2020 Chevrolet Equinox

Vehicle began sputtering suddenly while driving 40mph. "Reduced Engine Power" warning appeared on dash. While trying to limp it home, the vehicle died in the middle of a turning lane. Pushed vehicle to the side of the road and had it towed to a shop. Their notes attached below. Technician Notes: Customer concern verified with DTCs P0014 (Exhaust Camshaft Position System Performance) and P0017 (Exhaust Camshaft Position Not Plausible). Upon removing the exhaust cam position sensor, metal buildup was found. The vacuum pump failed, breaking the keyed driveshaft on the cam and causing the metal buildup. Recommendation: Replace the vacuum pump and exhaust camshaft with timing chains, or consider replacing the engine. Same catastrophic failure as many others have reported due to the vacuum pump seizing up. Metal shavings throughout motor now, likely ruining the whole motor.

While operating my vehicle, I experienced a sudden, catastrophic failure of the power-assisted braking system. The brake pedal completely lost hydraulic pressure, plunging effortlessly all the way to the floorboard. The vehicle failed to respond to normal foot-pedal application. Emergency stopping power was only achieved by pushing the pedal into the absolute floorboard, which engaged an emergency mechanical override and forced the Anti-lock Braking System (ABS) pump into a violent stutter/pulsation to halt the vehicle. No dashboard warning lights, diagnostic trouble codes (DTCs), or fluid level sensors illuminated prior to or during the braking failure. A certified automotive repair facility diagnosed the root cause as a total internal seizure and mechanical failure of the engine-driven brake booster vacuum pump. Because the vacuum pump is driven directly by the engine, its sudden lockup sheared and severely damaged the drive slots on the exhaust camshaft, necessitating an intensive engine teardown, camshaft replacement, and secondary component repair totaling $2,390. This design poses an extreme, life-threatening safety risk. The total loss of braking assist occurs without warning, and the mechanical failure simultaneously compromises internal engine timing components while moving at speed.

The contact owns a 2020 Chevrolet Equinox. The contact stated that the vehicle failed to start as needed. The check engine warning light was illuminated. The vehicle was towed to an independent mechanic, who replaced the fuel pump and fuel pump control module. The contact related the failure to NHTSA Campaign Number: 23V013000 (Fuel System, Gasoline); however, the VIN was not included in the recall. The manufacturer was not made aware of the failure. The failure mileage was 38,451.

While driving, my 2020 Chevrolet Equinox suddenly lost power and shut off without warning while I was pulling into traffic. The vehicle would buzz not crank afterward but would not restart. This created a safety hazard because the unexpected engine shutdown occurred while the vehicle was in motion. This is the second brake vacuum pump failure I have experienced with this vehicle. In 2022, the brake vacuum pump failed and was found shattered internally. At that time, the engine continued running, and the pump was replaced. During this most recent incident, the brake vacuum pump failed again, and the internal end of the pump broke apart. I replaced the vacuum pump and removed the broken pieces I could access, but the vehicle remains in a crank/no-start condition. The vehicle has not yet been inspected by a dealership or independent repair facility. However, after seeing the shattered pump components, a couple of mechanics I know expressed concern that the broken pieces may have affected the engine timing. That has not been confirmed. The failed pump and replacement parts are available for inspection.

I bought the 2020 equinox May the 9th 2026 the dealership concealed a lot of things going on this vehicle and I complain to them two days after purchase he told me I was stuck with it in the meanwhile as I drive the vehicle I have had repairs done but it's something going on with the acceleration it accelerates on its own sometimes and slow to pick up speed. The steering seems to get away from me at times that makes me feel like I'm going to lose control when driving. I have almost had a couple of accidents since then so what really worries me is the steering problems which I just had a little alignment done today July 15th 2026 and the accelerating from time to time went backing up or pulling off. I do feel like the safety of others can be at risk for should I say my safety is that risk at times so I am extremely cautious when I'm driving. No I have not had really anyone to look at I have been having a car looked at for many issues but that issue I am still trying to get in to see a mechanic that I'm used to dealing with but he's been backed up. No there are no lights of any such but when I purchased it the sensors in the tires and I've had that replaced and I've noticed this situation with the acceleration when I bought the vehicle and the slow speed pick up when driving.

As I was coming to a stop at light my brakes became very difficult to push the pedal down to stop. It took everything in me to get the vehicle to stop before entering the intersection and oncoming traffic. I was able to get the vehicle parked safely in a nearby parking lot but then the engine wouldn't start it just kept trying to turn over. The brake assist error popped up, and then the check engine light came on. I was able to get it started again about 20 minutes later, all the same warnings and lights. I white knuckled the drive back to my house... Once I got home the engine was smoking, smelled like it was burning, and oil was spilling out all over the place underneath, impossible to see where a leak was as it was coming from the entire engine. There was ZERO warning with the vehicle, no issues up to this point, and suddenly the equinox is now useless in my driveway unable to start with oil still leaking in multiple spots. An oil pan under the main leaking area, but there are still multiple areas of oil spilling even a week later. Oddly enough my onstar report for the month came to email a few days later reporting perfect engine health and zero issues - even thought the vehicle can't start now.

The turbocharger are bad on the 1.5 L vehicles. My current one , I had replaced already and my previous one had it too. Reduced engine power and should be recalled. I want to be reimbursed for the service and part replacement. 976.00 for the turbocharger and labor costs of 400.00. 3 1/2 hours of labor costs and the diagnostic test my nirth country GM in Hibbing. Should be recalled for all of these vehicles. 218-290-5027 Craig Johnson

The contact owns a 2020 Chevrolet Equinox. The contact stated that while driving approximately 5 MPH and approaching a stop sign, the brake pedal was depressed and there was a thumping sound coming from the brake pedal, with the message “Service Brake Assist” was displayed. The vehicle was taken to the residence and parked. The contact stated that the next day while driving approximately 63 MPH, the message "Reduced Engine Power" was displayed. The contact exited the highway, and while attempting to depress the brake pedal, the pedal was firm, and the vehicle failed to slow as intended. The contact continued to depress the brake pedal with force, and the check engine warning light was illuminated. The vehicle slowed down eventually. The vehicle was taken to an Auto Parts Store and a handheld diagnostic machine to diagnose the vehicle. The contact stated that the vehicle was turned off and failed to restart. The vehicle was restarted after three attempts. The vehicle was taken to the residence and the following day, the vehicle was towed to an independent mechanic where it was diagnosed and determined that the vacuum pump, camshaft, and timing belt needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 111,000.

December 2025 I was at a complete stop and the car clunked and the brake pedal got hard hard to push and then a couple months later a brake sensor light came on and when I plugged the code reader into it, it said give me a brake sensor code, and then it started slamming on the brakes all by itself when I went to takeoff hard like give you whiplash hard and it didn’t just do it once it did it a few times and then it wouldn’t go into reverse and then it wouldn’t go in neutral, and then it started smoking. My safety was affected by it, slamming on the brakes that could make someone hit me. It could hurt my back and neck. Yes, I have proof. Yes, I notified the dealer. Yes the vehicle has been inspected and I got an estimate by two different Car Lot the one I bought it from Ken valor motors, and Matt Mazzoni’s I have. Plus I have diagnose diagnostics printouts from OnStar and this is a 2020 vehicle. It should not be having these problems and now I’m stuck paying for a vehicle that I can’t even drive.!!