IllustrationFuel line is leaking under the car. I could smell gas when I would get out of my car.
2006 Chevrolet Hhr
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2006 Chevrolet Hhr do not stand out strongly from the model-year median of 565.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Hhr years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1050–25K
14725–50K
19650–75K
15075–100K
171100–150K
74150K+
843 reports with mileage · 163 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 458 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 222 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 119 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
47 crash reports8 fire reports24 injury reports
Fuel/propulsion System complaints
44 reportsGas line leaking under left rear tire
Rear Section of the rear fuel line started to rott out and started leaking. The sction is where there is insulation on the line, adjacent to the Left rear tire. The rest of the line is good with no corrosion or rust. When the car is running and stopped a puddle forms under the car that is gasoline. I noticed it about a week ag…
Read full complaint
Rear Section of the rear fuel line started to rott out and started leaking. The sction is where there is insulation on the line, adjacent to the Left rear tire. The rest of the line is good with no corrosion or rust. When the car is running and stopped a puddle forms under the car that is gasoline. I noticed it about a week ago , I smelled gas and thought the engine was the source, but later determined it was the fuel line as I could see the leak. It is by the rear plastic fuel line holder / support. The vehicle is always parked on a concrete driveway or paved street. Never on grass or dirt.
Fuel line rotting. Dripping gas towards rear of car. When I did my research this is very common with the Chevy cars. Like the HHR cavaliers and cobalts. Using a cheap metal then wrapping it in a heat shield that cause moisture to stay trapped causing the lines to rot.
FUEL LINE LEAK NEAR REAR TIRE. FOUND PRESSURE LINE ROTTED INSIDE OF HEAT PROTECTION WRAP.
FUEL VAPOR LINE RUSTING OUT .FROM WHAT I HEAR THIS PROBLEM IS RAMPANT AMONGST THIS MODEL AND COBALTS.
MY 2006 HHR FUEL LINE BROKE AT THE REAR WHEEL ON THE LEFT SIDE OF THE VEHICLE. THE FUEL LINE HAS A BEND AT THIS LOCATION AND THAT IS WHERE THE BREAK OCCURRED. GAS WAS SPRAYING OUT WHEN THE CAR WAS RUNNING. THIS OCCURRED IN 2019. I HAVE SINCE REPLACES THE FUEL LINES WITH NYLON FUEL LINES.
ON 11-01-2015, WHILE DRIVING THE CAR, A FUEL LINE BEGAN TO SPRAY GASOLINE. THE LEAK APPEARED TOWARD THE REAR TIRE ON THE DRIVER'S SIDE. THE LEAK WAS NOTICED BECAUSE THE FUEL CAUGHT FIRE. THE FUEL MUST HAVE BEEN SPRAYED ONTO A HOT PART. THE ON-FIRE FUEL LANDED ON THE PAVEMENT WHERE IT CONTINUED TO BURN UNTIL MANUALLY EXTINGUISHE…
Read full complaint
ON 11-01-2015, WHILE DRIVING THE CAR, A FUEL LINE BEGAN TO SPRAY GASOLINE. THE LEAK APPEARED TOWARD THE REAR TIRE ON THE DRIVER'S SIDE. THE LEAK WAS NOTICED BECAUSE THE FUEL CAUGHT FIRE. THE FUEL MUST HAVE BEEN SPRAYED ONTO A HOT PART. THE ON-FIRE FUEL LANDED ON THE PAVEMENT WHERE IT CONTINUED TO BURN UNTIL MANUALLY EXTINGUISHED WITH A FIRE EXTINGUISHER. TURNING OFF THE ENGINE STOPPED THE SPRAYING, BUT FUEL CONTINUED TO DRIP FROM THE AREA FOR SOME TIME. THE REPAIRING MECHANIC TOLD ME THAT THE LINE WAS RUSTED AND HAD A HOLE. HE SAID THAT PART OF THE LINE SITS IN A POCKET WHERE IT STAYS WET AND DIRT/SALT ACCUMULATE. HE FOUND A FUEL VAPOR LINE ALSO WAS HEAVILY RUSTED. THE LINES WERE REPLACED AT A COST OF 588.31. I'M REPORTING THIS NOW BECAUSE OF THE RECENT ANNOUNCEMENT OF AN INVESTIGATION OF SOME MODEL YEARS FOR THIS PROBLEM. MY YEAR WAS NOT ON THE LIST, BUT THE LINES RUSTED. THANK YOU FOR TAKING TIME TO READ THIS REPORT. PLEASE DO NOT HESITATE TO CONTACT ME IF YOU WOULD LIKE ADDITIONAL DETAILS OR IF I MAY CLARIFY ANY ITEM.
FUEL LINES LEADING BETWEEN THE FUEL PUMP AND ENGINE HAVE RUSTED SEVERELY AND HAVE CAUSED A PUNCTURE FUEL LINE WHICH LEAKS FUEL.
RUSTED FUEL LINES LEAK GASOLINE AND VAPORS ARE RELEASED INSIDE CAB.CAR WAS PARKED IN DRIVEWAY.CHECK ENGINE LIGHT CAME ON WAS TAKEN TO TIRES PLUS *AS*JB
Official recalls
514V171000 · Electrical System:ignition
Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
14V047000 · Air Bags; Electrical System:ignition:switch
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
08V444000 · Latches/locks/linkages:doors:latch
Sep 3, 2008
GM IS RECALLING 296,422 MY 2006-2008 CHEVROLET HHR VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT." THE DOOR ON THE STORAGE BIN IN THE TOP CENTER OF THE INSTRUMENT PANEL FAILED TO REMAIN CLOSED AS REQUIRED.
Consequence & remedy
Consequence: THIS STANDARD SPECIFIES PERFORMANCE REQUIREMENTS TO PROVIDE HEAD IMPACT PROTECTION FOR OCCUPANTS.
Remedy: A REDESIGNED LATCH WILL BE MADE AVAILABLE. THE RECALL BEGAN ON DECEMBER 23, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
08V046000 · Air Bags
Jan 30, 2008
GM IS RECALLING 181,516 MY 2006-2008 CHEVROLET HHR VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF RAIL AIR BAGS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.' IN TESTS, ONE OF THE UPPER INTERIOR OCCUPANT PROTECTION TEST POINTS EXCEEDED THE STANDARD'S REQUIREMENT.
Consequence & remedy
Consequence: THIS STANDARD SPECIFIES PERFORMANCE REQUIREMENTS TO PROVIDE HEAD IMPACT PROTECTION FOR OCCUPANTS.
Remedy: DEALERS WILL INSTALL AN ENERGY-ABSORBING PLASTIC PIECE TO THE HEADLINER TRIM. THE RECALL BEGAN ON APRIL 2, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
06V417000 · Air Bags:frontal
Oct 31, 2006
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
Consequence & remedy
Consequence: IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
Remedy: BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.