NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
1,006 reports69,000 miles · Jun 3, 2014
Steering
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS, THERE WAS A LOSS OF POWER STEERING AND THE STEERING WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS MANEUVERED TO THE SIDE OF THE ROAD WHERE THE ENGINE WAS TURNED OFF. UPON RESTARTING, THE VEHICLE WAS ABLE TO OPERATE NORMALLY. THE MALFUNC…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS, THERE WAS A LOSS OF POWER STEERING AND THE STEERING WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS MANEUVERED TO THE SIDE OF THE ROAD WHERE THE ENGINE WAS TURNED OFF. UPON RESTARTING, THE VEHICLE WAS ABLE TO OPERATE NORMALLY. THE MALFUNCTION RECURRED WHENEVER THE VEHICLE WAS IN MOTION. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 69,000.
NHTSA ODI #10595741
154,798 miles · Jun 3, 2014
Air BagsElectrical SystemCrash
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT WHILE TRAVELING APPROXIMATELY 65, THE CONTACT WAS CUT OFF BY ANOTHER VEHICLE WHICH CAUSED THE CONTACT TO LOSE CONTROL AND CRASH INTO AN EMBANKMENT. UPON IMPACT, THE AIR BAGS FAILED TO DEPLOY. THERE WERE NO INJURIES. THE CONTACT ATTEMPTED TO HAVE THE VEHICLE REPAI…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT WHILE TRAVELING APPROXIMATELY 65, THE CONTACT WAS CUT OFF BY ANOTHER VEHICLE WHICH CAUSED THE CONTACT TO LOSE CONTROL AND CRASH INTO AN EMBANKMENT. UPON IMPACT, THE AIR BAGS FAILED TO DEPLOY. THERE WERE NO INJURIES. THE CONTACT ATTEMPTED TO HAVE THE VEHICLE REPAIRED UNDER NHTSA CAMPAIGN NUMBER 14V047000 (AIR BAGS, ELECTRICAL SYSTEM) BUT WAS INFORMED THAT THE PARTS WERE NOT AVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 154,798.
NHTSA ODI #10595736
39,000 miles · Jun 2, 2014
Steering
TL - THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT IMMEDIATELY AFTER TURNING THE VEHICLE ON, THE POWER STEERING WARNING LAMP ILLUMINATED IN THE INSTRUMENT PANEL AND THE POWER STEERING STOP WORKING. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN WAS UNABLE TO DIAGNOSED THE FAILURE. THE VEHICLE WAS NOT REPAIR…
Read full complaint
TL - THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT IMMEDIATELY AFTER TURNING THE VEHICLE ON, THE POWER STEERING WARNING LAMP ILLUMINATED IN THE INSTRUMENT PANEL AND THE POWER STEERING STOP WORKING. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN WAS UNABLE TO DIAGNOSED THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 39,000 AND THE CURRENT MILEAGE WAS 79,441. PM
NHTSA ODI #10595474
106,000 miles · Jun 1, 2014
Steering
WHILE DRIVING AT APPROX. 35 MPH AND IN THE MIDDLE OF A 108 DEGREE TURN (ON-RAMP TO THE INTER-STATE), THE POWER STEERING WARNING LAMP CAME ON AND THE POWER STEERING QUIT WORKING. IT WAS VERY DIFFICULT TO MANEUVER THE VEHICLE ON TO THE INTER-STATE AND OFF THE ROAD SAFELY. AFTER SHUTTING THE IGNITION OFF AND RESTARTING THE CAR TH…
Read full complaint
WHILE DRIVING AT APPROX. 35 MPH AND IN THE MIDDLE OF A 108 DEGREE TURN (ON-RAMP TO THE INTER-STATE), THE POWER STEERING WARNING LAMP CAME ON AND THE POWER STEERING QUIT WORKING. IT WAS VERY DIFFICULT TO MANEUVER THE VEHICLE ON TO THE INTER-STATE AND OFF THE ROAD SAFELY. AFTER SHUTTING THE IGNITION OFF AND RESTARTING THE CAR THE POWER STEERING WAS WORKING NORMALLY AGAIN FOR APPROX. 30 MINUTES, THEN QUIT WORKING AGAIN. THIS HAPPENED SEVERAL TIMES IN 1 DAY. I HAD SEEN A REPORT ON 5/29/14, THAT 2009 AND 2010 HHR ARE BEING RECALLED FOR THIS PROBLEM, BUT MINE IS NOT. IT SEEMS THAT MY 2006 HHR SHOULD ALSO BE INCLUDED IN THIS RECALL. I AM STILL AWAITING THE NEW IGNITION PARTS TO COME INTO MY DEALER TO SATISFY THE IGNITION RECALL. I AM BEGINNING TO FEEL VERY UNSAFE WHILE DRIVING THIS VEHICLE. *TR
NHTSA ODI #10595372
94,000 miles · May 30, 2014
Electrical SystemSteering
THE VEHICLE LOST POWER STEERING CONTROL. A CHIME SOUNDED AND A MESSAGE APPEARED ON THE INSTRUMENT PANEL. THE POWER STEERING CUTS OUT REGULARLY SINCE, EVERY TIME THE VEHICLE IS DRIVEN. I HAVE CONTACTED GM NUMEROUS TIMES, THEY INSIST THAT MY VEHICLE IS NOT INCLUDED IN THE RECENT POWER STEERING RECALLS EVEN THOUGH IT USES THE SAME …
Read full complaint
THE VEHICLE LOST POWER STEERING CONTROL. A CHIME SOUNDED AND A MESSAGE APPEARED ON THE INSTRUMENT PANEL. THE POWER STEERING CUTS OUT REGULARLY SINCE, EVERY TIME THE VEHICLE IS DRIVEN. I HAVE CONTACTED GM NUMEROUS TIMES, THEY INSIST THAT MY VEHICLE IS NOT INCLUDED IN THE RECENT POWER STEERING RECALLS EVEN THOUGH IT USES THE SAME EXACT POWER STEERING MOTOR AS THE VEHICLES THAT ARE INCLUDED (MY LOCAL CHEVROLET DEALER HAS VERIFIED THIS AND HAS CONTACTED GM ON MY BEHALF TOO). I AM FRUSTRATED AND ANGRY THAT GM IS STILL NEGLECTING TO ADDRESS THIS SAFETY ISSUE. *TR
NHTSA ODI #10595151
95,000 miles · May 27, 2014
Engine
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 45 MPH, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE WAS MERGED TO THE SIDE OF THE ROAD. THE VEHICLE RESTARTED AFTER SEVERAL ATTEMPTS. THE FAILURE RECURRED TWICE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSIS AND REPAIRED. …
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 45 MPH, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE WAS MERGED TO THE SIDE OF THE ROAD. THE VEHICLE RESTARTED AFTER SEVERAL ATTEMPTS. THE FAILURE RECURRED TWICE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSIS AND REPAIRED. THE CONTACT WAS UNABLE TO PROVIDE THE SPECIFIC PART THAT WAS REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 95,000.
NHTSA ODI #10594297
107,000 miles · May 27, 2014
Steering
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT WHILE DRIVING 50 MPH, THE POWER STEERING WARNING LAMP ILLUMINATED AND THE STEERING WHEEL BECAME VERY HARD TO MANEUVER. THE CONTACT MENTIONED THAT AFTER TURNING THE VEHICLE OFF AND RESTARTING IT THE POWER STEERING WOULD RESUME NORMAL FUNCTION. THE VEHICLE WAS NOT…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT WHILE DRIVING 50 MPH, THE POWER STEERING WARNING LAMP ILLUMINATED AND THE STEERING WHEEL BECAME VERY HARD TO MANEUVER. THE CONTACT MENTIONED THAT AFTER TURNING THE VEHICLE OFF AND RESTARTING IT THE POWER STEERING WOULD RESUME NORMAL FUNCTION. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 107,000 AND THE CURRENT MILEAGE WAS 107,083.
NHTSA ODI #10594248
82,000 miles · May 24, 2014
Steering
THE POWER STEERING FAILURE LIGHT CAME ON AS WELL AS OTHER LIGHTS AND THE RADIO STOP WORKING,DEALER SAID POWER STEERING MODULE WAS NO GOOD BUT COULD NOT FIND OUT WHY DASH LIGHTS COME ON AND WHY RADIO STOPS WORKING WHEN WE SEEM TO HIT A BUMP.IT COST ME OVER 1700.00 DOLLARS TO REPAIR AND THEY SAID NOTHING WAS UNDER WARRANTY OR A RE…
Read full complaint
THE POWER STEERING FAILURE LIGHT CAME ON AS WELL AS OTHER LIGHTS AND THE RADIO STOP WORKING,DEALER SAID POWER STEERING MODULE WAS NO GOOD BUT COULD NOT FIND OUT WHY DASH LIGHTS COME ON AND WHY RADIO STOPS WORKING WHEN WE SEEM TO HIT A BUMP.IT COST ME OVER 1700.00 DOLLARS TO REPAIR AND THEY SAID NOTHING WAS UNDER WARRANTY OR A RECALL. I SEE THE COBALT WAS RECALL FOR THE SAME PROBLEM WHY NOT THE HHR SAME UNIT. *TR
NHTSA ODI #10593830
25,000 miles · May 22, 2014
SteeringSuspension
THERE APPEARS TO BE A LARGE AMOUNT OF COBALT AND HHR OWNERS WITH COMPLAINTS ABOUT SUSPENSION CLUNKING NOISES. RESEARCH SHOWS THERE IS AN ISSUE WITH THE STABILIZER BAR PARTS AND ALSO THE INTERMEDIATE STEERING SHAFT. THESE PROBLEMS OCCUR AT MANY INTERVALS OF MILEAGE RANGING FROM 10,000 MILES AND UP. GM HAS SINCE SUED THE MANUFACTU…
Read full complaint
THERE APPEARS TO BE A LARGE AMOUNT OF COBALT AND HHR OWNERS WITH COMPLAINTS ABOUT SUSPENSION CLUNKING NOISES. RESEARCH SHOWS THERE IS AN ISSUE WITH THE STABILIZER BAR PARTS AND ALSO THE INTERMEDIATE STEERING SHAFT. THESE PROBLEMS OCCUR AT MANY INTERVALS OF MILEAGE RANGING FROM 10,000 MILES AND UP. GM HAS SINCE SUED THE MANUFACTURER OF THE INTERMEDIATE STEERING SHAFT FOR THOSE REPLACED UNDER WARRANTY EQUALING $30MIL. I AM UNLUCKY AS MY VEHICLE WAS OUT OF WARRANTY (3YR/36000 MILES) AND COULD NOT GET ANY OF MY SUSPENSION AND STEERING PROBLEMS FIXED BY A KNOWN ISSUE FROM GM. THEY HAVE STATED THAT THE INTERMEDIATE STEERING SHAFT IS NOT A SAFETY CONCERN. NOW, IF A PART THAT IS VITAL IN CONNECTING THE STEERING COLUMN TO THE RACK AND PINION SYSTEM IS NOT A SAFETY CONCERN, THEN I BELIEVE GM EXECUTIVES ARE MORE CONCERNED WITH COST OF DOING THE RIGHT THING THAN SAFETY OF THEIR CUSTOMERS. THESE ARE PARTS THAT KEEP A VEHICLE FROM FLIPPING OVER DURING SHARP TURNS AT HIGHWAY SPEEDS AND THAT KEEP THE CAR TRAVELING IN THE DIRECTION THE OPERATOR DETERMINES USING THE STEERING WHEEL. AFTER REPLACING THE PARTS TO CORRECT MY ISSUES, THE PROBLEM HAS RE-OCCURRED. THE PARTS WERE NOT CHANGED SO EVEN AFTER "FIXING" IT, IT WOULD EVENTUALLY RETURN. *TR
NHTSA ODI #10593465
180,000 miles · May 22, 2014
Steering
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE STEERING WHEEL BECAME DIFFICULT TO TURN AND THE POWER STEERING WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE STEERING COLUMN NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CURRENT AND FAILUR…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE STEERING WHEEL BECAME DIFFICULT TO TURN AND THE POWER STEERING WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE STEERING COLUMN NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CURRENT AND FAILURE MILEAGE WAS 180,000. DR
NHTSA ODI #10593454
Official recalls
5Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Sep 3, 2008
GM IS RECALLING 296,422 MY 2006-2008 CHEVROLET HHR VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT." THE DOOR ON THE STORAGE BIN IN THE TOP CENTER OF THE INSTRUMENT PANEL FAILED TO REMAIN CLOSED AS REQUIRED.
Consequence & remedy
Consequence: THIS STANDARD SPECIFIES PERFORMANCE REQUIREMENTS TO PROVIDE HEAD IMPACT PROTECTION FOR OCCUPANTS.
Remedy: A REDESIGNED LATCH WILL BE MADE AVAILABLE. THE RECALL BEGAN ON DECEMBER 23, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Jan 30, 2008
GM IS RECALLING 181,516 MY 2006-2008 CHEVROLET HHR VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF RAIL AIR BAGS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.' IN TESTS, ONE OF THE UPPER INTERIOR OCCUPANT PROTECTION TEST POINTS EXCEEDED THE STANDARD'S REQUIREMENT.
Consequence & remedy
Consequence: THIS STANDARD SPECIFIES PERFORMANCE REQUIREMENTS TO PROVIDE HEAD IMPACT PROTECTION FOR OCCUPANTS.
Remedy: DEALERS WILL INSTALL AN ENERGY-ABSORBING PLASTIC PIECE TO THE HEADLINER TRIM. THE RECALL BEGAN ON APRIL 2, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Oct 31, 2006
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
Consequence & remedy
Consequence: IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
Remedy: BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration