TL* THE CONTACT OWNS A 1998 CHEVROLET LUMINA. THE CONTACT STATED THAT THERE WAS A RANDOM POWER STEERING LEAK. THE PREVIOUS OWNER HAD TO REPLACE THE FLUID CONSTANTLY. WHEN A MECHANIC REPLACED THE STEERING PUMP, THE FAILURE CONTINUED. THE MECHANIC INFORMED THE PREVIOUS OWNER THAT THE STEERING RACK MAY NEED TO BE REPLACED. THE CONT…
Read full complaint
TL* THE CONTACT OWNS A 1998 CHEVROLET LUMINA. THE CONTACT STATED THAT THERE WAS A RANDOM POWER STEERING LEAK. THE PREVIOUS OWNER HAD TO REPLACE THE FLUID CONSTANTLY. WHEN A MECHANIC REPLACED THE STEERING PUMP, THE FAILURE CONTINUED. THE MECHANIC INFORMED THE PREVIOUS OWNER THAT THE STEERING RACK MAY NEED TO BE REPLACED. THE CONTACT HAD ALSO TAKEN THE VEHICLE TO A MECHANIC WHO STATED THAT THE VEHICLE WAS INCLUDED IN A MANUFACTURER RECALL FOR NHTSA CAMPAIGN NUMBER: 03V527000 (STEERING); HOWEVER, THE RECALL WAS CLOSED. THE CONTACT WAS TO CHECK WITH THE MANUFACTURER TO DETERMINE A REPAIR SOLUTION FOR THE VEHICLE. THE FAILURE MILEAGE WAS NOT AVAILABLE.
NHTSA ODI #10967578
98,000 miles · Jul 17, 2014
Steering
DIFFICULTY TURNING THE STEERING WHEEL TO THE RIGHT AT LOW SPEEDS. CONTACTED GM AND INSTRUCTED TO TAKE THE VEHICLE TO A DEALER. CHARGED $100 AND TOLD THIS VEHICLE WAS NOT INCLUDED IN NHTSA RECALL 03V527000 DUE TO VIN. REPLACED RACK AND PINION MYSELF WHICH FIXED THE ISSUE. MY CAR SHOWS THE EXACT SAME SIGNS OF THE REASON YOU DID TH…
Read full complaint
DIFFICULTY TURNING THE STEERING WHEEL TO THE RIGHT AT LOW SPEEDS. CONTACTED GM AND INSTRUCTED TO TAKE THE VEHICLE TO A DEALER. CHARGED $100 AND TOLD THIS VEHICLE WAS NOT INCLUDED IN NHTSA RECALL 03V527000 DUE TO VIN. REPLACED RACK AND PINION MYSELF WHICH FIXED THE ISSUE. MY CAR SHOWS THE EXACT SAME SIGNS OF THE REASON YOU DID THIS RECALL. WHY WAS MY CAR NOT INCLUDED? I DEMAND AN ANSWER! *TR
NHTSA ODI #10611260
60,000 miles · May 23, 2013
Steering
TL* THE CONTACT OWNS A 1998 CHEVROLET LUMINA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 15 MPH, SHE NOTICED A GRINDING AND BANGING SOUND COMING FROM THE STEERING WHEEL. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 03V527000 (STEERING) BUT WAS ADVISED BY THE MANUFACTURER THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE…
Read full complaint
TL* THE CONTACT OWNS A 1998 CHEVROLET LUMINA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 15 MPH, SHE NOTICED A GRINDING AND BANGING SOUND COMING FROM THE STEERING WHEEL. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 03V527000 (STEERING) BUT WAS ADVISED BY THE MANUFACTURER THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 60,000. *TR
NHTSA ODI #10513309
86,000 miles · Apr 22, 2011
Steering
TL* THE CONTACT OWNS A 1998 CHEVROLET LUMINA. THE CONTACT STATED THE VEHICLE WOULD NOT STEER TO THE LEFT BECAUSE THE RACK AND PINION FAILED. THE DEALER WAS CONTACT WHO ADVISED THAT HIS VIN WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER: 03V527000 (STEERING:RACK AND PINION). THE MANUFACTURER WAS CONTACTED…
Read full complaint
TL* THE CONTACT OWNS A 1998 CHEVROLET LUMINA. THE CONTACT STATED THE VEHICLE WOULD NOT STEER TO THE LEFT BECAUSE THE RACK AND PINION FAILED. THE DEALER WAS CONTACT WHO ADVISED THAT HIS VIN WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER: 03V527000 (STEERING:RACK AND PINION). THE MANUFACTURER WAS CONTACTED AND CONFIRMED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL AND OFFERED NO FURTHER ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 86,000.
NHTSA ODI #10397149
104,000 miles · Dec 16, 2010
Steering
TL*THE CONTACT OWNS A 1998 CHEVROLET LUMINA. THE CONTACT STATED THAT THE VEHICLE BECAME DIFFICULT TO TURN, SIMILAR TO NHTSA CAMPAIGN ID NUMBER: 03V527000 ( STEERING:RACK AND PINION). THE MANUFACTURER WAS NOTIFIED AND ADVISED THE CONTACT THAT HER VEHICLE WAS NOT INCLUDED IN THE RECALL. THE CONTACT DID NOT INFORM THE DEALER. THE…
Read full complaint
TL*THE CONTACT OWNS A 1998 CHEVROLET LUMINA. THE CONTACT STATED THAT THE VEHICLE BECAME DIFFICULT TO TURN, SIMILAR TO NHTSA CAMPAIGN ID NUMBER: 03V527000 ( STEERING:RACK AND PINION). THE MANUFACTURER WAS NOTIFIED AND ADVISED THE CONTACT THAT HER VEHICLE WAS NOT INCLUDED IN THE RECALL. THE CONTACT DID NOT INFORM THE DEALER. THE VEHICLE WAS NOT REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 104,000.
NHTSA ODI #10370937
129,800 miles · Jul 11, 2009
Steering
TEMPORARY LOSS OF STEERING. ON 4 OCCASIONS WITHIN THE PAST 2 WEEKS I HAD RECENTLY LEFT MY RESIDENCE AND WAS MAKING EITHER A LEFT OR RIGHT TURN. AT THE START OF THE TURN I COULD NOT STEER THE CAR. IT WAS AS IF SOMETHING WAS BROKEN, I DID HEAR A SQUEAL. I WAS ABLE TO RETURN HOME (ABOUT 2 BLOCKS) AND AGAIN CHECKED THE POWER STEER…
Read full complaint
TEMPORARY LOSS OF STEERING. ON 4 OCCASIONS WITHIN THE PAST 2 WEEKS I HAD RECENTLY LEFT MY RESIDENCE AND WAS MAKING EITHER A LEFT OR RIGHT TURN. AT THE START OF THE TURN I COULD NOT STEER THE CAR. IT WAS AS IF SOMETHING WAS BROKEN, I DID HEAR A SQUEAL. I WAS ABLE TO RETURN HOME (ABOUT 2 BLOCKS) AND AGAIN CHECKED THE POWER STEERING FLUID AND THE SERPENTINE BELT. THE FLUID WAS CORRECT AND THE BELT IS ABOUT 8 MONTHS OLD. FOR THE RECALL #03V527000 IN 2003 I DID GO TO THE CHEVROLET DEALER IN FT. MYERS AND THEY CHECKED THE VEHICLE AND TOLD ME THAT THE CAR WAS OK. *TR
NHTSA ODI #10276403
125,000 miles · Feb 17, 2009
Electrical SystemSteering
VEHICLE WOULD NOT TURN USING THE KEY, TOOK OUR VEHICLE TO THE DEALERSHIP.. HAD A NEW KEY MADE.. THE KEY WAS NOT THE ISSUE..HAD A NEW IGNITION INSTALLED THROUGH DEALERSHIP, THE VEHICLE WORKED FOR A SHORT TIME BUT STARTING SHOWING THE SAME PROBLEMS. HUNDREDS OF $$ LATER, THE CAR IS PARKED NOW WE DON'T WANT TO PUT ANY MORE MONEY IN…
Read full complaint
VEHICLE WOULD NOT TURN USING THE KEY, TOOK OUR VEHICLE TO THE DEALERSHIP.. HAD A NEW KEY MADE.. THE KEY WAS NOT THE ISSUE..HAD A NEW IGNITION INSTALLED THROUGH DEALERSHIP, THE VEHICLE WORKED FOR A SHORT TIME BUT STARTING SHOWING THE SAME PROBLEMS. HUNDREDS OF $$ LATER, THE CAR IS PARKED NOW WE DON'T WANT TO PUT ANY MORE MONEY INTO IT, BUT CAN'T SELL IT UNLESS IT'S FIXED. THIS IS SOME SORT OF STEERING/IGNITION PROBLEM. THIS CAR HAS ALSO BEEN KNOWN TO STALL WHILE DRIVING IT. WE HAVE INSTALLED A NEW STARTER, A NEW ALTERNATOR, BATTERY WE ALSO HAD ALL THE ELECTRICAL WIRING RE-DONE.. WE DON'T KNOW WHY IT STALLS. *TR
NHTSA ODI #10259092
63,455 miles · Feb 4, 2009
Steering
RACK AND PINION.*TR
NHTSA ODI #10257416
76,800 miles · Jun 30, 2008
Steering
TL*THE CONTACT OWNS A 1998 CHEVROLET LUMINA. WHILE MAKING A LEFT TURN AT ANY SPEED, THE POWER STEERING BECOMES DIFFICULT TO MANEUVER. THE CONTACT IS AN ASC CERTIFIED MECHANIC AND STATED THAT THE FAILURE WAS WITH THE RACK AND PINION. THE DEALER STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 03V527000 (STEERIN…
Read full complaint
TL*THE CONTACT OWNS A 1998 CHEVROLET LUMINA. WHILE MAKING A LEFT TURN AT ANY SPEED, THE POWER STEERING BECOMES DIFFICULT TO MANEUVER. THE CONTACT IS AN ASC CERTIFIED MECHANIC AND STATED THAT THE FAILURE WAS WITH THE RACK AND PINION. THE DEALER STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 03V527000 (STEERING:RACK AND PINION). THE CURRENT MILEAGE WAS 78,045 AND FAILURE MILEAGE WAS 76,800.
NHTSA ODI #10232679
125,382 miles · Apr 10, 2008
Steering
TL*THE CONTACT OWNS A 1998 CHEVROLET LUMINA. WHILE DRIVING AT ANY SPEED, THE CONTACT EXPERIENCES DIFFICULTY TURNING THE STEERING WHEEL TO THE RIGHT. THE GARAGE STATED THAT THE STEERING RACK AND PINION WAS MALFUNCTIONING AND NEEDED TO BE REPLACED. THE FAILURE MILEAGE WAS 125,382. UPDATED 05/06/08. *LJ THE MANUFACTURE INFORM…
Read full complaint
TL*THE CONTACT OWNS A 1998 CHEVROLET LUMINA. WHILE DRIVING AT ANY SPEED, THE CONTACT EXPERIENCES DIFFICULTY TURNING THE STEERING WHEEL TO THE RIGHT. THE GARAGE STATED THAT THE STEERING RACK AND PINION WAS MALFUNCTIONING AND NEEDED TO BE REPLACED. THE FAILURE MILEAGE WAS 125,382. UPDATED 05/06/08. *LJ THE MANUFACTURE INFORMED THE CONSUMER HIS VEHICLE DID NOT MEET THE REQUIREMENTS FOR THE RECALL .UPDATED 05/08/08. *JB
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
CERTAIN PASSENGER VEHICLES HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE RETAINERS COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR PONTIAC AT 1-800-620-7668.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
EA03019 · Power Rack And Pinion Steering Failure
Opened Sep 15, 2003 · Closed Dec 18, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM'S LETTER TO NHTSA DATED DECEMBER 11, 2003, EXPANDS ITS ORIGINAL RECALL (NHTSA 02V286) TO INCLUDE CERTAIN W-BODY VEHICLES: 96-97 OLDS CUTLASS SUPREME; 98 OLDS INTRIGUE; 97-98 OLDS CUTLASS; 97-98 CHEVY LUMINA, MONTE CARLO AND MALIBU; 96 PONTIAC GRAND PRIX; AND 96-98 BUICK REGAL.THE NUMBER OF VEHICLES RECALLED IS 750,283.GM DETERMINED THAT FAILURE OF THE RACK AND PINION IS RELATED TO DAMAGE OF THE LOWER PINION BEARING AND THE LEVEL OF THE PINION BEARING PRE-LOAD SPRING FORCE.GM STATES, HIGHER RACK PRE-LOAD SPRING FORCE (133 LB.) IS THE DESIGN CHARACTERISTIC MOST CLOSELY ASSOCIATED WITH HIGHER BEARING DAMAGE RATES IN MOST OF THE VEHICLE APPLICATIONS THAT USED THE GENERAL BEARING COMPANY (GBC) BEARING.ALL OF THE VEHICLES COVERED IN THE EXPANDED RECALL HAVE THE 133 LB SPRING FORCE.THE 96 LUMINA/MONTE CARLO AND 97-98 CENTURY W-BODY VEHICLES INCLUDED IN THIS INVESTIGATION UTILIZE A LOWER SPRING FORCE AND ARE NOT INCLUDED IN THE RECALL.
Additional source detail variants (2)
Steering
GM'S LETTER TO NHTSA DATED DECEMBER 11, 2003, EXPANDS ITS ORIGINAL RECALL (NHTSA 02V286) TO INCLUDE CERTAIN W-BODY VEHICLES: 96-97 OLDS CUTLASS SUPREME; 98 OLDS INTRIGUE; 97-98 OLDS CUTLASS; 97-98 CHEVY LUMINA, MONTE CARLO AND MALIBU; 96 PONTIAC GRAND PRIX; AND 96-98 BUICK REGAL.THE NUMBER OF VEHICLES RECALLED IS 750,283.GM DETERMINED THAT FAILURE OF THE RACK AND PINION IS RELATED TO DAMAGE OF THE LOWER PINION BEARING AND THE LEVEL OF THE PINION BEARING PRE-LOAD SPRING FORCE.GM STATES, HIGHER RACK PRE-LOAD SPRING FORCE (133 LB.) IS THE DESIGN CHARACTERISTIC MOST CLOSELY ASSOCIATED WITH HIGHER BEARING DAMAGE RATES IN MOST OF THE VEHICLE APPLICATIONS THAT USED THE GENERAL BEARING COMPANY (GBC) BEARING.ALL OF THE VEHICLES COVERED IN THE EXPANDED RECALL HAVE THE 133 LB SPRING FORCE.THE 96 LUMINA/MONTE CARLO AND 97-98 CENTURY W-BODY VEHICLES INCLUDED IN THIS INVESTIGATION UTILIZE A LOWER SPRING FORCE AND ARE NOT INCLUDED IN THE RECALL.
Steering:rack And Pinion
GM'S LETTER TO NHTSA DATED DECEMBER 11, 2003, EXPANDS ITS ORIGINAL RECALL (NHTSA 02V286) TO INCLUDE CERTAIN W-BODY VEHICLES: 96-97 OLDS CUTLASS SUPREME; 98 OLDS INTRIGUE; 97-98 OLDS CUTLASS; 97-98 CHEVY LUMINA, MONTE CARLO AND MALIBU; 96 PONTIAC GRAND PRIX; AND 96-98 BUICK REGAL.THE NUMBER OF VEHICLES RECALLED IS 750,283.GM DETERMINED THAT FAILURE OF THE RACK AND PINION IS RELATED TO DAMAGE OF THE LOWER PINION BEARING AND THE LEVEL OF THE PINION BEARING PRE-LOAD SPRING FORCE.GM STATES, HIGHER RACK PRE-LOAD SPRING FORCE (133 LB.) IS THE DESIGN CHARACTERISTIC MOST CLOSELY ASSOCIATED WITH HIGHER BEARING DAMAGE RATES IN MOST OF THE VEHICLE APPLICATIONS THAT USED THE GENERAL BEARING COMPANY (GBC) BEARING.ALL OF THE VEHICLES COVERED IN THE EXPANDED RECALL HAVE THE 133 LB SPRING FORCE.THE 96 LUMINA/MONTE CARLO AND 97-98 CENTURY W-BODY VEHICLES INCLUDED IN THIS INVESTIGATION UTILIZE A LOWER SPRING FORCE AND ARE NOT INCLUDED IN THE RECALL.
RQ03001 · Power Rack And Pinion Steering Failure
Opened Jan 2, 2003 · Closed Sep 15, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Additional source detail variants (2)
Steering
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
1998 Chevrolet Lumina Problems, Complaints & Recalls | Skip That Year
Illustration