IllustrationWHILE DRIVING THE TRUCK BETWEEN 50-60 MPH, DRIVER HEARD A WINDING NOISE, BY TIME DRIVER PULLED OVER TO SHOULDER SAFELY, THE TRUCK WAS ON FIRE IN THE ENGINE COMPARTMENT. THE TRUCK WAS TOTALLED. *AK
1982 Chevrolet K20
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all K20 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 0 of 1 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports1 fire reports0 injury reports
What owners actually said
1 reportsOfficial recalls
182V081000 · Power Train:axle Assembly:axle Shaft
Aug 24, 1982
THE REAR AXLE SHAFTS RECEIVED IMPROPER HEAT TREATMENT DURING MANUFACTURE. THE SHAFT MAY BREAK AND THE TIRE AND WHEEL ASSEMBLY COULD DISENGAGE FROM THE VEHICLE.
Consequence & remedy
Consequence: Not supplied
Remedy: DEALER WILL REPLACE BOTH REAR AXLE SHAFT ASSEMBLIES, IF NECESSARY, FREE OF CHARGE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA92041 · Fuel System Integrity
Opened Dec 8, 1992 · Closed Mar 9, 1995
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly
There is no summary currently available
PE88016 · Exhaust Manifold Leaks
Opened Jan 14, 1988 · Closed Mar 31, 1988
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
SUMMARY:SOME 1981-86 TRUCKS WITH 7.4L ENGINES AND CAST IRON EXHAUSTMANIFOLDS MAY EXPERIENCE A CONDITION WHERE AN EXHAUST LEAK DEVELOPSBETWEEN THE MANIFOLD AND THE CYLINDER HEAD MATING SURFACE CAUSING A NOISECONDITION. MOST OF THE REPORTS (AND ALL OF THE INJURIES AND THEMANIFOLD FIRE) ARE FROM THE P30 MOTORHOME CHASSIS.GM STATES THAT A WARPEDOR CRACKED MANIFOLD WOULD PERMIT SMALL AMOUNTS OF EXHAUST GAS LEAKAGEGENERALLY RESULTING IN NOTICEABLE NOISE AND FUMES.THE EXHAUST MANIFOLDSARE SUSCEPTIBLE TO EXTREME HEAT CONDITIONS (SUCH AS OPERATING UNDER SEVEREENGINE/VEHICULAR LOAD CONDITIONS AND HIGH AMBIENT TEMPERATURES).THEMOTORHOME APPLICATION IS PARTICULARLY SUSCEPTIBLE TO THIS ALLEGED DEFECTSINCE THE VEHICLE IS NEARLY ALWAYS AT OR NEAR THE GVWR OF THE VEHICLE.THEFEW NUMBER OF REPORTS RECEIVED BY ODI FOR A PROBLEM WHICH BEGAN 8 YEARS AGOSUGGESTS THAT THE DEFECT EITHER OCCURS INFREQUENTLY OR IS NOT PERCEIVED ASA SIGNIFICANT SAFETY HAZARD.THE SERVICE BULLETIN WAS ISSUED TO IDENTIFYTHE HIGH TEMPERATURE PROBLEM AND PROVIDE A REMEDY AGAINST REOCCURRENCE.===