2016 Chevrolet Colorado

The contact owns a 2016 Chevrolet Colorado. The contact stated while driving approximately 40 MPH the "Stability Control" and "Service Power Steering" warning lights illuminated and the steering wheel seized. The contact was able to continue driving however, it was difficult to turn the steering wheel to the left or right. The contact stated that the failure recurred at various speeds. The contact regained normal power steering functionality by stopping and turning off and restarting the vehicle. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle was not diagnosed or repaired. The contact researched online and related the failure to NHTSA Campaign Number: 21V213000 (Steering); however, the VIN was not included. The manufacturer was not informed of the failure. The failure mileage was approximately 130,000.

With no warning while driving on the Interstate at highway speed, the service light came on reading "Power Steering Drive with Care"/"Stabilitrak". Safety was very at risk, since we were driving down the interstate at regular speed and getting ready to go through a mountainous section. We have taken the truck to the dealership and they were unable to duplicate the fault. they did notice low voltage codes and replaced the battery and negative battery terminal. We didn't have the truck back for 24 hours and I needed to head to town and on my way home the service light appeared again with the same reading and all of a sudden again lost power steering in he middle of traffic. I have read where recalls have been issued on 2014 and 2015 Colorado Trucks for this same issue and think this recall should be extended to the 2016 year models. Thinking this had been resolved and driving normally, it was scary having this happen again and knowing that it could happen at any time we are driving.

The contact owns a 2016 Chevrolet Colorado. The contact stated that while driving at an undisclosed speed, the steering wheel became difficult to steer. The power steering and the stabilizer warning lights were illuminated. Additionally, the contact stated that the failure progressively worsened, and the vehicle occasionally responded as needed after being restarted. The vehicle was taken to the local dealer, where the cause of the failure could not be determined. The vehicle was not diagnosed or repaired. The contact stated that the failure was related to NHTSA Campaign Number: 21V213000(Steering); however, the VIN was not included. The manufacturer was not made aware of the failure. The failure mileage was approximately 50,000.

Recently started having issues with Power Steering going out along with stability control. It will happen at different speeds and turning radius. No warning that it's about to happen. I will have to pull over turn off the truck. Most often I have to open the driver side door before the alert will reset and I gain access to power steering again. On several occasions I have to repeat this process multiple times. In one case I had to remove the negative battery cable for 30 minutes before I could once again gain access to power steering.

In the past two months, my 2016 Colorado with 79,000 miles has intermittently been losing power steering. It happens sporadically, in various speed and turning situations. It becomes very difficult to steer without the power assist. It happened while heading into a turn recently and has become more concerning. Shutting the truck off and restarting usually clears the problem (though not always). It can happen multiple times in a day and then not happen for more than a week. A diagnostic scanner showed code C0545

Power steering failure occurred while driving. This makes the truck very hard to turn. A warning message appears in the info screen “power steering assist failure” when the power steering failure happens. The only fix is to stop the truck, turn off the truck, open the drivers door, close the drivers door, and then restart the truck. The first occurrence of this failure was in July 2024. It has happened many times since: at slow and high speed, wet and dry conditions, on bumpy roads and smooth pavement. There does not seem to be a specific condition which triggers this event. Today, the power steering went out right as I was turning right. This caused me to turn very wide and forced me into the opposing lane of traffic. Thankfully, this did not cause an accident, however, the potential for an accident due to this failure is very high. A similar issue has been identified in the 2015 model year of this truck and there is an open recall for that model year but not this one. I believe the included model year list should be extended to include the 2016 model year at minimum.