NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
187 reportsClear category filter203,000 miles · Aug 11, 2010
Electrical SystemExterior Lighting
TL*THE CONTACT OWNS A 2000 CHEVROLET IMPALA. THE CONTACT STATED THAT THE COMBINATION CONTROL SWITCH WAS DEFECTIVE. WHENEVER THE HIGH BEAMS WERE ON AND THE LOW BEAMS WERE ACTIVATED THEY WOULD NOT FUNCTION INDEPENDENTLY. THE GEAR LEVER BOX THAT WAS ILLUMINATED AT NIGHT ALSO FAILED. THE VIN WAS NOT AVAILABLE. THE VEHICLE WAS NOT R…
Read full complaint
TL*THE CONTACT OWNS A 2000 CHEVROLET IMPALA. THE CONTACT STATED THAT THE COMBINATION CONTROL SWITCH WAS DEFECTIVE. WHENEVER THE HIGH BEAMS WERE ON AND THE LOW BEAMS WERE ACTIVATED THEY WOULD NOT FUNCTION INDEPENDENTLY. THE GEAR LEVER BOX THAT WAS ILLUMINATED AT NIGHT ALSO FAILED. THE VIN WAS NOT AVAILABLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 208,000.
NHTSA ODI #10348872
114,000 miles · Jun 14, 2010
Electrical SystemExterior Lighting
MY DAUGHTER WITH HER PERMIT WAS DRIVING THE VEHICLE AND THE TURN SIGNALS STOPPED WORKING IN THE MIDDLE OF TRAFFIC. LUCKILY SHE PULLED OVER SAFELY AND I CONTINUED TO DRIVE HOME. THE HAZARDS WORKED FINE AND AFTER SOME RESEARCH, THE HAZARD SWITCH IS THE FAILURE. THIS HAS BEEN GOING ON INTERMITTENTLY FOR A MONTH AND FINALLY THEY WOU…
Read full complaint
MY DAUGHTER WITH HER PERMIT WAS DRIVING THE VEHICLE AND THE TURN SIGNALS STOPPED WORKING IN THE MIDDLE OF TRAFFIC. LUCKILY SHE PULLED OVER SAFELY AND I CONTINUED TO DRIVE HOME. THE HAZARDS WORKED FINE AND AFTER SOME RESEARCH, THE HAZARD SWITCH IS THE FAILURE. THIS HAS BEEN GOING ON INTERMITTENTLY FOR A MONTH AND FINALLY THEY WOULD WORK ONLY ONE TIME AFTER CAR WAS TURNED ON. MY LOCAL DEALER WANTED $400 DOLLARS FOR A $60 PART AND LABOR. THANK GOD FOR USED PARTS AND AN EASY DASH REMOVE ONLY SEVEN BOLTS INSTRUCTIONS ONLINE. DO IT YOURSELF FOR CHEAP. MY DAUGHTER AT 16 DID MOST OF IT AS I TOLD HER WITH INSTRUCTIONS. I DO LOVE CHEVY WILL REMAIN LOYAL BUT THEY NEED TO WAKE UP AND SOLVE SOME ISSUES. *TR
NHTSA ODI #10336150
Mileage unknown · Apr 12, 2010
Electrical SystemFire
TL*THE CONTACT OWNED A 2000 CHEVROLET IMPALA. THE CONTACT WAS DRIVING APPROXIMATELY 65 MPH AND OBSERVED SMOKE COMING FROM THE VEHICLE. THE VEHICLE WAS DRIVEN TO THE SIDE OF THE ROAD AND THE FIRE WAS EXTINGUISHED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER. THE CAUSE OF THE FIRE HAD NOT BEEN DETERMINED. THERE WAS A RECALL DEF…
Read full complaint
TL*THE CONTACT OWNED A 2000 CHEVROLET IMPALA. THE CONTACT WAS DRIVING APPROXIMATELY 65 MPH AND OBSERVED SMOKE COMING FROM THE VEHICLE. THE VEHICLE WAS DRIVEN TO THE SIDE OF THE ROAD AND THE FIRE WAS EXTINGUISHED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER. THE CAUSE OF THE FIRE HAD NOT BEEN DETERMINED. THERE WAS A RECALL DEFECT WHICH THE MANUFACTURER FAILED TO HONOR. THE NHTSA CAMPAIGN ID NUMBER WAS UNKNOWN. THE FAILURE AND CURRENT MILEAGES WERE UNAVAILABLE.
NHTSA ODI #10325188
99,000 miles · Mar 24, 2010
Electrical SystemFuel System, GasolineFireInjury
ON FEB.10TH OR 11TH.MY NEIGHBOR WAS ATTEMPTING TO JUMP START MY CAR BECAUSE THE BATTERY HAD FAILED DUE TO A 3 DAY SNOW STORM. AFTER TURNED THE IGNITION THE SECOND TIME, THERE WAS A LOUD BOOM. WHEN WE CHECKED THE ENGINE, WE NOTED THE MANIFOLD COVER HAD CRACKED INTO SEVERAL PIECES. ALSO THE WIRES WERE ON FIRE. MY NEIGHBOR QUICKL…
Read full complaint
ON FEB.10TH OR 11TH.MY NEIGHBOR WAS ATTEMPTING TO JUMP START MY CAR BECAUSE THE BATTERY HAD FAILED DUE TO A 3 DAY SNOW STORM. AFTER TURNED THE IGNITION THE SECOND TIME, THERE WAS A LOUD BOOM. WHEN WE CHECKED THE ENGINE, WE NOTED THE MANIFOLD COVER HAD CRACKED INTO SEVERAL PIECES. ALSO THE WIRES WERE ON FIRE. MY NEIGHBOR QUICKLY EXTINGUISHED THE FLAMES. LATER, I WENT TO MY DEALER(FRANK Z CHEVROLET IN DAYTON, OH. ABOUT THE PROBLEM. I WAS TOLD BY THE ASSISTANT SERVICE MANAGER THAT THE REPAIRS COULD COST FROM $1,800-$2,000 MAINLY DUE TO THE FIRE DAMAGE. SINCE I HAVE BEEN UNEMPLOYED FOR 18 MONTHS, I HAVE NOT HAD THE CAR TOWED TO THE DEALER FOR AN ESTIMATE OF ACTUAL DAMAGE.
NHTSA ODI #10321865
145,000 miles · Feb 12, 2010
Electrical System
MY 2000 CHEVROLET IMPALA IS CAUSING A GREAT DEAL OF FINANCIAL HARDSHIPS AND IS LEAVING ME STRANDED IN AWKWARD SITUATIONS. AT UNPREDICTABLE TIMES IT WILL NOT START. I TURN THE KEY AND NOTHING. I TOOK IT TO A GM DEALER AND THEY PUT A NEW IGNITION SWITCH ON THE CAR AND IT WAS FINE FOR 6 MONTHS. COST $500. I OFTEN COULD WAIT 10 TO 1…
Read full complaint
MY 2000 CHEVROLET IMPALA IS CAUSING A GREAT DEAL OF FINANCIAL HARDSHIPS AND IS LEAVING ME STRANDED IN AWKWARD SITUATIONS. AT UNPREDICTABLE TIMES IT WILL NOT START. I TURN THE KEY AND NOTHING. I TOOK IT TO A GM DEALER AND THEY PUT A NEW IGNITION SWITCH ON THE CAR AND IT WAS FINE FOR 6 MONTHS. COST $500. I OFTEN COULD WAIT 10 TO 15 MINUTES AND IT WOULD START. BUT IT BEGAN HAPPENING MORE AND MORE. I TOOK IT IN TO A MECHANIC, HE RAN THE CODES AND DETERMINED IT WAS THE IGNITION SWITCH. COST $450 AND WITHIN A MONTH IT BEGAN DOING THE SAME THING. I GOT STRANDED AND HAD TO HAVE IT TOWED TO A GM DEALER AND THEY PUT A NEW BATTERY ON IT AND REMOVED ALL THE AFTER MARKET UNLOCKING MECHANISMS AND CHARGED $550. THREE DAYS LATER WE HAVE THE SAME PROBLEM. IT SEEMS TO BE CONNECTED TO THE PASS LOCK SYSTEM. THERE HAS TO BE A DEFECT OF SOME SORT GOING ON IN THE WHOLE STARTING ELECTRICAL SYSTEM. *TR
NHTSA ODI #10308907
173,009 miles · Nov 23, 2009
Electrical SystemElectronic Stability Control (esc)Power Train
TL* THE CONTACT OWNS A 2000 CHEVROLET IMPALA. WHILE DRIVING THE TRANSMISSION KEPT SLIPPING IN AND OUT OF GEAR. ALSO THE ELECTRONIC STABILITY CONTROL SYSTEM CAUSED THE VEHICLE TO DRIFT TO THE RIGHT OR LEFT. ALSO, THE LIGHTS FOR THE INSTRUMENT CONTROL PANEL FAILED. THE VEHICLE WAS TAKEN TO A MECHANIC AND THE TECHNICIAN LOCATED S…
Read full complaint
TL* THE CONTACT OWNS A 2000 CHEVROLET IMPALA. WHILE DRIVING THE TRANSMISSION KEPT SLIPPING IN AND OUT OF GEAR. ALSO THE ELECTRONIC STABILITY CONTROL SYSTEM CAUSED THE VEHICLE TO DRIFT TO THE RIGHT OR LEFT. ALSO, THE LIGHTS FOR THE INSTRUMENT CONTROL PANEL FAILED. THE VEHICLE WAS TAKEN TO A MECHANIC AND THE TECHNICIAN LOCATED SEVERAL DIAGNOSTIC ERROR CODES. THE FAILURE MILEAGE WAS 173,009. UPDATED 1/5/10 *CN THE DEALER REPLACED A SASH LIGHT SWITCH, UT THAT DIDN'T RESOLVE THE PROBLEM. UPDATED 01/06/10.*JB
NHTSA ODI #10293227
98,000 miles · Oct 18, 2009
Electrical System
ELECTRICAL SIGNALS QUIT WORKING INTERMITTENTLY,WILL START IF HAZARDS ARE PUSHED. *TR
NHTSA ODI #10288855
100,000 miles · Oct 16, 2009
Electrical System
BODY CONTROL MODULE, PASS LOCK SENSOR, IGNITION SWITCH. WILL NOT ALLOW CAR TO START CORRECTLY OFTEN NOT AT ALL. IF RESEARCH IS DONE THERE IS THOUSANDS OF COMPLAINTS ON GM VEHICLES WITH THIS SYSTEM HAVING THE SAME RECURRING PROBLEM. GM REFUSES TO ADMIT THAT THIS IS AN ISSUE WITH THIS SYSTEM. I HAVE NOT PERSONALLY HAD A INJURY …
Read full complaint
BODY CONTROL MODULE, PASS LOCK SENSOR, IGNITION SWITCH. WILL NOT ALLOW CAR TO START CORRECTLY OFTEN NOT AT ALL. IF RESEARCH IS DONE THERE IS THOUSANDS OF COMPLAINTS ON GM VEHICLES WITH THIS SYSTEM HAVING THE SAME RECURRING PROBLEM. GM REFUSES TO ADMIT THAT THIS IS AN ISSUE WITH THIS SYSTEM. I HAVE NOT PERSONALLY HAD A INJURY CAUSED BY THIS PROBLEM BUT THE POTENTIAL FOR AN INJURY IS THERE. IF I CAN NOT START MY VEHICLE BECAUSE OF THIS PROBLEM IT CAN AND HAS LEFT ME IN A POSITION THAT IS POTENTIALLY HAZARDOUS. *TR
NHTSA ODI #10288649
Mileage unknown · Sep 17, 2009
Electrical SystemSteering
MY 2000 IMPALAS PASS LOCK SYSTEM STOPS THE CAR FROM STARTING FOR UP TO 45 MINUTES AT A TIME. I TRY TO START THE CAR AND IT WONT TURN OVER OR DO ANYTHING. IT HAPPENS EVERY TIME I TRY TO START THE CAR. IT LEAVES MY FAMILY STRANDED WHEN WE TRY TO GO PLACES. WHAT WERE TO HAPPEN IF THERE WERE AN EMERGENCY? I'D BE STRANDED. ALSO THE S…
Read full complaint
MY 2000 IMPALAS PASS LOCK SYSTEM STOPS THE CAR FROM STARTING FOR UP TO 45 MINUTES AT A TIME. I TRY TO START THE CAR AND IT WONT TURN OVER OR DO ANYTHING. IT HAPPENS EVERY TIME I TRY TO START THE CAR. IT LEAVES MY FAMILY STRANDED WHEN WE TRY TO GO PLACES. WHAT WERE TO HAPPEN IF THERE WERE AN EMERGENCY? I'D BE STRANDED. ALSO THE STEERING CLUNKS ALOT WHEN I TURN. *TR
NHTSA ODI #10284444
92,000 miles · Sep 17, 2009
Electrical System
MY 2000 IMPALA HAS INTERMITTENT PROBLEMS WITH THE DIRECTION SIGNALS. AT TIMES THEY WORK FINE AND OTHER TIMES THEY DON'T. SOMETIMES WHILE THE DIRECTIONAL IS WORKING IT WILL STOP FOR NO REASON. THIS HAS RESULTED IN SEVERAL NEAR REAR END COLLISIONS EVEN WITH ARM SIGNALS. THIS OCCURS ON A NEARLY DAILY BASIS. I AM WAITING TO SEE …
Read full complaint
MY 2000 IMPALA HAS INTERMITTENT PROBLEMS WITH THE DIRECTION SIGNALS. AT TIMES THEY WORK FINE AND OTHER TIMES THEY DON'T. SOMETIMES WHILE THE DIRECTIONAL IS WORKING IT WILL STOP FOR NO REASON. THIS HAS RESULTED IN SEVERAL NEAR REAR END COLLISIONS EVEN WITH ARM SIGNALS. THIS OCCURS ON A NEARLY DAILY BASIS. I AM WAITING TO SEE IF THERE IS A RECALL AS THE COST TO REPLACE IS APPROXIMATELY $500 AS THE DIRECTIONAL SIGNAL IS SOLD AS A SINGLE UNIT (DIRECTIONAL ARM AND FLASHING UNIT ARE 1 PIECE). THE UNIT ITSELF IS OVER $300. *TR
NHTSA ODI #10284430
Official recalls
7Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Feb 24, 2004
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 3800 V6 (L36) ENGINES AND CERTAIN DELPHI FUEL PRESSURE REGULATORS, THE REGULATORS HAVE A MUCH HIGHER THAN USUAL RATE OF FUEL LEAKS. A LEAK CAN ALLOW FUEL TO ENTER THE INTAKE MANIFOLD THROUGH A VACUUM LINE. IF THE ENGINE DOES NOT START WHEN CRANKED, THE FUEL FROM THE LEAKING REGULATOR AND A MISTIMED SPARK CAN CAUSE A BACKFIRE.
Consequence & remedy
Consequence: THE BACKFIRE CAN RUPTURE THE INTAKE MANIFOLD. THE RUPTURE OF THE INTAKE MANIFOLD CAN DISPLACE A FUEL LINE, PULLING AN INJECTOR OUT OF PLACE, AND CAUSING A FUEL LEAK AND POSSIBLE FIRE.
Remedy: DEALERS WILL INSTALL NEW FUEL PRESSURE REGULATORS WITH IMPROVED DIAPHRAGMS. THE RECALL WILL BE CONDUCTED IN PHASED MAILINGS. PHASE 1 BEGAN ON JUNE 30, 2004, AND PHASE 2 BEGAN ON SEPTEMBER 30, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, OLDSMOBILE AT 1-800-630-6537, OR PONTIAC AT 1-800-620-7668.
Apr 24, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH A 3.4L ENGINE AND NON-ANTILOCK BRAKING SYSTEM (ABS). THESE VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." A FUEL RETURN LINE CAN BECOME SEVERED IN A FRONTAL COLLISION, RESULTING IN FUEL SPILLAGE.
Consequence & remedy
Consequence: IF AN IGNITION SOURCE WAS PRESENT, A FIRE COULD OCCUR.
Remedy: DEALERS WILL INSTALL A BRAKE MASTER CYLINDER BRACKET THAT WILL MAINTAIN POSITIONING OF THE FUEL LINE IN A FRONTAL CRASH. OWNER NOTIFICATION BEGAN JUNE 29, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020.
Nov 13, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME OF THESE VEHICLES EXHIBIT A CONDITION IN WHICH THE DRIVER SIDE IMPACT AIR BAG INFLATOR SEPARATES FROM THE AIR BAG MODULE DURING DEPLOYMENT.
Consequence & remedy
Consequence: IF THE INFLATOR SEPARATES, THE AIR BAG WILL NOT DEPLOY PROPERLY DURING A CRASH AND OCCUPANT PROTECTION WOULD BE REDUCED. IF IS ALSO POSSIBLE THAT A SEPARATED INFLATOR COULD BE PROPELLED DOWNWARD AND COULD RESULT IN INJURY TO A REAR SEAT PASSENGER WHOSE FOOT IS POSITIONED APPROXIMATELY UNDER THE INFLATOR MODULE.
Remedy: DEALERS WILL REPLACE THE SIDE IMPACT AIR BAG MODULE.
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE00005 · Inadvertent Engine Stalling
Opened Jan 19, 2000 · Closed Feb 29, 2000
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
Illustration