IllustrationThe door few open because the door latch broke off
2006 Chevrolet Hhr
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2006 Chevrolet Hhr do not stand out strongly from the model-year median of 565.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Hhr years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1050–25K
14725–50K
19650–75K
15075–100K
171100–150K
74150K+
843 reports with mileage · 163 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 458 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 222 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 119 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
47 crash reports8 fire reports24 injury reports
Suspension complaints
34 reportsCAR STARTED SMELLING GAS INSIDE WHEN DRIVING AND HAVE TO OPEN THE WINDOW TO GET SOME FRESH AIR. A CLICKING NOISE, TOO MUCH NOISE FROM THE FRONT SUSPENSION WHEN TURNING OR DRIVING..L TOOK THE CAR FOR OIL CHANGE AND THE DEALER TECH DID NOT WANT TO DRIVE THE CAR STATING THAT IT'S SAFETY ISSUES. THEY SAID THE LOWER CONTROL ARMS HAS…
Read full complaint
CAR STARTED SMELLING GAS INSIDE WHEN DRIVING AND HAVE TO OPEN THE WINDOW TO GET SOME FRESH AIR. A CLICKING NOISE, TOO MUCH NOISE FROM THE FRONT SUSPENSION WHEN TURNING OR DRIVING..L TOOK THE CAR FOR OIL CHANGE AND THE DEALER TECH DID NOT WANT TO DRIVE THE CAR STATING THAT IT'S SAFETY ISSUES. THEY SAID THE LOWER CONTROL ARMS HAS BEEN WEAR OUT AND THAT THE "SWAY BAR"IS SHORTER WEARING MY TIRES. IN JUST THIS YEAR L HAVE CHANGE THE 4 TIRES TWICE. DISCOUNT TIRES SAID THEY HAVE NOT SEEN SUCH A THING BEFORE THE WEARING OCCURES IN THE INSIDE PART OF THE TIRES... THE ENTIRE FRONT SUSPENSION IS COLLAPSING. GM NEED TO ISSUES A RECALL FOR THESE ISSUES.... THE DEALER GAVE ME A REPAIR QUOTE OF ALMOST $3000 ...GM NEED TO TAKE RESPONSIBILITY OF ALL THESE ISSUES AND OFFER A CREDIT OR REPURCHASED THE CAR BACK... L HAVE CHILDREN THAT L TRANSPORTER BACK AND FORTH TO SCHOOL AND TO HOSPITAL...AND NEED A SAFER CAR...
WHILE DRIVING THIS VEHICLE, THE POWER STEERING LIGHT FLASHES ON DASH BOARD AND I LOSE ALL THE FUNCTION OF THE POWER STEERING. IT HAS NOW HAPPENED 4 SEPARATE TIMES IN TWO WEEKS, THE LAST WHEN I WAS TURNING A CORNER AND NEARLY HIT A CAR ON THE SIDE OF THE ROAD BECAUSE I COULD NOT STEER THE VEHICLE. I HAVE A SAFETY RECALL LETTER …
Read full complaint
WHILE DRIVING THIS VEHICLE, THE POWER STEERING LIGHT FLASHES ON DASH BOARD AND I LOSE ALL THE FUNCTION OF THE POWER STEERING. IT HAS NOW HAPPENED 4 SEPARATE TIMES IN TWO WEEKS, THE LAST WHEN I WAS TURNING A CORNER AND NEARLY HIT A CAR ON THE SIDE OF THE ROAD BECAUSE I COULD NOT STEER THE VEHICLE. I HAVE A SAFETY RECALL LETTER FROM GENERAL MOTORS STATING THAT I HAD TO PAY OUT OF POCKET TO FIX AND THEN THEY WOULD DETERMINE IF IT FELL UNDER THERE RECALL. WHEN THE LETTER STATES TO BRING IT TO THE DEALERSHIP SHOULD THE POWER STEERING LIGHT EVER COMES ON THE DASH PANEL, WHICH IT HAS DONE KNOW 4 TIMES WHEN THE POWER STEERING FAILED. I COULD BEEN KILLED IF I HAD BEEN GOING FASTER OR KILLED SOME ONE. THIS IS AN ISSUE WITH THE GM FAULTY MECHANICS. FIRST IT WAS THE IGNITION HAVING TO GIVE MY VEHICLE UP FOR NEARLY 6 WEEKS TO HAVE IT FIXED. THIS IS A SERIOUS ISSUE THAT NEEDS TO BE ADDRESSED BY GENERAL MOTORS AND PAID FOR BY GENERAL MOTORS, NOT THE CONSUMER. WHAT IS IT GOING TO TAKE, ANOTHER DEATH BECAUSE OF THE MISTAKES. EVEN AFTER THEY NOTIFIED ME THAT IS A SAFETY ISSUE VIA LETTER, BUT I FIRST PAY OUT OF POCKET AND THEN DETERMINE IF THEY WILL REIMBURSE ME FOR IT. THE FIRST TIME I WAS IN DOWNTOWN LA GOING TO WORK AND ONCE AGAIN WHEN I TURNED LEFT WHILE DRIVING, THE SECOND ON THE 405 IN RUSH HOUR TRAFFIC, JUST AS I WAS ACCELERATING AND CHANGING LANES, THE LIGHT FLASHED ON THE DASH BOARD (POWER STEERING) AND I LOST ALL POWER STEERING CAPABILITY. THE THIRD WAS THE WEEK OF FEBRUARY 15, 2016. TURNING LEFT AGAIN AND THE FOURTH TIME JUST YESTERDAY AGAIN WHEN I TURNED LEFT.
A "CLUNKING" NOISE FROM THE FRONT SUSPENSION WHEN TURNING INTO A DRIVEWAY OR DIP IN STREET AT 3 OR 4 MILES PER HOUR. THIS PROBLEM HAS BEEN TAKEN TO THE CHEVROLET DEALERSHIP AND TO AN INDEPENDENT AUTO REPAIR SHOP WHERE I WAS TOLD THE "LOWER CONTROL ARMS REAR BUSHING WAS TORN (RUBBER) AND THEREFORE ALLOWING THE ARM TO MOVE TO WHE…
Read full complaint
A "CLUNKING" NOISE FROM THE FRONT SUSPENSION WHEN TURNING INTO A DRIVEWAY OR DIP IN STREET AT 3 OR 4 MILES PER HOUR. THIS PROBLEM HAS BEEN TAKEN TO THE CHEVROLET DEALERSHIP AND TO AN INDEPENDENT AUTO REPAIR SHOP WHERE I WAS TOLD THE "LOWER CONTROL ARMS REAR BUSHING WAS TORN (RUBBER) AND THEREFORE ALLOWING THE ARM TO MOVE TO WHERE IT CONTACTS THE FRAME OF THE VEHICLE. THIS IS DANGEROUS, AND COULD VERY WELL CAUSE THE STEERING TO MALFUNCTION AT A MOST INAPPROPRIATE TIME RESULTING IN A COLLAPSE OF THE FRONT END SUSPENSION. I WOULD LIKE GM TO CORRECT THIS DEFECT IN ENGINEERING, AND IF THEY CANNOT TO REPURCHASE MY VEHICLE SO I CAN PURCHASE A SAFE AND MORE RELIABLE VEHICLE. *TR
AT A RED LIGHT AND WAS REAR ENDED WHICH CAUSE ME TO IT THE REAR END OF THE CAR IN FRONT OF ME. *TR
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, THE VEHICLE SHOOK EXCESSIVELY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE MECHANIC STATED THAT THE FRONT PASSENGER WHEEL HUB ASSEMBLY NEEDED TO BE REPAIRED. THE VEHICLE WAS REPAIRED HOWEVER, SIX MONTHS AFTER THE REPAIR WAS PERFORM…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, THE VEHICLE SHOOK EXCESSIVELY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE MECHANIC STATED THAT THE FRONT PASSENGER WHEEL HUB ASSEMBLY NEEDED TO BE REPAIRED. THE VEHICLE WAS REPAIRED HOWEVER, SIX MONTHS AFTER THE REPAIR WAS PERFORMED THE FAILURE RECURRED. THE FAILURE MILEAGE WAS 118,000.
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 10 MPH OVER RAILROAD TRACKS, A NOISE EMITTED OUTSIDE OF THE VEHICLE. THE FAILURE ALSO RECURRED WHEN ENCOUNTERING A BUMP OR POTHOLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER ON THREE SEPARATE OCCASIONS WHERE THE STABILIZER LINK, SWAY BA…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 10 MPH OVER RAILROAD TRACKS, A NOISE EMITTED OUTSIDE OF THE VEHICLE. THE FAILURE ALSO RECURRED WHEN ENCOUNTERING A BUMP OR POTHOLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER ON THREE SEPARATE OCCASIONS WHERE THE STABILIZER LINK, SWAY BAR AND BUSHINGS, AND FRONT STRUTS WERE REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 12,000. UPDATED 8/19/14*CN UPDATED 08/23/2017*CT
2006 CHEVROLET HHR. CONSUMER WRITES IN REGARDS TO IGNITION SWITCH RECALL AND POWER STEERING AND OTHER VEHICLE PROBLEMS. *SMD THE CONSUMER STATED TWO DAYS AFTER GETTING THE VEHICLE BACK FROM THE DEALER, THE VEHICLE HAD TO BE FLAT-BEDDED BACK TO THE DEALER, BECAUSE IT WOULDN'T START. IT WAS DETERMINED THE IGNITION SWITCH NEEDE…
Read full complaint
2006 CHEVROLET HHR. CONSUMER WRITES IN REGARDS TO IGNITION SWITCH RECALL AND POWER STEERING AND OTHER VEHICLE PROBLEMS. *SMD THE CONSUMER STATED TWO DAYS AFTER GETTING THE VEHICLE BACK FROM THE DEALER, THE VEHICLE HAD TO BE FLAT-BEDDED BACK TO THE DEALER, BECAUSE IT WOULDN'T START. IT WAS DETERMINED THE IGNITION SWITCH NEEDED TO BE REPLACED. ALSO, THE RIGHT PASSENGER OUTSIDE MIRROR FELL OFF, THE RIGHT PASSENGER WIPER ARM BROKE, THE ROTORS WERE REPLACED TWICE IN TWO YEARS, AND THE REAR SHOCKS WERE REPLACED.*JB
THERE APPEARS TO BE A LARGE AMOUNT OF COBALT AND HHR OWNERS WITH COMPLAINTS ABOUT SUSPENSION CLUNKING NOISES. RESEARCH SHOWS THERE IS AN ISSUE WITH THE STABILIZER BAR PARTS AND ALSO THE INTERMEDIATE STEERING SHAFT. THESE PROBLEMS OCCUR AT MANY INTERVALS OF MILEAGE RANGING FROM 10,000 MILES AND UP. GM HAS SINCE SUED THE MANUFACTU…
Read full complaint
THERE APPEARS TO BE A LARGE AMOUNT OF COBALT AND HHR OWNERS WITH COMPLAINTS ABOUT SUSPENSION CLUNKING NOISES. RESEARCH SHOWS THERE IS AN ISSUE WITH THE STABILIZER BAR PARTS AND ALSO THE INTERMEDIATE STEERING SHAFT. THESE PROBLEMS OCCUR AT MANY INTERVALS OF MILEAGE RANGING FROM 10,000 MILES AND UP. GM HAS SINCE SUED THE MANUFACTURER OF THE INTERMEDIATE STEERING SHAFT FOR THOSE REPLACED UNDER WARRANTY EQUALING $30MIL. I AM UNLUCKY AS MY VEHICLE WAS OUT OF WARRANTY (3YR/36000 MILES) AND COULD NOT GET ANY OF MY SUSPENSION AND STEERING PROBLEMS FIXED BY A KNOWN ISSUE FROM GM. THEY HAVE STATED THAT THE INTERMEDIATE STEERING SHAFT IS NOT A SAFETY CONCERN. NOW, IF A PART THAT IS VITAL IN CONNECTING THE STEERING COLUMN TO THE RACK AND PINION SYSTEM IS NOT A SAFETY CONCERN, THEN I BELIEVE GM EXECUTIVES ARE MORE CONCERNED WITH COST OF DOING THE RIGHT THING THAN SAFETY OF THEIR CUSTOMERS. THESE ARE PARTS THAT KEEP A VEHICLE FROM FLIPPING OVER DURING SHARP TURNS AT HIGHWAY SPEEDS AND THAT KEEP THE CAR TRAVELING IN THE DIRECTION THE OPERATOR DETERMINES USING THE STEERING WHEEL. AFTER REPLACING THE PARTS TO CORRECT MY ISSUES, THE PROBLEM HAS RE-OCCURRED. THE PARTS WERE NOT CHANGED SO EVEN AFTER "FIXING" IT, IT WOULD EVENTUALLY RETURN. *TR
FUEL LEAK IN FRONT OF DRIVERS SIDE REAR WHEEL. THIS IS COMPLETELY UNACCEPTABLE IN AN 8 YEAR OLD VEHICLE. THE FUEL LINE CORRODED AND LEAKED HEAVILY, COST ME $254.22 TO REPLACE THIS FAULTY GAS LINE. I AM OBVIOUSLY NOT THE ONLY PERSON THIS HAS HAPPENED TO. I HAVE ALSO HAD ALL THE OTHER TYPICAL PROBLEMS SUCH AS THE KEY WILL NOT RELE…
Read full complaint
FUEL LEAK IN FRONT OF DRIVERS SIDE REAR WHEEL. THIS IS COMPLETELY UNACCEPTABLE IN AN 8 YEAR OLD VEHICLE. THE FUEL LINE CORRODED AND LEAKED HEAVILY, COST ME $254.22 TO REPLACE THIS FAULTY GAS LINE. I AM OBVIOUSLY NOT THE ONLY PERSON THIS HAS HAPPENED TO. I HAVE ALSO HAD ALL THE OTHER TYPICAL PROBLEMS SUCH AS THE KEY WILL NOT RELEASE FROM IGNITION, BAD ROTORS, LOOSE FRONT END BUSHINGS AND EXCESSIVE FRONT END VIBRATION OVER TYPICAL STREET CRACKS. BROKEN DRIVERS SIDE INTERIOR DOOR HANDLE, CRACKED WINDSHIELD...... *TR UPDATED 10/22/2014 *JS
Official recalls
514V171000 · Electrical System:ignition
Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
14V047000 · Air Bags; Electrical System:ignition:switch
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
08V444000 · Latches/locks/linkages:doors:latch
Sep 3, 2008
GM IS RECALLING 296,422 MY 2006-2008 CHEVROLET HHR VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT." THE DOOR ON THE STORAGE BIN IN THE TOP CENTER OF THE INSTRUMENT PANEL FAILED TO REMAIN CLOSED AS REQUIRED.
Consequence & remedy
Consequence: THIS STANDARD SPECIFIES PERFORMANCE REQUIREMENTS TO PROVIDE HEAD IMPACT PROTECTION FOR OCCUPANTS.
Remedy: A REDESIGNED LATCH WILL BE MADE AVAILABLE. THE RECALL BEGAN ON DECEMBER 23, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
08V046000 · Air Bags
Jan 30, 2008
GM IS RECALLING 181,516 MY 2006-2008 CHEVROLET HHR VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF RAIL AIR BAGS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.' IN TESTS, ONE OF THE UPPER INTERIOR OCCUPANT PROTECTION TEST POINTS EXCEEDED THE STANDARD'S REQUIREMENT.
Consequence & remedy
Consequence: THIS STANDARD SPECIFIES PERFORMANCE REQUIREMENTS TO PROVIDE HEAD IMPACT PROTECTION FOR OCCUPANTS.
Remedy: DEALERS WILL INSTALL AN ENERGY-ABSORBING PLASTIC PIECE TO THE HEADLINER TRIM. THE RECALL BEGAN ON APRIL 2, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
06V417000 · Air Bags:frontal
Oct 31, 2006
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
Consequence & remedy
Consequence: IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
Remedy: BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.