IllustrationUPPER AND LOWER CONTROL ARMS FAILED CAUSING FRONT END OF VEHICLE TO COLLAPSE. NLM
1996 Chevrolet Astro
Owner reports · Recalls · Investigations
More warning signs than most Astro years
Owner complaints for the 1996 Chevrolet Astro are substantially higher than the model-year median of 69.
About this comparison →How this year compares
Owner complaints by model year
Compare all Astro years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 22 of 263 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Suspension. Review the 60 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 60 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 33 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
17 crash reports1 fire reports7 injury reports
What owners actually said
263 reportsWIPER WOULD NOT TURN ON BECAUSE OF WIPER CONTROL MODULE FAILURE. YH
FUEL PUMP FAILURE DRIVING DOWN THE FREEWAY AT 60 MPH. THIS COULD BE DANGEROUS IN HEAVY TRAFFIC. MAJOR EXPENSE FOR THE MILEAGE ON THE VEHICLE. *AK
CONTROL ARM BROKE, CAUSING THE FRONT END TO DROP WHICH MAY CAUSE A LOSS OF VEHICLE CONTROL. ALSO, IDLER ARM BROKE 5 TIMES. DEALER COULD NOT DETERMINE THE CAUSE OF THE PROBLEM. *AK *ML
INTERMITTENTLY WINDSHIELD WIPERS BECOME INOPERABLE, OBSTRUCTING THE VIEW OF THE DRIVER. A RECALL HAS BEEN ISSUED ON VARIOUS MAKES AND MODELS. HOWEVER, THIS VEHICLE WAS NOT INCLUDED DUE TO VIN. MAMUFACTURER HAS BEEN NOTIFIED. *AK
ERRATIC OPERATION OF THE WINDSHIELD WIPER MOTOR. SOMETIMES WINDSHIELD WIPERS COME ON, AND SOMETIMES THEY DON'T. THEY WILL WORK ON HIGH SPEED FOR A LITTLE WHILE. THE DEALER HAS BEEN CONTACTED. *AK
WINDSHIELD WIPER WILL WORK INTERMITTENTLY, CAUSING POOR VISIBILITY . DEALER REPLACED CIRCUIT AND MODULES . *AK
WINDSHIELD WIPERS WOULD NOT WORK PROPERLY WHEN IN USE. WOULD WORK INTERMITTENTLY ON DIFFERENT MODE SETTINGS. SOMETIMES STOPPED ON THEIR OWN & THEN RESTARED ON THEIR OWN. THIS CAUSED THE DRIVER TO HAVE POOR VISIBILITY DURING RAIN. *AK
WINDSHIELD WIPERS WORK INTERMITTENTLY DURING RAIN STORMS, THEY WILL JUST SHUT DOWN IN THE MIDDLE OF OPERATION. DEALER HAS BEEN CONTACTED. *AK
ON 05/09/1999 ACCELEATOR CABLE BROKE, TOWED MONTY CHEV IN VICTORVILLE. 05/11/1999 FIXED. COST $154.16 TOW $105.00. 05/24/1999 LOST POWER ON FREEWAY TOWED BACK TO SAME DEALER AND FUEL PUMP AND FUEL FILTER REPLACED $336.48 TOW $12 0.00. NEXT DAY CAR STALLED DEALER TOWED BACK TO SHOP KEEP IT TWO DAYS AND SAID THEY COULDN'T FIND …
Read full complaint
ON 05/09/1999 ACCELEATOR CABLE BROKE, TOWED MONTY CHEV IN VICTORVILLE. 05/11/1999 FIXED. COST $154.16 TOW $105.00. 05/24/1999 LOST POWER ON FREEWAY TOWED BACK TO SAME DEALER AND FUEL PUMP AND FUEL FILTER REPLACED $336.48 TOW $12 0.00. NEXT DAY CAR STALLED DEALER TOWED BACK TO SHOP KEEP IT TWO DAYS AND SAID THEY COULDN'T FIND ANY THING WRONG. CAR HAS NOT RAN THAT WELL SINCE THEY WORKED ON IT, JUST RENT A CAR IF I NEEDED TO GO FAR. 9/16/1999 HAD TO HAVE ALL FUEL INJECTORS REPLACED AND TUNE-UP DONE ON IT $978.39 RAN GOOD FOR ABOUT ONE WEEK THEN CHECK ENGINE LIGHT INDICATED THE AIR INTAKE SENCOR WAS BAD REPLACED, CAME ON AGAIN. WAS SENT TO CAR CLINIC FOR DIAGNOSTIC ON SYSTEM 10/11/1999 FOUND CAT, CONVERTER IS COMPLETELY PLUGGED $80.00. HAVING REPLACED TODAY 10/11/1999 $150.00. APRIL OF THIS YEAR THE AIR CONDITIONING THAT RUNS TO THE REAR AIR HAD A LEAK IN THE LINE THAT RUNS BACK THERE CAUSED BY THE INSULATION RUBBING ON THE LINE. HAD THE REPAIRED AND FILLED BACK UP. $220.00
Official recalls
403V159000 · Visibility:windshield Wiper/washer
Apr 28, 2003
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
01V123000 · Seat Belts:front:warning Light/devices
Apr 10, 2001
VEHICLE DESCRIPTION: MINI VANS. SOME OF THESE VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION." THE "FASTEN SAFETY-BELT" AUDIBLE WARNING OCCASIONALLY MAY NOT COME ON OR MAY TERMINATE IN LESS THAN FOUR SECONDS AS REQUIRED BY THE STANDARD.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: DEALERS WILL INSTALL A NEW ALARM MODULE. OWNER NOTIFICATION BEGAN JUNE 27, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
99V009000 · Child Seat
Jan 20, 1999
VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH INTEGRATED DUAL CHILD SEATS. SOME OF THESE VEHICLES MAY BE MISSING A SEAT BELT RETRACTOR CLUTCH SPRING AND/OR PAWL SPRING IN THE CHILD SEAT. IF THE CLUTCH SPRING WAS MISSING, THE SEAT BELT WOULD LOCK IN THE RETRACTED POSITION AND COULD NOT BE USED. IF THE PAWL SPRING WAS MISSING, THE SEAT BELT RESTRAINT WOULD CONTINUALLY PLAY OUT AND WOULD NOT LOCK.
Consequence & remedy
Consequence: THESE CONDITIONS COULD INCREASE THE OCCUPANT'S RISK OF INJURY IN THE EVENT OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT THE SEAT BELTS ON THE CHILD SEATS, AND IF NECESSARY, REPLACE THE CHILD SEAT.
97V057000 · Seat Belts:rear/other
Apr 8, 1997
THE OUTBOARD SAFETY BELT WEBBING ON THE RIGHT-HAND REAR BUCKET SEAT CAN SEPARATE DURING A VEHICLE CRASH.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE VEHICLE OCCUPANT WOULD NOT BE PROPERLY RESTRAINED AND PERSONAL INJURY COULD RESULT.
Remedy: DEALERS WILL INSTALL A PROTECTOR ON THE REAR SEAT CUSHION FRAME.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA02006 · Windshield Wiper Failure
Opened May 31, 2002 · Closed Jul 23, 2003
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Additional source detail variants (2)
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.