NHTSA owner reports · September 18, 2026 snapshot.
Steering complaints
458 reportsClear category filter128,000 miles · Apr 24, 2015
Steering
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT WHILE MAKING A LEFT TURN AT 10 MPH, THE STEERING WHEEL BECAME DIFFICULT TO TURN. THE CONTACT HAD TO APPLY FORCE TO THE STEERING WHEEL IN ORDER TO TURN THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE MANUFACT…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT WHILE MAKING A LEFT TURN AT 10 MPH, THE STEERING WHEEL BECAME DIFFICULT TO TURN. THE CONTACT HAD TO APPLY FORCE TO THE STEERING WHEEL IN ORDER TO TURN THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 128,000.
NHTSA ODI #10712741
140,000 miles · Apr 6, 2015
Steering
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. WHILE DRIVING APPROXIMATELY 60 MPH, THE STEERING WHEEL BECAME DIFFICULT TO TURN WITHOUT WARNING. THE FAILURE RECURRED EACH TIME THE VEHICLE WAS DRIVEN. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE POWER STEERING COLUMN NEEDED TO BE REPLACED. THE VEHICLE WAS NOT RE…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. WHILE DRIVING APPROXIMATELY 60 MPH, THE STEERING WHEEL BECAME DIFFICULT TO TURN WITHOUT WARNING. THE FAILURE RECURRED EACH TIME THE VEHICLE WAS DRIVEN. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE POWER STEERING COLUMN NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 140,000.
NHTSA ODI #10704036
Mileage unknown · Mar 4, 2015
Electrical SystemSteering
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. AFTER THE VEHICLE WAS SERVICED UNDER NHTSA CAMPAIGN NUMBERS: 14V047000 (AIR BAGS, ELECTRICAL SYSTEM) AND 14V171000 (ELECTRICAL SYSTEM), THE STEERING WHEEL SEIZED AND THE VEHICLE STALLED. THE VEHICLE WAS ABLE TO RESTART. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. AFTER THE VEHICLE WAS SERVICED UNDER NHTSA CAMPAIGN NUMBERS: 14V047000 (AIR BAGS, ELECTRICAL SYSTEM) AND 14V171000 (ELECTRICAL SYSTEM), THE STEERING WHEEL SEIZED AND THE VEHICLE STALLED. THE VEHICLE WAS ABLE TO RESTART. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.
NHTSA ODI #10692136
Mileage unknown · Mar 3, 2015
Air BagsSteeringVehicle Speed ControlCrashInjury
CAR SPEEDED UP AND DOWN ,CAR STARTED TO SPIN IN CIRCLE,LOST POWER STEERING,LOST CONTROL OF CAR, FLIPPED AND ROLLED OVER 3 TIMES DOWN A 30 YD. CLIFF . NO HEAD AIR BAGS WORKED AT ALL ,ONLY THE STEERING WHEEL AIR BAG WORKED. TOOK OVER 2 HRS. TO BE FOUND BY POLICE. HAD TO USE CELL PHONE SIGNAL TO BE FOUND. *TR
NHTSA ODI #10691964
80,000 miles · Feb 27, 2015
Electrical SystemSteeringFire
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE INSTRUMENT PANEL SHORTED INTERMITTENTLY AND CAUSED ELECTRICAL FAILURES WITHIN THE VEHICLE. THE CONTACT MENTIONED THAT THE STEERING WHEEL WAS EXTREMELY TIGHT AND INTERMITTENTLY LOCKED WITHOUT WARNING. UPON USING THE CIGARETTE LIGHTER, SMOKE EMITTED INSIDE THE …
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE INSTRUMENT PANEL SHORTED INTERMITTENTLY AND CAUSED ELECTRICAL FAILURES WITHIN THE VEHICLE. THE CONTACT MENTIONED THAT THE STEERING WHEEL WAS EXTREMELY TIGHT AND INTERMITTENTLY LOCKED WITHOUT WARNING. UPON USING THE CIGARETTE LIGHTER, SMOKE EMITTED INSIDE THE VEHICLE INDICATING THAT THERE WAS AN ELECTRICAL FIRE WITH THE WIRES. THE FIRE EXTINGUISHED WITHOUT HAVING TO CONTACT THE FIRE DEPARTMENT. THE VEHICLE WAS NOT INSPECTED AND DIAGNOSED. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBERS: 14V171000 (ELECTRICAL SYSTEM) AND 14V047000 (AIR BAGS, ELECTRICAL SYSTEM) BUT WAS UNABLE TO DETERMINE WHEN THE RECALL REPAIR WOULD BE PERFORMED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.
NHTSA ODI #10691182
60,000 miles · Feb 23, 2015
Electrical SystemSteering
RECEIVED LETTER FROM CHEVROLET DATED 1-2015 STATING THAT "SOME 2006 HHR'S" MAY HAVE A DEFECT WHICH CAUSES POWER STEERING (PS) TO FAIL AT ANY TIME. CALLED LOCAL DEALER TO HAVE IT REPAIRED BUT MY CAR (VIN) IS NOT ON THE RECALL LIST. THE EXACT SEQUENCE OF PS FAILURE DESCRIBED IN LETTER HAS OCCURRED WITH MY CAR MULTIPLE TIMES BUT T…
Read full complaint
RECEIVED LETTER FROM CHEVROLET DATED 1-2015 STATING THAT "SOME 2006 HHR'S" MAY HAVE A DEFECT WHICH CAUSES POWER STEERING (PS) TO FAIL AT ANY TIME. CALLED LOCAL DEALER TO HAVE IT REPAIRED BUT MY CAR (VIN) IS NOT ON THE RECALL LIST. THE EXACT SEQUENCE OF PS FAILURE DESCRIBED IN LETTER HAS OCCURRED WITH MY CAR MULTIPLE TIMES BUT THEY, CHEVROLET DEALER, DOES NOT GUARANTEE THAT THIS WILL BE FIXED WITHOUT MY PAYING THE BILL AS IT (VIN) IS NOT ON THEIR LIST. MY CAR SHOULD BE ENTERED INTO THE RECALL LIST AS THIS IS A MANUFACTURERS MECHANICAL DEFECT AND NEEDS TO BE RECALLED AND REPAIRED AT GM'S COST. THIS IS THE 3RD LETTER (RECALL) ON THIS CAR; IGNITION CYLINDER, TRANSMISSION LOCK AND NOW POWER STEERING! *TR
NHTSA ODI #10690073
132,825 miles · Feb 12, 2015
Steering
ON THE DATE ABOVE I HAD MY POWER STEERING WARNING LIGHT COME ON AND STAYED ON FOR ABOUT 2 HOURS. THE NEXT DAY WHEN I STARTED THE CAR THE LIGHT WAS OUT. WELL THIS WEEK I RECEIVED A LETTER FROM GM STATING THAT IF THE LIGHT COMES ON OR IF YOU HAVE HAD AN ISSUE WITH THE LIGHT COMING ON TO TAKE IT TO YOUR DEALER.THESE ARE THE EXACT W…
Read full complaint
ON THE DATE ABOVE I HAD MY POWER STEERING WARNING LIGHT COME ON AND STAYED ON FOR ABOUT 2 HOURS. THE NEXT DAY WHEN I STARTED THE CAR THE LIGHT WAS OUT. WELL THIS WEEK I RECEIVED A LETTER FROM GM STATING THAT IF THE LIGHT COMES ON OR IF YOU HAVE HAD AN ISSUE WITH THE LIGHT COMING ON TO TAKE IT TO YOUR DEALER.THESE ARE THE EXACT WORDS IN THE LETTER: IF THIS CONDITION OCCURS ON YOUR 2006 CHEVROLET HHR, THE CONDITION WILL BE REPAIRED FOR YOU AT NO CHARGE. TODAY TOOK MY CAR IN FOR A ROUTINE SERVICE AND ASK THE DEALER ABOUT THE LETTER AND HE SAID HE WOULD CHECK ON IT. A FEW MINUTES LATER HE TOLD ME THEY HAD A POWER STEERING MOTOR IN STOCK AND IT WOULD TAKE ABOUT 45 MINUTES TO INSTALL IF I HAD THE TIME AND I SAID I COULD WAIT. HE CAME TO THE WAITING ROOM AND SAID I WAS READY TO GO AND THE STEERING MOTOR WAS NOT THE PROBLEM CAUSING THE LIGHT, BUT THE STEERING CONTROL MODULE WHICH IS PART OF THE STEERING COLUMN ASSEMBLY AND NOT COVERED BY THE LETTER. WELL GUESS WHAT, THE STEERING COLUMN ASSEMBLY IS ONLY SOLD WITH A NEW STEERING MOTOR, SO IF I REPLACED THE COLUMN GM GETS $578.59 FOR THE PART PLUS LABOR COST TO INSTALL AND THEY PAY FOR NOTHING TO CURE THE ISSUE. I WAS A MECHANIC ON ROAD TRUCKS AND HEAVY EQUIPMENT FOR SEVERAL YEARS AND KNOW IF YOU HAVE AN ELECTRIC MOTOR IT HAS TO GET IT'S COMMANDS ON HOW TO REACT FROM SOME TYPE OF CONTROL SOURCE ( STEERING CONTROL MODULE) WOULD BE MY GUESS WOULDN'T YOU THINK. NO WHERE IN MY LETTER DOES IT STATE STEERING MOTOR ONLY IS COVERED TO SOLVE THE ISSUE AND NO WHERE ON THE REIMBURSEMENT REQUEST FORM DOES IT SAY THEY WILL ONLY REIMBURSE FOR THE MOTOR. I HAD AN ONLINE CHAT WITH A GM CUSTOMER SERVICE AND WAS TOLD ONLY THE MOTOR ACCORDING TO HER WRITTEN INFORMATION. WHEN I REQUESTED A COPY OF WHAT IS COVERED, I WAS TOLD TO ASK THE DEALER FOR A COPY. *TR
NHTSA ODI #10682948
65,966 miles · Jan 21, 2015
Engine And Engine CoolingSteering
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH AND MAKING A RIGHT TURN, THE POWER STEERING WARNING LIGHT ILLUMINATED AND THE STEERING WHEEL SEIZED. THE CONTACT HAD TO RESTART THE VEHICLE IN ORDER FOR TO RESUME NORMAL FUNCTION. THE VEHICLE WAS TAKEN TO THE INDEPENDENT MECHANI…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH AND MAKING A RIGHT TURN, THE POWER STEERING WARNING LIGHT ILLUMINATED AND THE STEERING WHEEL SEIZED. THE CONTACT HAD TO RESTART THE VEHICLE IN ORDER FOR TO RESUME NORMAL FUNCTION. THE VEHICLE WAS TAKEN TO THE INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE FUSE BOX NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE PERSISTED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 65,966. ...UPDATED 03-11-15 *BF THE CONSUMER STATED THE PART WAS REPLACED AND THERE HAVE BEEN NO MORE STEERING ISSUE. HOWEVER, THE CHECK ENGINE LIGHT ILLUMINATED INTERMITTENTLY. UPDATED 03/26/15*JB
NHTSA ODI #10677110
25,000 miles · Dec 28, 2014
SteeringCrashInjury
DRIVING WITH CRUISE CONTROL ON, WEATHER VERY NICE AND ROAD DRY AROUND 7-7:30PM ON FAMILIAR ROAD. CAR HAD BEEN PULLING TO THE RIGHT FOR ABOUT A WEEK. HAD SON CHECK TIRES BEFORE LEAVING NEWARK OH AND HEADING HOME. ALL OF A SUDDEN THE VEHICLE WENT OFF ROAD TOTALED CAR AND I WAS IN HOSPITAL FOR 2 1/2DAYS. HAD BEEN KNOCKED OUT,…
Read full complaint
DRIVING WITH CRUISE CONTROL ON, WEATHER VERY NICE AND ROAD DRY AROUND 7-7:30PM ON FAMILIAR ROAD. CAR HAD BEEN PULLING TO THE RIGHT FOR ABOUT A WEEK. HAD SON CHECK TIRES BEFORE LEAVING NEWARK OH AND HEADING HOME. ALL OF A SUDDEN THE VEHICLE WENT OFF ROAD TOTALED CAR AND I WAS IN HOSPITAL FOR 2 1/2DAYS. HAD BEEN KNOCKED OUT, SEAT BELT RUBBED NECK TO ALMOST BLEEDING, AIR BAG BURNED HOLE IN SLEEVE OF COAT. NO BROKEN BONES BUT VERY SHAKEN UP. I WANT TO KNOW IF THIS WAS CAUSED BY THE STEERING PROBLEM THAT HAS BEEN BEEN ON RECALL. HAVE PICTURES OF THE CAR AND THE ROAD TO SHOW HOW THE TIRE MARKS ABRUPTLY TURN TO THE RIGHT.
NHTSA ODI #10669019
90,000 miles · Nov 25, 2014
Steering
THE FIRST TIME THIS HAPPEN I WAS ON THE INTERSTATE WITH MY WIFE AND KID IN THE CAR. THE ROAD CURVED TO THE RIGHT AND AS I WAS GOING AROUND IT, I LOST POWER STEERING. LUCKILY I WAS ABLE TO USE FORCE AND MAINTAIN CONTROL AROUND THE CORNER. IF MY WIFE WAS DRIVING SHE MIGHT NOT HAVE BEEN ABLE TO BECAUSE IT TOOK EVERYTHING I HAD TO T…
Read full complaint
THE FIRST TIME THIS HAPPEN I WAS ON THE INTERSTATE WITH MY WIFE AND KID IN THE CAR. THE ROAD CURVED TO THE RIGHT AND AS I WAS GOING AROUND IT, I LOST POWER STEERING. LUCKILY I WAS ABLE TO USE FORCE AND MAINTAIN CONTROL AROUND THE CORNER. IF MY WIFE WAS DRIVING SHE MIGHT NOT HAVE BEEN ABLE TO BECAUSE IT TOOK EVERYTHING I HAD TO TURN THE WHEEL AND GET AROUND THE CORNER. SINCE THEN IT HAS HAPPENED ALMOST EVERYDAY, SOMETIMES A FEW TIMES A DAY. WHEN THIS HAPPENS I GET A DASHBOARD MESSAGE THAT SAYS "POWER STEERING". MY WIFE WILL NOT DRIVE THE CAR UNLESS ITS JUST A QUICK TRIP TO THE STORE, AND WE REFUSE TO PUT OUR SON IN THAT CAR. THIS IS A VERY DANGEROUS PROBLEM AND I DON'T KNOW HOW THIS HAS NOT BEEN RECALLED YET. *TR
NHTSA ODI #10660785
Official recalls
5Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Sep 3, 2008
GM IS RECALLING 296,422 MY 2006-2008 CHEVROLET HHR VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT." THE DOOR ON THE STORAGE BIN IN THE TOP CENTER OF THE INSTRUMENT PANEL FAILED TO REMAIN CLOSED AS REQUIRED.
Consequence & remedy
Consequence: THIS STANDARD SPECIFIES PERFORMANCE REQUIREMENTS TO PROVIDE HEAD IMPACT PROTECTION FOR OCCUPANTS.
Remedy: A REDESIGNED LATCH WILL BE MADE AVAILABLE. THE RECALL BEGAN ON DECEMBER 23, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Jan 30, 2008
GM IS RECALLING 181,516 MY 2006-2008 CHEVROLET HHR VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF RAIL AIR BAGS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.' IN TESTS, ONE OF THE UPPER INTERIOR OCCUPANT PROTECTION TEST POINTS EXCEEDED THE STANDARD'S REQUIREMENT.
Consequence & remedy
Consequence: THIS STANDARD SPECIFIES PERFORMANCE REQUIREMENTS TO PROVIDE HEAD IMPACT PROTECTION FOR OCCUPANTS.
Remedy: DEALERS WILL INSTALL AN ENERGY-ABSORBING PLASTIC PIECE TO THE HEADLINER TRIM. THE RECALL BEGAN ON APRIL 2, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Oct 31, 2006
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
Consequence & remedy
Consequence: IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
Remedy: BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration