILL EXCESSIVE BRAKE PEDAL BLEED DOWN UNDER LIGHT PEDAL FORCE. I THINK I CAN HELP TO DETERMINE THE PROBLEM AND SUGGEST A CORRECTION. I WILL DISCUSS THIS WITH THE LEADER SERVICE MANAGER. I OWNED A 1993 LUMINA AND EXPERIENCED THE BRAKE PEDAL "GOING TO THE FLOOR BOARD" WHICH VERY NEARLY CAUSED ME TO HAVE TWO MAJOR ACCIDENTS. THE DEALERSHIP KEPT ASSURING ME THAT MY CAR BRAKES WORKED AS GOOD AS ALL THE NEW CARS. WITH THE HELP OF THE ST. LOUIS BETTER BUSINESS BUREAU AND A BRAKE TEST OFF OF OIL CHANGE RAMPS, THE BBB REPORT CONVINCED GM TO BUY BACK MY 1993 LUMINA. I FEEL THAT THE ONLY WAY TO COMMUNICATE WITH THE NHTSA IS BY REVIEWING THE MECHANICS OF THE BRAKE SYSTEM, BRAKE FLUID FLOW AND TEST PROCEDURES. PLEASE CONTACT ME FOR FURTHER INFORMATION. HOW MANY OWNERS HAVE HAD SIMILIAR PROBLEMS.
Official recalls
315V701000 · Engine And Engine Cooling:engine; Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
09V116000 · Engine And Engine Cooling
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
03V527000 · Steering:rack And Pinion
Dec 11, 2003
CERTAIN PASSENGER VEHICLES HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE RETAINERS COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR PONTIAC AT 1-800-620-7668.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA03019 · Power Rack And Pinion Steering Failure
Opened Sep 15, 2003 · Closed Dec 18, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM'S LETTER TO NHTSA DATED DECEMBER 11, 2003, EXPANDS ITS ORIGINAL RECALL (NHTSA 02V286) TO INCLUDE CERTAIN W-BODY VEHICLES: 96-97 OLDS CUTLASS SUPREME; 98 OLDS INTRIGUE; 97-98 OLDS CUTLASS; 97-98 CHEVY LUMINA, MONTE CARLO AND MALIBU; 96 PONTIAC GRAND PRIX; AND 96-98 BUICK REGAL.THE NUMBER OF VEHICLES RECALLED IS 750,283.GM DETERMINED THAT FAILURE OF THE RACK AND PINION IS RELATED TO DAMAGE OF THE LOWER PINION BEARING AND THE LEVEL OF THE PINION BEARING PRE-LOAD SPRING FORCE.GM STATES, HIGHER RACK PRE-LOAD SPRING FORCE (133 LB.) IS THE DESIGN CHARACTERISTIC MOST CLOSELY ASSOCIATED WITH HIGHER BEARING DAMAGE RATES IN MOST OF THE VEHICLE APPLICATIONS THAT USED THE GENERAL BEARING COMPANY (GBC) BEARING.ALL OF THE VEHICLES COVERED IN THE EXPANDED RECALL HAVE THE 133 LB SPRING FORCE.THE 96 LUMINA/MONTE CARLO AND 97-98 CENTURY W-BODY VEHICLES INCLUDED IN THIS INVESTIGATION UTILIZE A LOWER SPRING FORCE AND ARE NOT INCLUDED IN THE RECALL.
Additional source detail variants (2)
Steering
GM'S LETTER TO NHTSA DATED DECEMBER 11, 2003, EXPANDS ITS ORIGINAL RECALL (NHTSA 02V286) TO INCLUDE CERTAIN W-BODY VEHICLES: 96-97 OLDS CUTLASS SUPREME; 98 OLDS INTRIGUE; 97-98 OLDS CUTLASS; 97-98 CHEVY LUMINA, MONTE CARLO AND MALIBU; 96 PONTIAC GRAND PRIX; AND 96-98 BUICK REGAL.THE NUMBER OF VEHICLES RECALLED IS 750,283.GM DETERMINED THAT FAILURE OF THE RACK AND PINION IS RELATED TO DAMAGE OF THE LOWER PINION BEARING AND THE LEVEL OF THE PINION BEARING PRE-LOAD SPRING FORCE.GM STATES, HIGHER RACK PRE-LOAD SPRING FORCE (133 LB.) IS THE DESIGN CHARACTERISTIC MOST CLOSELY ASSOCIATED WITH HIGHER BEARING DAMAGE RATES IN MOST OF THE VEHICLE APPLICATIONS THAT USED THE GENERAL BEARING COMPANY (GBC) BEARING.ALL OF THE VEHICLES COVERED IN THE EXPANDED RECALL HAVE THE 133 LB SPRING FORCE.THE 96 LUMINA/MONTE CARLO AND 97-98 CENTURY W-BODY VEHICLES INCLUDED IN THIS INVESTIGATION UTILIZE A LOWER SPRING FORCE AND ARE NOT INCLUDED IN THE RECALL.
Steering:rack And Pinion
GM'S LETTER TO NHTSA DATED DECEMBER 11, 2003, EXPANDS ITS ORIGINAL RECALL (NHTSA 02V286) TO INCLUDE CERTAIN W-BODY VEHICLES: 96-97 OLDS CUTLASS SUPREME; 98 OLDS INTRIGUE; 97-98 OLDS CUTLASS; 97-98 CHEVY LUMINA, MONTE CARLO AND MALIBU; 96 PONTIAC GRAND PRIX; AND 96-98 BUICK REGAL.THE NUMBER OF VEHICLES RECALLED IS 750,283.GM DETERMINED THAT FAILURE OF THE RACK AND PINION IS RELATED TO DAMAGE OF THE LOWER PINION BEARING AND THE LEVEL OF THE PINION BEARING PRE-LOAD SPRING FORCE.GM STATES, HIGHER RACK PRE-LOAD SPRING FORCE (133 LB.) IS THE DESIGN CHARACTERISTIC MOST CLOSELY ASSOCIATED WITH HIGHER BEARING DAMAGE RATES IN MOST OF THE VEHICLE APPLICATIONS THAT USED THE GENERAL BEARING COMPANY (GBC) BEARING.ALL OF THE VEHICLES COVERED IN THE EXPANDED RECALL HAVE THE 133 LB SPRING FORCE.THE 96 LUMINA/MONTE CARLO AND 97-98 CENTURY W-BODY VEHICLES INCLUDED IN THIS INVESTIGATION UTILIZE A LOWER SPRING FORCE AND ARE NOT INCLUDED IN THE RECALL.
RQ03001 · Power Rack And Pinion Steering Failure
Opened Jan 2, 2003 · Closed Sep 15, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Additional source detail variants (2)
Steering
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.