NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
33 reportsClear category filter160,000 miles · Aug 21, 2008
Service Brakes, Hydraulic
TL*THE CONTACT OWNS A 1998 CHEVROLET LUMINA. THE CONTACT STATED THAT THE BRAKE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL WHILE DRIVING. HE NOTICED A SMALL PIN HOLE IN THE BRAKE LINE CAUSED BY CORROSION. THE VEHICLE HAS NOT BEEN DIAGNOSED BY A MECHANIC. THE SPEED WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 160,000. UP…
Read full complaint
TL*THE CONTACT OWNS A 1998 CHEVROLET LUMINA. THE CONTACT STATED THAT THE BRAKE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL WHILE DRIVING. HE NOTICED A SMALL PIN HOLE IN THE BRAKE LINE CAUSED BY CORROSION. THE VEHICLE HAS NOT BEEN DIAGNOSED BY A MECHANIC. THE SPEED WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 160,000. UPDATED 10/07/08. *LJ THE CONSUMER STATED THE RIGHT REAR STEEL BRAKE LINE WAS IMPROPERLY INSTALLED AT 2 LOCATIONS. UPDATED 10/08/08. *JB
NHTSA ODI #10239192
129,897 miles · Jun 12, 2008
Engine And Engine CoolingService Brakes, HydraulicVisibility
TL*THE CONTACT OWNS A 1998 CHEVROLET LUMINA. IN MARCH OF 2008, THE VEHICLE WAS PURCHASED WITH A CRACKED WINDSHIELD. THE DEALER REPAIRED THE WINDSHIELD. THE FOLLOWING DAY, WHILE DRIVING 20 MPH, THE BRAKES FAILED AND NEARLY CAUSED A CRASH. THE VEHICLE WAS TAKEN BACK TO THE DEALER AND THEY KEPT IT FOR THREE DAYS. A FEW DAYS LA…
Read full complaint
TL*THE CONTACT OWNS A 1998 CHEVROLET LUMINA. IN MARCH OF 2008, THE VEHICLE WAS PURCHASED WITH A CRACKED WINDSHIELD. THE DEALER REPAIRED THE WINDSHIELD. THE FOLLOWING DAY, WHILE DRIVING 20 MPH, THE BRAKES FAILED AND NEARLY CAUSED A CRASH. THE VEHICLE WAS TAKEN BACK TO THE DEALER AND THEY KEPT IT FOR THREE DAYS. A FEW DAYS LATER, THE VEHICLE SHUT OFF COMPLETELY. THE VEHICLE WAS REPAIRED ONCE MORE, BUT IT SHUT OFF AGAIN. THE DEALER REFUSED TO MAKE ANY MORE REPAIRS. THE CURRENT MILEAGE IS 140,000 AND FAILURE MILEAGE WAS 129,897. UPDATED 7/3/08 *CN THE CONSUMER STATED THE VEHICLE STALLED AT LEAST 10 TIMES. THE CONSUMER WAS INFORMED THE ENGINE WAS BAD. UPDATED 07/03/08
NHTSA ODI #10230850
Mileage unknown · Aug 28, 2006
Service Brakes, Hydraulic
MY BRAKES HAVE ALWAYS MALFUNCTIONED IN MY VEHICLE. THEY HAVE BEEN MAINTAINED AND WILL GO OUT WHEN I AM TURNING OR TRYING TO STOP. I HAD THEM CHECKED FOR 4 YEARS STRAIGHT- PADS CHANGED AND COMPLETELY SERVICED- MY MECHANIC SAID IT IS SOME COMPUTER SENSOR IN THE BRAKES THAT GOES OUT IN THIS PARTICULAR CHEVY. IT IS EXPENSIVE AND …
Read full complaint
MY BRAKES HAVE ALWAYS MALFUNCTIONED IN MY VEHICLE. THEY HAVE BEEN MAINTAINED AND WILL GO OUT WHEN I AM TURNING OR TRYING TO STOP. I HAD THEM CHECKED FOR 4 YEARS STRAIGHT- PADS CHANGED AND COMPLETELY SERVICED- MY MECHANIC SAID IT IS SOME COMPUTER SENSOR IN THE BRAKES THAT GOES OUT IN THIS PARTICULAR CHEVY. IT IS EXPENSIVE AND A DEFECT. I HAVE WENT THROUGH INTERSECTIONS- AND BEEN SO CLOSE IN REAR ENDING SEVERAL VEHICLES BECAUSE OF MY INABILITY TO STOP MY CAR. *JB
NHTSA ODI #10166708
Mileage unknown · Aug 17, 2004
Service Brakes, Hydraulic
WHILE APPLYING THE BRAKE PEDAL ANDC BRAKES BECAME INOPERATIVE. CONSUIMER WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE, AND PULLED OVER. *AK
NHTSA ODI #10088067
98,000 miles · Apr 24, 2003
Service Brakes, Hydraulic
ANTI-LOCK BRAKES RELAYS CLICK AND CYCLE CONTINUALLY WHEN BRAKING. DEALER STATES THE TRACTION CONTROL MODULE MAY BE MALFUNCTIONING. DOES NOT SEEM TO AFFECT NORMAL BRAKING. *NLM
NHTSA ODI #10016443
35,000 miles · Apr 7, 2003
EquipmentFuel System, GasolineService Brakes, Hydraulic
I PURCHASED MY VEHICLE USED AND IT STILL HAD 1000 MILE WARRANTY FROM THE DEALER. WHEN I GOT THE CAR THERE WAS A PROBLEM WITH THE FUEL PUMP SO THEY REPLACED IT. BEFORE I EVEN GOT OUT OF THE PARKING LOT THE (VIBRATION SHUDDER HOSE) WENT BAD. OR AT LEAST THAT IS WHAT THE GUY AT THE SERVICE AREA TOLD ME THE NAME WAS. THEY HAVE REPLA…
Read full complaint
I PURCHASED MY VEHICLE USED AND IT STILL HAD 1000 MILE WARRANTY FROM THE DEALER. WHEN I GOT THE CAR THERE WAS A PROBLEM WITH THE FUEL PUMP SO THEY REPLACED IT. BEFORE I EVEN GOT OUT OF THE PARKING LOT THE (VIBRATION SHUDDER HOSE) WENT BAD. OR AT LEAST THAT IS WHAT THE GUY AT THE SERVICE AREA TOLD ME THE NAME WAS. THEY HAVE REPLACED THAT. AND FOR ALMOST TWO YEARS NOW I HAVE BEEN FIGHTING WITH THEM THAT THE POWER STEERING HAS BEEN WHINING. ALSO THE BRAKES DO NOT STOP TO WELL IN THE RAIN. I TRAVEL A LOT AND WE GO THROUGH BRAKES LIKE WATER. WE ALSO HAD THE AC COMPRESSOR GO OUT LAST YEAR DURING THE SUMMER. THE CAR WAS ONLY 4 YEARS OLD. WE KEEP OUR CAR UP VERY WELL. I DO NOT UNDERSTAND ALL THESE PROBLEMS. I KNOW THIS MAY NOT SEEM LIKE BIG PROBLEMS BUT WHEN I KEEP MY CAR UP AND HAVE BEEN FIGHTING WITH THE DEALER DUE TO WHINING THIS IS FRUSTRATING.*JB
NHTSA ODI #10014066
Mileage unknown · Aug 19, 2002
Service Brakes, Hydraulic
WHEN BACKING UP AND SLOWING DOWN ABS STARTS TO CLATTER. ITS AN INTERMITTENT PROBLEM. PLEASE PROVIDE ANY FURTHER INFORMATION.*AK
NHTSA ODI #8016591
35,000 miles · May 17, 2002
Service Brakes, Hydraulic
I BOUGHT THIS CAR USED WITH 32,000 MI. FROM THE BEGINNING BRAKES WOULD NOT GRAB IN THE RAIN, THE BRAKE PEDAL WAS EXTREMELY HARD. THE DEALER SAID NOTHING WAS WRONG AND THAT'S THE WAY THIS CAR IS. I WAS TOLD THAT I WAS NOT USE TO 4 WHEEL DISC BRAKES. (I DRIVE A 4 WHEEL DISC CAR AT WORK.) I INSISTED THAT SOMETHING WAS WRONG. DEALER…
Read full complaint
I BOUGHT THIS CAR USED WITH 32,000 MI. FROM THE BEGINNING BRAKES WOULD NOT GRAB IN THE RAIN, THE BRAKE PEDAL WAS EXTREMELY HARD. THE DEALER SAID NOTHING WAS WRONG AND THAT'S THE WAY THIS CAR IS. I WAS TOLD THAT I WAS NOT USE TO 4 WHEEL DISC BRAKES. (I DRIVE A 4 WHEEL DISC CAR AT WORK.) I INSISTED THAT SOMETHING WAS WRONG. DEALER TURNED THE FRONT ROTORS WHICH DID NOT HELP. I INSTALLED HIGH PERFORMANCE DISC PADS ON ALL FOUR WHEELS WHICH HELPED A LOT BUT ONLY FOR ABOUT 20000 MILES. THE BRAKES USE TO WHEN THEY GOT WET. THIS CAR IS UNSAFE IN WET WEATHER! *TS ***DIMSII IVOQ ENTRY POSTED AFTER 12-12-02 CUT OVER TO ARTEMIS***762002
NHTSA ODI #10009208
Mileage unknown · Mar 20, 2002
Service Brakes, Hydraulic
I WAS GOING 55 MPH ON BELTWAY. I DISCOVERED THAT MY BRAKES WERE VERY HARD TO PUSH AND COULD NOT STOP. PULLED OFF TO SHOULDER AND COULD NOT PICK UP ANY ACELERATION. I HAD THE CAR TAKEN IMMEDIATELY TO DEALER FOR CHECK-UP. THE DEALER (FOX) ADVISED THAT THE BRAKE BOOSTER HOSE FROM THE MASTER BRAKE CYLINDER BECAME LOOSE AND WAS…
Read full complaint
I WAS GOING 55 MPH ON BELTWAY. I DISCOVERED THAT MY BRAKES WERE VERY HARD TO PUSH AND COULD NOT STOP. PULLED OFF TO SHOULDER AND COULD NOT PICK UP ANY ACELERATION. I HAD THE CAR TAKEN IMMEDIATELY TO DEALER FOR CHECK-UP. THE DEALER (FOX) ADVISED THAT THE BRAKE BOOSTER HOSE FROM THE MASTER BRAKE CYLINDER BECAME LOOSE AND WAS "CRIMPED" NEAR THE HOOD AND FIRE WALL. THIS RESULTED IN THE FLOW OF VACUUM PRESSURE BEING COMPROMISED AND STOPPING. THE DEALER ADVISED THAT THE BRAKE BOOSTER HOSE HAD TO BE "REPOSITIONED." THIS CORRECTED BOTH PROBLEMS OF FAILED BRAKING AND LACK OF ACCELLERATION. THE DEALER WOULD NOT OR COULD NOT FULLY EXPLAIN IF THIS WAS A MANUFACTURING PROBLEM OR WAS A RESULT OF HUMAN ERROR WHEN WORK IS PERFORMED ON THE CAR. THE DEALER WOULD NOT REPLACE THE "CRIMPED" BOOSTER HOSE. LOST OF BRAKES WHEN GOING HIGHWAY SPEEDS WAS QUITE UPSETTING. I THOUGHT I WOULD PASS THIS COMPLAINT ON FOR YOU REVIEW AND ANY ACTION YOU DEEM FIT. IF THIS IS A SAFTY PROBLEM, PERHAPS A TECH BULLETIN OR WARNING SHOULD BE ISSUED BY CHEV. THANK YOU. PLEASE FEEL FREE TO CONTACT ME FOR ANY OTHER INFORMATION REQUIRED ON YOUR PART.*AK
NHTSA ODI #759571
Mileage unknown · Feb 11, 2002
Service Brakes, Hydraulic
THE ANTI-LOCK BRAKES MAKES A CLICKING SOUND WHEN PEDAL IS PUSHED AS IF THEY ARE BEING ACTIVATED INTO THE SKID MODE AND EVERY TIME THEY CLICK THE LIGHTS ON THE CAR DIM. SO IF YOU GO TO SLOW DOWN THE BRAKES CLICK SEVERAL TIMES AND THE LIGHTS DIM AND ONCOMMING DRIVERS ARE ANNOYED BY MY LIGHTS DIMMING AND BRIGHTNING.*AK
NHTSA ODI #758094
Official recalls
3Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Dec 11, 2003
CERTAIN PASSENGER VEHICLES HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE RETAINERS COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR PONTIAC AT 1-800-620-7668.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA03019 · Power Rack And Pinion Steering Failure
Opened Sep 15, 2003 · Closed Dec 18, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM'S LETTER TO NHTSA DATED DECEMBER 11, 2003, EXPANDS ITS ORIGINAL RECALL (NHTSA 02V286) TO INCLUDE CERTAIN W-BODY VEHICLES: 96-97 OLDS CUTLASS SUPREME; 98 OLDS INTRIGUE; 97-98 OLDS CUTLASS; 97-98 CHEVY LUMINA, MONTE CARLO AND MALIBU; 96 PONTIAC GRAND PRIX; AND 96-98 BUICK REGAL.THE NUMBER OF VEHICLES RECALLED IS 750,283.GM DETERMINED THAT FAILURE OF THE RACK AND PINION IS RELATED TO DAMAGE OF THE LOWER PINION BEARING AND THE LEVEL OF THE PINION BEARING PRE-LOAD SPRING FORCE.GM STATES, HIGHER RACK PRE-LOAD SPRING FORCE (133 LB.) IS THE DESIGN CHARACTERISTIC MOST CLOSELY ASSOCIATED WITH HIGHER BEARING DAMAGE RATES IN MOST OF THE VEHICLE APPLICATIONS THAT USED THE GENERAL BEARING COMPANY (GBC) BEARING.ALL OF THE VEHICLES COVERED IN THE EXPANDED RECALL HAVE THE 133 LB SPRING FORCE.THE 96 LUMINA/MONTE CARLO AND 97-98 CENTURY W-BODY VEHICLES INCLUDED IN THIS INVESTIGATION UTILIZE A LOWER SPRING FORCE AND ARE NOT INCLUDED IN THE RECALL.
Additional source detail variants (2)
Steering
GM'S LETTER TO NHTSA DATED DECEMBER 11, 2003, EXPANDS ITS ORIGINAL RECALL (NHTSA 02V286) TO INCLUDE CERTAIN W-BODY VEHICLES: 96-97 OLDS CUTLASS SUPREME; 98 OLDS INTRIGUE; 97-98 OLDS CUTLASS; 97-98 CHEVY LUMINA, MONTE CARLO AND MALIBU; 96 PONTIAC GRAND PRIX; AND 96-98 BUICK REGAL.THE NUMBER OF VEHICLES RECALLED IS 750,283.GM DETERMINED THAT FAILURE OF THE RACK AND PINION IS RELATED TO DAMAGE OF THE LOWER PINION BEARING AND THE LEVEL OF THE PINION BEARING PRE-LOAD SPRING FORCE.GM STATES, HIGHER RACK PRE-LOAD SPRING FORCE (133 LB.) IS THE DESIGN CHARACTERISTIC MOST CLOSELY ASSOCIATED WITH HIGHER BEARING DAMAGE RATES IN MOST OF THE VEHICLE APPLICATIONS THAT USED THE GENERAL BEARING COMPANY (GBC) BEARING.ALL OF THE VEHICLES COVERED IN THE EXPANDED RECALL HAVE THE 133 LB SPRING FORCE.THE 96 LUMINA/MONTE CARLO AND 97-98 CENTURY W-BODY VEHICLES INCLUDED IN THIS INVESTIGATION UTILIZE A LOWER SPRING FORCE AND ARE NOT INCLUDED IN THE RECALL.
Steering:rack And Pinion
GM'S LETTER TO NHTSA DATED DECEMBER 11, 2003, EXPANDS ITS ORIGINAL RECALL (NHTSA 02V286) TO INCLUDE CERTAIN W-BODY VEHICLES: 96-97 OLDS CUTLASS SUPREME; 98 OLDS INTRIGUE; 97-98 OLDS CUTLASS; 97-98 CHEVY LUMINA, MONTE CARLO AND MALIBU; 96 PONTIAC GRAND PRIX; AND 96-98 BUICK REGAL.THE NUMBER OF VEHICLES RECALLED IS 750,283.GM DETERMINED THAT FAILURE OF THE RACK AND PINION IS RELATED TO DAMAGE OF THE LOWER PINION BEARING AND THE LEVEL OF THE PINION BEARING PRE-LOAD SPRING FORCE.GM STATES, HIGHER RACK PRE-LOAD SPRING FORCE (133 LB.) IS THE DESIGN CHARACTERISTIC MOST CLOSELY ASSOCIATED WITH HIGHER BEARING DAMAGE RATES IN MOST OF THE VEHICLE APPLICATIONS THAT USED THE GENERAL BEARING COMPANY (GBC) BEARING.ALL OF THE VEHICLES COVERED IN THE EXPANDED RECALL HAVE THE 133 LB SPRING FORCE.THE 96 LUMINA/MONTE CARLO AND 97-98 CENTURY W-BODY VEHICLES INCLUDED IN THIS INVESTIGATION UTILIZE A LOWER SPRING FORCE AND ARE NOT INCLUDED IN THE RECALL.
RQ03001 · Power Rack And Pinion Steering Failure
Opened Jan 2, 2003 · Closed Sep 15, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Additional source detail variants (2)
Steering
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Illustration