NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
187 reportsClear category filter95,000 miles · Oct 3, 2006
Electrical System
MY 2000 IMPALA HAS A PROBLEM WITH THE PASSLOCK SYSTEM WHICH CAUSES THE VEHICLE TO STOP WORKING OR SURGE WHILE DRIVING AND CAUSES INTERMITTENT DIFFICULTIES WITH STARTING. THIS IS A WIDESPREAD PROBLEM AMONG GM OWNERS AND WE HAVE MADE NEARLY 13 VISITS TO THE DEALER TO ADDRESS THIS SAFETY ISSUE. WE HAVE HAD THE IGNITION REPLACED, …
Read full complaint
MY 2000 IMPALA HAS A PROBLEM WITH THE PASSLOCK SYSTEM WHICH CAUSES THE VEHICLE TO STOP WORKING OR SURGE WHILE DRIVING AND CAUSES INTERMITTENT DIFFICULTIES WITH STARTING. THIS IS A WIDESPREAD PROBLEM AMONG GM OWNERS AND WE HAVE MADE NEARLY 13 VISITS TO THE DEALER TO ADDRESS THIS SAFETY ISSUE. WE HAVE HAD THE IGNITION REPLACED, BUT ON MOST VISITS GM STAFF ARE UNABLE TO DIAGNOSE, AND HENCE, UNABLE TO TREAT THE PROBLEM. ANOTHER SAFETY ISSUE IS RELATED TO STARTING. SINCE MY WIFE DRIVES THE CAR, SHE IS OFTEN LEFT UNSAFE IN AREAS DURING THE 20+ TIMES THAT SHE HAS NOT BEEN ABLE TO START HER CAR. WHILE NO INJURIES HAVE YET BEEN LINKED TO THIS PROBLEM WITH OUR VEHICLE, IS SUCH A WIDESPREAD PROBLEM WITH GM VEHICLES THAT IT NEEDS TO BE ADDRESSED. THANK YOU FOR YOUR ATTENTION TO THIS MATTER. *JB
NHTSA ODI #10169848
80,000 miles · Sep 18, 2006
Electrical SystemPower TrainWheels
DT*: THE CONTACT STATED THE CHECK ENGINE LIGHT ILLUMINATED INTERMITTENTLY. WHILE ACCELERATING FROM A STOP, THE TRANSMISSION DROPPED TO THE LOWEST GEAR WITHOUT WARNING, AND HESITATED BEFORE ENGAGING TO THE NEXT GEAR. THE VEHICLE WAS TAKEN TO A SERVICE DEALER, WHO WAS UNABLE TO DETERMINE THE CAUSE OF THE PROBLEM. ALSO, THE FU…
Read full complaint
DT*: THE CONTACT STATED THE CHECK ENGINE LIGHT ILLUMINATED INTERMITTENTLY. WHILE ACCELERATING FROM A STOP, THE TRANSMISSION DROPPED TO THE LOWEST GEAR WITHOUT WARNING, AND HESITATED BEFORE ENGAGING TO THE NEXT GEAR. THE VEHICLE WAS TAKEN TO A SERVICE DEALER, WHO WAS UNABLE TO DETERMINE THE CAUSE OF THE PROBLEM. ALSO, THE FUEL GAUGE DISPLAYED AN INCORRECT READING. FINALLY, WHILE DRIVING 30 MPH, THERE WAS A RATTLING NOISE IN REAR WHEELS. THE LAST TWO PROBLEMS WERE INSPECTED BY A DEALER.
NHTSA ODI #10168500
97,000 miles · Sep 12, 2006
Electrical SystemEngine And Engine Cooling
I HAVE A 2000 IMPALA LS WITH 97000 MILES. THE CAR WILL STALL AT HIGHWAY SPEED. THIS HAS HAPPENED TO BOTH MY WIFE AND MYSELF SEVERAL TIMES THIS SUMMER. THE CAR HAS BEEN IN THE DEALERSHIP FOR 3 OF THE LAST 4 WEEKS AND I AM TOLLED THEY CAN'T FIND THE PROBLEM. I HAVE DONE A INTERNET CHECK AND HAVE FOUNDED SEVERAL OTHER OWNERS WITH…
Read full complaint
I HAVE A 2000 IMPALA LS WITH 97000 MILES. THE CAR WILL STALL AT HIGHWAY SPEED. THIS HAS HAPPENED TO BOTH MY WIFE AND MYSELF SEVERAL TIMES THIS SUMMER. THE CAR HAS BEEN IN THE DEALERSHIP FOR 3 OF THE LAST 4 WEEKS AND I AM TOLLED THEY CAN'T FIND THE PROBLEM. I HAVE DONE A INTERNET CHECK AND HAVE FOUNDED SEVERAL OTHER OWNERS WITH THE SAME ISSUE. THIS NEEDS TO BE ADDRESSED BEFORE SOMEONE IS KILLED. *NM
NHTSA ODI #10167928
89,400 miles · Aug 25, 2006
Electrical SystemEngine And Engine Cooling
DT*: THE CONTACT STATED WITHOUT WARNING THE VEHICLE STALLED INTERMITTENTLY AT VARIOUS SPEEDS. THE CONSUMER ATTEMPTED TO RESTART THE VEHICLE. AT TIME IT WOULD START RIGHT UP. OTHER TIMES THE VEHICLE HAD TO COOL DOWN BEFORE IT WOULD RESTART. THE DEALERSHIP REPROGRAMMED THE COMPUTER BUT THE PROBLEM PERSISTED. *AK UPDATED 9/2…
Read full complaint
DT*: THE CONTACT STATED WITHOUT WARNING THE VEHICLE STALLED INTERMITTENTLY AT VARIOUS SPEEDS. THE CONSUMER ATTEMPTED TO RESTART THE VEHICLE. AT TIME IT WOULD START RIGHT UP. OTHER TIMES THE VEHICLE HAD TO COOL DOWN BEFORE IT WOULD RESTART. THE DEALERSHIP REPROGRAMMED THE COMPUTER BUT THE PROBLEM PERSISTED. *AK UPDATED 9/22/2006 - THE VEHICLE STALLED A COUPLE TIMES A WEEK. *NM
NHTSA ODI #10166535
80,000 miles · Jul 21, 2006
Electrical System
FOR THE LAST YEAR MY SECURITY LIGHT WILL RANDOMLY COME ON. SOON AFTER..SOMETIMES HOURS, SOMETIMES DAYS...THE CAR WILL NOT START. I CONTACTED MY DEALER AND THEY SAID IT IS A PASSLOCK SECURITY CODE PROBLEM. THE CAR THINKS IT IS GETTING STOLEN AND YOU HAVE TO WAIT 15-20 MINUTES AND TRY AGAIN. THE CODE IS EASY TO FIX BUT IT IS A…
Read full complaint
FOR THE LAST YEAR MY SECURITY LIGHT WILL RANDOMLY COME ON. SOON AFTER..SOMETIMES HOURS, SOMETIMES DAYS...THE CAR WILL NOT START. I CONTACTED MY DEALER AND THEY SAID IT IS A PASSLOCK SECURITY CODE PROBLEM. THE CAR THINKS IT IS GETTING STOLEN AND YOU HAVE TO WAIT 15-20 MINUTES AND TRY AGAIN. THE CODE IS EASY TO FIX BUT IT IS ALSO $395. THE ONLY PLACE THAT CAN FIX IT IS THE DEALERSHIP. I HAVE DONE SOME INVESTIGATING AND MANY IMPALAS HAVE THIS PROBLEM. MY DEALER SUGGESTED I WRITE A COMPLAINT BECAUSE THEY SEE IT A LOT AND HOPEFULLY A RECALL COULD OCCUR. I DON'T KNOW WHEN IT IS GOING TO HAPPEN AGAIN AND BEING A YOUNG FEMALE IT IS SCARY WHEN I WALK OUT TO MY CAR LATE AT NIGHT OR ALONE. I HAVE FOUND CAR WEBSITE FORUMS AND MANY HAVE LISTED THIS SAME PROBLEM. I APPRECIATE YOUR TIME AND HOPE THAT SOMETHING CAN BE DONE. THIS CAN BE A SAFETY ISSUE FOR MANY PEOPLE.
NHTSA ODI #10163045
94,325 miles · Jul 12, 2006
Electrical System
DT: THE CONTACT STATED, WHILE DRIVING IN CLEAR, DRY WEATHER, THE VEHICLE LUNGED FORWARD AND ALL POWER IN THE VEHICLE FAILED ON FOUR SEPARATE OCCASSIONS. ONCE STOPPED, THE VEHICLE RESTARTED. THE SERVICE DEALER INSPECTED THE VEHICLE BY COMPUTER DIANOSTIC, ON TWO SEPARATE OCCASSIONS, WHICH DID NOT REVEAL THE PROBLEM. THE VEHICLE''S…
Read full complaint
DT: THE CONTACT STATED, WHILE DRIVING IN CLEAR, DRY WEATHER, THE VEHICLE LUNGED FORWARD AND ALL POWER IN THE VEHICLE FAILED ON FOUR SEPARATE OCCASSIONS. ONCE STOPPED, THE VEHICLE RESTARTED. THE SERVICE DEALER INSPECTED THE VEHICLE BY COMPUTER DIANOSTIC, ON TWO SEPARATE OCCASSIONS, WHICH DID NOT REVEAL THE PROBLEM. THE VEHICLE''S ELECTRICAL POWER FAILED FOR THE FOURTH TIME.
NHTSA ODI #10162187
97,500 miles · Jun 13, 2006
Electrical SystemEngine And Engine CoolingFire
DT*: THE CONTACT STATED THE ENGINE WOULD NOT START AFTER THE VEHICLE WAS PARKED OVERNIGHT. INITIALLY, IT WAS SUSPECTED THE BATTERY WAS DISCHARGED AND THE BATTERY WAS CHARGED FOR TWENTY MINUTES. AFTERWARDS, THE CONTACT ATTEMPTED TO START THE VEHICLE, WITH THE KEY IN THE IGNITION, AND THE INTAKE MANIFOLD EXPLODED. A LARGE FIRE…
Read full complaint
DT*: THE CONTACT STATED THE ENGINE WOULD NOT START AFTER THE VEHICLE WAS PARKED OVERNIGHT. INITIALLY, IT WAS SUSPECTED THE BATTERY WAS DISCHARGED AND THE BATTERY WAS CHARGED FOR TWENTY MINUTES. AFTERWARDS, THE CONTACT ATTEMPTED TO START THE VEHICLE, WITH THE KEY IN THE IGNITION, AND THE INTAKE MANIFOLD EXPLODED. A LARGE FIREBALL ALONG WITH PIECES OF THE INTAKE MANIFOLD AND THE ENGINE COVER SHOT OUT OF THE UNDERHOOD AREA. THE VEHICLE WAS TOWED TO A DEALER FOR INSPECTION. THE DEALER DETERMINED THE BACKFIRING OCCURRED DUE TO THE CONTACT STARTING THE ENGINE WHILE APPLYING THE ACCELERATOR PEDAL. THE MANUFACTURER WAS ALERTED.
NHTSA ODI #10159726
40,000 miles · Apr 17, 2006
Electrical SystemFire
CAR RUNNING WELL -NO PROBLEMS AT ALL. PARKED CAR A LOCAL SHOPPING AREA. APPARENTLY ENGINE CAUGHT FIRE WHILE I WAS IN STORE. IT WAS NOTICED BY EMPLOYEE OF STORE WHO CALLED FIRE DEPARTMENT. ALTHOUGH THEY CAME QUICKLY THE CAR HAD TO BE TOTALED AS THE FIRE CONSUMED AND MELTED THE ENTIRE ENGINE. *JB
NHTSA ODI #10155517
35 miles · Apr 6, 2006
Electrical SystemFireInjury
2000 CHEVROLET IMPALA LOCKED ME IN CAR AND COULDN'T GET OUT. FINALLY GOT DOOR OPEN. *JB
NHTSA ODI #10154677
94,000 miles · Feb 13, 2006
Electrical SystemExterior Lighting
DT*: THE CONTACT STATED WHILE DRIVING AT VARIOUS SPEEDS, THE HEADLIGHTS GO ON AND OFF INTERMITTENTLY AT NIGHT. THIS LAST FROM 30 SECONDS TO 1 MINUTE. THE VEHICLE WAS TAKEN TO THE LOCAL DEALERSHIP FOR INSPECTION. THE DEALER COULD NOT DUPLICATE THE PROBLEM AND NO REPAIRS WERE MADE.
NHTSA ODI #10150129
Official recalls
7Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Feb 24, 2004
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 3800 V6 (L36) ENGINES AND CERTAIN DELPHI FUEL PRESSURE REGULATORS, THE REGULATORS HAVE A MUCH HIGHER THAN USUAL RATE OF FUEL LEAKS. A LEAK CAN ALLOW FUEL TO ENTER THE INTAKE MANIFOLD THROUGH A VACUUM LINE. IF THE ENGINE DOES NOT START WHEN CRANKED, THE FUEL FROM THE LEAKING REGULATOR AND A MISTIMED SPARK CAN CAUSE A BACKFIRE.
Consequence & remedy
Consequence: THE BACKFIRE CAN RUPTURE THE INTAKE MANIFOLD. THE RUPTURE OF THE INTAKE MANIFOLD CAN DISPLACE A FUEL LINE, PULLING AN INJECTOR OUT OF PLACE, AND CAUSING A FUEL LEAK AND POSSIBLE FIRE.
Remedy: DEALERS WILL INSTALL NEW FUEL PRESSURE REGULATORS WITH IMPROVED DIAPHRAGMS. THE RECALL WILL BE CONDUCTED IN PHASED MAILINGS. PHASE 1 BEGAN ON JUNE 30, 2004, AND PHASE 2 BEGAN ON SEPTEMBER 30, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, OLDSMOBILE AT 1-800-630-6537, OR PONTIAC AT 1-800-620-7668.
Apr 24, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH A 3.4L ENGINE AND NON-ANTILOCK BRAKING SYSTEM (ABS). THESE VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." A FUEL RETURN LINE CAN BECOME SEVERED IN A FRONTAL COLLISION, RESULTING IN FUEL SPILLAGE.
Consequence & remedy
Consequence: IF AN IGNITION SOURCE WAS PRESENT, A FIRE COULD OCCUR.
Remedy: DEALERS WILL INSTALL A BRAKE MASTER CYLINDER BRACKET THAT WILL MAINTAIN POSITIONING OF THE FUEL LINE IN A FRONTAL CRASH. OWNER NOTIFICATION BEGAN JUNE 29, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020.
Nov 13, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME OF THESE VEHICLES EXHIBIT A CONDITION IN WHICH THE DRIVER SIDE IMPACT AIR BAG INFLATOR SEPARATES FROM THE AIR BAG MODULE DURING DEPLOYMENT.
Consequence & remedy
Consequence: IF THE INFLATOR SEPARATES, THE AIR BAG WILL NOT DEPLOY PROPERLY DURING A CRASH AND OCCUPANT PROTECTION WOULD BE REDUCED. IF IS ALSO POSSIBLE THAT A SEPARATED INFLATOR COULD BE PROPELLED DOWNWARD AND COULD RESULT IN INJURY TO A REAR SEAT PASSENGER WHOSE FOOT IS POSITIONED APPROXIMATELY UNDER THE INFLATOR MODULE.
Remedy: DEALERS WILL REPLACE THE SIDE IMPACT AIR BAG MODULE.
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE00005 · Inadvertent Engine Stalling
Opened Jan 19, 2000 · Closed Feb 29, 2000
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
Illustration