NHTSA owner reports · September 18, 2026 snapshot.
Steering complaints
124 reportsClear category filterMileage unknown · Jul 10, 2019
Electrical SystemService BrakesSteeringCrashInjury
TL* THE CONTACT OWNED A 2000 CHEVROLET IMPALA. THE CONTACT STATED THAT THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM). THE CONTACT DID NOT RECEIVE A RECALL NOTIFICATION AND STATED THAT THE VEHICLE EXPERIENCED THE FAILURE LISTED IN THE RECALL CAMPAIGN. WHILE DRIVING 50 MPH, THE KEY POSITION MOVED…
Read full complaint
TL* THE CONTACT OWNED A 2000 CHEVROLET IMPALA. THE CONTACT STATED THAT THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM). THE CONTACT DID NOT RECEIVE A RECALL NOTIFICATION AND STATED THAT THE VEHICLE EXPERIENCED THE FAILURE LISTED IN THE RECALL CAMPAIGN. WHILE DRIVING 50 MPH, THE KEY POSITION MOVED WHILE IT WAS IN THE IGNITION. THE FAILURE AFFECTED THE ENGINE, POWER STEERING, AND THE CONTACT WAS UNABLE TO BRAKE. AS A RESULT, THE CONTACT CRASHED HEAD ON INTO ANOTHER VEHICLE. THE DRIVER'S SIDE AND FRONT PASSENGER SIDE AIR BAGS DEPLOYED. A POLICE REPORT WAS FILED. THE INSURANCE COMPANY WAS NOTIFIED AND DECLARED THE VEHICLE DESTROYED. THE DRIVER SUSTAINED AN EXTENSIVE LACERATION WHEN THE DRIVER'S SIDE AIR BAG COMPONENTS PROJECTED FROM THE STEERING WHEEL. THE DRIVER HAD CONTINUOUS HEADACHES AND THE INJURY REQUIRED STITCHES. CHEVROLET OF MORRISTOWN (5320 WEST ANDREW JOHNSON HWY, MORRISTOWN, TN 37814, 423-408-2966) WAS NOTIFIED AND DID NOT ASSIST. THE MANUFACTURER SUGGESTED THAT THE CONTACT CALL A LAWYER. THE MANUFACTURER WAS NOT INITIALLY NOTIFIED OF THE CRASH, BUT WAS LATER CONTACTED TO REPORT THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.
NHTSA ODI #11230751
195,795 miles · Mar 16, 2017
Electrical SystemSteering
TL* THE CONTACT OWNS A 2000 CHEVROLET IMPALA. THE CONTACT STATED THAT THE STEERING WHEEL SEIZED AND AN UNKNOWN FLASHING WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 195,795.
NHTSA ODI #10966402
155,000 miles · Jul 22, 2016
Steering
TL* THE CONTACT OWNS A 2000 CHEVROLET IMPALA. WHILE DRIVING 25 MPH, THE STEERING WHEEL SEIZED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS EXCLUDED FROM NHTSA CAMPAIGN NUMBERS: 09E005000 (STEERING) AND 08E063000 (STEERING). THE…
Read full complaint
TL* THE CONTACT OWNS A 2000 CHEVROLET IMPALA. WHILE DRIVING 25 MPH, THE STEERING WHEEL SEIZED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS EXCLUDED FROM NHTSA CAMPAIGN NUMBERS: 09E005000 (STEERING) AND 08E063000 (STEERING). THE FAILURE MILEAGE WAS APPROXIMATELY 155,000.
NHTSA ODI #10887737
181,038 miles · Feb 2, 2016
SteeringSuspension
I HAVE SEEN A LOT OF PEOPLE SAY THAT THEIR RACK AND PINION HAS BROKEN AND THEY HAVE FIX IT AND IT HAS BROKEN AGAIN. THE RACK AND PINION ON MY CAR HAS BROKEN. I DONT FEEL VERY COMFORTABLE WITH DRIVING THIS CAR AT ALL. THEY TOLD ME THAT THE TIRE IS ABOUT TO FALL OFF. CAN YOU PLEASE GET THIS FIX. THE CAR HAS BEEN DRIVING VERY WELL …
Read full complaint
I HAVE SEEN A LOT OF PEOPLE SAY THAT THEIR RACK AND PINION HAS BROKEN AND THEY HAVE FIX IT AND IT HAS BROKEN AGAIN. THE RACK AND PINION ON MY CAR HAS BROKEN. I DONT FEEL VERY COMFORTABLE WITH DRIVING THIS CAR AT ALL. THEY TOLD ME THAT THE TIRE IS ABOUT TO FALL OFF. CAN YOU PLEASE GET THIS FIX. THE CAR HAS BEEN DRIVING VERY WELL ON THE STREETS AND HIGHWAY. IT HAS STARTED TO SHAKE WHILE I WAS ON THE HIGHWAY. I MADE IT HOME SAFE TO BE TOLD THAT MY RACK AND PINION HAD BROKE. I FEAR FOR MY LIFE IF SOMETHING WOULD HAVE HAPPEN AS I WAS DRIVING ON THE HIGHWAY.
NHTSA ODI #10823725
76,000 miles · Jan 4, 2016
Steering
TL* THE CONTACT OWNS A 2000 CHEVROLET IMPALA. THE CONTACT STATED THAT WHILE DRIVING 20 MPH AND COMING TO A STOP, THE CONTACT NOTICED THAT THE STEERING WHEEL SEIZED WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE CONTACTS RESIDENCE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE F…
Read full complaint
TL* THE CONTACT OWNS A 2000 CHEVROLET IMPALA. THE CONTACT STATED THAT WHILE DRIVING 20 MPH AND COMING TO A STOP, THE CONTACT NOTICED THAT THE STEERING WHEEL SEIZED WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE CONTACTS RESIDENCE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 76,000.
NHTSA ODI #10817657
10,000 miles · Dec 22, 2015
SteeringCrash
TL* THE CONTACT RENTED A 2000 CHEVROLET IMPALA. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 45 MPH DURING INCLEMENT WEATHER, THE VEHICLE SKIDDED OUT OF CONTROL TO THE LEFT, THE CONTACT APPLIED FORCE TO THE STEERING WHEEL BUT IT DID NOT RESPOND CAUSING THE CONTACTS VEHICLE TO BE SCRAPED ON THE LEFT SIDE FROM A GUARD RA…
Read full complaint
TL* THE CONTACT RENTED A 2000 CHEVROLET IMPALA. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 45 MPH DURING INCLEMENT WEATHER, THE VEHICLE SKIDDED OUT OF CONTROL TO THE LEFT, THE CONTACT APPLIED FORCE TO THE STEERING WHEEL BUT IT DID NOT RESPOND CAUSING THE CONTACTS VEHICLE TO BE SCRAPED ON THE LEFT SIDE FROM A GUARD RAIL. THE CONTACT STATED THAT THE VEHICLE THEN VEERED TO THE RIGHT AND SLIGHTLY WENT OVER A CURB. THE POWER STEERING WARNING LIGHT FLASHED WHEN THE FAILURE OCCURRED. THE CONTACT WAS ABLE TO PULL THE VEHICLE OFF TO THE SIDE OF THE ROAD, TURNED OFF THE VEHICLE AND WAS ABLE TO RESTART. THE DRIVER DID NOT SUSTAIN ANY INJURIES AND NO MEDICAL ATTENTION. A POLICE REPORT WAS NOT FILED. THE RENTAL COMPANY WAS NOTIFIED OF THE POWER STEERING FAILURE. THE MANUFACTURER WAS ALSO NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 10,000.
NHTSA ODI #10811757
160,000 miles · Feb 16, 2015
Fuel/propulsion SystemSteeringCrash
THE CAR SAID ENGINE POWER REDUCED. STARTING DISABLED AND CUT OFF. LOSING ALL CONTROL OF BRAKES STEERING AND ACCELERATION. AT THIS POINT I REARENDED ANOTHER VEHICLE. *TR
NHTSA ODI #10683592
168,000 miles · Oct 28, 2014
EngineSteering
TL* THE CONTACT OWNS A 2000 CHEVROLET IMPALA. WHILE DRIVING APPROXIMATELY 35 MPH, THE STEERING WHEEL BECAME DIFFICULT TO TURN AND THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE MI…
Read full complaint
TL* THE CONTACT OWNS A 2000 CHEVROLET IMPALA. WHILE DRIVING APPROXIMATELY 35 MPH, THE STEERING WHEEL BECAME DIFFICULT TO TURN AND THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 168,000.
NHTSA ODI #10650851
165,000 miles · Oct 27, 2014
Electrical SystemPower TrainSteering
FOLLOW-UP ON COMPLAINT# 10650094. I HAVE RESEARCHED THIS PROBLEM,AND TRIED TO GET ASSISTANCE FROM GM WITH NO RESULTS OTHER THAT THE RUN-AROUND. I HAVE EXPLAINED THAT THE RECALL OF THIS VEHICLE AND REPAIR THAT IS SUGGESTED IS NOT THE ISSUE. THE IGNITION IS A 2 PART SWITCH AND THE MECHANICAL PART OF THE SWITCH IS ONLY PART OF THE…
Read full complaint
FOLLOW-UP ON COMPLAINT# 10650094. I HAVE RESEARCHED THIS PROBLEM,AND TRIED TO GET ASSISTANCE FROM GM WITH NO RESULTS OTHER THAT THE RUN-AROUND. I HAVE EXPLAINED THAT THE RECALL OF THIS VEHICLE AND REPAIR THAT IS SUGGESTED IS NOT THE ISSUE. THE IGNITION IS A 2 PART SWITCH AND THE MECHANICAL PART OF THE SWITCH IS ONLY PART OF THE PROBLEM. THE ISSUE IN MY CASE IS THAT THE ELECTRICAL PART OF THE SWITCH IS WHAT CONTROLS THE POWER, BRAKES, AIRBAG, AND ALL OTHER FUNCTIONS. YOU NEED TO LOOK AT THE ENTIRE SWITCH ASSEMBLY. THE ELECTRICAL PART IS WHAT FAILED. *TR
NHTSA ODI #10650360
167,000 miles · Oct 26, 2014
Service BrakesSteering
I WAS HEADING TO WORK I SLOWED TO TURN RIGHT ON TO THE ON RAMP OF THE INTERSTATE, AS I BEGAN MY TURN I LOST ALL POWER THE VEHICLE SHUT OFF, LIGHTS WENT DEAD AND THE BRAKES WENT OUT. I MADE IT TO THE CURB AND VEHICLE WOULD NOT RESTART.VEHICLE HAD TO BE TOWED HOME. I HAVE CHECKED ALL THAT COULD HAVE CAUSED THE ISSUE AND HAVE NARRO…
Read full complaint
I WAS HEADING TO WORK I SLOWED TO TURN RIGHT ON TO THE ON RAMP OF THE INTERSTATE, AS I BEGAN MY TURN I LOST ALL POWER THE VEHICLE SHUT OFF, LIGHTS WENT DEAD AND THE BRAKES WENT OUT. I MADE IT TO THE CURB AND VEHICLE WOULD NOT RESTART.VEHICLE HAD TO BE TOWED HOME. I HAVE CHECKED ALL THAT COULD HAVE CAUSED THE ISSUE AND HAVE NARROWED IT DOWN TO THE IGNITION SWITCH, BATTERY HAS BEEN REPLACED EVEN THOUGH IT CHECKED FINE. STARTER IS BRAND NEW. MASS AIR SENSOR CHECKS OK AND CAM AND CRANK SENSORS CHECK OK. I WAS LUCKY IF I HAD BEEN ON THE INTERSTATE I WOULD HAVE HAD NO CHANCE TO RECOVER FROM THIS FAILURE. EVEN THOUGH THIS VEHICLE IS 14 YEARS OLD THIS TYPE OF FAILURE SHOULD NOT HAVE HAPPENED. I HAVE NEVER CARRIED MORE THAN THE IGNITION KEY AND KEY FOB ON THE KEY RING AS BOTH MY WIFE AND I USE THE VEHICLE. *TR
NHTSA ODI #10650094
Official recalls
7Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Feb 24, 2004
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 3800 V6 (L36) ENGINES AND CERTAIN DELPHI FUEL PRESSURE REGULATORS, THE REGULATORS HAVE A MUCH HIGHER THAN USUAL RATE OF FUEL LEAKS. A LEAK CAN ALLOW FUEL TO ENTER THE INTAKE MANIFOLD THROUGH A VACUUM LINE. IF THE ENGINE DOES NOT START WHEN CRANKED, THE FUEL FROM THE LEAKING REGULATOR AND A MISTIMED SPARK CAN CAUSE A BACKFIRE.
Consequence & remedy
Consequence: THE BACKFIRE CAN RUPTURE THE INTAKE MANIFOLD. THE RUPTURE OF THE INTAKE MANIFOLD CAN DISPLACE A FUEL LINE, PULLING AN INJECTOR OUT OF PLACE, AND CAUSING A FUEL LEAK AND POSSIBLE FIRE.
Remedy: DEALERS WILL INSTALL NEW FUEL PRESSURE REGULATORS WITH IMPROVED DIAPHRAGMS. THE RECALL WILL BE CONDUCTED IN PHASED MAILINGS. PHASE 1 BEGAN ON JUNE 30, 2004, AND PHASE 2 BEGAN ON SEPTEMBER 30, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, OLDSMOBILE AT 1-800-630-6537, OR PONTIAC AT 1-800-620-7668.
Apr 24, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH A 3.4L ENGINE AND NON-ANTILOCK BRAKING SYSTEM (ABS). THESE VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." A FUEL RETURN LINE CAN BECOME SEVERED IN A FRONTAL COLLISION, RESULTING IN FUEL SPILLAGE.
Consequence & remedy
Consequence: IF AN IGNITION SOURCE WAS PRESENT, A FIRE COULD OCCUR.
Remedy: DEALERS WILL INSTALL A BRAKE MASTER CYLINDER BRACKET THAT WILL MAINTAIN POSITIONING OF THE FUEL LINE IN A FRONTAL CRASH. OWNER NOTIFICATION BEGAN JUNE 29, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020.
Nov 13, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME OF THESE VEHICLES EXHIBIT A CONDITION IN WHICH THE DRIVER SIDE IMPACT AIR BAG INFLATOR SEPARATES FROM THE AIR BAG MODULE DURING DEPLOYMENT.
Consequence & remedy
Consequence: IF THE INFLATOR SEPARATES, THE AIR BAG WILL NOT DEPLOY PROPERLY DURING A CRASH AND OCCUPANT PROTECTION WOULD BE REDUCED. IF IS ALSO POSSIBLE THAT A SEPARATED INFLATOR COULD BE PROPELLED DOWNWARD AND COULD RESULT IN INJURY TO A REAR SEAT PASSENGER WHOSE FOOT IS POSITIONED APPROXIMATELY UNDER THE INFLATOR MODULE.
Remedy: DEALERS WILL REPLACE THE SIDE IMPACT AIR BAG MODULE.
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE00005 · Inadvertent Engine Stalling
Opened Jan 19, 2000 · Closed Feb 29, 2000
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
Illustration