2020 Chevrolet Equinox

With the vehicle around 73,000 and while driving on the highway, the brake system failed to fully function. Using extreme pressure to compress the brakes the vehicle finally slowed and came to a stop with out injury or vehicle accident. After getting the vehicle moved to an independent service center, and further inspection it was found that the vacuum pump exploded. After researching it appears the problem is consistent with other reports but no resolution has been made until it's too late. The component is not currently being inspected by the manufacturer and has only been inspected by independent service center. No warning lights or other symptoms displayed prior to the failure and the only time it first appeared was on the highway at high speeds.

On August 3rd, while driving on the freeway at 55mph, my vehicle's brakes became extremely stiff, and I could not press them down to engage the braking system. I was about to collide with the vehicle in front of me, so I quickly veered right without looking because I had no time. After moving to the right, the brakes finally slowed the vehicle to around 40mph. Luckily, the traffic light turned green, allowing me to continue moving with the remaining momentum. As I attempted to take a turn on a bridge above the freeway, the steering wheel became stiff. At this point, I was unsure whether I could turn the car at that speed with the steering not responding. I need General Motors and Chevrolet to take action on the severity of the situation and make the necessary and appropriate restitution to me for the traumatic and physical injuries sustained during the incident. For the amount of time I've been without a vehicle, I am now running high risk of loosing my job. $3,700. is what they are charging me, which is conveniently not under warranty. When consistently stating that no one really sure what's covered and what's not covered.

I am experiencing a recurring issue with my vehicle where the Park Assist system keeps activating unexpectedly, and the Check Engine Light (CEL) also comes on. I have taken the vehicle to O’Reilly Auto Parts for a diagnostic scan, and they reported no repairable codes present. Additionally, I visited Tires Plus, and their assessment was that if the light goes off on its own, then no issue is present that requires repair. Despite the temporary disappearance of the warning lights, the issue keeps returning, which raises concern. The Park Assist activation is not being manually triggered and appears without warning, often accompanied by the CEL. This inconsistent behavior suggests there may be an intermittent or underlying issue with the vehicle’s sensors, wiring, or onboard systems that may not register a permanent diagnostic code. At this time, no repairs have been performed due to both locations stating that no actionable codes or faults were detected. However, the issue continues to happen periodically, and I would like further inspection or documentation of the problem, especially if it worsens or begins affecting vehicle safety or drivability.

I purchased this vehicle as a Certified Pre-Owned vehicle from George Moore Chevrolet in Jacksonville, Florida, in October 2023. At the time of purchase, the vehicle had approximately 35,000 miles, and it now has approximately 60,000 miles. I have maintained all recommended service intervals and oil changes as required. On June 14, 2025, while stopped at a traffic signal with my foot on the brake pedal, the pedal suddenly sank to the floor, causing the vehicle to roll forward into traffic unexpectedly. I was able to place the vehicle in neutral and then park to prevent a collision. After turning the vehicle off and restarting it when the light changed, the brakes continued to fail. I carefully maneuvered to a nearby area behind a warehouse and allowed the vehicle to come to a complete stop by shifting into neutral. I contacted a tow truck through my State Farm roadside assistance program and had the vehicle transported to my local mechanic. Upon inspection on June 16, 2025, the technician determined that the brake lines were corroded and leaking. Initially, he suspected the master brake cylinder, but it was confirmed not to be leaking. He noted that the metal-braided portion of the brake line had completely deteriorated on one side and was severely compromised on the other. Both brake lines were replaced to restore braking function. Fortunately, I was able to avoid an accident, but this was an alarming experience that I have never encountered in any vehicle I have owned. My mechanic expressed concern about the extent of corrosion on such a relatively new vehicle and indicated this could represent a broader safety issue. I respectfully request that this matter be documented and investigated to ensure that other drivers are not placed at similar risk.

•Initial incident: July 2, 2025 •Recurring occurrences: August 8, 2025 Vehicle Issue Description: Several months ago, the vehicle’s check engine light came on. A diagnostic scan was performed at O’Reilly Auto Parts, but no error codes were detected. The vehicle was taken to an independent repair shop for further inspection. The shop found no mechanical issues and confirmed the vehicle was operating normally at that time. On August 6, 2025, the “Service Brake Assist” warning appeared briefly on the dashboard but turned off shortly afterward. The parking brake warning light also came on that same day, then went off. These warning lights reappeared intermittently on August 8, 2025. No repairs have been made as there are no active recalls related to these issues. However, it is noted that there are consumer complaints reporting similar problems. This raises concerns about potential intermittent or undetected safety system faults, particularly involving the brake assist system and parking brake functionality. Checked brakes again no issues determined per Bridgestone and Mavis.

I was driving just got off the freeway and went to hit the brakes and the brake pedal was hard as a rock I had to use force to slow down to safely get over from the left lane to the right lane to get into a parking lot was a pretty scary experience, called AAA had it towed to the dealer they said the vacuum pump failed which I suspected because of the other complaints regarding the same thing, there was no recalls on my car dealer fixed it under warranty and they said there was no damage to the camshaft. The dealer was amazing and would reccamend them, I also had to pay 100 deductible. As others have stated theres a recall on the vacuum pumps but certain Vin #s are not included. Gm needs to included all Vin #s for the equinox in the recall whats it gonna take somebody to get killed!