IllustrationWHEN DRIVING AT AN UNDETERMINED SPEED, THE VEHICLE STALLED. THIS CAUSED THE DRIVER TO DRIFT TO THE SIDE OF THE ROAD. THE CONSUMER HAD THE VEHICLE TOWED TO THE DEALER. THE MECHANIC INFORMED THE OWNER THAT THE FUEL PUMP HAD FAILED. PLEASE PROVIDE ANY FURTHER DETAILS. *JB
2000 Chevrolet Impala
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Impala years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
330–25K
6825–50K
7150–75K
7275–100K
105100–150K
69150K+
418 reports with mileage · 400 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 187 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 159 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 124 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
49 crash reports73 fire reports41 injury reports
What owners actually said
818 reportsTHE CONSUMER STATED THAT SINCE SHE PURCHASED THE VEHICLE IN AUGUST 2003 THE BRAKES DID NOT WORKED PROPERLY. WHEN APPLYING THE BRAKES THEY CONSTANTLY GRABBED AND LET GO. SHE DID NOT KNOW WHETHER SHE COULD TALK TO THE DEALER ABOUT THE PROBLEM, BUT WILL GET IN TOUCH WITH THE DEALER TOMORROW. *AK THE BRAKES WERE REPAIRED AT T…
Read full complaint
THE CONSUMER STATED THAT SINCE SHE PURCHASED THE VEHICLE IN AUGUST 2003 THE BRAKES DID NOT WORKED PROPERLY. WHEN APPLYING THE BRAKES THEY CONSTANTLY GRABBED AND LET GO. SHE DID NOT KNOW WHETHER SHE COULD TALK TO THE DEALER ABOUT THE PROBLEM, BUT WILL GET IN TOUCH WITH THE DEALER TOMORROW. *AK THE BRAKES WERE REPAIRED AT THE DEALERSHIP. THE BRAKES PULSATED WHEN THEY WERE APPLIED THE TRUNK LIGHT WAS INOPERATIVE. *SC *JB
WHILE DRIVING AIR BAG INDICATOR LIGHT FLASHED THEN STAYED ON. DEALERSHIP SERVICED VEHICLE AND REPLACED DRIVER SIDE SEAT AIR BAG. *AK *NM
TURN SIGNALS WORK INTERMITTENLY.*MR
ON JULY 4, 2003 MY 2000 CHEVROLET IMPALA WAS LUBED AT THE CHEVROLET DEALERSHIP BECAUSE OF STEERING ISSUES. THE CAR WOULD VIBRATE, POP, AND JERK WHEN ACCELERATING, SLOWING DOWN OR MAKING TURNS AND STEERING BECOMES VERY TIGHT AND DIFFICULT TO TURN. IT TOOK 3 SEPARATE VISITS TO THE DEALERSHIP BEFORE THEY DISCOVERED WHAT THEY THOU…
Read full complaint
ON JULY 4, 2003 MY 2000 CHEVROLET IMPALA WAS LUBED AT THE CHEVROLET DEALERSHIP BECAUSE OF STEERING ISSUES. THE CAR WOULD VIBRATE, POP, AND JERK WHEN ACCELERATING, SLOWING DOWN OR MAKING TURNS AND STEERING BECOMES VERY TIGHT AND DIFFICULT TO TURN. IT TOOK 3 SEPARATE VISITS TO THE DEALERSHIP BEFORE THEY DISCOVERED WHAT THEY THOUGHT WAS THE SOURCE OF THE PROBLEM. I HAVE SEVERAL CHILDREN AND I AM GREATLY CONCERNED ABOUT OUR SAFETY. I DO NOT KNOW WHAT ELSE TO DO BECAUSE THIS SEEMS TO BE A RECURRING PROBLEM WITH MANY 2000 IMPALAS. I DID A LOT OF RESEACH AND FOUND OTHER COMPLAINTS ON YOUR SITE DUE TO THE SAME ISSUE, AS WELL AS COMPLAINTS ON WWW.IMPALAHQ.COM. I'VE ALSO READ ISSUES WHERE SOME POLICE DEPARTMENTS ARE USING THIS SAME MODEL AND THEY HAVE REPORTED ACCIDENTS DUE TO STEERING LOST, WHICH SEEMS TO BE RELATED TO THE INTERMEDIATE STEERING SHAFT ISSUES. THE LAST STEERING SHAFT LUBE WAS 11 MONTHS AGO AND COST ME $140. LOOKS LIKE I WILL HAVE TO HAVE THIS SERVICE DONE EVERY 10-12 MONTHS TO KEEP THIS CAR FROM LOOSING STEERING. I CAN NOT PUT A PRICE ON THE SAFETY OF MY CHILDREN, BUT I CAN INFORM OTHER AND HOPE CHEVY WILL FIND A SOLUTION TO THIS PROBLEM QUICKLY. *AK
PERIODIC TRANSMISSION SLIP FROM INITIAL DATE OF PURCHASE - DEALER COULD NOT DUPLICATE WHEN TAKEN IN FOR SERVICE, UNTIL OUT OF WARRANTY. REFLASH E-PROM/UPDATE DONE AT 75K MILES TO CORRECT PROBLEM. NOW AT 110K DEALER SAYS NEW TRANSMISSION IS NEEDED AS CAR IS EXHIBITING SAME PROBLEMS. CAR HEADLIGHTS GO OUT WHEN USING HIGH BEAMS. C…
Read full complaint
PERIODIC TRANSMISSION SLIP FROM INITIAL DATE OF PURCHASE - DEALER COULD NOT DUPLICATE WHEN TAKEN IN FOR SERVICE, UNTIL OUT OF WARRANTY. REFLASH E-PROM/UPDATE DONE AT 75K MILES TO CORRECT PROBLEM. NOW AT 110K DEALER SAYS NEW TRANSMISSION IS NEEDED AS CAR IS EXHIBITING SAME PROBLEMS. CAR HEADLIGHTS GO OUT WHEN USING HIGH BEAMS. CAR HAS LOST ALL POWER TWICE WHEN DRIVING AND COMPLETELY SHUT OFF, THUS CAUSING A SIGNIFICANT STEERING PROBLEM UNTIL THE CAR COULD BE STOPPED. GROUNDING WIRES ADDED TO SEE IF CORRECTION COULD BE MADE. LIGHTS & CAR HAVE NOT QUIT YET, BUT TRANSMISSION CONTINUES TO EXHIBIT SHIFTING PROBLEMS WITH CHECK ENGINE LIGHT COMING ON. WHEN CAR IS SHUT OFF THE ENGINE LIGHT WILL GO OUT AND NOT COME BACK ON AND THE CAR WILL RESET IT SELF AND RUN OKAY FOR AWHILE. THE CAR ALSO EXHIBITS A LOUD WHINING NOISE WHEN THE SLIPPAGE / JERKING IS ABOUT TO OCCUR. GM WILL NOT ALLOW CONVERSATION WITH ANYONE BUT A CUSTOMER SERVICE PERSON. ALL FILE NUMBERS GIVEN TO ME BY GM PERSONNEL WHEN CAR WAS UNDER WARRANTY ARE NOT LOADED INTO THEIR DATA BASE, THUS NOTHING CAN BE DONE, MILEAGE IS TOO HIGH AND THESE THINGS ARE EXPECTED TO HAPPEN. *NM
VEHICLE STALLS, MOVING ANYWERE FROM 30-70-MPH. HAS NEARLY CAUSED 4 ACCIDENTS. TWICE WE WERE NEARLY REARENDED; ONCE THIS HAPPENDED WHEN WE WERE PASSING A VEHICLE AND WE LOST CONTROL; AND ONCE THIS OCCURRED AS I WAS DRIVING AROUND A CORNER TOWARDS A GROUP OF CHILDREN. HAS BEEN TO DEALER FOR REPAIR 6 TIMES FOR SAME CAUSE. STILL…
Read full complaint
VEHICLE STALLS, MOVING ANYWERE FROM 30-70-MPH. HAS NEARLY CAUSED 4 ACCIDENTS. TWICE WE WERE NEARLY REARENDED; ONCE THIS HAPPENDED WHEN WE WERE PASSING A VEHICLE AND WE LOST CONTROL; AND ONCE THIS OCCURRED AS I WAS DRIVING AROUND A CORNER TOWARDS A GROUP OF CHILDREN. HAS BEEN TO DEALER FOR REPAIR 6 TIMES FOR SAME CAUSE. STILL NOT CORRECTLY DIAGNOSED OR REPAIRED. IS UNSAFE TO DRIVE. DEALER HAS REPLACED "WIRES", PLUGS, FUEL PUMP, AND COMPUTER "PARTS" TO NO AVAIL.*AK
THE SERVICE VEHICLE SOON AND LOW COOLANT LEVEL LIGHTS KEEP COMING ON. I HAD THE RADIATOR CHECKED AND THERE IS NOTHING WRONG WITH IT. THE LIGHT STILL COMES ON AND SO DID THE SERVICE VEHICLE SOON LIGHT. TOOK THE CAR BACK IN AGAIN TODAY TO GET IT HOPEFULLY FIXED. A SENSOR WAS SHORTING OUT FOR THE DRIVER DISPLAY AND REPLACED. I…
Read full complaint
THE SERVICE VEHICLE SOON AND LOW COOLANT LEVEL LIGHTS KEEP COMING ON. I HAD THE RADIATOR CHECKED AND THERE IS NOTHING WRONG WITH IT. THE LIGHT STILL COMES ON AND SO DID THE SERVICE VEHICLE SOON LIGHT. TOOK THE CAR BACK IN AGAIN TODAY TO GET IT HOPEFULLY FIXED. A SENSOR WAS SHORTING OUT FOR THE DRIVER DISPLAY AND REPLACED. I ALSO HAD TROUBLE LAST YEAR WITH THE DIRECTIONAL SIGNALS GOING NUTS. IT WAS FINALLY DIAGNOSED AS A FAULTY HAZARD SWITCH THAT NEEDED TO BE REPLACED. *LA
I BOUGHT A CHEVY IMPALA IN THE FALL OF 2000 . ONE OF THE SPECIAL FEATURES I HAD WAS THE AUTO DIMMER IN THE REAR VIEW MIRROR . IN DEC. OF 2003 I NOTICED A 1/2 INCH HOLE APPEARING ON THE MIRROR WHICH WAS CLEAR . I GUESS A YELLOW REFLECTIVE COATING IS PUT ON THE MIRROR TO HELP THE DIMMING . I SPOKE WITH A DEALERSHIP ADVISOR FROM TH…
Read full complaint
I BOUGHT A CHEVY IMPALA IN THE FALL OF 2000 . ONE OF THE SPECIAL FEATURES I HAD WAS THE AUTO DIMMER IN THE REAR VIEW MIRROR . IN DEC. OF 2003 I NOTICED A 1/2 INCH HOLE APPEARING ON THE MIRROR WHICH WAS CLEAR . I GUESS A YELLOW REFLECTIVE COATING IS PUT ON THE MIRROR TO HELP THE DIMMING . I SPOKE WITH A DEALERSHIP ADVISOR FROM THE DEALERSHIP I BOUGHT THE CAR AND DIDN'T SEEM CONCERNED AND SAID IF I WANTED A NEW MIRROR OF THIS TYPE IT WOULD COST BETWEEN $200AND $300 . I SAID NO AT THAT TIME . LAST WEEK FRIDAY APRIL 30 , 2004 WHEN I GOT INTO MY CAR AFTER WORK I FOUND THE YELLOW REFLECTIVE COATING HAD JUST ABOUT MELTED AWAY LEAVING ONLY A SMALL COATING AT THE BOTTOM AND WHAT APPEARED WATER DROPLETS ON THE MIRROR ITSELF . I WENT TO A CHEVY DEALERSHIP TO HAVE THIS INCIDENT WITNESSED AND RECORDED IN MY CAR FILE . TWO SERVICE MANAGERS SAID THEY HAD NEVER SEEN ANYTHING LIKE THIS BEFORE . THE FOLLOWING MONDAY I WENT TO THE CAR DEALERSHIP WHERE I BOUGHT THE CAR TO INQUIRE ABOUT MY OPTIONS AND TO HAVE THEM ACTUALLY SEE THE PROBLEM . ON THE WAY OVER I TOUCHED THE BOTTOM OF THE MIRROR AND FOUND A GOOEY BLACK SUBSTANCE ON MY FINGERS . APPARENTLY THE BOTTOM HAD MELTED . THE SERVICE PEOPLE SAID THERE MUST HAVE BEEN AN ELECTRICAL SHORT THAT OCCURED . BUT COULDN'T EXPLAIN ANYTHING ELSE . THE WARRANTY HAD RUN OUT SO THEY SUGGESTED I CALL CHEVY CUSTOMER SERVICE FOR HELP . THEY SET UP A FILE FOR MY COMPLAINT BUT FOUND NO ONE ELSE HAD REPORTED SUCH A PROBLEM . THEY CALLED THE DEALERSHIP TO VERIFY MY STORY AND AGREED EVERYTHING I SAID WAS TRUE . BUT WOULD NOT REPLACE THE MIRROR BECAUSE THE WARRANTY HAD RUN OUT AND BECAUSE OF THE MILEAGE . ACCORDING TO THE DEALERSHIP THE MILEAGE WOULD MAKE NO DIFFERENCE . THE CHEVY REP DID SAY THAT FOR CUSTOMER LOYALTY THEY WOULD GIVE ME A $500 CERTIFICATE IF I WANTED TO BUY A NEW CAR . $200-$300 IS STILL ALOT OF MONEY FOR ME TO INVEST . I DON'T KNOW WHAT I WILL DO BECAUSE I DO WORRY BECAUSE THE DEALERSHIP ADVISOR DID SAY SOMETHING ELS COULD HAPPEN . *AK
THERE IS A CLUNKING AND CLICKING SOUND WHEN STEERING. THIS IS A KNOWN PROBLEM WHERE A LOT OF CONSUMERS HAVE COMPLAINED ABOUT AND CHEVROLET WILL NOT FIX THE PROBLEM AT NO COST. CHEVROLET SAID THAT THEY CAN EITHER CHANGE THE INTERMEDIATE STEERING SHAFT OR USE THE LUBRICATION KIT TO FIX IT. THEY WILL NOT EVEN USE THE LUBRICATON KIT…
Read full complaint
THERE IS A CLUNKING AND CLICKING SOUND WHEN STEERING. THIS IS A KNOWN PROBLEM WHERE A LOT OF CONSUMERS HAVE COMPLAINED ABOUT AND CHEVROLET WILL NOT FIX THE PROBLEM AT NO COST. CHEVROLET SAID THAT THEY CAN EITHER CHANGE THE INTERMEDIATE STEERING SHAFT OR USE THE LUBRICATION KIT TO FIX IT. THEY WILL NOT EVEN USE THE LUBRICATON KIT TO FIX IT AT LEAST. THIS IS NOT RIGHT THAT THE CONSUMER SHOULD PAY FOR A MISTAKE THAT THE MANUFACTURER CREATED DUE TO A LACK OF LUBRICATION . *AK
Official recalls
715V701000 · Engine And Engine Cooling:engine; Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
14V400000 · Electrical System:ignition
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
09V116000 · Engine And Engine Cooling
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
04V090000 · Fuel System, Gasoline:delivery
Feb 24, 2004
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 3800 V6 (L36) ENGINES AND CERTAIN DELPHI FUEL PRESSURE REGULATORS, THE REGULATORS HAVE A MUCH HIGHER THAN USUAL RATE OF FUEL LEAKS. A LEAK CAN ALLOW FUEL TO ENTER THE INTAKE MANIFOLD THROUGH A VACUUM LINE. IF THE ENGINE DOES NOT START WHEN CRANKED, THE FUEL FROM THE LEAKING REGULATOR AND A MISTIMED SPARK CAN CAUSE A BACKFIRE.
Consequence & remedy
Consequence: THE BACKFIRE CAN RUPTURE THE INTAKE MANIFOLD. THE RUPTURE OF THE INTAKE MANIFOLD CAN DISPLACE A FUEL LINE, PULLING AN INJECTOR OUT OF PLACE, AND CAUSING A FUEL LEAK AND POSSIBLE FIRE.
Remedy: DEALERS WILL INSTALL NEW FUEL PRESSURE REGULATORS WITH IMPROVED DIAPHRAGMS. THE RECALL WILL BE CONDUCTED IN PHASED MAILINGS. PHASE 1 BEGAN ON JUNE 30, 2004, AND PHASE 2 BEGAN ON SEPTEMBER 30, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, OLDSMOBILE AT 1-800-630-6537, OR PONTIAC AT 1-800-620-7668.
01V136000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
Apr 24, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH A 3.4L ENGINE AND NON-ANTILOCK BRAKING SYSTEM (ABS). THESE VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." A FUEL RETURN LINE CAN BECOME SEVERED IN A FRONTAL COLLISION, RESULTING IN FUEL SPILLAGE.
Consequence & remedy
Consequence: IF AN IGNITION SOURCE WAS PRESENT, A FIRE COULD OCCUR.
Remedy: DEALERS WILL INSTALL A BRAKE MASTER CYLINDER BRACKET THAT WILL MAINTAIN POSITIONING OF THE FUEL LINE IN A FRONTAL CRASH. OWNER NOTIFICATION BEGAN JUNE 29, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020.
00V371000 · Air Bags:side/window
Nov 13, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME OF THESE VEHICLES EXHIBIT A CONDITION IN WHICH THE DRIVER SIDE IMPACT AIR BAG INFLATOR SEPARATES FROM THE AIR BAG MODULE DURING DEPLOYMENT.
Consequence & remedy
Consequence: IF THE INFLATOR SEPARATES, THE AIR BAG WILL NOT DEPLOY PROPERLY DURING A CRASH AND OCCUPANT PROTECTION WOULD BE REDUCED. IF IS ALSO POSSIBLE THAT A SEPARATED INFLATOR COULD BE PROPELLED DOWNWARD AND COULD RESULT IN INJURY TO A REAR SEAT PASSENGER WHOSE FOOT IS POSITIONED APPROXIMATELY UNDER THE INFLATOR MODULE.
Remedy: DEALERS WILL REPLACE THE SIDE IMPACT AIR BAG MODULE.
00V228003 · Seat Belts
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE00005 · Inadvertent Engine Stalling
Opened Jan 19, 2000 · Closed Feb 29, 2000
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available