I HAVE READ SEVERAL COMPLAINTS ON FORUMS, SUCH AS THE ONES ON CARCOMPLAINTS.COM, ABOUT THIS ISSUE. 2004 CHEVY IMPALA... USING THE HIGH BEAMS, AND SUDDENLY ITS DARK OUT SIDE... THE LIGHTS JUST TURN OFF! YOU HAVE TO FLICKER THE HIGH BEAMS A FEW TIMES, AND THE NORMAL LIGHTS WILL COME BACK ON. MY LIGHTS HAVE TURNED OFF WHILE DR…
Read full complaint
I HAVE READ SEVERAL COMPLAINTS ON FORUMS, SUCH AS THE ONES ON CARCOMPLAINTS.COM, ABOUT THIS ISSUE. 2004 CHEVY IMPALA... USING THE HIGH BEAMS, AND SUDDENLY ITS DARK OUT SIDE... THE LIGHTS JUST TURN OFF! YOU HAVE TO FLICKER THE HIGH BEAMS A FEW TIMES, AND THE NORMAL LIGHTS WILL COME BACK ON. MY LIGHTS HAVE TURNED OFF WHILE DRIVING IN THE DARK AT LEAST 400 TIMES SO FAR! THIS IS GOING TO GET SOMEONE KILLED! EVERYONE WANTS AROUND $700 TO FIX THE ISSUE, I THINK CHEVY SHOULD STEP UP AND PAY THIS! *TR
NHTSA ODI #10258713
72,000 miles · Feb 12, 2009
Exterior LightingVehicle Speed Control
THE HEADLIGHTS KEEP CUTTING OUT WITH INCREASED FREQUENCY WITH ALL EXTERIOR LIGHTS INCLUDING THE DASH LIGHTS. ALSO, THE SPEEDOMETER WILL STOP WORKING AND JUST KEEP INCREASING UNTIL IT POINTS STRAIGHT DOWN. BOTH HAVE HAPPENED SEVERAL TIMES. *TR
NHTSA ODI #10258508
Mileage unknown · Feb 12, 2009
Exterior LightingInterior Lighting
MY 2004 IMPALA HAS PROBLEMS WITH IT'S LIGHT/DIMMER SWITCH. ONE HAS TO CLICK THE HANDLE TWICE IN ORDER TO DIM/BRIGHTEN THE LIGHTS. A COUPLE OF TIME THE DASH LIGHTS AND HEADLIGHTS ALL WENT COMPLETELY OUT WHEN I TRIED TO DIM/BRIGHTEN THE LIGHTS. THIS IS A HAZARD. THERE SHOULD BE A RECALL!!!!! *TR
NHTSA ODI #10258456
27,200 miles · Feb 11, 2009
Exterior LightingVisibility
DRIVING ON A DARK RURAL ROAD AT NIGHT AND TRIED TO PUT MY LIGHTS ON HIGH BEAM. THE LIGHTS WENT TOTALLY OUT WHEN I TRIED TO PUT THEM ON HIGH BEAM. PREVIOUSLY DURING THE PAST 3 MONTHS THEY HAVE FLICKERED WHEN I WENT TO PUT THEM ON HIGH BEAM BUT DID NOT GO TOTALLY OUT. I HAVE TRIED SEVERAL MORE TIMES TO PUT THEM ON HIGH BEAM AND…
Read full complaint
DRIVING ON A DARK RURAL ROAD AT NIGHT AND TRIED TO PUT MY LIGHTS ON HIGH BEAM. THE LIGHTS WENT TOTALLY OUT WHEN I TRIED TO PUT THEM ON HIGH BEAM. PREVIOUSLY DURING THE PAST 3 MONTHS THEY HAVE FLICKERED WHEN I WENT TO PUT THEM ON HIGH BEAM BUT DID NOT GO TOTALLY OUT. I HAVE TRIED SEVERAL MORE TIMES TO PUT THEM ON HIGH BEAM AND THE LIGHTS GO OUT TOTALLY EACH TIME SO I DO NOT DARE TO TRY TO PUT THEM ON HIGH BEAM NOW AT ALL. I HAVE CALLED A DEALERSHIP TO HAVE THIS LOOKED INTO. THEY SAY THEY WILL HAVE TO TEST THE CAR FIRST THEN TAKE THE STEERING COLUMN APART AND PROBABLY REPLACE THE SWITCH. ESTIMATED COST UP TO $1000.00 MY CAR HAS ONLY 27,499 MILES ON IT AND I BOUGHT IT BRAND NEW IN 2004. *TR
NHTSA ODI #10258419
63,000 miles · Jan 21, 2009
Exterior Lighting
WHILE DRIVING AT NIGHT MY HIGH BEAMS WILL SUDDENLY SHUT OFF. IF I HIT THE DIM/BRIGHT SWITCH, THE LOW BEAMS WILL COME BACK ON. I HAVE TRIED TAKING THE LIGHTS OFF OF THE AUTOMATIC SETTING BUT IT MAKES NO DIFFERENCE. IT IS VERY DANGEROUS TO BE DRIVING AT NIGHT AND THE LIGHTS ALL OF A SUDDEN SHUT OFF. *TR
NHTSA ODI #10255853
67,919 miles · Dec 9, 2008
Exterior Lighting
TL*THE CONTACT OWNS A 2004 CHEVROLET IMPALA. WHILE DRIVING APPROXIMATELY 45 MPH IN THE EVENING, THE EXTERIOR HEADLIGHTS ON BOTH THE DRIVER AND PASSENGER SIDES FAILED. THE CONTACT STOPPED THE VEHICLE AND TURNED THE DIMMER SWITCH ON AND OFF, WHICH ALLOWED THE EXTERIOR LIGHTS TO REGAIN POWER. THE VEHICLE WAS DRIVEN TO THE CONTAC…
Read full complaint
TL*THE CONTACT OWNS A 2004 CHEVROLET IMPALA. WHILE DRIVING APPROXIMATELY 45 MPH IN THE EVENING, THE EXTERIOR HEADLIGHTS ON BOTH THE DRIVER AND PASSENGER SIDES FAILED. THE CONTACT STOPPED THE VEHICLE AND TURNED THE DIMMER SWITCH ON AND OFF, WHICH ALLOWED THE EXTERIOR LIGHTS TO REGAIN POWER. THE VEHICLE WAS DRIVEN TO THE CONTACT'S RESIDENCE. THE FOLLOWING DAY, THE VEHICLE WAS DRIVEN TO THE DEALER AND THEY STATED THAT THE DIMMER SWITCH NEEDED TO BE REPLACED. THE DIMMER SWITCH WAS REPLACED THAT SAME DAY. THE MANUFACTURER STATED THAT THERE WAS NO RECALL; THEREFORE, THEY WERE NOT LIABLE FOR THE REPAIRS. THE CURRENT MILEAGE WAS 67,924 AND FAILURE MILEAGE WAS 67,919. UPDATED 12/30/08 *CN UPDATED 12/30/08. *JB
NHTSA ODI #10251211
85,000 miles · Jul 25, 2008
Exterior Lighting
HEADLIGHTS WENT OFF DURING DRIVING AT NIGHT. THIS HAPPENED EIGHT TO TEN TIMES OVER A PERIOD OF THREE TO FOUR MONTHS, WITH LIGHTS ON HIGH BEAM. LIGHTS CAME BACK ON WHEN DIMMER LEVER WAS ACTIVATED. INSTRUMENT PANEL REMAINED ILLUMINATED WHEN HEADLIGHTS WENT OFF. *TR
NHTSA ODI #10235815
Mileage unknown · Jun 20, 2008
Exterior Lighting
HIGH BEAM LIGHTS ARE DISABLED AFTER ABOUT 10 MINUTES OF USE. *TR
NHTSA ODI #10231825
5,100 miles · Apr 20, 2008
Exterior Lighting
NO PRIOR EVENT. TURN SIGNAL FLASHER CEASED TO FUNCTION FULL TIME. IT HAS BEEN INTERMITTENT FOR SEVERAL DAYS. HAZARD LIGHTS NOR TURN SIGNALS BLINK. BULBS COME ON AND STAY ON. NO FLASHER. *TR
NHTSA ODI #10225161
42,000 miles · Apr 7, 2008
Exterior Lighting
THE TURN SIGNALS AND HAZARD LIGHTS NO LONGER BLINK WHEN TURNED ON. THE BULBS LIGHT UP BUT DO NOT BLINK ON AND OFF. *TR
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
General Motors LLC (GM) notified the agency on April 2, 2015, that they are is recalling certain model year 2004 Buick Regal vehicles manufactured April 9, 2003, to June 1, 2003, 2004 Chevrolet Impala vehicles manufactured April 8, 2003, to June 23, 2003, and 2004 Chevrolet Monte Carlo vehicles manufactured April 7, 2003, to June 23, 2003. On May 18, 2015, GM expanded the recall to cover an additional 49,751 2004 Pontiac Grand Prix vehicles manufactured January 6, 2003, to June 25, 2004. In the affected vehicles, the valve cover gasket may leak.
Consequence & remedy
Consequence: The leaking engine oil can drip onto the hot surface of the exhaust manifold, increasing the risk of a fire.
Remedy: GM will notify owners, and dealers will remove the plastic cover and plastic oil fill tube extension and replace the front valve cover and gasket. These repairs will be done free of charge. The recall began on April 24, 2015. Owners may contact Buick customer service at 1-800-521-7300, Pontiac customer service at 1-800-762-2737 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14574.
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
CERTAIN PASSENGER VEHICLES WERE PRODUCED WITH LOWER THAN SPECIFIED TORQUE ON BOTH FRONT BRAKE CALIPER TO STEERING KNUCKLE ATTACHMENT BOLTS. WITH IMPROPER TORQUE, THE CLAMP LOAD AT THE JOINT MAY NOT BE ADEQUATE TO PREVENT MOVEMENT BETWEEN THE CALIPER BRACKET AND KNUCKLE.
Consequence & remedy
Consequence: DEPENDING ON WHETHER ONE OR BOTH BOLTS BACKS OUT OR FRACTURES, THE RESULT CAN BE LOCKING OF THE AFFECTED WHEEL DURING BRAKING AND AN ABRUPT STEERING INPUT IN THE DIRECTION OF THE LOCKED WHEEL, REDUCED BRAKING AND NOISE FROM THE AFFECTED WHEEL, OR SEVERING OF A BRAKE HOSE, INCREASED BRAKE PEDAL TRAVEL, AND REDUCED STEERING CONTROL. REDUCED BRAKING OR STEERING CONTROL COULD CAUSE A CRASH.
Remedy: DEALERS ARE TO TIGHTEN BOTH BOLTS TO THE SPECIFIED TORQUE. OWNER NOTIFICATION BEGAN ON JUNE 28, 2004. OWNERS SHOULD CONTACT CHEVROLET 1-800-630-2438 OR PONTIAC 1-800-620-7668.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2004 Chevrolet Impala Problems, Complaints & Recalls | Skip That Year
Illustration