2023 Chevrolet Bolt Euv

The steering is heavier on the car and does not return to center after turning. This causes danger while driving if someone cuts off in front of me or I have to stop suddenly due to an animal or any other conditions. I am also assuming this will be dangerous to drive in wet weather as well. I took it to the dealer to check it, and it was diagnosed as a failing steering system; the rack and pinion need to be replaced.

What component or system failed or malfunctioned, and is it available for inspection upon request? The vehicle displayed a Service ESC warning, indicating a possible malfunction in the electronic stability control system. I have had difficulty reproducing the issue, but the vehicle and any related components are available for inspection upon request. How was your safety or the safety of others put at risk? The malfunction may have reduced the vehicle’s stability and traction assistance, which could increase the risk of losing control while driving. Has the problem been reproduced or confirmed by a dealer or independent service center? I have taken the vehicle to the dealer three times. The first time, the dealer replaced the battery. The second time, the dealer installed a software update. The third time, they were unable to reproduce the issue. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? The vehicle has been inspected by the dealer. No inspection by police, insurance representatives, or other third parties has occurred. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? The Service ESC warning first appeared while driving on July 19, 2026 and May 22, 2026. I did notice the service light turn on before then, but do not have a picture to send at this time.

Rattling noise started coming from the steering wheel, it can be felt through the steering wheel. Doing an inspection it's coming from the the U joint area and steering wheel. The steering wheel also doesn't properly turn back into place when turning at lower speeds. Issue started around 40k miles. Searching the online the issue lots of people are having the same issue. Per Chevy Dealership, In need of roughly $2,850 repair parts are Steering Gear, Steering Shaft, Steering ujoin

I was driving on the highway with GM Super Cruise engaged. I was within the speed limit on a straight road with my hands near the wheel. Without warning, the steering turned sharply to the left on its own and locked — I was unable to correct it or override the system. The vehicle left the road, spun, and was totaled. I walked away with minor injuries. There were no warning lamps or messages prior to the failure. The vehicle has been inspected by police (report exists) and insurance representatives. The vehicle is currently at a dealership and is available for inspection. The problem has not been reproduced or confirmed by a dealer. I believe the Super Cruise system malfunctioned and caused the steering to lock in a direction I could not override.

Steering gear assembly malfunction. Internal rack & pinion failure is present. Rack is binding/seized. When making a turn on the vehicle, the steering wheel does not return to center, creating a highly dangerous situation where if the steering wheel is not manually returned to center it can cause a motor vehicle accident. In other words, once a turn is initiated the car will remain in a turned state unless the steering wheel is wrestled with to return to traveling in a straight line. The problem has been reproduced and confirmed by an independent service center. The vehicle has not been inspected by the manufacturer, police, insurance representative, or others outside of an independent service center. There were no warning lamps, messages, or other symptoms of the problem prior the failure. The failure appeared starting at about 25,000 miles and gradually became worse to just under 40,000 miles which is the mileage on the car now.