IllustrationHAVE REPEATED PROBLEMS WITH NOISES THAT DEALERSHIP CAN NOT LOCATE. HAVE TAKEN THE VEHICLE ON SEVERAL OCCASIONS AND HAVE BEEN WITHOUT VEHICLE FOR OVER 30 SPORATIC DAYS. *AK
1999 Chevrolet Astro
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1999 Chevrolet Astro do not stand out strongly from the model-year median of 69.
About this comparison →How this year compares
Owner complaints by model year
Compare all Astro years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 32 of 133 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 21 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 21 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 19 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
18 crash reports2 fire reports15 injury reports
What owners actually said
133 reportsBRAKE PEDAL WAS TOO CLOSE TO ACCELERATOR PEDAL. THE BRAKE PEDAL WAS BENT TO THE RIGHT, AND THE DRIVER'S FOOT BECAME LODGED UNDER THE BRAKE PEDAL, PREVENTING HER FROM STOPPING THE VEHICLE, RESULTING IN AN ACCIDENT. *AK *ML
WHEN APPLYING THE ABS BRAKES ON WET PAVEMENT FRONT BRAKES LOCK UP, CAUSING EXTENDED STOPPING DISTANCE. CAUSE UNKNOWN. PLEASE GIVE ANY FURTHER DETAILS. *AK
HAS FAILED TO START ON SEVERAL OCCASIONS, NOTICED STRONG BURNING ODOR FROM UNDER HOOD THIS MOST RECENT TIME ELECTRICAL COMPONENTS UNDER HOOD WERE VIBRATING AND SMOKING. PROCEDING THAT ALL ELECTRCIALL COMPONENTS OF VEHICLE HAVE FAILED INCLUDING INTERIOR LIGHTS, HORN HAZARD LIGHTS, ALARM SYSTEM. TRANSMISSION SLIPS AND SLAMS INT…
Read full complaint
HAS FAILED TO START ON SEVERAL OCCASIONS, NOTICED STRONG BURNING ODOR FROM UNDER HOOD THIS MOST RECENT TIME ELECTRICAL COMPONENTS UNDER HOOD WERE VIBRATING AND SMOKING. PROCEDING THAT ALL ELECTRCIALL COMPONENTS OF VEHICLE HAVE FAILED INCLUDING INTERIOR LIGHTS, HORN HAZARD LIGHTS, ALARM SYSTEM. TRANSMISSION SLIPS AND SLAMS INTO GEAR VIOLENTLY AT HIGHER SPEEDS USUALLY ON FREEWAY. DEALERSHIP SAYS NO PROBLEM PICKED UP BY ON BOARD COMPUTERS. *AK
-VEHICLE STALLS @ LOW SPEEDS IN BOTH DIRECTIONS & DEALER IS UNABLE TO DIAGNOSE OR REPAIR THE ISSUE. - REAR DIFFERENTIAL HAS BEEN SERVICED MULTIPLE TIMES. *AK
NO SUMMARY
ABS FAILED. YH
THE WHEEL BEARINGS ON THE FRONT WHEELS ARE SPILLING QUITE A BIT OF GREASE ON THE RIMS. THE DEALER WAS CONTACTED ABOUT THIS PROBLEM. THE DEALER WAS NOT ABLE TO DO ANYTHING ABOUT THE PROBLEM. PLEASE PROVIDE ANY FURTHER INFORMATION. *AK
CARPET IS NOT STUCK TO THE FLOOR .CARPET SLIPS AND SLIDES. *AK
DEFECTS LISTED AS AWD AND TRANSFER CASE MAY BE SAME PROBLEM AND WERE EXPERIENCED FROM THE FIRST 300 MILES AND ON (UPON SLOWING DOWN OR ACCELERATING A "CLUNK" WAS HEARD AND FELT FROM THE FRONT END ALSO WHEN CORNERING THE VEHICLE "LURCHED/WHEELS GRABBED" LIKE IT WAS STUCK IN 4WD. IN JULY IMMEDIATLY AFTER IT HAD BEEN INTO THE DEAL…
Read full complaint
DEFECTS LISTED AS AWD AND TRANSFER CASE MAY BE SAME PROBLEM AND WERE EXPERIENCED FROM THE FIRST 300 MILES AND ON (UPON SLOWING DOWN OR ACCELERATING A "CLUNK" WAS HEARD AND FELT FROM THE FRONT END ALSO WHEN CORNERING THE VEHICLE "LURCHED/WHEELS GRABBED" LIKE IT WAS STUCK IN 4WD. IN JULY IMMEDIATLY AFTER IT HAD BEEN INTO THE DEALER TO BE SERVICED AGAIN THE BRAKES CAUSED THE VAN TO PULL LEFT AT 35-50 MPH AND WHEN SLOWED FOR CORNERS WOULD SOUND LIKE "LOOSE PARTS RUBBING TOGETHER". IN AUGUST OF 1999 (JUST BEFORE THE REPLACEMENT TRANSFER CASE CAME IN) VAN HIT LOOSE GRAVEL TRAVELING AT 45-50 MPH, PULLED ONTO SOFT SHOULDER, FORWARD ABOUT 12 FT, CAUGHT TRACTION AND CAME UP ON ROAD, FRONT LEFT WHEEL WAS OFF GROUND WHEN IT CAME DOWN THE TIRE POPPED OFF THE BEAD, WHEEL GROUND INTO PAVEMENT, FLIPPING VAN ON FRONT, LEFT SIDE/CORNER, THEN ONTO HOOD AND WINDSHIELD, THEN ONTO FULL RIGHT SIDE THEN UPRIGHT CROSSWAYS IN LANE IT HAD BEEN TRAVELING IN. THE VAN WAS TOTALED.
Official recalls
101V123000 · Seat Belts:front:warning Light/devices
Apr 10, 2001
VEHICLE DESCRIPTION: MINI VANS. SOME OF THESE VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION." THE "FASTEN SAFETY-BELT" AUDIBLE WARNING OCCASIONALLY MAY NOT COME ON OR MAY TERMINATE IN LESS THAN FOUR SECONDS AS REQUIRED BY THE STANDARD.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: DEALERS WILL INSTALL A NEW ALARM MODULE. OWNER NOTIFICATION BEGAN JUNE 27, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.