IllustrationWHILE BACKING INTO A PARKING SPACE THE RIGHT FRONT LOWER CONTROL ARM SNAPPED OFF DROPPING THE FRONT END TO THE GROUND. *TR
1999 Chevrolet Astro
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1999 Chevrolet Astro do not stand out strongly from the model-year median of 69.
About this comparison →How this year compares
Owner complaints by model year
Compare all Astro years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 32 of 133 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 21 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 21 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 19 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
18 crash reports2 fire reports15 injury reports
Suspension complaints
6 reportsCOMMENTS: WHY DID EVERYONE MISS THE 1999 CHEVY ASTRO VAN WITH AWD? I ALREADY HAD THE FRONT WHEEL BEARINGS REPLACED (AT MY COST) EARLIER THIS YEAR FOR THE SAME PROBLEM!!! PARTS ARE NO LONGER AVAILABLE, BUT LOCAL FIRESTONE GARAGE PERFORMED THE MAINTENANCE, AND HAS THE RECORDS OF THE SERVICE. NEAR-MISS TOO MANY TIMES AT LOW SPE…
Read full complaint
COMMENTS: WHY DID EVERYONE MISS THE 1999 CHEVY ASTRO VAN WITH AWD? I ALREADY HAD THE FRONT WHEEL BEARINGS REPLACED (AT MY COST) EARLIER THIS YEAR FOR THE SAME PROBLEM!!! PARTS ARE NO LONGER AVAILABLE, BUT LOCAL FIRESTONE GARAGE PERFORMED THE MAINTENANCE, AND HAS THE RECORDS OF THE SERVICE. NEAR-MISS TOO MANY TIMES AT LOW SPEED STOPPING PROBLEMS. SOME ONE NEEDS TO INCLUDE THE CHEVY & GMC MINI-VANS!!! *JB
THIS IS AN INTERMITTENT FAILURE WHICH WAS REPAIRED ONCE AT MANUFACTURER'S EXPENSE AND IS NOW OCCURRING INTERMITTENTLY AGAIN BUT WITH MORE FREQUENCY. I AM BEING TOLD BY CHEVROLET THAT IT IS MY PROBLEM NOW AND I MAINTAIN THAT THIS IS AN INHERENT PROBLEM WITH THE VEHICLE AND THEY ARE RESPONSIBLE FOR HELPING ME REPAIR THIS MAJOR PRO…
Read full complaint
THIS IS AN INTERMITTENT FAILURE WHICH WAS REPAIRED ONCE AT MANUFACTURER'S EXPENSE AND IS NOW OCCURRING INTERMITTENTLY AGAIN BUT WITH MORE FREQUENCY. I AM BEING TOLD BY CHEVROLET THAT IT IS MY PROBLEM NOW AND I MAINTAIN THAT THIS IS AN INHERENT PROBLEM WITH THE VEHICLE AND THEY ARE RESPONSIBLE FOR HELPING ME REPAIR THIS MAJOR PROBLEM WITH THE SUSPENSION OF THIS AWD VEHICLE.*AK
BRAKES HAVE BEEN SEVERLY WORN OUT*AK CONSUMER STATED THE SEATBELTS, ARM RESTS, CONSOLE THE TRIM ON THE SEAT CUSHION HAS TORN, THERE IS WIND NOISE FROM HIGH TOP ROOF, WINDOW IS LOOSE, RADIO IS INOPERATIVE, POWER STEERING FLUID LEAKING, STEERING COOLUMN IS MAKING A NOISE, WEATHERSTRIP COMING OFF OF BACK DOOR, TIRES SHAKE, THERE I…
Read full complaint
BRAKES HAVE BEEN SEVERLY WORN OUT*AK CONSUMER STATED THE SEATBELTS, ARM RESTS, CONSOLE THE TRIM ON THE SEAT CUSHION HAS TORN, THERE IS WIND NOISE FROM HIGH TOP ROOF, WINDOW IS LOOSE, RADIO IS INOPERATIVE, POWER STEERING FLUID LEAKING, STEERING COOLUMN IS MAKING A NOISE, WEATHERSTRIP COMING OFF OF BACK DOOR, TIRES SHAKE, THERE IS A HARD THUMP WHE GOING OVER BUMPS, CIGARETTE LIGHTER IS INOPERATIVE,TRANSMISSION SHIFTS HARD, PRESSURE GUAGE GETS STUCK, WINDOW GETS STUCK, THERE ARE NO LOW BEAM LIGHTS, WINDSHIELD WIPERS ARE INOPERATIVE, DOOR LOCK DO NOT COME ALL THE WAY UP, THE FRONT END OF VEHICLE DIPS, AND THE SHOCKS FEEL WEAK, THE LIFGATE DOES NOT STAY OPEN, INTERIOR LIGHTS STAY ON TO LONG, VEHICLE REMOTE IS INOPERATIVE, SLIDING DOOR IS HARD TO OPEN AT TIMES, OIL PRESSURE GUAGE READS HIGH, REFRIGERATOR NOT OPERATING FROM REAR SOCKET, HEATING SYSTEM IS INOPERATIVE, BATTERY GOES DEAD.*SLC
HAVE REPEATED PROBLEMS WITH NOISES THAT DEALERSHIP CAN NOT LOCATE. HAVE TAKEN THE VEHICLE ON SEVERAL OCCASIONS AND HAVE BEEN WITHOUT VEHICLE FOR OVER 30 SPORATIC DAYS. *AK
VEHICLE EXPERIENCING VIBRATION IN THE FRONT END AT SPEEDS RANGING FROM 60 TO 75 MPH. HOWEVER, VEHICLE WAS TAKEN TO DEALER ON (3) DIFFERENT OCCASIONS, DEALER COULD NOT FIND PROBLEM. *YC
Official recalls
101V123000 · Seat Belts:front:warning Light/devices
Apr 10, 2001
VEHICLE DESCRIPTION: MINI VANS. SOME OF THESE VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION." THE "FASTEN SAFETY-BELT" AUDIBLE WARNING OCCASIONALLY MAY NOT COME ON OR MAY TERMINATE IN LESS THAN FOUR SECONDS AS REQUIRED BY THE STANDARD.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: DEALERS WILL INSTALL A NEW ALARM MODULE. OWNER NOTIFICATION BEGAN JUNE 27, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.