TL* THE CONTACT OWNS A 2004 CHEVROLET IMPALA. THE CONTACT RECEIVED A NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF …
Read full complaint
TL* THE CONTACT OWNS A 2004 CHEVROLET IMPALA. THE CONTACT RECEIVED A NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
NHTSA ODI #10667630
Mileage unknown · Dec 22, 2014
Electrical SystemVehicle Speed Control
2004 CHEVROLET IMPALA DEALER HAS NOT RECEIVED PART FOR RECALL *CN THE CONSUMER STATED IN DECEMBER 2013, HE BEGAN TO EXPERIENCE A PROBLEM WHILE DRIVING ON THE INTERSTATE AT 65 MPH. THE VEHICLE WOULD LOSE POWER, INCLUDING THE SPEEDOMETER DROPPING TO ZERO. A LOCAL REPAIR SHOP INSPECTED THE VEHICLE, AND INFORMED THE CONSUMER, THE …
Read full complaint
2004 CHEVROLET IMPALA DEALER HAS NOT RECEIVED PART FOR RECALL *CN THE CONSUMER STATED IN DECEMBER 2013, HE BEGAN TO EXPERIENCE A PROBLEM WHILE DRIVING ON THE INTERSTATE AT 65 MPH. THE VEHICLE WOULD LOSE POWER, INCLUDING THE SPEEDOMETER DROPPING TO ZERO. A LOCAL REPAIR SHOP INSPECTED THE VEHICLE, AND INFORMED THE CONSUMER, THE SPEEDOMETER IN THE CLUSTER HAD APPARENTLY GONE BAD. THE CLUSTER WAS REPLACED. HOWEVER, THE PROBLEM HAPPENED AGAIN. THE CONSUMER WENT TO ANOTHER SHOP AND THEY STATED THE SPEED CONTROL SENSOR WAS NOT FUNCTIONING PROPERLY. THE PART WAS REPLACED AND THE PROBLEM DID NOT RETURN. *JB
NHTSA ODI #10660597
96,000 miles · Dec 16, 2014
Electrical SystemCrash
TL* THE CONTACT OWNED A 2004 CHEVROLET IMPALA. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 35 MPH, THE VEHICLE STALLED WITHOUT WARNING AND CRASHED INTO A BARRIER AND A SPEED SIGN. THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED AND NO INJURIES WERE SUSTAINED. THE VEHICLE WAS DESTROYED. THE VEHICLE WAS INCLUDE…
Read full complaint
TL* THE CONTACT OWNED A 2004 CHEVROLET IMPALA. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 35 MPH, THE VEHICLE STALLED WITHOUT WARNING AND CRASHED INTO A BARRIER AND A SPEED SIGN. THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED AND NO INJURIES WERE SUSTAINED. THE VEHICLE WAS DESTROYED. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 96,000.
NHTSA ODI #10664511
Mileage unknown · Dec 16, 2014
Electrical System
2004 CHEVROLET IMPALA KEYS AND IGNITION SWITCH. *MW THE CONSUMER STATED THE REPAIRS WERE DONE ON OCTOBER 13, 2014. HOWEVER, SHE DID NOT BELIEVE THE RECALL ADEQUATELY ADDRESSED THE PROBLEM SHE EXPERIENCED WITH THE IGNITION. ON MAY 7, 2014, SHE WAS UNABLE TO START THE VEHICLE, BECAUSE THE SECURITY LIGHT MALFUNCTIONED AND LOCKED…
Read full complaint
2004 CHEVROLET IMPALA KEYS AND IGNITION SWITCH. *MW THE CONSUMER STATED THE REPAIRS WERE DONE ON OCTOBER 13, 2014. HOWEVER, SHE DID NOT BELIEVE THE RECALL ADEQUATELY ADDRESSED THE PROBLEM SHE EXPERIENCED WITH THE IGNITION. ON MAY 7, 2014, SHE WAS UNABLE TO START THE VEHICLE, BECAUSE THE SECURITY LIGHT MALFUNCTIONED AND LOCKED THE IGNITION. THE IGNITION CYLINDER WAS REPLACED AT A COST OF $ 525.21. *JB UPDATED 12/10/14. *JB
NHTSA ODI #10659533
Mileage unknown · Dec 8, 2014
Electrical System
2004 CHEVROLET IMPALA. CUSTOMER REQUESTING REIMBURSEMENT CAR QUIT, DUE TO IGNITION SWITCH MALFUNCTION. *MW
NHTSA ODI #10658456
55 miles · Nov 25, 2014
Electrical SystemExterior Lighting
DRIVING DOWN THE ROAD WITH MY HIGH BEAMS ON, MY HEADLIGHTS WENT OUT COMPLETELY. MY LOW BEAMS WORK OK BUT IF I USE HIGH BEAMS THEY RANDOMLY GO OUT. THIS IS THE SECOND GM VEHICLE I HAVE HAD WITH THIS PROBLEM. THE MECHANIC AT THE GM DEALERSHIP SAID 4 OF HIS 6 FAMILY MEMBERS HAVE HAD SAME PROBLEM. A FORMER CO-WORKER HAD SAME PROBLE…
Read full complaint
DRIVING DOWN THE ROAD WITH MY HIGH BEAMS ON, MY HEADLIGHTS WENT OUT COMPLETELY. MY LOW BEAMS WORK OK BUT IF I USE HIGH BEAMS THEY RANDOMLY GO OUT. THIS IS THE SECOND GM VEHICLE I HAVE HAD WITH THIS PROBLEM. THE MECHANIC AT THE GM DEALERSHIP SAID 4 OF HIS 6 FAMILY MEMBERS HAVE HAD SAME PROBLEM. A FORMER CO-WORKER HAD SAME PROBLEM. I CONTACTED GM AND WAS TOLD MY CAR WAS TO OLD FOR THEM TO FIX IT... *TR
NHTSA ODI #10660984
160,000 miles · Nov 20, 2014
Electrical System
THE KEY SWITCH IS BAD SOME TIMES AFTER IT IS STARTED ALL DASH IS NOT WORKING AND SECURITY SYSTEM IS LOCKED AND YOU HAVE TO SHUT IT DOWN SOME TIMES MORE THEN ONCE HAVE BEEN TOLD THE KEY SWITCH IS BAD I ASK SOMEONE AT G.M. IF THEY COULD SEND ME THE SWITCH BUT TOLD ME I HAD TO TAKE IT TO A SHOP DID THAT AND ALL THAT WAS DONE I…
Read full complaint
THE KEY SWITCH IS BAD SOME TIMES AFTER IT IS STARTED ALL DASH IS NOT WORKING AND SECURITY SYSTEM IS LOCKED AND YOU HAVE TO SHUT IT DOWN SOME TIMES MORE THEN ONCE HAVE BEEN TOLD THE KEY SWITCH IS BAD I ASK SOMEONE AT G.M. IF THEY COULD SEND ME THE SWITCH BUT TOLD ME I HAD TO TAKE IT TO A SHOP DID THAT AND ALL THAT WAS DONE IS PUT A PIECE OF SOMETHING IN THE KEY THAT DID NOT HELP THAT THE SWITCH IS BAD IS THERE ANY ONE THAT CAN HELP OR JUST SEND ME A SWITCH I CAN PUT IT IN. *TR
NHTSA ODI #10659792
Mileage unknown · Nov 13, 2014
Electrical System
I JUST BOUGHT A 2004 CHEVY IMPALA JUST 1 WEEK AGO (70K MILES), AND I'M ALREADY HAVING MAJOR IGNITION TROUBLE. WHEN I TURN THE KEY, NOTHING HAPPENS -- THE SECURITY LIGHT BLINKS A FEW TIMES. WE REPLACED THE BATTERY AND CRANKING RELAY SWITCH, AND NO LUCK. I'VE SEARCH THE WEB AND YOUTUBE, AND THIS APPEARS TO BE A COMMON PROBLEM. SOM…
Read full complaint
I JUST BOUGHT A 2004 CHEVY IMPALA JUST 1 WEEK AGO (70K MILES), AND I'M ALREADY HAVING MAJOR IGNITION TROUBLE. WHEN I TURN THE KEY, NOTHING HAPPENS -- THE SECURITY LIGHT BLINKS A FEW TIMES. WE REPLACED THE BATTERY AND CRANKING RELAY SWITCH, AND NO LUCK. I'VE SEARCH THE WEB AND YOUTUBE, AND THIS APPEARS TO BE A COMMON PROBLEM. SOME SAY THAT THE CAR NEEDS TO "RELEARN" MY KEY. OTHER SITES SAY I NEED TO DEACTIVATE/RESET THE SECURITY SYSTEM. SOMETIMES THE CAR STARS WITH NO PROBLEM. I DON'T KNOW WHAT TRIGGERS THE ISSUE. THIS IS BEYOND FRUSTRATING, AND I DON'T HAVE ANY MORE MONEY TO PUT IN THIS CAR. PLEASE, PLEASE HELP. THANKS! *TR
NHTSA ODI #10654896
Mileage unknown · Nov 12, 2014
Electrical System
2004 CHERVROLET IMALA. CONSUMER IS REQUESTING REIMBURSEMENT FOR REPAIRS MADE TO THE IGNITION. *KL THE CONSUMER STATED THE VEHICLE STALLED, WHILE DRIVING. A LOCAL REPAIR SHOP REPLACED THE IGNITION SWITCH. *JB
NHTSA ODI #10651232
Mileage unknown · Nov 7, 2014
Electrical System
TL* THE CONTACT OWNS A 2004 CHEVROLET IMPALA. THE CONTACT RECEIVED A NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM) AND STATED THAT THE PARTS WERE UNAVAILABLE. THE DEALER WAS UNCERTAIN WHEN THE PARTS WOULD BECOME AVAILABLE TO SERVICE THE VEHICLE UNDER THE RECALL. THE MANUFACTURER WAS NOTIFIED OF THE PROB…
Read full complaint
TL* THE CONTACT OWNS A 2004 CHEVROLET IMPALA. THE CONTACT RECEIVED A NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM) AND STATED THAT THE PARTS WERE UNAVAILABLE. THE DEALER WAS UNCERTAIN WHEN THE PARTS WOULD BECOME AVAILABLE TO SERVICE THE VEHICLE UNDER THE RECALL. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM AND THE CONTACT HAD NOT EXPERIENCED A FAILURE.
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
General Motors LLC (GM) notified the agency on April 2, 2015, that they are is recalling certain model year 2004 Buick Regal vehicles manufactured April 9, 2003, to June 1, 2003, 2004 Chevrolet Impala vehicles manufactured April 8, 2003, to June 23, 2003, and 2004 Chevrolet Monte Carlo vehicles manufactured April 7, 2003, to June 23, 2003. On May 18, 2015, GM expanded the recall to cover an additional 49,751 2004 Pontiac Grand Prix vehicles manufactured January 6, 2003, to June 25, 2004. In the affected vehicles, the valve cover gasket may leak.
Consequence & remedy
Consequence: The leaking engine oil can drip onto the hot surface of the exhaust manifold, increasing the risk of a fire.
Remedy: GM will notify owners, and dealers will remove the plastic cover and plastic oil fill tube extension and replace the front valve cover and gasket. These repairs will be done free of charge. The recall began on April 24, 2015. Owners may contact Buick customer service at 1-800-521-7300, Pontiac customer service at 1-800-762-2737 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14574.
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
CERTAIN PASSENGER VEHICLES WERE PRODUCED WITH LOWER THAN SPECIFIED TORQUE ON BOTH FRONT BRAKE CALIPER TO STEERING KNUCKLE ATTACHMENT BOLTS. WITH IMPROPER TORQUE, THE CLAMP LOAD AT THE JOINT MAY NOT BE ADEQUATE TO PREVENT MOVEMENT BETWEEN THE CALIPER BRACKET AND KNUCKLE.
Consequence & remedy
Consequence: DEPENDING ON WHETHER ONE OR BOTH BOLTS BACKS OUT OR FRACTURES, THE RESULT CAN BE LOCKING OF THE AFFECTED WHEEL DURING BRAKING AND AN ABRUPT STEERING INPUT IN THE DIRECTION OF THE LOCKED WHEEL, REDUCED BRAKING AND NOISE FROM THE AFFECTED WHEEL, OR SEVERING OF A BRAKE HOSE, INCREASED BRAKE PEDAL TRAVEL, AND REDUCED STEERING CONTROL. REDUCED BRAKING OR STEERING CONTROL COULD CAUSE A CRASH.
Remedy: DEALERS ARE TO TIGHTEN BOTH BOLTS TO THE SPECIFIED TORQUE. OWNER NOTIFICATION BEGAN ON JUNE 28, 2004. OWNERS SHOULD CONTACT CHEVROLET 1-800-630-2438 OR PONTIAC 1-800-620-7668.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2004 Chevrolet Impala Problems, Complaints & Recalls | Skip That Year
Illustration