Electrical SystemEngine And Engine CoolingEquipment
WHEN DRIVING DIFFERENTIAL WOULD MAKE GRINDING NOISE. NOISE WAS LIKE IT WAS STRAINING WHEN ACCLELRATING AND/OR BRAKING. *AK CONSUMER HAD A LOSS OF POWER HAD TO REPLACE SWAY BUSHINGS, VEHICLE BEGAN TO OVER HEAT IN WHICH THERMOSTAT WAS REPLACED, CONSUMER COMPLAINED OF NOISES FROM REAR END BUT WAS ADVISED COULD NOT DUPLICATE, CONS…
Read full complaint
WHEN DRIVING DIFFERENTIAL WOULD MAKE GRINDING NOISE. NOISE WAS LIKE IT WAS STRAINING WHEN ACCLELRATING AND/OR BRAKING. *AK CONSUMER HAD A LOSS OF POWER HAD TO REPLACE SWAY BUSHINGS, VEHICLE BEGAN TO OVER HEAT IN WHICH THERMOSTAT WAS REPLACED, CONSUMER COMPLAINED OF NOISES FROM REAR END BUT WAS ADVISED COULD NOT DUPLICATE, CONSUMER ALSO COMPLAINED OF A TICKING NOISE BUT WAS ADVISED THAT WAS NORMAL, ALSO SPEAKER ON LEFT SIDE HAS STATIC UNABLE TO BE DUPLICATED, NOISE IN BRAKES WHEN BACKING UP,FRONT DOOR DOES NOT CLOSE PROPERLY MAKES A BANG NOISE,DRIVE BELT SQUEAKING, SERPENTINE BELT WAS REPLACED, WATER LEAKING INTO VEHICLE WINDSHIELD WAS FITTING POOLY REPLACED WINDSHIELD, VACUUM BRAKE BOOSTER WAS REPLACED,STEERING WHEEL VIBRATES AT 40 MPH, CIGARRETTE LIGHTER WHEN IN USE SMOKES DUE TO ASHES ON LIGHTER ELEMENT ALSO IGNITION COIL HAD TO BE RELACED DUE TO CORROSION HYDRAULIC SYSTEM WAS REPLACED .*JB
NHTSA ODI #889102
Mileage unknown · Jul 25, 1999
EquipmentService Brakes, Hydraulic
CONCERNING AIRCONDITIONING SYSTEM: THE A/C WAS INNOPERATIVE WHEN I PURCHASED THE VEHICLE AND HAD TO BE SERVICED BEFORE IT WAS RELEASED TO MY OWNERSHIP. FOR EACH AUTMN SEASON SINCE I HAVE OWNED THE VEHICLE, THE A/C HAS FAILED AFTER THE FIRST HARD FREEZE FOR OUR AREA. IT HAS BEEN MY SUSPICION THAT AN O-RING OR SEAL HAS BEEN DEF…
Read full complaint
CONCERNING AIRCONDITIONING SYSTEM: THE A/C WAS INNOPERATIVE WHEN I PURCHASED THE VEHICLE AND HAD TO BE SERVICED BEFORE IT WAS RELEASED TO MY OWNERSHIP. FOR EACH AUTMN SEASON SINCE I HAVE OWNED THE VEHICLE, THE A/C HAS FAILED AFTER THE FIRST HARD FREEZE FOR OUR AREA. IT HAS BEEN MY SUSPICION THAT AN O-RING OR SEAL HAS BEEN DEFECTIVE. THIS PAST MAY WHEN I TOOK IT IN FOR A/C SERVICE BECAUSE IT WOULD NOT COOL, I HAD TO PAY OUT-OF-POCKET FOR THE SERVICE SINCE THE VEHICLE WAS OFF WARRANTY. MY COMPLAINT IS THAT GM/CHEVROLET APPEARS TO PROVIDE DEFECTIVE SEALS/O-RINGS/VALVES FOR AFTERMARKET REPAIRS. THE DEALERSHIP REPORTED THAT "CHEVROLET AIRCONDITIONERS ALWAYS LEAK AND COOLANT REFILL IS EXPECTED". HA! MY SECOND COMPALAINT ABOUT THIS VEHICLE IS ITS BRAKING SYSTEM/SERVICE. THE DEALERSHIP TURNED THE ROTORS ON THIS VEHICLE AT 21000 MILES. I FIND THAT ODD BECAUSE I DON'T DRIVE IN STOP/GO CONDITIONS FOR THE MAJORITY OF MY TRAVELS (I LIVE IN VERY RURAL AREA). SINCE THAT SERVICING MY BRAKES HAVE PULSED UNDER NORMAL BRAKING CONDIDTIONS, YET THE DEALER ASSURES MY THAT IT IS JUST THE ABS. ??? NOT LIKELY. IF SO, IT IS ABNORMAL IN MY OPINION.
VEHICLE DESCRIPTION: CHEVROLET AND GMC G VANS EQUIPPED WITH SLIDING SIDE DOORS AND REMEDIED DURING SAFETY CAMPAIGN (95V197/95-C-58) BETWEEN JULY 18, 1997 AND FEBRUARY 6, 1999. THE SLIDING SIDE-DOOR REAR LATCH WAS REPLACED WITH A LATCH THAT WAS IMPROPERLY RIVETED.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE DOOR MAY NOT PERFORM AS REQUIRED AND INCREASED INJURIES COULD RESULT.
Remedy: DEALERS WILL REPLACE THE SLIDING DOOR REAR LATCH.
THESE VEHICLES WERE BUILT WITH A SLIDING SIDE-DOOR REAR LATCH THAT WAS IMPROPERLY RIVETED. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 206, "DOOR LOCKS AND DOOR RETENTION COMPONENTS."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: IN THE EVENT OF A VEHICLE CRASH, THE DOOR WILL NOT PERFORM AS REQUIRED BY THE STANDARD.
Remedy: DEALERS WILL REPLACE THE SLIDING DOOR REAR LATCH ON ALL SUSPECT VEHICLES.
BOTH THE SUPPLEMENTAL INFLATABLE RESTRAINT (SIR) CAUTION LABEL AND AN ENGINE START LABEL WERE INSTALLED ON THE SAME SIDE OF THE DRIVER'S SUN VISOR. THIS DOES NOT COMPLY WITH FMVSS NO. 208, "OCCUPANT CRASH PROTECTION."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: OPERATORS COULD FAIL TO NOTICE AND HEED THE WARNING LABELS.
Remedy: A NEW LABEL, WITH INSTALLATION INSTRUCTIONS, WILL BE SENT DIRECTLY TO OWNERS. OWNERS WILL INSTALL THE LABEL OR CAN HAVE THEIR DEALER INSTALL THE LABEL FOR THEM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
1995 Chevrolet G20 Problems, Complaints & Recalls | Skip That Year
Illustration