NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
159 reportsClear category filter75,000 miles · Dec 9, 2007
Electrical SystemEngine And Engine CoolingService Brakes, HydraulicCrashInjury
CAR WENT OUT OF CONTROL AFTER DRIVER PUT THE CAR INTO GEAR TO MOVE IT FROM A PARKED, IDLING POSITION, AFTER NOTICING A BURNING LIKE ODOR. IT WAS NOTED BY THE DRIVER AT THAT TIME THAT THE TEMPERATURE GAUGE WAS IN THE RED ZONE. WHEN THE DRIVER ATTEMPTED TO MOVE THE CAR TO A SAFER PARKING AREA ONLY A FEW FEET IN DISTANCE, SHE HEA…
Read full complaint
CAR WENT OUT OF CONTROL AFTER DRIVER PUT THE CAR INTO GEAR TO MOVE IT FROM A PARKED, IDLING POSITION, AFTER NOTICING A BURNING LIKE ODOR. IT WAS NOTED BY THE DRIVER AT THAT TIME THAT THE TEMPERATURE GAUGE WAS IN THE RED ZONE. WHEN THE DRIVER ATTEMPTED TO MOVE THE CAR TO A SAFER PARKING AREA ONLY A FEW FEET IN DISTANCE, SHE HEARD A SHARP SNAPPING SOUND AND ALSO FELT A VIBRATION IN THE STEERING WHEEL/COLUMN AREA. THE CAR SUDDENLY LURCHED FORWARD, THE HEAD LIGHTS AND DASH LIGHTING WENT COMPLETELY OUT AS THE CAR BEGAN ACCELERATING OUT OF CONTROL. IN ADDITION, THERE WAS NO STEERING OR BRAKE CONTROL. NO WORK HAS BEEN DONE YET TO CORRECT THESE PROBLEMS BECAUSE AN INSURANCE COMPANY IS INVOLVED. *TR
NHTSA ODI #10211275
123,100 miles · Jun 16, 2007
Engine And Engine Cooling
ONE DAY IT JUST GOT WARM. WE TURNED IT OFF AND THE RADIATOR BUBBLED. I LET IT COOLED DOWN. I CHECKED THE OIL AND WATER. IT WAS PROBABLY A QUART LOW AND THE OIL LOOKED A TOUCH MILKY. OIL WAS NOT OVER FULL. I ASSUMED IT WAS FINE. THE NEXT TRIP TO TOWN AND BACK(ABOUT 20 MILES ROUND TRIP)IT RAN WARM ON THE WAY HOME. WHEN WE GOT HOME…
Read full complaint
ONE DAY IT JUST GOT WARM. WE TURNED IT OFF AND THE RADIATOR BUBBLED. I LET IT COOLED DOWN. I CHECKED THE OIL AND WATER. IT WAS PROBABLY A QUART LOW AND THE OIL LOOKED A TOUCH MILKY. OIL WAS NOT OVER FULL. I ASSUMED IT WAS FINE. THE NEXT TRIP TO TOWN AND BACK(ABOUT 20 MILES ROUND TRIP)IT RAN WARM ON THE WAY HOME. WHEN WE GOT HOME THE RADIATOR WAS BOILING A LITTLE BIT AGAIN. AFTER IT COOLED OFF I CHECKED THE WATER IS HALF TO THREE QUARTERS GALLON LOW ON WATER. OIL WAS REGISTERING A LITTLE MORE THAN A QUART OVER FULL AND REAL MILKY LOOKING. THAT IS WHEN I NOTICED THERE WAS A PROBLEM. I CHANGE OIL AND FILTER. TOPPED OFF WATER. I ADDED SOME ALUMINUM SEAL AND TOPPED OFF THE WATER. AFTER I DID THAT IT SEEMED LIKE IT WAS FIXED FOR ABOUT 8 DAYS THEN IT DID IT AGAIN. I HAVEN'T STARTED IT OR DRIVEN IT SINCE. IT IS GOING TO COST ABOUT 500-800 DOLLARS TO GET IT FIXED. MY COMPLAINT IS THAT GENERAL MOTORS KNOWS ABOUT THE INTAKE MANIFOLD GASKET PROBLEM BUT THEY WON'T RECALL ANY OF THESE VEHICLES. THERE IS EVEN A PETITION ONLINE TO GET THEM TO. MY CAR IS A 2000 CHEVROLET IMPALA. I DIDN'T FEEL LIKE I SHOULD HAVE TO PAY FOR THEIR MISTAKE. I CAN'T AFFORD TO GET IT FIXED AND I AM STILL MAKING PAYMENTS ON IT. I DIDN'T WANT IT TO GO TO WASTE IT IS A VERY NICE CAR. I REALLY LIKE MY CAR. I WISH I COULD DRIVE IT. *AK
NHTSA ODI #10193490
40 miles · Feb 23, 2007
Electrical SystemEngine And Engine Cooling
PASSLOCK SYSTEM FAILURE 3 TIMES IN 100,000 MILES $300 REPAIR EACH TIME. STRANDED IN PARKING LOTS TILL THE CAR RESETS THEN WILL START. MY WIFE IS SCARED TO DEATH WHEN SHE IS IN THE PARKING LOT JUST SITTING THERE WAITING FOR THE CAR TO RESET. INTAKE GASKET FAILURE 2 TIMES IN 100,000 MILES $600 EACH TIME. SUB FRAME FAILURE INT…
Read full complaint
PASSLOCK SYSTEM FAILURE 3 TIMES IN 100,000 MILES $300 REPAIR EACH TIME. STRANDED IN PARKING LOTS TILL THE CAR RESETS THEN WILL START. MY WIFE IS SCARED TO DEATH WHEN SHE IS IN THE PARKING LOT JUST SITTING THERE WAITING FOR THE CAR TO RESET. INTAKE GASKET FAILURE 2 TIMES IN 100,000 MILES $600 EACH TIME. SUB FRAME FAILURE INTERMEDIATE SHAFT FAILURE 3 TIMES. *JB
NHTSA ODI #10183306
56,000 miles · Feb 16, 2007
Engine And Engine Cooling
INTAKE MANIFOLD GASKET LEAK ON 2000 CHEVY IMPALA. *NM
NHTSA ODI #10182754
25,000 miles · Nov 24, 2006
Engine And Engine Cooling
DT*: THE CONTACT STATED WHILE DRIVING 30 MPH ON NORMAL ROAD CONDITIONS, THE ENGINE STALLED. THERE WERE NO WARNINGS PRIOR TO THE INCIDENT. THE VEHICLE WAS TAKEN TO THE SERVICE DEALER, WHO COULD NOT DETERMINE THE CAUSE OF THE PROBLEM.
NHTSA ODI #10174180
78,000 miles · Oct 24, 2006
Engine And Engine Cooling
2000 CHEVROLET IMPALA LS, 3.8 ENGINE. AT 78,000 MILES THE "LOWER INTAKE MANIFOLD GASKET" FAILED CAUSING LOSS OF COOLANT. REQUIRED $804 REPAIR. MY RESEARCH INDICATES THIS IS A WIDESPREAD PATTERN FAILURE OF GM 3.8 LITER ENGINES OF THAT YEAR, DUE TO INSUFFICIENT TORQUE ON THE INTAKE MANIFOLD BOLTS AND/OR A FAULTY GASKET. T…
Read full complaint
2000 CHEVROLET IMPALA LS, 3.8 ENGINE. AT 78,000 MILES THE "LOWER INTAKE MANIFOLD GASKET" FAILED CAUSING LOSS OF COOLANT. REQUIRED $804 REPAIR. MY RESEARCH INDICATES THIS IS A WIDESPREAD PATTERN FAILURE OF GM 3.8 LITER ENGINES OF THAT YEAR, DUE TO INSUFFICIENT TORQUE ON THE INTAKE MANIFOLD BOLTS AND/OR A FAULTY GASKET. THIS AFFECTS OTHER GM BRANDS USING THE SAME ENGINE. A PROPERLY MAINTAINED ENGINE SHOULD NOT SUFFER THIS TYPE OF FAILURE AT 78K MILES. *NM
NHTSA ODI #10171754
97,000 miles · Sep 12, 2006
Electrical SystemEngine And Engine Cooling
I HAVE A 2000 IMPALA LS WITH 97000 MILES. THE CAR WILL STALL AT HIGHWAY SPEED. THIS HAS HAPPENED TO BOTH MY WIFE AND MYSELF SEVERAL TIMES THIS SUMMER. THE CAR HAS BEEN IN THE DEALERSHIP FOR 3 OF THE LAST 4 WEEKS AND I AM TOLLED THEY CAN'T FIND THE PROBLEM. I HAVE DONE A INTERNET CHECK AND HAVE FOUNDED SEVERAL OTHER OWNERS WITH…
Read full complaint
I HAVE A 2000 IMPALA LS WITH 97000 MILES. THE CAR WILL STALL AT HIGHWAY SPEED. THIS HAS HAPPENED TO BOTH MY WIFE AND MYSELF SEVERAL TIMES THIS SUMMER. THE CAR HAS BEEN IN THE DEALERSHIP FOR 3 OF THE LAST 4 WEEKS AND I AM TOLLED THEY CAN'T FIND THE PROBLEM. I HAVE DONE A INTERNET CHECK AND HAVE FOUNDED SEVERAL OTHER OWNERS WITH THE SAME ISSUE. THIS NEEDS TO BE ADDRESSED BEFORE SOMEONE IS KILLED. *NM
NHTSA ODI #10167928
74,900 miles · Aug 30, 2006
Engine And Engine Cooling
DT*: THE CONTACT STATED WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE STALLED DURING STARTUP AND CRUISING. THE ENGINE STALLED 35 TIMES. THE VEHICLE WOULD USUALLY RESTARTED AFTER 5 TO 11 ATTEMPTS. ON 08/24/06, THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP WHO WAS UNABLE TO LOCATE THE …
Read full complaint
DT*: THE CONTACT STATED WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE STALLED DURING STARTUP AND CRUISING. THE ENGINE STALLED 35 TIMES. THE VEHICLE WOULD USUALLY RESTARTED AFTER 5 TO 11 ATTEMPTS. ON 08/24/06, THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP WHO WAS UNABLE TO LOCATE THE CAUSE OF THE PROBLEM. THE MANUFACTURER WAS CONTACTED AND A COMPLAINT WAS TAKEN.
NHTSA ODI #10167052
89,400 miles · Aug 25, 2006
Electrical SystemEngine And Engine Cooling
DT*: THE CONTACT STATED WITHOUT WARNING THE VEHICLE STALLED INTERMITTENTLY AT VARIOUS SPEEDS. THE CONSUMER ATTEMPTED TO RESTART THE VEHICLE. AT TIME IT WOULD START RIGHT UP. OTHER TIMES THE VEHICLE HAD TO COOL DOWN BEFORE IT WOULD RESTART. THE DEALERSHIP REPROGRAMMED THE COMPUTER BUT THE PROBLEM PERSISTED. *AK UPDATED 9/2…
Read full complaint
DT*: THE CONTACT STATED WITHOUT WARNING THE VEHICLE STALLED INTERMITTENTLY AT VARIOUS SPEEDS. THE CONSUMER ATTEMPTED TO RESTART THE VEHICLE. AT TIME IT WOULD START RIGHT UP. OTHER TIMES THE VEHICLE HAD TO COOL DOWN BEFORE IT WOULD RESTART. THE DEALERSHIP REPROGRAMMED THE COMPUTER BUT THE PROBLEM PERSISTED. *AK UPDATED 9/22/2006 - THE VEHICLE STALLED A COUPLE TIMES A WEEK. *NM
NHTSA ODI #10166535
97,500 miles · Jun 13, 2006
Electrical SystemEngine And Engine CoolingFire
DT*: THE CONTACT STATED THE ENGINE WOULD NOT START AFTER THE VEHICLE WAS PARKED OVERNIGHT. INITIALLY, IT WAS SUSPECTED THE BATTERY WAS DISCHARGED AND THE BATTERY WAS CHARGED FOR TWENTY MINUTES. AFTERWARDS, THE CONTACT ATTEMPTED TO START THE VEHICLE, WITH THE KEY IN THE IGNITION, AND THE INTAKE MANIFOLD EXPLODED. A LARGE FIRE…
Read full complaint
DT*: THE CONTACT STATED THE ENGINE WOULD NOT START AFTER THE VEHICLE WAS PARKED OVERNIGHT. INITIALLY, IT WAS SUSPECTED THE BATTERY WAS DISCHARGED AND THE BATTERY WAS CHARGED FOR TWENTY MINUTES. AFTERWARDS, THE CONTACT ATTEMPTED TO START THE VEHICLE, WITH THE KEY IN THE IGNITION, AND THE INTAKE MANIFOLD EXPLODED. A LARGE FIREBALL ALONG WITH PIECES OF THE INTAKE MANIFOLD AND THE ENGINE COVER SHOT OUT OF THE UNDERHOOD AREA. THE VEHICLE WAS TOWED TO A DEALER FOR INSPECTION. THE DEALER DETERMINED THE BACKFIRING OCCURRED DUE TO THE CONTACT STARTING THE ENGINE WHILE APPLYING THE ACCELERATOR PEDAL. THE MANUFACTURER WAS ALERTED.
NHTSA ODI #10159726
Official recalls
7Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Feb 24, 2004
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 3800 V6 (L36) ENGINES AND CERTAIN DELPHI FUEL PRESSURE REGULATORS, THE REGULATORS HAVE A MUCH HIGHER THAN USUAL RATE OF FUEL LEAKS. A LEAK CAN ALLOW FUEL TO ENTER THE INTAKE MANIFOLD THROUGH A VACUUM LINE. IF THE ENGINE DOES NOT START WHEN CRANKED, THE FUEL FROM THE LEAKING REGULATOR AND A MISTIMED SPARK CAN CAUSE A BACKFIRE.
Consequence & remedy
Consequence: THE BACKFIRE CAN RUPTURE THE INTAKE MANIFOLD. THE RUPTURE OF THE INTAKE MANIFOLD CAN DISPLACE A FUEL LINE, PULLING AN INJECTOR OUT OF PLACE, AND CAUSING A FUEL LEAK AND POSSIBLE FIRE.
Remedy: DEALERS WILL INSTALL NEW FUEL PRESSURE REGULATORS WITH IMPROVED DIAPHRAGMS. THE RECALL WILL BE CONDUCTED IN PHASED MAILINGS. PHASE 1 BEGAN ON JUNE 30, 2004, AND PHASE 2 BEGAN ON SEPTEMBER 30, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, OLDSMOBILE AT 1-800-630-6537, OR PONTIAC AT 1-800-620-7668.
Apr 24, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH A 3.4L ENGINE AND NON-ANTILOCK BRAKING SYSTEM (ABS). THESE VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." A FUEL RETURN LINE CAN BECOME SEVERED IN A FRONTAL COLLISION, RESULTING IN FUEL SPILLAGE.
Consequence & remedy
Consequence: IF AN IGNITION SOURCE WAS PRESENT, A FIRE COULD OCCUR.
Remedy: DEALERS WILL INSTALL A BRAKE MASTER CYLINDER BRACKET THAT WILL MAINTAIN POSITIONING OF THE FUEL LINE IN A FRONTAL CRASH. OWNER NOTIFICATION BEGAN JUNE 29, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020.
Nov 13, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME OF THESE VEHICLES EXHIBIT A CONDITION IN WHICH THE DRIVER SIDE IMPACT AIR BAG INFLATOR SEPARATES FROM THE AIR BAG MODULE DURING DEPLOYMENT.
Consequence & remedy
Consequence: IF THE INFLATOR SEPARATES, THE AIR BAG WILL NOT DEPLOY PROPERLY DURING A CRASH AND OCCUPANT PROTECTION WOULD BE REDUCED. IF IS ALSO POSSIBLE THAT A SEPARATED INFLATOR COULD BE PROPELLED DOWNWARD AND COULD RESULT IN INJURY TO A REAR SEAT PASSENGER WHOSE FOOT IS POSITIONED APPROXIMATELY UNDER THE INFLATOR MODULE.
Remedy: DEALERS WILL REPLACE THE SIDE IMPACT AIR BAG MODULE.
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE00005 · Inadvertent Engine Stalling
Opened Jan 19, 2000 · Closed Feb 29, 2000
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
Illustration