IllustrationDRIVING VEHICLE AT SPEED 45MPH, ENGINE COMPARTMENT FIRE, NEAR THE TRANSMISSION AREA. *AK
1995 Chevrolet G20
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all G20 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 9 of 82 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 33 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
12 crash reports2 fire reports7 injury reports
What owners actually said
82 reportsPOWER STEERING HAS FAILED ON TWO OCCASIONS ON VEHICLE. *AK
POWER STEERING HAS FAILED ON TWO OCCASIONS ON VEHICLE. *AK
WIHLE DRIVING ON THE ABS SYSTEM FAILED. PLEASE DESCRIBE. *AK
DRIVER'S AND PASSENGER'S SEAT BELTS ARE NOT WORKING. PLEASE DESCRIBE DETAILS. TT
BOTH FRONT TIRES WORN EXCESSIVELY SHOWING SIGNS OF RUBBING SMEERS. PLEASE DESCRIBE DETAILS. TT
FRONT AND SECOND ROW SEAT BELTS ALWAYS SEEM STUCK OR LOOSE AND BECOME TANGLED. BELTS DO NOT RETRACT PROPERLY. PLEASE DESCRIBE. TT
WHEN APPLY THE BRAKE TRUCK PULLS TO THE LEFT TOOK TO DEALER COULDN'T FIND PROBLEM . TT
REAR SEAT LAP/SHOULDER BOLTS BROKE FROM WHEEL WELL CAN NOT FASTEN SEAT BELT. TT
VEHICLES STALLS OUT INTERMITTENTLY WITH NO WARNING.CAUSING COMPLETE LOSS OF ALL CONTROLS. TT
Official recalls
399V126000 · Latches/locks/linkages:doors:latch
May 19, 1999
VEHICLE DESCRIPTION: CHEVROLET AND GMC G VANS EQUIPPED WITH SLIDING SIDE DOORS AND REMEDIED DURING SAFETY CAMPAIGN (95V197/95-C-58) BETWEEN JULY 18, 1997 AND FEBRUARY 6, 1999. THE SLIDING SIDE-DOOR REAR LATCH WAS REPLACED WITH A LATCH THAT WAS IMPROPERLY RIVETED.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE DOOR MAY NOT PERFORM AS REQUIRED AND INCREASED INJURIES COULD RESULT.
Remedy: DEALERS WILL REPLACE THE SLIDING DOOR REAR LATCH.
95V197000 · Latches/locks/linkages:doors:latch
Oct 17, 1995
THESE VEHICLES WERE BUILT WITH A SLIDING SIDE-DOOR REAR LATCH THAT WAS IMPROPERLY RIVETED. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 206, "DOOR LOCKS AND DOOR RETENTION COMPONENTS."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: IN THE EVENT OF A VEHICLE CRASH, THE DOOR WILL NOT PERFORM AS REQUIRED BY THE STANDARD.
Remedy: DEALERS WILL REPLACE THE SLIDING DOOR REAR LATCH ON ALL SUSPECT VEHICLES.
94V227000 · Equipment:other:labels
Nov 21, 1994
BOTH THE SUPPLEMENTAL INFLATABLE RESTRAINT (SIR) CAUTION LABEL AND AN ENGINE START LABEL WERE INSTALLED ON THE SAME SIDE OF THE DRIVER'S SUN VISOR. THIS DOES NOT COMPLY WITH FMVSS NO. 208, "OCCUPANT CRASH PROTECTION."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: OPERATORS COULD FAIL TO NOTICE AND HEED THE WARNING LABELS.
Remedy: A NEW LABEL, WITH INSTALLATION INSTRUCTIONS, WILL BE SENT DIRECTLY TO OWNERS. OWNERS WILL INSTALL THE LABEL OR CAN HAVE THEIR DEALER INSTALL THE LABEL FOR THEM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.