IllustrationBrake light tail light and rear blinker housing keeps melting leaving us with no working lights what so ever. Costly and dangerous
2006 Chevrolet Hhr
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2006 Chevrolet Hhr do not stand out strongly from the model-year median of 565.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Hhr years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1050–25K
14725–50K
19650–75K
15075–100K
171100–150K
74150K+
843 reports with mileage · 163 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 458 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 222 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 119 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
47 crash reports8 fire reports24 injury reports
Exterior Lighting complaints
16 reportsTL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT AFTER STARTING THE VEHICLE, THE BRAKE WARNING LIGHT ILLUMINATED CONTINUOUSLY WHILE IT WAS 27 DEGREE FAHRENHEIT. THE CONTACT MENTIONED THAT THERE WERE MULTIPLE COMPLAINTS DUE TO COLD WEATHER AND THAT THE BRAKE LIGHT MAY REMAIN ILLUMINATED. IN ADDITION, THE CONTACT…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT AFTER STARTING THE VEHICLE, THE BRAKE WARNING LIGHT ILLUMINATED CONTINUOUSLY WHILE IT WAS 27 DEGREE FAHRENHEIT. THE CONTACT MENTIONED THAT THERE WERE MULTIPLE COMPLAINTS DUE TO COLD WEATHER AND THAT THE BRAKE LIGHT MAY REMAIN ILLUMINATED. IN ADDITION, THE CONTACT NOTICED THAT THERE WAS AN UNKNOWN TECHNICAL SERVICE BULLETIN FOR THE ISSUE. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 153,000.
WHILE DRIVING DOWN THE ROAD WE HAD A HANDFUL OF TIMES WHERE THE LIGHTS WOULD FLICKER. WE WERE TOLD WE HAD TO REPLACE THE HEADLIGHT/BLINKER SWITCH AS IT WAS FAULTY DUE TO THIS VEHICLE HAVING THE "LIGHTS- AUTO ON/OFF" SWITCH LOCATED ON THIS. WE DID, IT DIDN'T FIX IT. WE WERE TOLD LOOSE HEADLIGHT BULBS. REPLACED, STILL HAPPENS. ONL…
Read full complaint
WHILE DRIVING DOWN THE ROAD WE HAD A HANDFUL OF TIMES WHERE THE LIGHTS WOULD FLICKER. WE WERE TOLD WE HAD TO REPLACE THE HEADLIGHT/BLINKER SWITCH AS IT WAS FAULTY DUE TO THIS VEHICLE HAVING THE "LIGHTS- AUTO ON/OFF" SWITCH LOCATED ON THIS. WE DID, IT DIDN'T FIX IT. WE WERE TOLD LOOSE HEADLIGHT BULBS. REPLACED, STILL HAPPENS. ONLY NOW, WE HAVE ZERO DIM LIGHTS BUT ONLY HEADLIGHTS IF WE TURN ON HIGHBEAMS (BRIGHTS). STILL, WE GET THE FLICKERING HEADLIGHTS, THIS DOESN'T EFFECT THE BLINKER LIGHTS, YELLOW RUNNING LIGHTS OR SEEM TO EFFECT THE BRAKE LIGHTS. PART OF THE AUTO LIGHTS DEAL IS WHEN IT'S DARK, IT WILL DIM THE DASH LIGHTS SO THEY AREN'T INTRUSIVE TO YOUR DRIVING, BUT IF IT'S BROAD DAYLIGHT, THEY WILL BRIGHTEN SO YOUR ABLE TO SEE THEM. I'LL START THE VEHICLE, AND THE DASH WILL BE COMPLETELY DIM, SO DIM YOU CAN BARELY SEE IT. AFTER DRIVING A GOOD LENGTH OF TIME (AT LEAST 30 MINUTES!) THEY'LL FLASH BETWEEN BRIGHT AND DIM, DAYLIGHT OR DARK THIS HAPPENS. THIS ALSO HAPPENS WHEN THE HEADLIGHTS GO COMPLETELY OUT. THEY CLAIM ALL FUSES ARE FINE AND WORDING HARNESS IS FINE BUT, OBVIOUSLY IT'S NOT. I HAVE BEEN READING SOME FORUMS IN THE CHEVYHHR.NET AND I AM NOT THE ONLY PERSON WITH THIS ISSUE. THIS HAS CAUSED SOMEONE TO NEARLY HIT ME HEAD ON AS I WAS TRYING TO MOVE OFF THE ROAD DUE TO MY HEADLIGHTS GOING OUT, AND THEY WERE ATTEMPTING TO PASS A VEHICLE, AND HAD TO MOVE TO MY LANE TO DO SO! I HAVE CHILDREN, AND AFTER SCHOOL ACTIVITIES END WHEN THE SUN IS GOING DOWN/IT'S DARK OUT SO TO TRAVEL HOME, THE SUN IS OFF THE HORIZON AND IT'S PITCH BLACK OUT. THIS ALSO SEEMS TO CAUSE MY BATTERY TO DRAIN, AND NEED A JUMP DAILY. I WAS TOLD MY BATTERY NEEDED REPLACED, DID THAT STILL NO FIX, TOLD IT WAS MY ALTERNATOR, STILL ISN'T FIXED. THAN I WAS TOLD I MUST BE LEAVING INTERNAL LIGHTS ON WHEN EXITING THE CAR. SOMETHING IS NOT RIGHT WITH THIS VEHICLE AND IT IS VERY UNSAFE!
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE TURN SIGNAL LIGHT BULBS WERE OUT AND THE EXTERIOR LENS WAS BURNED WITH A HOLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 141,131.
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. WHILE DRIVING 35 MPH, THE STEERING WHEEL BECAME DIFFICULT TO TURN INTERMITTENTLY BEFORE FAILING COMPLETELY. THE CONTACT ALSO STATED THAT THE LOW BEAM HEADLIGHTS FAILED. THE CONTACT STATED THAT THE BULBS WERE REPLACED, BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC W…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. WHILE DRIVING 35 MPH, THE STEERING WHEEL BECAME DIFFICULT TO TURN INTERMITTENTLY BEFORE FAILING COMPLETELY. THE CONTACT ALSO STATED THAT THE LOW BEAM HEADLIGHTS FAILED. THE CONTACT STATED THAT THE BULBS WERE REPLACED, BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHERE IT COULD NOT BE DIAGNOSED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 151,000.
RIGHT REAR BRAKE LIGHT LIGHT SOCKET MELTED LOCK-IN AREA TO LENS. BOTH HEADLIGHTS ARE STARTING TO BURN THROUGH LENS ON TURN SIGNAL BULB INSIDE HL.
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE VEHICLE FAILED TO SHIFT OUT OF PARK. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE BRAKE SWITCH NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 1…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE VEHICLE FAILED TO SHIFT OUT OF PARK. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE BRAKE SWITCH NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 125,000.
LOST ALL ELECTRONIC POWER AND STEERING AND SHUT OFF WOUND UP IN THE DITCH WHICH STOPPED THE CAR KEY WOULD NOT TURN TO THE OFF POSIPOSITION. *TR
TURN SIGNALS DO NOT CANCEL. DEALER FOUND BROKEN CLOCK SPRING IN DRIVERS AIR BAG. REPLACED ON WARRANTY. HELLO, ANYONE LISTENING? *TR
SITTING STILL UNDER CARPORT (CAR NOT MOVING). TURNED ON IGNITION TO CHECK GAS AMOUNT AND THE LIGHTS ON THE DASH DID NOT COME ON. I MOVED IT OUT FROM CARPORT AND THEY CAME ON. FEW HOURS LATER THE LIGHTS WOULD NOT COME ON AGAIN. THE ONLY KEYS ON KEY RING ARE 1 HOUSE KEY, 1 CAR DOOR KEY AND THE KEY FOB. THIS CAR WAS NOT MOVING WHEN…
Read full complaint
SITTING STILL UNDER CARPORT (CAR NOT MOVING). TURNED ON IGNITION TO CHECK GAS AMOUNT AND THE LIGHTS ON THE DASH DID NOT COME ON. I MOVED IT OUT FROM CARPORT AND THEY CAME ON. FEW HOURS LATER THE LIGHTS WOULD NOT COME ON AGAIN. THE ONLY KEYS ON KEY RING ARE 1 HOUSE KEY, 1 CAR DOOR KEY AND THE KEY FOB. THIS CAR WAS NOT MOVING WHEN THIS HAPPENED. *TR
Official recalls
514V171000 · Electrical System:ignition
Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
14V047000 · Air Bags; Electrical System:ignition:switch
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
08V444000 · Latches/locks/linkages:doors:latch
Sep 3, 2008
GM IS RECALLING 296,422 MY 2006-2008 CHEVROLET HHR VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT." THE DOOR ON THE STORAGE BIN IN THE TOP CENTER OF THE INSTRUMENT PANEL FAILED TO REMAIN CLOSED AS REQUIRED.
Consequence & remedy
Consequence: THIS STANDARD SPECIFIES PERFORMANCE REQUIREMENTS TO PROVIDE HEAD IMPACT PROTECTION FOR OCCUPANTS.
Remedy: A REDESIGNED LATCH WILL BE MADE AVAILABLE. THE RECALL BEGAN ON DECEMBER 23, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
08V046000 · Air Bags
Jan 30, 2008
GM IS RECALLING 181,516 MY 2006-2008 CHEVROLET HHR VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF RAIL AIR BAGS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.' IN TESTS, ONE OF THE UPPER INTERIOR OCCUPANT PROTECTION TEST POINTS EXCEEDED THE STANDARD'S REQUIREMENT.
Consequence & remedy
Consequence: THIS STANDARD SPECIFIES PERFORMANCE REQUIREMENTS TO PROVIDE HEAD IMPACT PROTECTION FOR OCCUPANTS.
Remedy: DEALERS WILL INSTALL AN ENERGY-ABSORBING PLASTIC PIECE TO THE HEADLINER TRIM. THE RECALL BEGAN ON APRIL 2, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
06V417000 · Air Bags:frontal
Oct 31, 2006
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
Consequence & remedy
Consequence: IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
Remedy: BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.