IllustrationDRIVER'S SIDE SEAT BELT IS LOCATED TOO FAR BEHIND DRIVER. THIS CAUSES IT TO RUB AGAINST DRIVER'S NECK. THEN, NECK BECOMES CHAFFED. *AK
1993 Chevrolet C20
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all C20 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 0 of 16 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 6 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports0 fire reports0 injury reports
What owners actually said
16 reportsGEAR SHIFT WOULD INTERMITTENTLY STICK/LOCK UP IN PARK. DEALER/MFR'S NOTIFIED. *AK THE VEHICLE WAS FIXED ON RECALL BUT THE PROBLEM WAS NOT CORRECTED. THE DEALER INDICATED THAT THERE WOULD BE A CHARGE TO THE CONSUMER TO DO IT AGIAN. *YH
WAS TRAVELING 65MPH & HEARD A RUMBLING IN REAR. PULLED OVER & TIRES WERE STILL INFLATED. HAD EXITED THE HIGHWAY & PULLED OVER AGAIN BECAUSE OF NOISE. CHECKED THE TIRES AGAIN & THIS TIME NOTICED TREAD HAD SEPARATED FROM RIGHT REAR TIRE. THE WAS BALD. TOOK VEHICLE TO TIRE SHOP & BOUGHT ANOTHER TIRE. DO NOT HAVE TIRE. GENERAL, A…
Read full complaint
WAS TRAVELING 65MPH & HEARD A RUMBLING IN REAR. PULLED OVER & TIRES WERE STILL INFLATED. HAD EXITED THE HIGHWAY & PULLED OVER AGAIN BECAUSE OF NOISE. CHECKED THE TIRES AGAIN & THIS TIME NOTICED TREAD HAD SEPARATED FROM RIGHT REAR TIRE. THE WAS BALD. TOOK VEHICLE TO TIRE SHOP & BOUGHT ANOTHER TIRE. DO NOT HAVE TIRE. GENERAL, AMERITECH ST, P225/75R15 WITH 30,000 MILES ON IT.*AK
IN 21 MONTHS AND 35,000 MILES I HAVE HAD TO REPLACE BEARINGS 4 TIMES, SEALS 6 TIMES & AXLES 2 TIMES
WHEN VEHICLE REACHES 15 MPH AND HIGHER THE ABS LIGHT ILLUMINATES. THE DEALER HAS BEEN NOTIFIED. *AK *ML
WHEN APPLYING BRAKES THERE IS A VIBRATION IN THE PEDAL, AND BRAKES BUILD UP AND WON'T RELEASE UNTIL OWNER BLEEDS THE BRAKES. THIS HAPPENS DURING ANY BRAKING SITUATION. DEALER/MANUFACTURER HAVE BEEN NOTIFIED ABOUT THE PROBLEM. ALSO, OWNER FOUND OUT THAT THE BRAKE FLUID GOES THROUGH THE RUBBER FLEX LINE SLOWLY. THE CLAMP ARO…
Read full complaint
WHEN APPLYING BRAKES THERE IS A VIBRATION IN THE PEDAL, AND BRAKES BUILD UP AND WON'T RELEASE UNTIL OWNER BLEEDS THE BRAKES. THIS HAPPENS DURING ANY BRAKING SITUATION. DEALER/MANUFACTURER HAVE BEEN NOTIFIED ABOUT THE PROBLEM. ALSO, OWNER FOUND OUT THAT THE BRAKE FLUID GOES THROUGH THE RUBBER FLEX LINE SLOWLY. THE CLAMP AROUND THE RUBBER FLEX LINE IS VERY TIGHT WHICH CAUSES THIS PROBLEM. OWNER REPAIRED BRAKE PROBLEM HIMSELF. PLEASE PROVIDE ANY FURTHER DETAILS. *AK
HAD RECEIVED RECALL (#93V016000). HAD THE WORK DONE ON TRANSMISSION. OWNER NOT SATISFIED WITH THE RESULTS. DOES NOT FEEL REPAIRS DONE CORRECTLY. *AK
RECALL 95V246000; AFTER THE RECALL WAS PERFOMED ON THE SEAT RECLINER , THE SEAT RECLINER BROKE AND THE DEALER WILL NOT REDO THE RECALL. NOTHING WAS WRONG WITH THE SEAT RECLINER BEFORE THE RECALL WORK. *AK
REPLACED BRAKE SHOES FIVE TIMES; ALSO THE ROTORS WERE WARPED ON TWO TO THREE DIFFERENT TIMES, THE RUNNING BOARD LIGHT SHORTED OUT. *AK
DRIVERS SHOULDER/LAP BELT FAILS TO ENGAGE, ALLOWING FREE MOVEMENT EVEN W/BRAKE APPLIED. PLEASE DESCRIBE DETAILS. *AK
Official recalls
395V246000 · Seats
Dec 21, 1995
THE SEAT RECLINER TO SEAT FRAME ATTACHING BOLTS ON THESE VEHICLE COULD LOOSEN, FATIGUE AND FRACTURE, ALLOWING THE SEAT BACK TO SUDDENLY RECLINE.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR TO THE DRIVER'S SEAT, THIS COULD RESULT IN A SUDDEN LOSS OF VEHICLE CONTROL INCREASING THE RISK OF A VEHICLE ACCIDENT.
Remedy: DEALERS WILL REMOVE ALL FOAM AND/OR FABRIC SANDWICHED BETWEEN THE RECLINER ASSEMBLY AND THE SEAT FRAME, INSTALL WASHERS BETWEEN THE SEAT RECLINER AND THE SEAT FRAME AT EACH ATTACHMENT POINT, AND INSTALL NEW ATTACHING BOLTS TORQUED TO A HIGHER SPECIFICATION. THESE CORRECTIONS WILL BE MADE TO BOTH THE DRIVER'S AND PASSENGER'S SEATS.
94V044001 · Fuel System, Other:storage:tank Assembly
Apr 5, 1994
VEHICLES ALTERED BY PAS, INC. HAVE COMPRESSED NATURAL GAS FUEL TANKS THAT CAN DEVELOP STRESS CORROSION, WHICH CRACK THE E-GLASS WRAPPING. THIS STRESS CORROSION CRACKING CAN LEAD TO TANK RUPTURES.
Consequence & remedy
Consequence: IF THE TANK RUPTURES, PERSONAL INJURY TO INDIVIDUALS IN OR NEAR THE VEHICLE MAY OCCUR.
Remedy: GM IS OFFERING TO EXCHANGE THESE VEHICLES WITH A COMPARABLY EQUIPPED 1994 GASOLINE 1/2 OR 3/4 TON GM PICKUP. IF THE OWNER CHOOSES NOT TO EXCHANGE THE NATURAL GAS VEHICLE, GM WILL REPURCHASE THE VEHICLE.
93V016000 · Power Train:automatic Transmission
Feb 1, 1993
UNANTICIPATED HEAT IN THE TRANSMISSION CAN FORCE THE TRANSMISSION FLUID OUT OF THE VENT TUBE.
Consequence & remedy
Consequence: THE VENTED TRANSMISSION FLUID CAN CATCH FIRE IF EXPOSEDTO A SOURCE OF IGNITION.
Remedy: INSTALL A LONGER TRANSMISSION VENT HOSE ROUTED TO THE LEFT SIDE OF THE ENGINE COMPARTMENT OF THE VEHICLE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE95050 · Front Seat Back Collapse
Opened Sep 22, 1995 · Closed Dec 22, 1995
Status: closed (inferred from source dates) · Seats
FRONT SEAT BACK RECLINER ATTACHMENT BOLTS LOOSEN, FATIGUE, AND FRACTURE, ALLOWING THE SEAT TO COLLAPSE BACKWARDS WITHOUT WARNING.
EA94029 · Engine Compartment Fires
Opened Jul 29, 1994 · Closed Jul 31, 1996
Status: closed (inferred from source dates) · Engine And Engine Cooling
AN ALLEGED MALFUNCTION IN THE ATLERNATOR RESULTING IN ENGINE COMPARTMET FIRES.