IllustrationPurchased 3 weeks ago. Third time filling up and first time in the garage. Noticed the fuel tank is leaking at the pump due to defective plastic. Car only has 55k miles, this should not be an issue. Is Chevy going to fix this or am I out the 2k repair bill?
2010 Chevrolet Corvette
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2010 Chevrolet Corvette do not stand out strongly from the model-year median of 29.
About this comparison →How this year compares
Owner complaints by model year
Compare all Corvette years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
260–25K
1725–50K
1650–75K
675–100K
1100–150K
1150K+
67 reports with mileage · 17 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel/propulsion System. Review the 44 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 14 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports0 fire reports2 injury reports
Fuel/propulsion System complaints
44 reportsThe fuel tank is leaking at the pump due to defective plastic. There should be a lot of reports of this happening on this vehicle and it is more dangerous than any other defect I have ever heard of.
Have a strong odor of gasoline coming from vehicle parked in garage. Have not noticed any gasoline in the garage floor, only the strong odor.
After filling up my gas tank in my 2010 Chevrolet Corvette I notice a strong gas smell that permeates through my entire garage and house. Upon investigation from an auto repair shop it has been determined I need to replace a faulty cracked fuel pump. Upon further investigation it seems there was a "Special Coverage Adjustment"…
Read full complaint
After filling up my gas tank in my 2010 Chevrolet Corvette I notice a strong gas smell that permeates through my entire garage and house. Upon investigation from an auto repair shop it has been determined I need to replace a faulty cracked fuel pump. Upon further investigation it seems there was a "Special Coverage Adjustment" from GM for this repair only for up to 120k miles. This should be a recall!!! as it is a very dangerous situation! So because I am over 120k , (just purchased from dealer) I am responsible for the 3k repair? That is 100% not acceptable. 15682 Primary Tank Module Flange Fuel and Vapor Leaks Copyright 2016 General Motors. Reference Number: N150682 Release Date: January 2017 GWM Number: 2015682
Upon filling the car to a full tank that is a strong gas smell that permeates the cab. This smell is persistent even while driving with the convertible top down. People driving behind me were are able to smell the gasoline vapors. The vapors and smell subside once I get below 3/4 tank of gas.
Seems to be a common issue and GM has a tsb for it but they only covered the repare for 10 years and 120k I am at 11 with 70k miles. The fuel is leaking from the top of the tank and could cause a fire.
My 2010 Chevrolett Grand Sport has developed a very strong odor of gasoline. Both when parked in garage and while driving. It’s obviously leaking gasoline somewhere which could result in a fire or death.
I NOTICED THE HEAVY SMELL OF GAS FUMES AFTER PUTTING GAS IN MY VET. THE SMELL IS MOST PROMINENT WHEN THE CAR IS OFF AND PARKED IN THE GARAGE. I AM SURE THAT THE SMELL IS ALWAYS PRESENT AND THAT BEING PARKED IN A PARKING LOT OR OUTSIDE DISSIPATES THE SMELL. I HAVE TRIED FILLING THE TANK HALF WAY TO SEE IF THAT WOULD HELP BUT…
Read full complaint
I NOTICED THE HEAVY SMELL OF GAS FUMES AFTER PUTTING GAS IN MY VET. THE SMELL IS MOST PROMINENT WHEN THE CAR IS OFF AND PARKED IN THE GARAGE. I AM SURE THAT THE SMELL IS ALWAYS PRESENT AND THAT BEING PARKED IN A PARKING LOT OR OUTSIDE DISSIPATES THE SMELL. I HAVE TRIED FILLING THE TANK HALF WAY TO SEE IF THAT WOULD HELP BUT THE SMELL OF GAS IS STILL THERE. IT IS STRONGEST IN THE REAR HATCH AREA ON THE DRIVERS SIDE. THE SMELL IN GARAGE IS SO STRONG I HAVE TO LEAVE THE GARAGE DOOR OPEN TO VENT. I AM FEARFUL THAT THE FUMES MAY IGNITE MY GAS WATER HEATER WHICH IS LOCATED ABOUT 7-8FT AWAY OR START A CAR FIRE IF GAS HITS THE HOT EXHAUST PIPE. THIS IS TRULY SOMETHING THAT CHEVY NEEDS TO REVIEW TO SEE IF FAULTY EQUIPMENT WAS PLACED IN THE C6 MODELS. I HAVE HAD THE VET FOR 4 YEARS IT IS A 2010 AND THE MILEAGE IS JUST OVER 55K. I JUST NOTICED THIS ISSUE ABOUT 3 MONTHS AGO, BUT IT SEEMS TO BE GETTING WORSE. I HOPE THAT MY PROPERTY IS NOT DAMAGED BY A FUEL SOURCE ORIGINATING FROM THE CAR OR WORSE YET, A DEATH RELATED TO AN EXPLOSION OR FIRE.
I HAVE A STRONG ODOR OF FUEL INSIDE THE CABIN OF THE VEHICLE AND ALSO OUTSIDE BY THE GAS TANK FILLER AREA. IT IS VERY PREVALENT WHEN VEHICLE IS PARKED AFTER RUNNING IT.
FUEL VAPORS COMING FROM THE FUEL TANK ;POSSIBLE CRACK IN FUEL PUMP SPRAYING FUEL EVERYWHERE;I CAN CLOSE MY GARAGE DOOR BECAUSE I CAN'T BREATHE BECAUSE OF THE GAS ODOR.IT'S WORSE WHEN I PUT TEN GALLONS OR MORE
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.