IllustrationHAD TO REPLACE CLUSTER TWO TIMES FOR THE GAUGES. NOW I AM IN FOR THE SECOND TIME IN A MONTH FOR THE 4X4....CHEVY HAS HAD MY VEHICLE MORE THEN I HAVE...... *TR
2003 Chevrolet Avalanche
Owner reports · Recalls · Investigations
More warning signs than most Avalanche years
Owner complaints for the 2003 Chevrolet Avalanche are substantially higher than the model-year median of 82.
About this comparison →How this year compares
Owner complaints by model year
Compare all Avalanche years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
280–25K
3025–50K
2850–75K
2375–100K
35100–150K
17150K+
161 reports with mileage · 43 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes. Review the 51 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 42 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 27 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
10 crash reports2 fire reports5 injury reports
Electrical System complaints
42 reportsI HAVE REPLACED THE INSTRUMENT CLUSTER 4 TIMES. 2 TIMES IN 2006 AND 2 TIMES IN 2008, BECAUSE THE NEW ONES PUT IN WERE DEFECTIVE. THE CUSTOMER SHOULD IN NO WAY HAVE TO PAY FOR THIS MANUFACTURING DEFECT. THIS WAS ON A 2003 CHEVROLET AVALANCHE. *TR
SPEEDOMOTER WILL NOT WORK, THEN STICK AND THEN NOT WORK. *TR
MY SPEEDOMETER NEEDLE STARTED GOING HAYWIRE. SOME DAYS IT WORKS AND SOME IT DOESN'T. WHEN IT ISN'T WORKING IT WILL SAY I AM DOING ANY WHERE FROM 30 TO 120 WHEN I AM NOT MOVING. THIS IS A GENUINE SAFETY HAZARD AND THERE NEEDS TO BE A RECALL DONE ASAP. I CALLED THE DEALERSHIP AND WAS TOLD THAT THEY WOULD HAVE TO DUPLICATE THE P…
Read full complaint
MY SPEEDOMETER NEEDLE STARTED GOING HAYWIRE. SOME DAYS IT WORKS AND SOME IT DOESN'T. WHEN IT ISN'T WORKING IT WILL SAY I AM DOING ANY WHERE FROM 30 TO 120 WHEN I AM NOT MOVING. THIS IS A GENUINE SAFETY HAZARD AND THERE NEEDS TO BE A RECALL DONE ASAP. I CALLED THE DEALERSHIP AND WAS TOLD THAT THEY WOULD HAVE TO DUPLICATE THE PROBLEM AND TO SEE IF THE VEHICLE QUALIFIES. I HAVE READ MANY OTHER COMPLAINTS REGARDING THE SAME PROBLEM. *TR
SPEED ODOMETER HAS NOT WORKED FOR 3 OUT OF THE 6 YEARS I HAD THE TRUCK, 2003 CHEVY AVALANCHE. *TR
MY SPEEDOMETER, OIL GAUGE,GAS GAUGE HAS STOPPED WORKING IN THE DASH APPROXIMATELY 9 MOTHS AGO AND WE HAVE CONTACTED OUR LOCAL GM RETAILER AND THEY SAID THAT THERE IS NOT A RECALL ON A MANUFACTURER DEFECT. I WAS TOLD THAT IT WAS A CLUSTER THAT WAS THE PROBLEM BY MY PERSONAL MECHANIC AND THAT IT IS VERY EXPENSIVE TO FIX. I DO NO…
Read full complaint
MY SPEEDOMETER, OIL GAUGE,GAS GAUGE HAS STOPPED WORKING IN THE DASH APPROXIMATELY 9 MOTHS AGO AND WE HAVE CONTACTED OUR LOCAL GM RETAILER AND THEY SAID THAT THERE IS NOT A RECALL ON A MANUFACTURER DEFECT. I WAS TOLD THAT IT WAS A CLUSTER THAT WAS THE PROBLEM BY MY PERSONAL MECHANIC AND THAT IT IS VERY EXPENSIVE TO FIX. I DO NOT THINK THAT I SHOULD HAVE TO FIX THIS PROBLEM SINCE IT IS A MANUFACTURER DEFECT. I HAVE SEVERAL FRIEND THAT HAVE A CHEVROLET WITH THE SAME PROBLEM. I PAID ALOT OF MONEY FOR THIS VEHICLE AND I THINK THAT GM SHOULD FIX THE PROBLEM THAT WE DID NOT KNOW WE WERE PURCHASING IN THE FIRST PLACE. *TR
SPEEDOMETER STOPPED WORKING CORRECTLY ON MY 2003 CHEVY AVALANCHE. RECEIVED A LETTER FROM GM SAYING THEY WOULD REPLACE THE CLUSTER ON VEHICLES UNDER 75,000 MILES. MY VEHICLE HAD 90,000. THIS ISSUE IS BEING EXPERIENCED BY A LARGE AMOUNT OF OWNERS AND IS A SAFETY HAZARD. *TR
SPEEDOMETER FAILURE- READ ANYWHERE FROM 20 -80 MPH WHILE AT REST THEN WOULD MOVE BACK DOWN TO 0 AFTER STARTING THE CAR SEVERAL TIMES (DROPPING 5-10 MPH PER START) NOW IT IS PEGGED AT OVER 120 MPH AND WILL NOT MOVE. *TR
GENERAL MOTORS MAILED ME A NOTICE ADVISING THAT MY VEHICLE (2003 AVALANCHE WHICH I PURCHASED NEW IN OCT 2003) "COULD DEVELOP A CONDITION WHERE ONE OR MORE OF THE INSTRUMENT PANEL GAUGE NEEDLES MAY STICK, FLUTTER, OR BECOME INOPERATIVE." IT WAS ADDITIONALLY NOTED THAT "THIS CONDITION MAY CAUSE INACCURATE READINGS, INCLUDING SPEED…
Read full complaint
GENERAL MOTORS MAILED ME A NOTICE ADVISING THAT MY VEHICLE (2003 AVALANCHE WHICH I PURCHASED NEW IN OCT 2003) "COULD DEVELOP A CONDITION WHERE ONE OR MORE OF THE INSTRUMENT PANEL GAUGE NEEDLES MAY STICK, FLUTTER, OR BECOME INOPERATIVE." IT WAS ADDITIONALLY NOTED THAT "THIS CONDITION MAY CAUSE INACCURATE READINGS, INCLUDING SPEEDOMETER AND THE FUEL GAUGE." REMEDY OF REPLACEMENT WAS OFFERED FOR VEHICLES WITHIN 7 YEARS OF ORIGINAL DATE PLACED IN SERVICE OR 70,000 MILES, WHICHEVER OCCURS FIRST. MY VEHICLE EXHIBITS THIS PROBLEM IN SPEEDOMETER. MY VEHICLE HAS OVER 80,000 MILES AND IS NOT INCLUDED IN THE REPAIR OFFER. THE CONDITION IN MINE IS EXHIBITED WHEN TEMPERATURES ARE BELOW 45-50 DEGREES (TYPICALLY IN WINTER), AND BEGAN LAST WINTER. I ASSOCIATED IT WITH THE WEATHER AND DIDN'T THINK TOO MUCH ABOUT IT. HOWEVER, NOW THAT I KNOW IT IS A DEFECT, I BELIEVE GM SHOULD BE EXPECTED TO CORRECT THIS DEFECT IN ALL AFFECTED VEHICLES. I BELIEVE IT CAN BE CONSIDERED A SAFETY ISSUE - NO SPEEDOMETER - NO FUEL GAUGE READING, ESPECIALLY WHEN THEY ARE WORKING PROPERLY SOMETIMES AND AT OTHERS NOT AT ALL OR INACCURATELY. *TR
IT JUST BEGAN ABOUT A MONTH AGO. THE SPEEDOMETER WAS REGISTERING THE WRONG SPEED AND NOW IT DOES NOT MOVE AT ALL. HUGE SAFETY ISSUE! I AM AN MP AND HOW CAN I EXPECT OTHERS TO FOLLOW THE LAWS WHEN I CAN NOT EVEN TELL HOW FAST I AM GOING? *TR
Official recalls
405V163000 · Seat Belts:rear/other
Apr 22, 2005
ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.
Consequence & remedy
Consequence: A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.
Remedy: DEALERS WILL CUT OPEN THE GUIDE LOOP, REMOVE A PORTION OF THE LOOP, AND THEN THE REMAINING TWO SIDES SHOULD BE FOLDED OVER AND SECURED WITH A RETAINER FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR HUMMER AT 1-800-732-5493.
04V129000 · Structure:body:tailgate:hinge And Attachments
Mar 17, 2004
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE GALVANIZED STEEL TAILGATE SUPPORT CABLES THAT RETAIN THE TAILGATE IN THE FULL OPEN (HORIZONTAL) POSITION MAY CORRODE, WEAKEN, AND EVENTUALLY FRACTURE. IF BOTH CABLES FRACTURED, THE TAILGATE WOULD SUDDENLY DROP AND STRIKE THE TOP SURFACE OF THE REAR BUMPER.
Consequence & remedy
Consequence: ANYONE SITTING OR STANDING ON THE HORIZONTAL SURFACE OF THE TAILGATE WHEN BOTH CABLES FRACTURED COULD BE INJURED BY FALLING FROM THE TAILGATE. ON VEHICLES THAT HAVE HAD THE BUMPER REMOVED, THE TAILGATE MAY DROP EVEN LOWER. ADDITIONALLY, IF THERE IS CARGO ON THE TAILGATE THE CARGO MAY FALL OFF IF THE SUPPORT CABLES FRACTURE.
Remedy: DEALERS WILL REPLACE THE CABLES. INTERIM OWNER NOTIFICATION BEGAN ON APRIL 7, 20004. THE RECALL BEGAN ON SEPTEMBER 24, 2004, WHEN REPLACEMENT PARTS WERE AVAILABLE, AND WILL CONTINUE THROUGH OCTOBER 29, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463, OR VISIT WWW.MYGMLINK.COM, AND ENTER YOUR VEHICLE IDENTIFICATION NUMBER.
04V045000 · Service Brakes, Hydraulic
Feb 4, 2004
CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, ?PASSENGER CAR BRAKE SYSTEMS.? SOME OF THESE VEHICLES WERE PRODUCED WITH AN OUT-OF-SPECIFICATION BRAKE HYDRO-BOOST HOUSING RELIEF VALVE BORE.
Consequence & remedy
Consequence: CONSEQUENTLY, THE VALVE O-RING SEAL MAY FRACTURE. STEERING EFFORTS MAY BE SLIGHTLY INCREASED WHILE BRAKING OR PARKING. UNDER CERTAIN DRIVING CONDITIONS, A FRACTURED SEAL MAY REQUIRE A SLIGHT INCREASE IN THE APPLIED BRAKE PEDAL EFFORT TO ACHIEVE THE SAME VEHICLE DECELERATION RATE AS PRIOR TO THE SEAT FRACTURE.
Remedy: DEALERS ARE TO REPLACE THE HYDRO-BOOST RELIEF VALVE. THE RECALL BEGAN ON JUNE 18, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339; CHEVROLET AT 1-800-630-2438; GMC AT 1-866-996-9463; OR HUMMER AT 1-866-486-6376.
03V019000 · Fuel System, Gasoline:storage:tank Assembly
Jan 27, 2003
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, VEHICLES, DURING A 30 DEGREE LEFT ANGLE FRONTAL IMPACT OF SUFFICIENT SEVERITY, A TEAR COULD DEVELOP IN THE MID-FRAME CROSS MEMBER AT ITS ATTACHMENT TO THE LEFT FRAME RAIL. IF THE MID-FRAME CROSS MEMBER TEARS DURING FRONTAL IMPACT AND PRODUCES A SHARP EDGE, CONTACT OF THE SHARP EDGE WITH THE FUEL TANK COULD RESULT IN A PUNCTURE OF THE FUEL TANK AND POSSIBLE FUEL LEAKAGE.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A FUEL TANK SHIELD. OWNER NOTIFICATION BEGAN FEBRUARY 20, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4PE10010 · Brake Line Corrosion Failure
Opened Mar 30, 2010 · Closed Jan 5, 2011
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:power Assist:hydraulic:hoses, Lines/piping, And Fittings
The Office of Defects Investigation (ODI) received Defect Petition DP10-003 on March 2, 2010, requesting the investigation of model year (MY) 2003 Chevrolet Silverado 2500HD 4WD pickup trucks for corrosion failures of the vehicle brake lines.DP10-003 was granted and on March 30, 2010, Preliminary Evaluation PE10-010 was opened on more than six million model year 1999 through 2003 light trucks and sport utility vehicles manufactured and sold by General Motors Corporation (GM).On July 2, 2010, ODI received GM's response to an information request, which included GM's assessment of the frequency and safety consequences of the alleged defect. GM stated that:(1) the brake system of the subject vehicles is split front/rear and should a brake pipe suddenly fail for any reason, the affected vehicle would be capable of stopping with the pressure supplied by the remaining circuit; (2) the subject vehicles were designed to meet the hydraulic circuit partial failure requirements of Federal Motor Vehicle Safety Standards 105 and 135, Light Vehicle Brake Systems; and (3) should a brake fluid leak occur for any reason, the brake system malfunction indicator lamp (MIL) would illuminate and warn the driver before the brake fluid level was low enough to cause a loss of line pressure.ODI's and GM's analysis indicates that 85 percent of the complaints occurred on vehicles used primarily in States that use salt on the roads during Winter months (Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin).Overall the complaint rates per 100,000 vehicles for Salt Belt States is 43.0 and Non-Salt Belt is 3.0.In approximately 25 percent of the complaints the brake pipe failure occurred suddenly, with no warning (i.e., no MIL, Brake Fluid Loss Warning), and resulted in extended stopping distances.In 30 of these the increase in stopping distance that resulted was a factor in the crash and in 10 others the vehicle was intentionally steered off the road or into another lane of travel in order to avoid a crash.This investigation has been upgraded to an Engineering Analysis (EA11-001) for subject vehicles sold or currently registered in Salt Belt States to further assess the scope, frequency and safety risks associated with sudden failures of corroded brake pipes that can result in decreased brake effectiveness. ODI will continue to gather information on subject vehicles outside the Salt Belt as well.
Additional source detail variants (2)
Service Brakes, Hydraulic
The Office of Defects Investigation (ODI) received Defect Petition DP10-003 on March 2, 2010, requesting the investigation of model year (MY) 2003 Chevrolet Silverado 2500HD 4WD pickup trucks for corrosion failures of the vehicle brake lines.DP10-003 was granted and on March 30, 2010, Preliminary Evaluation PE10-010 was opened on more than six million model year 1999 through 2003 light trucks and sport utility vehicles manufactured and sold by General Motors Corporation (GM).On July 2, 2010, ODI received GM's response to an information request, which included GM's assessment of the frequency and safety consequences of the alleged defect. GM stated that:(1) the brake system of the subject vehicles is split front/rear and should a brake pipe suddenly fail for any reason, the affected vehicle would be capable of stopping with the pressure supplied by the remaining circuit; (2) the subject vehicles were designed to meet the hydraulic circuit partial failure requirements of Federal Motor Vehicle Safety Standards 105 and 135, Light Vehicle Brake Systems; and (3) should a brake fluid leak occur for any reason, the brake system malfunction indicator lamp (MIL) would illuminate and warn the driver before the brake fluid level was low enough to cause a loss of line pressure.ODI's and GM's analysis indicates that 85 percent of the complaints occurred on vehicles used primarily in States that use salt on the roads during Winter months (Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin).Overall the complaint rates per 100,000 vehicles for Salt Belt States is 43.0 and Non-Salt Belt is 3.0.In approximately 25 percent of the complaints the brake pipe failure occurred suddenly, with no warning (i.e., no MIL, Brake Fluid Loss Warning), and resulted in extended stopping distances.In 30 of these the increase in stopping distance that resulted was a factor in the crash and in 10 others the vehicle was intentionally steered off the road or into another lane of travel in order to avoid a crash.This investigation has been upgraded to an Engineering Analysis (EA11-001) for subject vehicles sold or currently registered in Salt Belt States to further assess the scope, frequency and safety risks associated with sudden failures of corroded brake pipes that can result in decreased brake effectiveness. ODI will continue to gather information on subject vehicles outside the Salt Belt as well.
Service Brakes, Hydraulic:power Assist:hydraulic:hoses, Lines/piping, And Fittings
The Office of Defects Investigation (ODI) received Defect Petition DP10-003 on March 2, 2010, requesting the investigation of model year (MY) 2003 Chevrolet Silverado 2500HD 4WD pickup trucks for corrosion failures of the vehicle brake lines.DP10-003 was granted and on March 30, 2010, Preliminary Evaluation PE10-010 was opened on more than six million model year 1999 through 2003 light trucks and sport utility vehicles manufactured and sold by General Motors Corporation (GM).On July 2, 2010, ODI received GM's response to an information request, which included GM's assessment of the frequency and safety consequences of the alleged defect. GM stated that:(1) the brake system of the subject vehicles is split front/rear and should a brake pipe suddenly fail for any reason, the affected vehicle would be capable of stopping with the pressure supplied by the remaining circuit; (2) the subject vehicles were designed to meet the hydraulic circuit partial failure requirements of Federal Motor Vehicle Safety Standards 105 and 135, Light Vehicle Brake Systems; and (3) should a brake fluid leak occur for any reason, the brake system malfunction indicator lamp (MIL) would illuminate and warn the driver before the brake fluid level was low enough to cause a loss of line pressure.ODI's and GM's analysis indicates that 85 percent of the complaints occurred on vehicles used primarily in States that use salt on the roads during Winter months (Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin).Overall the complaint rates per 100,000 vehicles for Salt Belt States is 43.0 and Non-Salt Belt is 3.0.In approximately 25 percent of the complaints the brake pipe failure occurred suddenly, with no warning (i.e., no MIL, Brake Fluid Loss Warning), and resulted in extended stopping distances.In 30 of these the increase in stopping distance that resulted was a factor in the crash and in 10 others the vehicle was intentionally steered off the road or into another lane of travel in order to avoid a crash.This investigation has been upgraded to an Engineering Analysis (EA11-001) for subject vehicles sold or currently registered in Salt Belt States to further assess the scope, frequency and safety risks associated with sudden failures of corroded brake pipes that can result in decreased brake effectiveness. ODI will continue to gather information on subject vehicles outside the Salt Belt as well.
DP05009 · Parking Brake Failure
Opened Dec 20, 2005 · Closed May 31, 2006
Status: closed (inferred from source dates) · Parking Brake; Parking Brake:conventional; Parking Brake:conventional:mechanical
ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.
Additional source detail variants (3)
Parking Brake:conventional
ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.
Parking Brake:conventional:mechanical
ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.
Parking Brake
ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.
EA04012 · Hydraulic Pump Failres
Opened Apr 30, 2004 · Closed Feb 28, 2005
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist; Steering:hydraulic Power Assist System
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
Additional source detail variants (2)
Service Brakes, Hydraulic:power Assist
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
Steering:hydraulic Power Assist System
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
EA04005 · Tailgate Cable Breakage
Opened Feb 19, 2004 · Closed Sep 28, 2004
Status: closed (inferred from source dates) · Latches/locks/linkages:tailgate:latch; Structure:body:tailgate ; Structure:body:tailgate:hinge And Attachments
GENERAL MOTORS FILED A DEFECT NOTICE 04V-129 ON MARCH 17, 2004, WHICH OUTLINES A PROGRAM TO REPLACE THE TAILGATE CABLES INSTALLED IN AFFECTED MODEL YEAR 2000-2004 VEHICLES.REFER TO ODI'S CLOSING REPORT FOR EA04-005 FOR ADDITIONAL INFORMATION.ODI IS AWARE OF REPORTS OF TAILGATE CABLE BREAKAGE OCCURRING IN MODEL YEAR 1999 AND EARLIER VEHICLES.THESE VEHICLES WERE EQUIPPED WITH SIMILAR TAILGATE CABLES AS ADDRESSED BY 04V-129, BUT ARE NOT BEING ADDRESSED BY CAMPAIGN O4V-129.ODI IS INITIATING A SEPARATE INVESTIGATION TO ADDRESS THESE VEHICLES.THE COMPLAINT-INJURY-FATALITY STATISTICS SUMMARIZED ABOVE PERTAIN TO MODEL YEAR 2000-2004 VEHICLES. THE COMPLAINT-INJURY STATISTICS FOR MODEL YEAR 1999 AND EARLIER VEHICLES ARE SUMMARIZED ON THE OPENING RESUME FOR THAT INVESTIGATION.
Additional source detail variants (6)
Latches/locks/linkages:tailgate:latch
GENERAL MOTORS FILED A DEFECT NOTICE 04V-129 ON MARCH 17, 2004, WHICH OUTLINES A PROGRAM TO REPLACE THE TAILGATE CABLES INSTALLED IN AFFECTED MODEL YEAR 2000-2004 VEHICLES.REFER TO ODI'S CLOSING REPORT FOR EA04-005 FOR ADDITIONAL INFORMATION.ODI IS AWARE OF REPORTS OF TAILGATE CABLE BREAKAGE OCCURRING IN MODEL YEAR 1999 AND EARLIER VEHICLES.THESE VEHICLES WERE EQUIPPED WITH SIMILAR TAILGATE CABLES AS ADDRESSED BY 04V-129, BUT ARE NOT BEING ADDRESSED BY CAMPAIGN O4V-129.ODI IS INITIATING A SEPARATE INVESTIGATION TO ADDRESS THESE VEHICLES.THE COMPLAINT-INJURY-FATALITY STATISTICS SUMMARIZED ABOVE PERTAIN TO MODEL YEAR 2000-2004 VEHICLES. THE COMPLAINT-INJURY STATISTICS FOR MODEL YEAR 1999 AND EARLIER VEHICLES ARE SUMMARIZED ON THE OPENING RESUME FOR THAT INVESTIGATION.
Latches/locks/linkages:tailgate:latch
GENERAL MOTORS FILED A DEFECT NOTICE 04V-129 ON MARCH 17, 2004, WHICH OUTLINES A PROGRAM TO REPLACE THE TAILGATE CABLES INSTALLED IN AFFECTED MODEL YEAR 2000-2004 VEHICLES.REFER TO ODI'S CLOSING REPORT FOR EA04-005 FOR ADDITIONAL INFORMATION.ODI IS AWARE OF REPORTS OF TAILGATE CABLE BREAKAGE OCCURRING IN MODEL YEAR 1999 AND EARLIER VEHICLES.THESE VEHICLES WERE EQUIPPED WITH SIMILAR TAILGATE CABLES AS ADDRESSED BY 04V-129, BUT ARE NOT BEING ADDRESSED BY CAMPAIGN O4V-129.ODI IS INITIATING A SEPARATE INVESTIGATION TO ADDRESS THESE VEHICLES.THE COMPLAINT-INJURY-FATALITY STATISTICS SUMMARIZED ABOVE PERTAIN TO MODEL YEAR 2000-2004 VEHICLES. THE COMPLAINT-INJURY STATISTICS FOR MODEL YEAR 1999 AND EARLIER VEHICLES ARE SUMMARIZED ON THE OPENING RESUME FOR THAT INVESTIGATION.
Structure:body:tailgate
GENERAL MOTORS FILED A DEFECT NOTICE 04V-129 ON MARCH 17, 2004, WHICH OUTLINES A PROGRAM TO REPLACE THE TAILGATE CABLES INSTALLED IN AFFECTED MODEL YEAR 2000-2004 VEHICLES.REFER TO ODI'S CLOSING REPORT FOR EA04-005 FOR ADDITIONAL INFORMATION.ODI IS AWARE OF REPORTS OF TAILGATE CABLE BREAKAGE OCCURRING IN MODEL YEAR 1999 AND EARLIER VEHICLES.THESE VEHICLES WERE EQUIPPED WITH SIMILAR TAILGATE CABLES AS ADDRESSED BY 04V-129, BUT ARE NOT BEING ADDRESSED BY CAMPAIGN O4V-129.ODI IS INITIATING A SEPARATE INVESTIGATION TO ADDRESS THESE VEHICLES.THE COMPLAINT-INJURY-FATALITY STATISTICS SUMMARIZED ABOVE PERTAIN TO MODEL YEAR 2000-2004 VEHICLES. THE COMPLAINT-INJURY STATISTICS FOR MODEL YEAR 1999 AND EARLIER VEHICLES ARE SUMMARIZED ON THE OPENING RESUME FOR THAT INVESTIGATION.
Structure:body:tailgate
GENERAL MOTORS FILED A DEFECT NOTICE 04V-129 ON MARCH 17, 2004, WHICH OUTLINES A PROGRAM TO REPLACE THE TAILGATE CABLES INSTALLED IN AFFECTED MODEL YEAR 2000-2004 VEHICLES.REFER TO ODI'S CLOSING REPORT FOR EA04-005 FOR ADDITIONAL INFORMATION.ODI IS AWARE OF REPORTS OF TAILGATE CABLE BREAKAGE OCCURRING IN MODEL YEAR 1999 AND EARLIER VEHICLES.THESE VEHICLES WERE EQUIPPED WITH SIMILAR TAILGATE CABLES AS ADDRESSED BY 04V-129, BUT ARE NOT BEING ADDRESSED BY CAMPAIGN O4V-129.ODI IS INITIATING A SEPARATE INVESTIGATION TO ADDRESS THESE VEHICLES.THE COMPLAINT-INJURY-FATALITY STATISTICS SUMMARIZED ABOVE PERTAIN TO MODEL YEAR 2000-2004 VEHICLES. THE COMPLAINT-INJURY STATISTICS FOR MODEL YEAR 1999 AND EARLIER VEHICLES ARE SUMMARIZED ON THE OPENING RESUME FOR THAT INVESTIGATION.
Structure:body:tailgate:hinge And Attachments
GENERAL MOTORS FILED A DEFECT NOTICE 04V-129 ON MARCH 17, 2004, WHICH OUTLINES A PROGRAM TO REPLACE THE TAILGATE CABLES INSTALLED IN AFFECTED MODEL YEAR 2000-2004 VEHICLES.REFER TO ODI'S CLOSING REPORT FOR EA04-005 FOR ADDITIONAL INFORMATION.ODI IS AWARE OF REPORTS OF TAILGATE CABLE BREAKAGE OCCURRING IN MODEL YEAR 1999 AND EARLIER VEHICLES.THESE VEHICLES WERE EQUIPPED WITH SIMILAR TAILGATE CABLES AS ADDRESSED BY 04V-129, BUT ARE NOT BEING ADDRESSED BY CAMPAIGN O4V-129.ODI IS INITIATING A SEPARATE INVESTIGATION TO ADDRESS THESE VEHICLES.THE COMPLAINT-INJURY-FATALITY STATISTICS SUMMARIZED ABOVE PERTAIN TO MODEL YEAR 2000-2004 VEHICLES. THE COMPLAINT-INJURY STATISTICS FOR MODEL YEAR 1999 AND EARLIER VEHICLES ARE SUMMARIZED ON THE OPENING RESUME FOR THAT INVESTIGATION.
Structure:body:tailgate:hinge And Attachments
GENERAL MOTORS FILED A DEFECT NOTICE 04V-129 ON MARCH 17, 2004, WHICH OUTLINES A PROGRAM TO REPLACE THE TAILGATE CABLES INSTALLED IN AFFECTED MODEL YEAR 2000-2004 VEHICLES.REFER TO ODI'S CLOSING REPORT FOR EA04-005 FOR ADDITIONAL INFORMATION.ODI IS AWARE OF REPORTS OF TAILGATE CABLE BREAKAGE OCCURRING IN MODEL YEAR 1999 AND EARLIER VEHICLES.THESE VEHICLES WERE EQUIPPED WITH SIMILAR TAILGATE CABLES AS ADDRESSED BY 04V-129, BUT ARE NOT BEING ADDRESSED BY CAMPAIGN O4V-129.ODI IS INITIATING A SEPARATE INVESTIGATION TO ADDRESS THESE VEHICLES.THE COMPLAINT-INJURY-FATALITY STATISTICS SUMMARIZED ABOVE PERTAIN TO MODEL YEAR 2000-2004 VEHICLES. THE COMPLAINT-INJURY STATISTICS FOR MODEL YEAR 1999 AND EARLIER VEHICLES ARE SUMMARIZED ON THE OPENING RESUME FOR THAT INVESTIGATION.