IllustrationHAZARD LIGHT SWITCH HAD SHORTED OUT. VEHICLE HAD NO WORKING BRAKE AND TURN SIGNALS, THEY HAD TO BE REPLACED. THERE IS RECALL 01V364000 CONCERNING MULTI-FUNCTION SWITCH FAILURE, BUT THIS VEHICLE IS NOT AFFECTED.*AK
2001 Chevrolet Blazer
Owner reports · Recalls · Investigations
More warning signs than most Blazer years
Owner complaints for the 2001 Chevrolet Blazer are substantially higher than the model-year median of 32.
About this comparison →How this year compares
Owner complaints by model year
Compare all Blazer years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
150–25K
3525–50K
4550–75K
2275–100K
18100–150K
7150K+
142 reports with mileage · 184 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Exterior Lighting. Review the 68 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 40 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 40 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
35 crash reports5 fire reports19 injury reports
Exterior Lighting complaints
68 reportsTURN SIGNALS AND BRAKE LIGHTS GO OUT. TOOK VEHICLE TO DEALER WHO INDICATED HAZARD SWITCH WAS FAULTY. *AK
I PURCHASED MY VEHICLE IN 4/01 AND SEVEN MONTHS LATER I BEGAN EXPERIENCING A HOST OF PROBLEMS WITH MY VEHICLE, STARTING WITH MULTIFUNCTION SWITCH WORN, THEN HOOD HINGES WORN, EXHAUST (MUFFLER BROKEN) RIGHT SPEAKER INOPERABLE, LEFT FRONT SEAT ADJUSTER BROKEN, GRILL ASSEMBLY LOOSE, BRAKE PEDAL BROKEN AND FINALLY TRANSMISSION FAIL…
Read full complaint
I PURCHASED MY VEHICLE IN 4/01 AND SEVEN MONTHS LATER I BEGAN EXPERIENCING A HOST OF PROBLEMS WITH MY VEHICLE, STARTING WITH MULTIFUNCTION SWITCH WORN, THEN HOOD HINGES WORN, EXHAUST (MUFFLER BROKEN) RIGHT SPEAKER INOPERABLE, LEFT FRONT SEAT ADJUSTER BROKEN, GRILL ASSEMBLY LOOSE, BRAKE PEDAL BROKEN AND FINALLY TRANSMISSION FAILURE (NEEDS REPLACING). I HAVE DONE A BIT OF INQUIRING TO OTHER CHEVY BLAZER OWNERS AND FOUND OUT THAT THEY HAVE OR HAD EXPERIENCE SOME IF NOT ALL OF THE SAME PROBLEMS THAT I AM EXPERIENCING NOW. I AM HEREBY RESPECTFULLY REQUESTING YOUR ASSISTANCE IN RECTIFYING THIS COMPLAINT. I DON'T THINK THAT AFTER 11MTHS OF PURCHASING MY VEHICLE I SHOULD BE NEEDING MY TRANSMISSION REPLACE. FROM PASSED EXPERIENCED WITH REPLACING A TRANSMISSION ON MY WIFE NEW VEHICLE (MAZDA MX3) BACK IN 1992 IT HAS NEVER BEEN THE SAME. WE HAD BEEN HAVING THE SAME PROBLEMS AND MORE WITH IT. WE WERE ABLE TO ACTUALLY GET ANOTHER VEHICLE AND THE SAME PROBLEM KEEP OCCURING . AFTER THAT LONG AND TIRING EXPERIENCE WITH MY WIFE'S CAR I NOW THAT THIS WON'T BE NO DIFFERENT. I HAVE PURCHASED A LEMON AND I NEED TO KNOW WHAT RECOURSE I CAN TAKE TO INSURE THAT I WOULD NOT BE STUCK WITH A VEHICLE THAT WOULD BE COSTING ME MORE TO HAVE IT CONSTANTLY FIXED AND REPLACE. I THANK YOU FOR YOUR HELP AND ASSISTANCE IN THIS LONG AND TIRING ORDEAL. I ANXIOUSLY AWAIT HEARING FROM YOU. RESPECTFULLY YOURS. *AK
TO WHOM IT MAY CONCERN,I'M VERY UPSET AND DISSATISFIED FIRST OF ALL THE FIRST DAY I PURCHASED THE 2001 CHEVROLET BLAZER I HAD IT NOT EVEN A WEEK AND PEOPLE WHERE NOTICING THE DRIVERS SIDE MUST HAVE BEEN DAMAGED AT THE FACTORY,SO I BROUGHT IT BACK AND PHILLIPS CHEVROLET WAS SHOCKED TO SEE THIS ALSO,AND I AM LEASING THIS VEHICLE A…
Read full complaint
TO WHOM IT MAY CONCERN,I'M VERY UPSET AND DISSATISFIED FIRST OF ALL THE FIRST DAY I PURCHASED THE 2001 CHEVROLET BLAZER I HAD IT NOT EVEN A WEEK AND PEOPLE WHERE NOTICING THE DRIVERS SIDE MUST HAVE BEEN DAMAGED AT THE FACTORY,SO I BROUGHT IT BACK AND PHILLIPS CHEVROLET WAS SHOCKED TO SEE THIS ALSO,AND I AM LEASING THIS VEHICLE AND DEFINITELY WAS GOING GET BLAMED FOR SOMETHING THAT WAS DEFECTED FROM THE START.THEY WHERE GREAT THE EXCHANGED THE VEHICLE FOR ME AND THIS IS A LEMON ALSO I AM VERY UPSET AT THE FACT THAT THIS IS 4TIMES NOW THAT MY FUEL INJECTORS HAVE MESSED UP AND I HAVE TAKEN THIS VEHICLE 2 TIMES TO O'CONNER CHEVROLET WHERE THEY HAVE REPLACED ONE AND CLEANED THEM BOTH TIMES.SO THEN IT HAPPENS FOR A THIRD TIME SO I TAKE IT TO PHILLIPS WHERE I BOUGHT IT THINKING THE WILL TAKE BEETER CARE OF THERE VEHICLE,THEY CLEAH 3 INJECTORS 3 TIMES THEY SAID AND RESET THE CODES, AND TOLD ME TO USE SHELL GAS SO I DID THIS AND NOW EXACTLY A MONTH LATER MY ENGINE SERVICE LIGHT CAME ON AGAIN3/29/02.NOW IM VERY UPSET TO WHERE I DONT EVEN WANT THIS VEHICLE. ALSO THE MULTI-FUNCTION SWITCH HAS BEEN REPLACED.SO NOW YOU TELL ME SHOULD I BE HAPPY I DONT THINK SO.ICANT AFFORD TO KEEP TAKING OFF FROM MY JOB FOR THIS INCONVIENCE.WHAT A JOKE. *AK
WHILE DRIVING, BRAKES AND HAZARD LIGHTS WENT OUT WITH NO WARNING. CAUSE UNKNOWN. *AK CONSUMER FOUND THAT THE VEHICLE HAD A RECALL ON HAZARD AND BREAK LIGHTS, NHTSA CAMPAIGN ID NUMBER: 01V364000 AND 01V364000, DEALER WILL NOT HONOR THE RECALL AND CONSUMER HAD TO PAY $362.91 FOR THE REPAIR. CONSUMER IS ASKING A FULL REFUND FROM…
Read full complaint
WHILE DRIVING, BRAKES AND HAZARD LIGHTS WENT OUT WITH NO WARNING. CAUSE UNKNOWN. *AK CONSUMER FOUND THAT THE VEHICLE HAD A RECALL ON HAZARD AND BREAK LIGHTS, NHTSA CAMPAIGN ID NUMBER: 01V364000 AND 01V364000, DEALER WILL NOT HONOR THE RECALL AND CONSUMER HAD TO PAY $362.91 FOR THE REPAIR. CONSUMER IS ASKING A FULL REFUND FROM MANUFACTURER. *YD
WHILE DRIVING ABS FUNCTION POORLY. *AK VEHICLE IS EXPERIENCING MULTI-FUNCTION SWITCH ASSEMBLY PROBLEM WHICH CAUSED LOSS OF HAZARD LIGHTS, BRAKE LIGHTS, TURN SIGNAL LIGHTS AND HAZARD LIGHTS. CONSUMER IS STATING THAT THE VEHICLE HAD A RECALL, # 01V364000, WHEN HE CALLED CHEVROLET CORPORATION, THEY TOLD HIM THAT THE COST WOULD …
Read full complaint
WHILE DRIVING ABS FUNCTION POORLY. *AK VEHICLE IS EXPERIENCING MULTI-FUNCTION SWITCH ASSEMBLY PROBLEM WHICH CAUSED LOSS OF HAZARD LIGHTS, BRAKE LIGHTS, TURN SIGNAL LIGHTS AND HAZARD LIGHTS. CONSUMER IS STATING THAT THE VEHICLE HAD A RECALL, # 01V364000, WHEN HE CALLED CHEVROLET CORPORATION, THEY TOLD HIM THAT THE COST WOULD BE COVERED BUT DEALER SAID NO. CONSUMER IS LOOKING FOR REIMBURSEMENT OF $362.92. *YD
THE BRAKE AND HAZARD LIGHTS DO NOT COME ON AT ALL MAKING DRIVERS ANY PASSENGERS VERY UNSAFE AND VULNERABLE TO REAR END CRASHES ON THE ROADWAY.*AK
FAULTY MULTI-FUNCTION SWITCH PART RESULTING IN NO BRAKE LIGHTS.
BRAKE AND HAZARD LIGHT SWITCH FAILS. TWO KNOWN CASES. TECH SAYS ALL 2001'S WILL FAIL! NO RECALL???*AK
BRAKE LIGHTS WILL NOT WORK WHEN APPLYING BRAKES. BULBS AND FUSES ARE ALL OK, HAZARD FLASHER WHEN FLASHING CAUSES AN ELECTRICAL STATIC SOUND UNDER DASH AND WHEN WIGGLING THE HAZARD FLASHER SWITCH, BRAKE LIGHTS WILL WORK AND COME ON. I ALSO OWN A 1996 CHEVROLET BLAZER THAT HAD THE SAME PROBLEM AND WAS REPAIRED AT BOB HOOK CHEVROL…
Read full complaint
BRAKE LIGHTS WILL NOT WORK WHEN APPLYING BRAKES. BULBS AND FUSES ARE ALL OK, HAZARD FLASHER WHEN FLASHING CAUSES AN ELECTRICAL STATIC SOUND UNDER DASH AND WHEN WIGGLING THE HAZARD FLASHER SWITCH, BRAKE LIGHTS WILL WORK AND COME ON. I ALSO OWN A 1996 CHEVROLET BLAZER THAT HAD THE SAME PROBLEM AND WAS REPAIRED AT BOB HOOK CHEVROLET 09/07/99 INVOICE NO. 156312. VERY LITTLE CHANCE THAT I OWN TWO OF THE SAME VEHICLES FIVE YEARS APART AND SAME DEFECT HAPPENS TO BOTH. THIS IS A SERIOUS SAFETY PROBLEM THAT NEEDS TO BE RECALLED BEFORE ACCIDENTS OCCUR BECAUSE THE VEHICLE BEHIND DIDN'T SEE VEHICLE IN FRONT STOP. I AM NOT ONLY CONCERNED ABOUT MY FAMILY BEING SAFE BUT FOR THE SAFETY OF OTHERS! WHY WOULD THE DEALER SERVICE SHOP TELL ME THAT THE PART WILL HAVE TO BE ORDERED AND THERE IS A NATIONAL BACK ORDER ON THAT PART BUT TO CONTINUE TO DRIVE THE VEHICLE? I HAVE CONTACTED GM. AND FILED A COMPLAINT # C05965366 AND THEY SAID; WE WILL DO THE BEST WE CAN TO GET THE PART SHIPPED. PLEASE HELP GET THIS DEFECT RECALLED SO POTENTIAL ACCIDENTS CAN BE AVOID. *AK
Official recalls
308V231000 · Exterior Lighting:brake Lights:switch
May 21, 2008
GENERAL MOTORS IS RECALLING 5,862 MY 2000-2002 CHEVROLET BLAZER, MY 2000-2001 GMC JIMMY, AND MY 2000 OLDSMOBILE BRAVADA SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. THE RECALL BEGAN ON JUNE 17, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR OLDSMOBILE AT 1-800-630-6537, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> . NOTE: THIS CAMPAIGN IS AN EXPANSION OF A PREVIOUS RECALL (PLEASE SEE 01V364).
01V364000 · Exterior Lighting:brake Lights:switch; Exterior Lighting:hazard Flashing Warning Lights:switch
Dec 3, 2001
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Exterior Lighting:brake Lights:switch
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
00V228003 · Seat Belts
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2RQ08001 · Hazard Light Switch Failure
Opened Feb 28, 2008 · Closed Jul 9, 2008
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:hazard Flashing Warning Lights:unit
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
Exterior Lighting:hazard Flashing Warning Lights:unit
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
PE01032 · Loss Of Stop Lamp Illumination
Opened Sep 6, 2001 · Closed Dec 20, 2001
Status: closed (inferred from source dates) · Exterior Lighting
No summary supplied.