IllustrationDT: THE CONTACT OWNS A 2000 CHEVROLET EXPRESS. THE DRIVERS SEAT IS BROKEN. TWO DAYS AGO I REALIZED THAT THE BRACKETS THAT HOLD THE SEAT IN BROKE. THE MANUFACTURER NEEDS TO MAKE THE BRACKET BIGGER SO THAT THE SEAT DOES NOT PUSH BACK OR FORWARD. *AK
2000 Chevrolet Express
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Express years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
50–25K
625–50K
1050–75K
275–100K
2100–150K
1150K+
26 reports with mileage · 58 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 17 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Tires. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Seats. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
2 crash reports1 fire reports1 injury reports
Seats complaints
10 reportsDRIVER'S SIDE POWER SEAT CONTINUED TO FAIL. THE PART WAS REPLACED THREE TIMES. HOWEVER THE PROBLEM RECURRED. *AK
FAILURE OF DRIVER SEAT POWER ADJUSTABLE SEAT MECHANISM. TWO REAR PIVOTS ARE FAILING. THE STEEL OF THE UPPER PIVOT LINK IS FATIGUING UNTIL COMPLETE FAILURE. SEAT CAN MOVE DURING RAPID TURNING OR HARD BTEAKING. SEAT ROTATES ABOUT FRONT PIVIT POINTS. WE HAVE HAD VEHICLE ABOUT 2 1/2 YEARS AND HAVE HAD TO REPLACE THE SEAT ADJUST…
Read full complaint
FAILURE OF DRIVER SEAT POWER ADJUSTABLE SEAT MECHANISM. TWO REAR PIVOTS ARE FAILING. THE STEEL OF THE UPPER PIVOT LINK IS FATIGUING UNTIL COMPLETE FAILURE. SEAT CAN MOVE DURING RAPID TURNING OR HARD BTEAKING. SEAT ROTATES ABOUT FRONT PIVIT POINTS. WE HAVE HAD VEHICLE ABOUT 2 1/2 YEARS AND HAVE HAD TO REPLACE THE SEAT ADJUST MECHANISM TWICE.*AK
THE REAR BRACKETS ON THE DRIVER'S POWER SEAT ADJUSTER ASSEMBLY COMPLETELY BROKE. THE WHOLE SEAT NOW PIVOTS FORWARD ON THE FRONT BRACKETS. WE BROUGHT IT TO THE ATTENTION OF OUR LOCAL GM SERVICE CENTER AND WERE TOLD IT WOULD COST NEARLY $900 TO REPAIR. WE FEEL THIS IS A SAFETY ISSUE AND WOULD LIKE YOUR HELP IN IDENTIFYING THE HIST…
Read full complaint
THE REAR BRACKETS ON THE DRIVER'S POWER SEAT ADJUSTER ASSEMBLY COMPLETELY BROKE. THE WHOLE SEAT NOW PIVOTS FORWARD ON THE FRONT BRACKETS. WE BROUGHT IT TO THE ATTENTION OF OUR LOCAL GM SERVICE CENTER AND WERE TOLD IT WOULD COST NEARLY $900 TO REPAIR. WE FEEL THIS IS A SAFETY ISSUE AND WOULD LIKE YOUR HELP IN IDENTIFYING THE HISTORY OF THIS TYPE OF FAILURE. WHAT STEPS SHOULD BE TAKEN WITH THE MANUFACTURER TO HAVE THEM REPAIR THIS AT THEIR EXPENSE?*AK
WHILE DRIVING , THE DRIVER AND PASSENGER SIDE SEAT SNAPPED OFF THE BASE, ON DIFFERENT OCCASIONS. *AK THE SEAT BELTS UNLATCHED BY THEMSELVES, THE REAR BENCH SEAT FAILED TO STAY TIGHT, THE SIDE DOORS WERE DIFFICULT TO OPEN AND THE OUTSIDE MIRRORS VIBRATED AND THE BRAKES WERE FAULTY *JB *NM
1ST TIME SEAT BROKE WAS COVERED UNDER WARRANTY. 2ND WAS ON ME, MILEAGE OVER 60000. THE BRACKET THAT HOLDS THE SEAT IS LIKE 4 THIN WASHERS, 1ST TIME 2 BRAKE, DEALER REPLACED. LESS THAN 6 MONTHS LATER, THEY ALL BROKE. I HAD TO WIRE THE SEAT IN PLACE TO STOP FROM COMING COMPLETELY OFF. CAN'T USE THE 6 WAY POWER AT ALL, FOR FEAR OF …
Read full complaint
1ST TIME SEAT BROKE WAS COVERED UNDER WARRANTY. 2ND WAS ON ME, MILEAGE OVER 60000. THE BRACKET THAT HOLDS THE SEAT IS LIKE 4 THIN WASHERS, 1ST TIME 2 BRAKE, DEALER REPLACED. LESS THAN 6 MONTHS LATER, THEY ALL BROKE. I HAD TO WIRE THE SEAT IN PLACE TO STOP FROM COMING COMPLETELY OFF. CAN'T USE THE 6 WAY POWER AT ALL, FOR FEAR OF SOMETHING ELSE COMING OFF OR BRAKING. I WOULD GUESS THAT THERE OTHER FULL SIZE VANS OUT THERE THAT HAVE THE SAME PROBLEM. THE DEALER MIGHT SAY ITS ON THE CONVERSION COMPANY, BUT IT WASN'T IN MY CASE. THANK YOU. *TS *NLM **DIMSII IVOQ ENTRY POSTED AFTER 12-12-02 CUT OVER TO ARTEMIS**770174
CONSUMER STATES THAT DRIVER SEAT CAME OFF THE TRACKS CAUSING THE SEAT TO MOVE BACKWARD AND FORWARD. TS
WHILE DRIVING TRACK BOLTS BROKE FOR THE SECOND TIME. CONTACTED DEALER, AND THE DEALER CANNOT FIND A REMEDY.*AK THE POWER SEAT ANCHOR BROKE AND DETACHED FROM THE SEAT TRACK WHILE DRIVING ALMOST CAUSING LOSS OF CONTROL. *MJ
MY WIFE WAS SITTING IN THE DRIVER SEAT OF THE VAN. THE VAN WAS PARKED. HER LEG MADE CONTACT WITH THE POWER SEAT CONTROL MOVING THE SEAT FORWARD AND TRAPPING HER IN THE VEHICLE WITH HER KNEE STUCK UNDER THE DASHBOARD. THE SEAT WOULD NOT RETURN TO IT'S ORIGINAL POSITION AND THERE IS NO RELEASE MECHANISM OTHER THAN THE POWER CONTRO…
Read full complaint
MY WIFE WAS SITTING IN THE DRIVER SEAT OF THE VAN. THE VAN WAS PARKED. HER LEG MADE CONTACT WITH THE POWER SEAT CONTROL MOVING THE SEAT FORWARD AND TRAPPING HER IN THE VEHICLE WITH HER KNEE STUCK UNDER THE DASHBOARD. THE SEAT WOULD NOT RETURN TO IT'S ORIGINAL POSITION AND THERE IS NO RELEASE MECHANISM OTHER THAN THE POWER CONTROL KNOB. THE SEAT WAS INSTALLED BY MARK III CONVERSION VANS AND SOLD AS NEW BY THE D & C CHEVROLET GM DEALER. *AK
THIRD SEAT, SEAT BELT RECEIVER BROKEN AT DELIVERY, REAR SEAT WAS FOLDED DOWN IT BROKE AGAIN
Official recalls
100V085000 · Steering:hydraulic Power Assist:hose, Piping, And Connections
Mar 16, 2000
VEHICLE DESCRIPTION: PASSENGER VANS EQUIPPED WITH A BRAKE WARNING INDICATOR. SOME OF THESE VEHICLES HAVE A POWER STEERING COOLER HOSE THAT CAN SEPARATE FROM THE POWER BRAKE BOOSTER FLUID FLOW SWITCH ASSEMBLY.
Consequence & remedy
Consequence: IF THIS OCCURS, POWER STEERING FLUID COULD FLOW ONTO HOT ENGINE PARTS AND AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Remedy: DEALERS WILL INSPECT FOR THREE SCREW CLAMPS TO THE POWER STEERING HOSE JOINTS. IF THE CLAMPS ARE NOT THE SCREW TYPE, DEALERS WILL REPLACE THE CLAMPS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA04012 · Hydraulic Pump Failres
Opened Apr 30, 2004 · Closed Feb 28, 2005
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist; Steering:hydraulic Power Assist System
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
Additional source detail variants (2)
Service Brakes, Hydraulic:power Assist
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
Steering:hydraulic Power Assist System
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.