NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
326 reports70,000 miles · Aug 10, 2005
Exterior Lighting
A PERSON IN A VEHICLE THAT HAD BEEN BEHIND MY VEHICLE STOPPED ME AND INFORMED ME THAT I HAD NO BREAK LIGHTS. I CALLED GM MOTORS AND ASKED THEM TO FIX THE PROBLEM BECAUSE I HAD A PIECE OF PAPER STUFFED IN THE HAZARD SWITCH ON THE STEERING COLUMN SO MY BREAK LIGHTS WOULD WORK. I WAS TOLD BY GM THAT MY VEHICLE DID NOT FALL UNDER T…
Read full complaint
A PERSON IN A VEHICLE THAT HAD BEEN BEHIND MY VEHICLE STOPPED ME AND INFORMED ME THAT I HAD NO BREAK LIGHTS. I CALLED GM MOTORS AND ASKED THEM TO FIX THE PROBLEM BECAUSE I HAD A PIECE OF PAPER STUFFED IN THE HAZARD SWITCH ON THE STEERING COLUMN SO MY BREAK LIGHTS WOULD WORK. I WAS TOLD BY GM THAT MY VEHICLE DID NOT FALL UNDER THE RECALL BY THE VIN NUMBER. *NM
NHTSA ODI #10132232
56,218 miles · Jul 11, 2005
Suspension
MY 2001 CHEVY BLAZER HAD UNEVEN TIRE WEAR INDICATING THE NEED FOR A FRONT END ALIGNMENT. DURING THE INSPECTION I WAS INFORMED THAT THE LOWER BALL JOINTS HAD TO BE REPLACED AS WELL AS THE IDLER ARM AND SHOULD DO THE UPPER JOINTS AS WELL. I HAD NEVER HEARD OF A VEHICLE WITH 56,000 MILES NEEDING TO HAVE THIS DONE. OF COURSE, NOW…
Read full complaint
MY 2001 CHEVY BLAZER HAD UNEVEN TIRE WEAR INDICATING THE NEED FOR A FRONT END ALIGNMENT. DURING THE INSPECTION I WAS INFORMED THAT THE LOWER BALL JOINTS HAD TO BE REPLACED AS WELL AS THE IDLER ARM AND SHOULD DO THE UPPER JOINTS AS WELL. I HAD NEVER HEARD OF A VEHICLE WITH 56,000 MILES NEEDING TO HAVE THIS DONE. OF COURSE, NOW I HEAR OF MANY OWNERS HAVING THE SAME PROBLEM. THE UNEXPECTED $900 BILL WAS NOT PLEASANT! THE MECHANIC SAID IT WAS A COMMON PROBLEM THAT HE SAW WITH CHEVY PRODUCTS. DO I HAVE ANY CHANCE OF BEING COMPENSATED FOR THE LESS THAN QUALITY PARTS INSTALLED ON MY VEHICLE?
NHTSA ODI #10128382
63,000 miles · Jul 7, 2005
Service Brakes, Hydraulic
DT: CONSUMER STATED ABS BRAKES WERE NOT WORKING CORRECTLY. THE ABS WAS INITIALIZING AT LOW SPEED STOPS. THE PROBLEM WAS ONGOING FOR 5-6 WEEKS. THE CONSUMER'S MECHANIC INDICATED THAT THE BRAKES WERE FINE. THE CONSUMER FOUND INFORMATION ON THE INTERNET ABOUT OTHER COMPLAINTS OF THE SAME NATURE. THE ABS WOULD NOT STOP THE VEHICLE…
Read full complaint
DT: CONSUMER STATED ABS BRAKES WERE NOT WORKING CORRECTLY. THE ABS WAS INITIALIZING AT LOW SPEED STOPS. THE PROBLEM WAS ONGOING FOR 5-6 WEEKS. THE CONSUMER'S MECHANIC INDICATED THAT THE BRAKES WERE FINE. THE CONSUMER FOUND INFORMATION ON THE INTERNET ABOUT OTHER COMPLAINTS OF THE SAME NATURE. THE ABS WOULD NOT STOP THE VEHICLE AND THE PROBLEM SEEMED TO BE GETTING WORSE. *AK
NHTSA ODI #10127763
Mileage unknown · Jun 3, 2005
Parking Brake
CONCERNS WITH THE PARKING BRAKE ON THE 2001 CHEVROLET BLAZER.***NO ANSWER REQUIRED***. *MR ALTHOUGH THE PARKING BRAKE WAS ENGAGED AND THE VEHICLE WAS IN NEUTRAL THE VEHICLE WAS ABLE TO ROLL BACKWARDS. THIS IS THE SECOND TIME THIS HAS OCCURRED. THE PARKING BRAKE HAS BEEN ADJUSTED THREE TIMES. *NM
NHTSA ODI #10124731
26,660 miles · Jun 2, 2005
Wheels
I HAVE A 2001 CHEVY BLAZER, 4 DR & 4 WHEEL DRIVE. AND AFTER ONLY 28,660 MI. ALL 4 FRONT & REAR ROTORS RUSTED OUT CAUSING THE REPLACEMENT OF ALL FRONT & REAR BRAKE PADS & ROTORS TO BE REPLACED.FOR ALL 4 ROTORS TO RUST OUT AT THE SAME TIME AND AT SUCH LOW MILEAGE REQUIRES ME TO COMPLAIN. IT WAS AN ACCIDENT WAITING TO HAPPEN. I …
Read full complaint
I HAVE A 2001 CHEVY BLAZER, 4 DR & 4 WHEEL DRIVE. AND AFTER ONLY 28,660 MI. ALL 4 FRONT & REAR ROTORS RUSTED OUT CAUSING THE REPLACEMENT OF ALL FRONT & REAR BRAKE PADS & ROTORS TO BE REPLACED.FOR ALL 4 ROTORS TO RUST OUT AT THE SAME TIME AND AT SUCH LOW MILEAGE REQUIRES ME TO COMPLAIN. IT WAS AN ACCIDENT WAITING TO HAPPEN. I COMPLAINED TO THE CHEVY DIVISION WITH NO RESULTS. I WAS TOLD IT WAS NORMAL WEAR AND TEAR, WHICH I THINK IS REDICULOUS. I OWNED CHEVIES MOST OF MY LIFE AND I NEVER HAD A PROBLEM LIKE THIS. I COULD SEE ONE OR TWO ROTORS GOING BAD BUT NOT 4 AT THE SAME TIME.ESPECIALLY RUSTING OUT.
NHTSA ODI #10124029
60,000 miles · May 3, 2005
Electrical SystemFire
CALLER STATED THAT VEHICLE WAS IN PARK WITH THE IGNITION OFF, AND ABOUT FIFTEEN MINUTES AFTER CALLER PARKED THE CAR, SOMEONE NOTIFIED HIM THAT THE VEHICLE WAS ON FIRE AND BURNING HEAVILY. FIRE SEEMED TO BE CONFINED TO THE ENGINE COMPARTMENT. CALLER SPECULATED THAT THE FIRE BEGAN ON THE PASSENGER'S SIDE OF THE ENGINE COMPARTMEN…
Read full complaint
CALLER STATED THAT VEHICLE WAS IN PARK WITH THE IGNITION OFF, AND ABOUT FIFTEEN MINUTES AFTER CALLER PARKED THE CAR, SOMEONE NOTIFIED HIM THAT THE VEHICLE WAS ON FIRE AND BURNING HEAVILY. FIRE SEEMED TO BE CONFINED TO THE ENGINE COMPARTMENT. CALLER SPECULATED THAT THE FIRE BEGAN ON THE PASSENGER'S SIDE OF THE ENGINE COMPARTMENT. BY THE TIME THE FIRE DEPARTMENT SHOWED UP, THE FIRE WAS PUT OUT THROUGH THE APPLICATION OF WATER.*AK
NHTSA ODI #10119462
Mileage unknown · Apr 28, 2005
Electrical SystemEngine And Engine CoolingExterior Lighting
2001 CHEVROLET BLAZER DEVELOPING VARIOUS PROBLEMS.***NO ANSWER REQUIRED***. *MR THE DIFFERENTIAL PINION SHAFT SEAL WAS LEAKING. WHEN IT RAINED THE TRANSMISSION SLIPPED, THE CIGARETTE LIGHTER WAS INOPERATIVE, THE LIGHTER SOCKET WAS REPLACED. THE HEATER WAS NOT BLOWING HOT AIR, THE SERVICE ENGINE SOON LIGHT ILLUMINATED, THE BRAK…
Read full complaint
2001 CHEVROLET BLAZER DEVELOPING VARIOUS PROBLEMS.***NO ANSWER REQUIRED***. *MR THE DIFFERENTIAL PINION SHAFT SEAL WAS LEAKING. WHEN IT RAINED THE TRANSMISSION SLIPPED, THE CIGARETTE LIGHTER WAS INOPERATIVE, THE LIGHTER SOCKET WAS REPLACED. THE HEATER WAS NOT BLOWING HOT AIR, THE SERVICE ENGINE SOON LIGHT ILLUMINATED, THE BRAKE LIGHT WAS INOPERABLE, THE DIRECTIONAL SWITCH WAS REPLACED. THE FRONT REAR ROTORS WERE ROTTED, THE REAR WHEEL WELL MOLDING WAS COMING UNDONE, THE DRIVERS WINDOW WAS LEAKING WATER. THE VEHICLE WAS NOT SHIFTING PROPERLY, THE ALTERNATOR WAS REPLACED, THE TAIL GATE GLASS WOULD NOT LOCK, THE DRIVER DOOR DID NOT SHUT EASILY, THE BATTERY WAS REPLACED. THE HEADLIGHTS WERE INOPERABLE. THE DRIVER SEAT RECLINER WAS REPLACED, THE RETRACTOR IN THE SEAT BELT WAS RESET. THE REAR WINDOW MOLDING WAS LOOSE. THE OIL COOLER LINES WERE LEAKING.*JB
NHTSA ODI #10120392
37,813 miles · Apr 21, 2005
Parking Brake
THE PARKING BRAKE FALLS TO THE FLOOR WHEN THE DRIVER PRESSES DOWN ON IT, CAUSING THE VEHICLE TO MOVE SLIGHTLY. THE CONSUMER IS CONCERNED THAT THE VEHICLE IS NOT SECURE, AND COULD CAUSE IT TO ROLL AND CAUSE AN ACCIDENT. *AK THE PARKING BRAKES HAD TO BE ADJUSTED 3 TIMES IN 2 YEARS. THE BRAKE WOULD EVENTUALLY GO DOWN TO THE F…
Read full complaint
THE PARKING BRAKE FALLS TO THE FLOOR WHEN THE DRIVER PRESSES DOWN ON IT, CAUSING THE VEHICLE TO MOVE SLIGHTLY. THE CONSUMER IS CONCERNED THAT THE VEHICLE IS NOT SECURE, AND COULD CAUSE IT TO ROLL AND CAUSE AN ACCIDENT. *AK THE PARKING BRAKES HAD TO BE ADJUSTED 3 TIMES IN 2 YEARS. THE BRAKE WOULD EVENTUALLY GO DOWN TO THE FLOOR BOARD AGAIN. THE CONSUMER BELIEVES THERE IS EITHER A DESIGN FLAW OR THE PARTS WERE DEFECTIVE AT THE TIME OF ASSEMBLY. *BF *NM THE LAST ADJUSTMENT, THE PARKING BRAKE WAS WITHIN ONE INCH OF THE FLOOR BOARD. *SC *JB
NHTSA ODI #10115674
43,000 miles · Apr 18, 2005
Exterior Lighting
MULTI FUNCTION SWITCH EXPERIENCED THE SAME DEFECT AS STATED IN RECALL 01V364000; HOWEVER, THIS VEHICLE WA SNOT INCLUDED DUE TO VIN. *AK *BF *NM
NHTSA ODI #10044304
70,000 miles · Mar 31, 2005
Exterior Lighting
2001 CHEVROLET BLAZER REAR LEFT TAIL LIGHT DOES NOT WORK , CANGED BULBS CHANGES FUSES, BUT YET NOTHING HAPPENS, A FEW YEARS BACK I BROUGHT IT IN FOR A RECALL ON A TAIL LIGHT SWITCH THAT WAS RECALLED YET, IT SEEMS AS IF THE NEW PART MIGHT BE MALFUNCTIONING AGAIN
NHTSA ODI #10116184
Official recalls
3May 21, 2008
GENERAL MOTORS IS RECALLING 5,862 MY 2000-2002 CHEVROLET BLAZER, MY 2000-2001 GMC JIMMY, AND MY 2000 OLDSMOBILE BRAVADA SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. THE RECALL BEGAN ON JUNE 17, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR OLDSMOBILE AT 1-800-630-6537, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> . NOTE: THIS CAMPAIGN IS AN EXPANSION OF A PREVIOUS RECALL (PLEASE SEE 01V364).
Dec 3, 2001
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Exterior Lighting:brake Lights:switch
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2RQ08001 · Hazard Light Switch Failure
Opened Feb 28, 2008 · Closed Jul 9, 2008
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:hazard Flashing Warning Lights:unit
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
Exterior Lighting:hazard Flashing Warning Lights:unit
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
PE01032 · Loss Of Stop Lamp Illumination
Opened Sep 6, 2001 · Closed Dec 20, 2001
Status: closed (inferred from source dates) · Exterior Lighting
No summary supplied.
Illustration