IllustrationWE HAVE ALSO HAD PROBLEMS WITH THE RIGHT SIDE AXLE AND BEARINGS. ALSO THE COIL WENT OUT, AS WELL AS THE ENGINE SMALL BLOCK - WHICH DID NOT FIX THE PROBLEM - THEY THEN HAD TO REPLACE THE ENTIRE ENGINE.
1995 Chevrolet G20
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all G20 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 9 of 82 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 33 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
12 crash reports2 fire reports7 injury reports
Electrical System complaints
6 reportsWHEN DRIVING DIFFERENTIAL WOULD MAKE GRINDING NOISE. NOISE WAS LIKE IT WAS STRAINING WHEN ACCLELRATING AND/OR BRAKING. *AK CONSUMER HAD A LOSS OF POWER HAD TO REPLACE SWAY BUSHINGS, VEHICLE BEGAN TO OVER HEAT IN WHICH THERMOSTAT WAS REPLACED, CONSUMER COMPLAINED OF NOISES FROM REAR END BUT WAS ADVISED COULD NOT DUPLICATE, CONS…
Read full complaint
WHEN DRIVING DIFFERENTIAL WOULD MAKE GRINDING NOISE. NOISE WAS LIKE IT WAS STRAINING WHEN ACCLELRATING AND/OR BRAKING. *AK CONSUMER HAD A LOSS OF POWER HAD TO REPLACE SWAY BUSHINGS, VEHICLE BEGAN TO OVER HEAT IN WHICH THERMOSTAT WAS REPLACED, CONSUMER COMPLAINED OF NOISES FROM REAR END BUT WAS ADVISED COULD NOT DUPLICATE, CONSUMER ALSO COMPLAINED OF A TICKING NOISE BUT WAS ADVISED THAT WAS NORMAL, ALSO SPEAKER ON LEFT SIDE HAS STATIC UNABLE TO BE DUPLICATED, NOISE IN BRAKES WHEN BACKING UP,FRONT DOOR DOES NOT CLOSE PROPERLY MAKES A BANG NOISE,DRIVE BELT SQUEAKING, SERPENTINE BELT WAS REPLACED, WATER LEAKING INTO VEHICLE WINDSHIELD WAS FITTING POOLY REPLACED WINDSHIELD, VACUUM BRAKE BOOSTER WAS REPLACED,STEERING WHEEL VIBRATES AT 40 MPH, CIGARRETTE LIGHTER WHEN IN USE SMOKES DUE TO ASHES ON LIGHTER ELEMENT ALSO IGNITION COIL HAD TO BE RELACED DUE TO CORROSION HYDRAULIC SYSTEM WAS REPLACED .*JB
NO SUMMARY
VEHICLE HAD TROUBLE STARTING, REPLACED BATTERY, STARTER AND ALTERNATOR WIRING TO RECTIFY PROBLEMS. MJS
BRAKE LIGHTS WERE LOST WHEN WIRING HARNESS CHAFED/SHORTED OUT DUE TO A FAULTY DESIGN. *AK
VEHICLES STALLS OUT INTERMITTENTLY WITH NO WARNING.CAUSING COMPLETE LOSS OF ALL CONTROLS. TT
Official recalls
399V126000 · Latches/locks/linkages:doors:latch
May 19, 1999
VEHICLE DESCRIPTION: CHEVROLET AND GMC G VANS EQUIPPED WITH SLIDING SIDE DOORS AND REMEDIED DURING SAFETY CAMPAIGN (95V197/95-C-58) BETWEEN JULY 18, 1997 AND FEBRUARY 6, 1999. THE SLIDING SIDE-DOOR REAR LATCH WAS REPLACED WITH A LATCH THAT WAS IMPROPERLY RIVETED.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE DOOR MAY NOT PERFORM AS REQUIRED AND INCREASED INJURIES COULD RESULT.
Remedy: DEALERS WILL REPLACE THE SLIDING DOOR REAR LATCH.
95V197000 · Latches/locks/linkages:doors:latch
Oct 17, 1995
THESE VEHICLES WERE BUILT WITH A SLIDING SIDE-DOOR REAR LATCH THAT WAS IMPROPERLY RIVETED. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 206, "DOOR LOCKS AND DOOR RETENTION COMPONENTS."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: IN THE EVENT OF A VEHICLE CRASH, THE DOOR WILL NOT PERFORM AS REQUIRED BY THE STANDARD.
Remedy: DEALERS WILL REPLACE THE SLIDING DOOR REAR LATCH ON ALL SUSPECT VEHICLES.
94V227000 · Equipment:other:labels
Nov 21, 1994
BOTH THE SUPPLEMENTAL INFLATABLE RESTRAINT (SIR) CAUTION LABEL AND AN ENGINE START LABEL WERE INSTALLED ON THE SAME SIDE OF THE DRIVER'S SUN VISOR. THIS DOES NOT COMPLY WITH FMVSS NO. 208, "OCCUPANT CRASH PROTECTION."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: OPERATORS COULD FAIL TO NOTICE AND HEED THE WARNING LABELS.
Remedy: A NEW LABEL, WITH INSTALLATION INSTRUCTIONS, WILL BE SENT DIRECTLY TO OWNERS. OWNERS WILL INSTALL THE LABEL OR CAN HAVE THEIR DEALER INSTALL THE LABEL FOR THEM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.