TL*THE CONTACT OWNS A 1999 CHEVROLET CORVETTE. WHILE THE VEHICLE WAS PARKED HE ATTEMPTED TO ENGAGE THE WINDSHIELD WIPERS BUT THEY WOULD NOT COME ON. UPON EXAMINING THE VEHICLE HE NOTICED THAT THERE WAS WATER IN THE WINDSHIELD WIPER MODULE. THE VEHICLE WAS NOT EXAMINED FOR THE CAUSE OF FAILURE AND IT WAS NOT REPAIRED. THE FAILUR…
Read full complaint
TL*THE CONTACT OWNS A 1999 CHEVROLET CORVETTE. WHILE THE VEHICLE WAS PARKED HE ATTEMPTED TO ENGAGE THE WINDSHIELD WIPERS BUT THEY WOULD NOT COME ON. UPON EXAMINING THE VEHICLE HE NOTICED THAT THERE WAS WATER IN THE WINDSHIELD WIPER MODULE. THE VEHICLE WAS NOT EXAMINED FOR THE CAUSE OF FAILURE AND IT WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 92,000.
NHTSA ODI #10356763
48,000 miles · Sep 10, 2005
Visibility
99 CORVETTE...GLASS TOP WHICH CAME WITH CAR HAS LARGE WHITE STRIPE FROM FRONT TO BACK ON RIGHT SIDE AND LEFT SIDE HAS PEELING IN LARGE CIRCLE...I HAVE READ ON FORUMS THIS HAS HAPPENED TO MORE THAN JUST ME! HELP!! ALSO TACHOMETER HAS QUIT WORKING. *JB
NHTSA ODI #10136067
Mileage unknown · Dec 2, 2003
Engine And Engine CoolingExterior LightingPower Train
THE STEERING WHEEL WOULD LOCK AFTER LEAVING THE VEHICLE IDLING FOR A PERIOD OF THREE TO FIVE MINUTES. WHEN PLACING THE KEY IN THE IGNITION, THE WARNING INDICATOR SUGGESTED TAKING THE KEY OUT AND TRY AGAIN IN TEN SECONDS. THE DEALER MADE SOME REPAIRS TO THE STEERING COLUMN, BUT THE PROBLEM STILL OCCURRED. *AK OTHER PROBLEMS…
Read full complaint
THE STEERING WHEEL WOULD LOCK AFTER LEAVING THE VEHICLE IDLING FOR A PERIOD OF THREE TO FIVE MINUTES. WHEN PLACING THE KEY IN THE IGNITION, THE WARNING INDICATOR SUGGESTED TAKING THE KEY OUT AND TRY AGAIN IN TEN SECONDS. THE DEALER MADE SOME REPAIRS TO THE STEERING COLUMN, BUT THE PROBLEM STILL OCCURRED. *AK OTHER PROBLEMS ARE AS FOLLOWED: THE RIGHT WINDOW LEAKED WATER WHERE THE TOP MEETS THE WINDSHIELD(BADLY), THE REAR DIFFERENTIAL AREA LEAKED FLUID WHEN SAT OVERNIGHT, THERE WAS A RATTLING NOISE UNDERNEATH THE VEHICLE DUE TO THE TRANSMISSION COOLER LINERS BEING MISADJUSTED, THERE WAS A RATTLE IN THE ENGINE WHEN ACCELERATED UP A HILL OR WHEN TAKING OFF, THE DRIVER DOOR LEAKED WHEN IT RAINED AND SCRAPES WHEN ROLLED DOWN, THERE WAS A GRINDING IN THE REAR END WHEN BACKED UP OR WHEN IT'S COLD, THE RIGHT DOOR GLASS RATTLED WHILE THE VEHICLE WAS IN MOTION, AND THE WIPERS WERE INOPERATIVE. THE CONVERTIBLE TOP WAS REPLACED. *SCC THE FOG LAMP WAS REPLACED AND THE SPOILER WAS LOOSE. *JB
NHTSA ODI #10044225
Mileage unknown · Dec 2, 2002
Visibility
WHILE VEHICLE WAS PARKED CONSUMER OPENED THE BACK LID AND IMMEDIATELY NOTICED SMOKE COMING FROM THE SEAT. UPON CLOSER INSPECTION, CONSUMER NOTICED A BURN HOLE FORMING ON THE SEAT, CONSUMER THEN PLACED A PIECE OF PAPER ADJACENT TO THE BURN HOLE AND FULLY REOPENED BACK LID, ALMOST IMMEDIATELY THE PAPER STARTED TO BURN DUE TO …
Read full complaint
WHILE VEHICLE WAS PARKED CONSUMER OPENED THE BACK LID AND IMMEDIATELY NOTICED SMOKE COMING FROM THE SEAT. UPON CLOSER INSPECTION, CONSUMER NOTICED A BURN HOLE FORMING ON THE SEAT, CONSUMER THEN PLACED A PIECE OF PAPER ADJACENT TO THE BURN HOLE AND FULLY REOPENED BACK LID, ALMOST IMMEDIATELY THE PAPER STARTED TO BURN DUE TO THE SUNLIGHT HITTING IT THROUGH THE BACK LID GLASS. THE GLASS BEHAVED SIMILAR TO A MAGNIFYING GLASS, WHICH CAUSED THE SEAT AND PAPER TO BURN. TS *JB
NHTSA ODI #8023538
Mileage unknown · Mar 1, 2000
Parking BrakeSteeringVisibility
STEERING WHEEL AND COLUMN ARE DEFECTIVE. YH REF. IN EA02-031 *CJS
NHTSA ODI #551176
Mileage unknown · Oct 6, 1999
Electrical SystemFuel System, GasolineUnknown Or Other
(1) WINDSHIELD MOUNTED REAR-VIEW MIRROR SHAKES/VIBRATES BADLY AT IDLE AND ON HIGHWAY, ESPECIALLY WITH CONVERTIBLE TOP DOWN, MAKING FOLLOWING VEHICLES APPEAR BLURRY. DEALER REPLACED MIRROR ONCE, SECOND DEALER RETIGHTENED TO WINDSHIELD, BUT PROBLEM REMAINS. (2) DRIVE BELTS MAKE GROWLING SOUND AT IDLE, A/C ON, WHEN SHIFTING BETWE…
Read full complaint
(1) WINDSHIELD MOUNTED REAR-VIEW MIRROR SHAKES/VIBRATES BADLY AT IDLE AND ON HIGHWAY, ESPECIALLY WITH CONVERTIBLE TOP DOWN, MAKING FOLLOWING VEHICLES APPEAR BLURRY. DEALER REPLACED MIRROR ONCE, SECOND DEALER RETIGHTENED TO WINDSHIELD, BUT PROBLEM REMAINS. (2) DRIVE BELTS MAKE GROWLING SOUND AT IDLE, A/C ON, WHEN SHIFTING BETWEEN PARK & REVERSE, OR BETWEEN REVERSE & DRIVE. BELT & TENSIONER REPLACED PER EXISTING SERVICE ADVISORY, BUT PROBLEM STILL OCCURS. (3) REAR MOUNTED CD CHANGER DOES NOT FUNCTION IF VEHICLE IS STARTED SOON AFTER INSERTING CD CARTRIDGE; "ERR" DISPLAYED ON RADIO. ONCE "ERR" IS DISPLAYED, MUST REMOVE AND REINSERT CD CARTRIDGE TO MAKE WORK AGAIN (RESTARTING VEHICLE OR TURNING RADIO OFF/ON DOESN'T HELP). VOLTAGE AT CD CHANGER DROPS DOWN TO ABOUT 10V WHEN STARTING VEHICLE. DEALERS CLUELESS. (4) ELECTRIC FUEL PUMP BEHIND DRIVER SEAT MAKES ANNOYING BUZZING SOUND WHEN VEHICLE STOPPED, AT IDLE, ESP. NOTICEABLE WITH WINDOWS UP. DEALER SAYS NOISE IS NORMAL AND EXISTING SERVICE ADVISORIES ONLY APPLY TO '97 & '98 VEHICLES.
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH ELECTRONIC COLUMN LOCK SYSTEMS (ECL), WHEN THE IGNITION SWITCH IS TURNED TO "LOCK," THE ECL SYSTEM PREVENTS TURNING OF THE STEERING SYSTEM. WHEN THE VEHICLE IS STARTED, THE ECL UNLOCKS THE STEERING SYSTEM. THE VEHICLE IS DESIGNED SO THAT IF THE COLUMN FAILS TO UNLOCK WHEN THE VEHICLE IS STARTED AND THE CUSTOMER TRIES TO DRIVE, THE FUEL SUPPLY WILL BE SHUT OFF SO THAT THE VEHICLE CANNOT MOVE WHEN THE VEHICLE CANNOT BE STEERED. IF VOLTAGE AT THE POWERTRAIN CONTROL MODULE IS LOW OR INTERRUPTED, HOWEVER, THE FUEL SHUT OFF MAY NOT OCCUR AND THE VEHICLE CAN BE ACCELERATED WHILE THE STEERING SYSTEM IS LOCKED. ALSO WHEN THE CONTROL SYSTEM SHOWS THAT THE ECL IS UNLOCKED AND THE VEHICLE IS BEING DRIVEN, THE LOCK PIN LOCATION CAN VARY. DEPENDING ON THE LOCATION OF THE LOCK PLATE RELATIVE TO THE SWITCH TRANSITION POINT, THERE COULD THEN BE CONTACT BETWEEN THE LOCK PLATE AND PIN CAUSING THE STEERING TO LOCK WHILE DRIVING .
Consequence & remedy
Consequence: IF THIS OCCURS, A CRASH COULD OCCUR WITHOUT WARNING.
Remedy: ON VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, THE DEALER WILL DISABLE THE STEERING COLUMN LOCK BY REMOVING THE COLUMN LOCK PLATE. WHEN THE IGNITION KEY IS REMOVED, THE TRANSMISSION SHIFTER WILL LOCK BUT THE STEERING COLUMN WILL NOT LOCK. ON VEHICLES EQUIPPED WITH A MANUAL TRANSMISSION, THE DEALER WILL REPROGRAM THE POWERTRAIN CONTROL MODULE, PERFORM A DIMENSIONAL CHECK OF THE COLUMN LOCK AND, IF NECESSARY, REPLACE THE LOCK PLATE. THE STEERING COLUMN ON THESE VEHICLES WILL CONTINUE TO LOCK WHEN THE KEY IS REMOVED. OWNER NOTIFICATION TO OWNERS OF 1997 VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS BEGAN ON APRIL 26, 2004. OWNERS OF 1998 THROUGH 2004 VEHICLES (EXCEPT 1997-1998 MANUAL TRANSMISSION VEHICLES) WILL BE NOTIFIED BEGINNING ON AUGUST 2, 2004. THE REMAINING OWNERS (1997-1998 MANUAL TRANSMISSION VEHICLES) WILL BE NOTIFIED LATER IN 2004, WHEN PARTS ARE AVAILABLE. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Additional source detail variants (3)
Steering:column
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Steering:column LOCKING:ANTI-THEFT Device
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Steering
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
PE02054 · Steering Column Lockup
Opened Jul 1, 2002 · Closed Nov 15, 2002
Status: closed (inferred from source dates) · Steering
SEE RESUME IN REPOSITORY.
EA00009 · Front Lap Belt Malfunction
Opened Mar 16, 2000 · Closed Apr 18, 2000
Status: closed (inferred from source dates) · Seat Belts
ODI OPENED THIS EA00-009 ON MARCH 16, 2000, TO CONTINUE ANALYSES BEGUN UNDER PRELIMINARY EVALUATION PE99-076.THE ALLEGED DEFECT: LAP BELT WEBBING IN BOTH SEATING POSITIONS TENDS TO FOLD OVER WHILE ENTERING THE RETRACTOR OPENING.THESE FOLDS FREQUENTLY IMPEDE PROPER WEBBING RETRACTION.IF THE RETRACTOR HAS BEEN INADVERTENTLY TOGGLED INTO AUTOMATIC LOCK RETRACTOR (ALR) MODE BY BEING EXTENDED TO ITS FULL LENGTH, IT MAY FAIL TO RESET ITSELF TO THE NORMAL EMERGENCY LOCK RETRACTOR (ELR) MODE.SUCH A CONDITION HAS BEEN SHOWN TO RENDER THE ACTIVE RESTRAINT UNUSABLE.CONCLUSION: GM WILL REMEDY THE ALLEGED DEFECT IN 71,569 SUBJECT VEHICLES BUILT PRIOR TO AUGUST 1999 BY ADDING WEBBING GUIDE INSERTS TO THE LAP RETRACTOR OPENINGS OF BOTH SEATING POSITIONS TO PREVENT THE ADMISSION OF FOLDED WEBBING ONTO THE RETRACTOR SPOOL.THIS ENGINEERING ANALYSIS HAS BEEN CLOSED.
PE99076 · Front Lap Belt Malfunction
Opened Dec 10, 1999 · Closed Mar 16, 2000
Status: closed (inferred from source dates) · Seat Belts
There is no summary currently available
PE99066 · Steering Column Lock Module
Opened Nov 8, 1999 · Closed Jul 21, 2000
Status: closed (inferred from source dates) · Steering
There is no summary currently available
1999 Chevrolet Corvette Problems, Complaints & Recalls | Skip That Year
Illustration