IllustrationLIKE MANY PTHERS, POWER STEERING INDICATOR ON DASH AND NO POWER STEERING. WORKS FOR FEW SECONDS WHEN CAR US RESTARTED THEN OUT AGAIN. HAVE REPLACED PUMP TWICE ALREADY .
2007 Chevrolet Hhr
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2007 Chevrolet Hhr do not stand out strongly from the model-year median of 565.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Hhr years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
650–25K
8725–50K
15050–75K
12175–100K
132100–150K
43150K+
598 reports with mileage · 128 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 424 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 111 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 48 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
42 crash reports4 fire reports23 injury reports
What owners actually said
726 reportsWHILE DRIVING THE POWER STEERING FAILED AND THE INDICATOR CAME ON THE DASH INDICATING FAILURE. IF THE CAR IS TURNED OFF AND THEN RESTARTED THE POWER STEERING WILL WORK FINE FOR AWHILE BUT WILL EVENTUALLY FAIL AGAIN, USUALLY WITHIN 15-20 MIN. THIS STARTED AT 78,000MILES.
TL* THE CONTACT OWNS A 2007 CHEVROLET HHR. WHILE DRIVING 30 MPH ON VARIOUS OCCASIONS, THE POWER STEERING WARNING INDICATOR ILLUMINATED AND THE STEERING WHEEL SEIZED. THE VEHICLE WAS NOT TAKEN TO A DEALER TO BE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 114,000. …
Read full complaint
TL* THE CONTACT OWNS A 2007 CHEVROLET HHR. WHILE DRIVING 30 MPH ON VARIOUS OCCASIONS, THE POWER STEERING WARNING INDICATOR ILLUMINATED AND THE STEERING WHEEL SEIZED. THE VEHICLE WAS NOT TAKEN TO A DEALER TO BE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 114,000.
FUEL LINE HAS MULTIPLE ISSUE OF LEAKING
POWER STEERING
STARTED DRIVING DOWN THE ROAD POWER STEERING LIGHT AND BELLS CAME ON AND LOST STEERING. ALMOST CRASHED INTO THE DITCH . LUCKILY NOBODY WAS COMING TOWARDS US OR BEHIND US . DO NOT DARE TO DRIVE MY CAR NOW I HAVE A YOUNG CHILD.
RUSTED FUEL LINES ON DRIVER'S SIDE NEAR THE REAR. THIS IS A MAJOR DESIGN FLAW WITH CHEVY HHRS. I NOTICED A BAD FUEL ODOR COMING FROM THE VEHICLE WHEN IT WAS PARKED. UPON FURTHER INVESTIGATION THERE IS A SOLID "DRIP" FROM WHERE THE LINE HAS RUSTED OUT. IT NEEDS TO BE FIXED BEFORE THERE IS A FIRE OR EXPLOSION AND SOMEBODY IS…
Read full complaint
RUSTED FUEL LINES ON DRIVER'S SIDE NEAR THE REAR. THIS IS A MAJOR DESIGN FLAW WITH CHEVY HHRS. I NOTICED A BAD FUEL ODOR COMING FROM THE VEHICLE WHEN IT WAS PARKED. UPON FURTHER INVESTIGATION THERE IS A SOLID "DRIP" FROM WHERE THE LINE HAS RUSTED OUT. IT NEEDS TO BE FIXED BEFORE THERE IS A FIRE OR EXPLOSION AND SOMEBODY IS SERIOUSLY HURT OR KILLED.
THIS COMPLAINT CONCERNS A 2007 CHEVROLET HHR LT WHICH WAS PURCHASED AS A NEW VEHICLE. IT IS 'ALWAYS GARAGED'. IT HAS 36,1XX ORIGINAL MILES. ABOUT 2 WEEKS AGO WE BEGAN TO NOTICE 'CHUNKS' OF RUST GATHERING UNDER THE REAR OF THE VEHICLE. AN INSPECTION MADE BY SELF REVEALED EXTENSIVE RUST-OUT TO THE "REAR REINFORCEMENT BAR" (PART #1…
Read full complaint
THIS COMPLAINT CONCERNS A 2007 CHEVROLET HHR LT WHICH WAS PURCHASED AS A NEW VEHICLE. IT IS 'ALWAYS GARAGED'. IT HAS 36,1XX ORIGINAL MILES. ABOUT 2 WEEKS AGO WE BEGAN TO NOTICE 'CHUNKS' OF RUST GATHERING UNDER THE REAR OF THE VEHICLE. AN INSPECTION MADE BY SELF REVEALED EXTENSIVE RUST-OUT TO THE "REAR REINFORCEMENT BAR" (PART #10 IN THE ENCLOSED DIAGRAM). I CONTACTED "GM" VIA THEIR 'SOCIAL MEDIA CUSTOMER CARE CENTER', THOROUGHLY EXPLAINED THE ISSUE, AND WAS DIRECTED TO A LOCAL BUICK/GMC DEALERSHIP FOR AN EVALUATION, WITHIN HOURS I HEARD A NEGATIVE RESPONSE TO MY REQUEST FOR ASSISTANCE. SUBSEQUENT ATTEMPTS BY SELF HAVE NOT GIVEN ME A SATISFACTORY EXPLANATION AS TO THE "WHY" OF THIS RUSTED PART. THIS VEHICLE HAS ALWAYS BEEN MAINTAINED TO A HIGH DEGREE. THE EXAMINER TOLD ME HE DID NOT OBSERVE ANY OTHER RUST ISSUES ON OR UNDER THIS VEHICLE. KEEP IN MIND THAT I AM NOT AN 'AUTOMOTIVE' ENGINEER; BUT- TO MY 'UNTRAINED EYE' PART OF THE PROBLEM IS THAT THE PART IS DEEPLY HIDDEN WITHIN THE REAR BUMPER COVER; AND THE DESIGN OF THE REAR BUMPER COVER IS SUCH THAT IT FOSTERS THE COLLECTION OF DEBRIS FROM THE ROAD ON IT'S HORIZONTAL SURFACES. THIS DEBRIS THEN IS IN SITU WITH THE METAL PARTS OF THE ACTUAL 'REAR BUMPER'. GIVEN TIME THE DEBRIS RETAINS MOISTURE WHICH 'APPARENTLY' THEN COVERS THE METAL PARTS. ...AND ONE GETS THE RESULTS SHOWN IN THE PHOTOS. NONE OF THIS WOULD BE VISIBLE UNLESS A PERIODIC, CAREFUL EXAMINATION OF THE HIDDEN PARTS WERE TO BE MADE BY THE OWNER/OPERATOR OF THE VEHICLE. A "POSSIBLE" MEASURE TO BE TAKEN WOULD BE FOR GENERAL MOTORS TO EDUCATE/INFORM OWNER/OPERATORS AS TO THE POTENTIAL FOR A PROBLEM. ANOTHER "POSSIBLE" SOLUTION, WERE THIS A VEHICLE STILL IN PRODUCTION (AND NOT YET ANOTHER GM 'ORPHAN' CAR) WOULD BE, OF COURSE, TO CORRECT THE APPARENT, ORIGINAL 'DESIGN DEFICIENCY'.
TL* THE CONTACT OWNS A 2007 CHEVROLET HHR. WHILE AT A FUEL STATION, A SMELL OF FUEL WAS DETECTED FROM THE VEHICLE. THE CONTACT LOOKED UNDERNEATH THE VEHICLE AND NOTICED A LEAK IN THE FUEL LINE. THERE WAS NO WARNING INDICATOR ILLUMINATED. THE DEALER AND MANUFACTURER WERE NOT MADE AWARE OF THE FAILURE. THE FAILURE WAS NEITHER DIAG…
Read full complaint
TL* THE CONTACT OWNS A 2007 CHEVROLET HHR. WHILE AT A FUEL STATION, A SMELL OF FUEL WAS DETECTED FROM THE VEHICLE. THE CONTACT LOOKED UNDERNEATH THE VEHICLE AND NOTICED A LEAK IN THE FUEL LINE. THERE WAS NO WARNING INDICATOR ILLUMINATED. THE DEALER AND MANUFACTURER WERE NOT MADE AWARE OF THE FAILURE. THE FAILURE WAS NEITHER DIAGNOSED NOR REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 157,000.
DRIVING AND PUSHED ON CLUTCH TO CHANGE GEARS , I HEARD A SNAP AND THE CLUTCH LOST ALL PRESSURE AND WENT TO THE FLOOR OF THE VEHICLE. UPON INSPECTION BY A MECHANIC , IT WAS DETERMINED THAT THE CLUTCH CYLINDER HAD PUNCHED THROUGH THE FIREWALL. THIS SHOULD NOT HAVE HAPPENED AND IS A MANUFACTURING DEFECT. I WAS DRIVING IN TRAFFIC AN…
Read full complaint
DRIVING AND PUSHED ON CLUTCH TO CHANGE GEARS , I HEARD A SNAP AND THE CLUTCH LOST ALL PRESSURE AND WENT TO THE FLOOR OF THE VEHICLE. UPON INSPECTION BY A MECHANIC , IT WAS DETERMINED THAT THE CLUTCH CYLINDER HAD PUNCHED THROUGH THE FIREWALL. THIS SHOULD NOT HAVE HAPPENED AND IS A MANUFACTURING DEFECT. I WAS DRIVING IN TRAFFIC AND THIS CAUSED THE CAR TO TURN OFF. IT COULD HAVE CAUSED A VERY SERIOUS ACCIDENT.
Official recalls
414V171000 · Electrical System:ignition
Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
14V047000 · Air Bags; Electrical System:ignition:switch
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
08V444000 · Latches/locks/linkages:doors:latch
Sep 3, 2008
GM IS RECALLING 296,422 MY 2006-2008 CHEVROLET HHR VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT." THE DOOR ON THE STORAGE BIN IN THE TOP CENTER OF THE INSTRUMENT PANEL FAILED TO REMAIN CLOSED AS REQUIRED.
Consequence & remedy
Consequence: THIS STANDARD SPECIFIES PERFORMANCE REQUIREMENTS TO PROVIDE HEAD IMPACT PROTECTION FOR OCCUPANTS.
Remedy: A REDESIGNED LATCH WILL BE MADE AVAILABLE. THE RECALL BEGAN ON DECEMBER 23, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
08V046000 · Air Bags
Jan 30, 2008
GM IS RECALLING 181,516 MY 2006-2008 CHEVROLET HHR VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF RAIL AIR BAGS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.' IN TESTS, ONE OF THE UPPER INTERIOR OCCUPANT PROTECTION TEST POINTS EXCEEDED THE STANDARD'S REQUIREMENT.
Consequence & remedy
Consequence: THIS STANDARD SPECIFIES PERFORMANCE REQUIREMENTS TO PROVIDE HEAD IMPACT PROTECTION FOR OCCUPANTS.
Remedy: DEALERS WILL INSTALL AN ENERGY-ABSORBING PLASTIC PIECE TO THE HEADLINER TRIM. THE RECALL BEGAN ON APRIL 2, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.