IllustrationI HAD CAME BACK HOME AND PUT THE CAR INTO PARK, I TURNED THE ENGINE OFF, AND TRIED TO PULL OUT THE KEY AND THE KEY WAS STUCK IN THE ON POSITION. *TR
2006 Chevrolet Hhr
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2006 Chevrolet Hhr do not stand out strongly from the model-year median of 565.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Hhr years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1050–25K
14725–50K
19650–75K
15075–100K
171100–150K
74150K+
843 reports with mileage · 163 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 458 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 222 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 119 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
47 crash reports8 fire reports24 injury reports
Power Train complaints
82 reportsPOWER STEERING MESSAGE ON DASH; SECURITY LIGHT COMES ON; RPM, SPEED, AND GAS GAUGES JUMP, TRANSMISSION JERKS, CLICKING IN CENTER CONSOLE UNDER SHIFTER. AFTER TURNING ENGINE OFF FOR PERIOD OF TIME RUNS LIKE NORMAL, RESTART AN DRIVE FOR PERIOD OF TIME AND POWER STEERING GOES OUT WHILE DRIVING. *TR
AFTER TRAVELING BACK AND FORTH FROM ONE COUNTY TO ANOTHER (APPROX 130 MILES ROUNDTRIP) AS I EXITED THE FWY THE CAR WAS DRIVING NORMAL EXCEPT FOR I WAS ON EMPTY AT THIS POINT. I CAME TO A COMPLETE STOP WHEN LIGHT TURNED GREEN I BEGAN TO ACCELERATE. UPON ACCELERATION AT APPROX. 10-15MPH THE CAR MADE A HARD JERKING MOTION AS THOUGH…
Read full complaint
AFTER TRAVELING BACK AND FORTH FROM ONE COUNTY TO ANOTHER (APPROX 130 MILES ROUNDTRIP) AS I EXITED THE FWY THE CAR WAS DRIVING NORMAL EXCEPT FOR I WAS ON EMPTY AT THIS POINT. I CAME TO A COMPLETE STOP WHEN LIGHT TURNED GREEN I BEGAN TO ACCELERATE. UPON ACCELERATION AT APPROX. 10-15MPH THE CAR MADE A HARD JERKING MOTION AS THOUGH IT WAS HAVING A HARD TIME SHIFTING GEARS HOWEVER MY 06 HHR IS AN AUTOMATIC. AT THIS POINT I ALSO NOTICED THAT THE CHECK ENGINE LIGHT HAD NOW ILLUMINATED ON THE INSTRUMENT PANEL. I TOOK THE CAR STRAIGHT HOME AND DID NOT ATTEMPT TO DRIVE AGAIN FOR 3-4 DAYS. THEN ONE DAY I DROVE IT APPROX 15 MILES ALL WAS GOOD. I WENT SHOPPING UPON LEAVING THE CAR STILL APPEARED TO BE NORMAL. THEN WHILE ON THE FWY APPROX 70MPH I NOTICED THE CHECK ENGINE LIGHT ON AGAIN AS WELL AS THE T/C LIGHT (TRACTION CONTROL) THE CAR CONTINUED TO DRIVE "NORMAL" BUT ONCE I CAME TO A STOP ON THE OFFRAMP AND BEGAN TO ACCELERATE THE JERKING MOTION HAPPENED AGAIN. I'VE NOTICED THAT ON A FEW OCCASIONS THIS HAPPENS ONCE THE GAS IS ON EMPTY. I ALSO NOTICED ON ONE OCCASION THAT ONCE I HAD PUT A LITTLE OVER HALF A TANK OF GAS IN AS WELL AS A BOTTLE OF FUEL INJECTOR CLEANER THAT THE INDICATOR LIGHTS SHUT OFF AS WELL AS THE JERKING HAD DISAPPEARS. WE HAVE HAD THE TRANSMISSION FLUSHED AND STILL THE PROBLEM PERSISTS. ASIDE FROM THAT WHEN YOU TRY TO REMOTE START THE ENGINE ONCE THE CHECK ENGINE LIGHT HAS COME ON THE REMOTE START NO LONGER WORKS. YOU HEAR THE ELECTRICAL ALL COME ON BUT THAT'S IT. THEN ALL OF A SUDDEN THE OTHER NIGHT I ATTEMPT TO EXIT MY CAR AND THE DRIVER DOOR HANDLE SNAPPED RIGHT OFF. MY HUSBAND CONTACTED THE LOCAL DEALERSHIP REQUESTING PRICE FOR THE PART AND WAS TOLD $300+. I JUST FOUND THE PIECE FOR $63.00 ONLINE. ..UNBELIEVABLE! BUT THE HANDLE BROKE SO EASILY. I DIDN'T PULL HARD. IF I HAD THE DOOR WOULD'VE AT LEAST POPPED OPEN A LIL. BUT IT DIDN'T BUDGE. *TR
SOME PORTION OF THE SHIFTER MECHANISM FAILED. IT ALLOWS THE VEHICLE TO SHIFT GEARS AT WILL, WITH OR WITHOUT A KEY AND WITH OR WITHOUT THE ENGINE RUNNING. IT ALSO ALLOWS THE VEHICLE TO BE PUT INTO GEAR WITHOUT DEPRESSING THE BRAKE PEDAL. THE VEHICLE CAN 'BUMP' FROM 'PARK' INTO ANY GEAR AND FROM ANY GEAR TO ANY OTHER GEAR, INCLUDI…
Read full complaint
SOME PORTION OF THE SHIFTER MECHANISM FAILED. IT ALLOWS THE VEHICLE TO SHIFT GEARS AT WILL, WITH OR WITHOUT A KEY AND WITH OR WITHOUT THE ENGINE RUNNING. IT ALSO ALLOWS THE VEHICLE TO BE PUT INTO GEAR WITHOUT DEPRESSING THE BRAKE PEDAL. THE VEHICLE CAN 'BUMP' FROM 'PARK' INTO ANY GEAR AND FROM ANY GEAR TO ANY OTHER GEAR, INCLUDING "REVERSE". WHILE DRIVING, ONE BUMP CAUSED IT TO SHIFT INTO 'NEUTRAL'. ANOTHER CAUSED A DOWNSHIFT. ONE CAN LEAVE TURN OFF THE IGNITION & LEAVE THE CAR WITHOUT PUTTING IT SECURELY INTO 'PARK'. I AM NOT POSITIVE, BUT I BELIEVE I COULD ALSO MAKE THE STEERING COLUMN LOCK WHILE THE IGNITION WAS ON. I TRIED THIS WHILE ATTEMPTING TO REMOVE THE KEY. I DID NTO WANT TO TRY AGAIN, FEARING I WOULD MAKE THE SITUATION WORSE. ADDITIONALLY, THE KEY IS NOW RETAINED IN THE IGNITION AND CAN NOT BE REMOVED. THE CAR CAN BE MORE EASILY STOLEN. (ON MINE, I FOUND OUT HOW TO FORCE THE KEY OUT OF THE IGNITION. BUT THE GEAR SHIFTER CAN STILL BUMP AROUND.) THE MENTIONED CRASH WAS FROM EXITING THE CAR EITHER WITHOUT IT BEING SECURELY IN 'PARK' OR FROM HAVING IT FALLOUT OF 'PARK'. IT ROLLED INTO A PARKED VEHICLE. I ENTERED "0 MPH" BECAUSE I WASN'T THERE TO SEE THE CAR ROLL. IT WAS ON A SMALL ENOUGH INCLINE THAT NO DAMAGE WAS DONE OTHER THAN SCRATCHES. *TR
FOR ABOUT A MONTH MY KEY KEPT GETTING STUCK IN THE IGNITION BUT I COULD ALWAYS GET IT OUT MYSELF. I WOULD SHIFT FROM "PARK" TO "DRIVE" AND THEN BACK TO "PARK" TO REMOVE IT. FINALLY ONE DAY I COULD NOT REMOVE IT. I BROUGHT IT TO THE DEALERSHIP AND HAD TO HAVE A PART IN THE SHIFTER REPLACED TO FIX THE PROBLEM. APPARENTLY THE "CAR"…
Read full complaint
FOR ABOUT A MONTH MY KEY KEPT GETTING STUCK IN THE IGNITION BUT I COULD ALWAYS GET IT OUT MYSELF. I WOULD SHIFT FROM "PARK" TO "DRIVE" AND THEN BACK TO "PARK" TO REMOVE IT. FINALLY ONE DAY I COULD NOT REMOVE IT. I BROUGHT IT TO THE DEALERSHIP AND HAD TO HAVE A PART IN THE SHIFTER REPLACED TO FIX THE PROBLEM. APPARENTLY THE "CAR" COULD NO LONGER RECOGNIZE IT WAS IN PARK AND SAFE TO REMOVE THE KEYS. THE COST WAS $250.00 AND NOW THE KEY STILL STICKS. IT SEEMS LIKE THIS IS A REAL PROBLEM AND CHEVY SHOULD TAKE RESPONSIBILITY FOR IT. *JB
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT SHE SHIFTED INTO PARK AND THE KEY WOULD NOT REMOVE FROM THE IGNITION. THE CONTACT ALSO STATED THAT THE BUTTON LOCATED ON THE GEAR SHIFT WAS JAMMED INSIDE OF THE SHIFTER ITSELF. DUE TO THE JAMMING OF THAT BUTTON, THE GEAR SHIFT MOVED FREELY BETWEEN GEARS EVEN THOU…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT SHE SHIFTED INTO PARK AND THE KEY WOULD NOT REMOVE FROM THE IGNITION. THE CONTACT ALSO STATED THAT THE BUTTON LOCATED ON THE GEAR SHIFT WAS JAMMED INSIDE OF THE SHIFTER ITSELF. DUE TO THE JAMMING OF THAT BUTTON, THE GEAR SHIFT MOVED FREELY BETWEEN GEARS EVEN THOUGH THE BRAKE PEDAL WAS NOT DEPRESSED. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE FAILURE MILEAGE WAS 82,000.
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT WAS UNABLE TO REMOVE THE KEY FROM THE IGNITION. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING WHERE THE TECHNICIAN ADVISED THAT THE GEAR SHIFTER WOULD HAVE TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 64,186.
DISPLAY SHOWED POWER STEERING ERROR AND TRANSMISSION BOX WAS CLICKING. CAR STARTED BUCKING AS IF TRANSMISSION WAS GOING OUT. TOOK TO DEALER WHO COULD NOT REPLICATE ERROR AFTER THREE DAYS. PICKED UP CAR AND NOW CD PLAYER SHOWS ERR O. THIS IS FRUSTRATING AS HECK! DEALER DID SAY THAT THERE WAS A BULLETIN THAT 2006 HHR'S DID HA…
Read full complaint
DISPLAY SHOWED POWER STEERING ERROR AND TRANSMISSION BOX WAS CLICKING. CAR STARTED BUCKING AS IF TRANSMISSION WAS GOING OUT. TOOK TO DEALER WHO COULD NOT REPLICATE ERROR AFTER THREE DAYS. PICKED UP CAR AND NOW CD PLAYER SHOWS ERR O. THIS IS FRUSTRATING AS HECK! DEALER DID SAY THAT THERE WAS A BULLETIN THAT 2006 HHR'S DID HAVE THIS TYPE OF PROBLEM. DEALER REP. OWNS 2007 HHR AND HOPED HE DID NOT HAVE THE SAME ISSUE. SPENT OVER $700 TOTAL AND PROBLEM STILL THERE? CHEVROLET / GM WHERE IS YOUR LOYALTY TO YOUR LOYAL CUSTOMERS? ISSUE A RECALL AND FIX THESE ISSUES BEFORE THERE ARE DEATHS BECAUSE OF THEM AND YOU ARE FORCED TO DO WHAT IS RIGHT BY THE GOV.'T. *TR
MY GEAR SHIFTER IS MALFUNCTIONING. IT IS STUCK IN PARK. I DO NOT HAVE RELIABLE TRANSPORTATION AND WOULD LIKE THIS REPAIR TO BE ON THE RECALL LIST WITH CHEVY BEING THAT THERE ARE A MULTITUDE OF COMPLAINTS ABOUT THE GEAR SHIFTER. *TR
I PUT MY CAR IN PARK AND WHEN I WENT TO TAKE THE KEY OUT OF THE IGNITION IT WOULD NOT COME OUT. I REALIZED THAT THE KEY WOULD NOT COME OUT BECAUSE THE GEAR SHIFTER PIECE WAS PUSHED ALL THE WAY IN, IT WAS BROKE. THIS MEANT THAT MY CAR WAS LEFT ON AND THE BATTERY WAS DRAINED BECAUSE I COULD NOT TURN MY CAR OFF. NOW MY CAR WILL NOT…
Read full complaint
I PUT MY CAR IN PARK AND WHEN I WENT TO TAKE THE KEY OUT OF THE IGNITION IT WOULD NOT COME OUT. I REALIZED THAT THE KEY WOULD NOT COME OUT BECAUSE THE GEAR SHIFTER PIECE WAS PUSHED ALL THE WAY IN, IT WAS BROKE. THIS MEANT THAT MY CAR WAS LEFT ON AND THE BATTERY WAS DRAINED BECAUSE I COULD NOT TURN MY CAR OFF. NOW MY CAR WILL NOT START AT ALL THE BATTERY IS CHARGED BUT THE CAR WILL NOT TURNOVER. I HAVE LOOKED ONLINE AND HAVE FOUND THAT THERE ARE MANY COMPLAINTS CONCERNING THE SAME PROBLEM WITH THIS VEHICLE. I AM TOLD BY THE DEALERSHIP THAT I HAVE TO PAY $710 TO HAVE THIS PROBLEM FIXED. CAN YOU PLEASE LOOK INTO THIS BECAUSE THIS SEEMS TO BE A BIG PROBLEM. *TR
Official recalls
514V171000 · Electrical System:ignition
Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
14V047000 · Air Bags; Electrical System:ignition:switch
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
08V444000 · Latches/locks/linkages:doors:latch
Sep 3, 2008
GM IS RECALLING 296,422 MY 2006-2008 CHEVROLET HHR VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT." THE DOOR ON THE STORAGE BIN IN THE TOP CENTER OF THE INSTRUMENT PANEL FAILED TO REMAIN CLOSED AS REQUIRED.
Consequence & remedy
Consequence: THIS STANDARD SPECIFIES PERFORMANCE REQUIREMENTS TO PROVIDE HEAD IMPACT PROTECTION FOR OCCUPANTS.
Remedy: A REDESIGNED LATCH WILL BE MADE AVAILABLE. THE RECALL BEGAN ON DECEMBER 23, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
08V046000 · Air Bags
Jan 30, 2008
GM IS RECALLING 181,516 MY 2006-2008 CHEVROLET HHR VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF RAIL AIR BAGS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.' IN TESTS, ONE OF THE UPPER INTERIOR OCCUPANT PROTECTION TEST POINTS EXCEEDED THE STANDARD'S REQUIREMENT.
Consequence & remedy
Consequence: THIS STANDARD SPECIFIES PERFORMANCE REQUIREMENTS TO PROVIDE HEAD IMPACT PROTECTION FOR OCCUPANTS.
Remedy: DEALERS WILL INSTALL AN ENERGY-ABSORBING PLASTIC PIECE TO THE HEADLINER TRIM. THE RECALL BEGAN ON APRIL 2, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
06V417000 · Air Bags:frontal
Oct 31, 2006
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
Consequence & remedy
Consequence: IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
Remedy: BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.