IllustrationSITTING IN THE FRONT PASSANGER'S SEAT AND THE SEAT COLLAPSED AND FELL BACKWARDS. TOOK VEHICLE TO THE DEALER AND HAD SEAT REPLACED. VEHICLE WAS NOT UNDER THE RECALL #93V187000. *AK
1991 Chevrolet Astro
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1991 Chevrolet Astro do not stand out strongly from the model-year median of 69.
About this comparison →How this year compares
Owner complaints by model year
Compare all Astro years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 1 of 95 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 42 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 8 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
12 crash reports4 fire reports6 injury reports
Seats complaints
3 reportsWHEN VEHICLE WAS INVOLVED IN ACCIDENT BOTH DRIVER AND PASSENGER SEAT BROKE. TT LOSS CONTROL OF VEHICLE ON WET ROAD DURING HEAVY RAIN FALL, VEHICLE TURNED OVER ON SHOULDER OFF ROAD ONTO PASSENGER SIDE, SEAT BELTREMIANED FASTENED, BUT BACK PORTION AT MANUAL CRANCK DEVICE ON BOTH SEATS BROKE AWAY, THIS ALLOWED DRIVER TO SLIDE OUT F…
Read full complaint
WHEN VEHICLE WAS INVOLVED IN ACCIDENT BOTH DRIVER AND PASSENGER SEAT BROKE. TT LOSS CONTROL OF VEHICLE ON WET ROAD DURING HEAVY RAIN FALL, VEHICLE TURNED OVER ON SHOULDER OFF ROAD ONTO PASSENGER SIDE, SEAT BELTREMIANED FASTENED, BUT BACK PORTION AT MANUAL CRANCK DEVICE ON BOTH SEATS BROKE AWAY, THIS ALLOWED DRIVER TO SLIDE OUT FROM UNDER SEAT BELT AND SHOULDER BELT, TO BE TOSSED TO REAR OF VAN, LANDING BEHIND BACK SEAT, DRIVER SUFFERED MULTIPLE BRUISES AND SCRRAPES TO FACE,LIMBS AND BODY , SOME OF THESE INJURIS HAVE LEFT PERMANENT CIRCULATION PROBLEMS IN ANKLE.*JB
DRIVER AND PASSENGER SIDE COLLAPSED UPON BEING REAR ENDED. TT
Official recalls
393V187000 · Seats
Nov 16, 1993
THE RECLINER MECHANISM AND THE SEAT FRAME MAY HAVE FOAM AND/OR VINYL BETWEEN THEM, CREATING A "SOFT" JOINT. THIS "SOFT" JOINT RESULTS IN LOWER THAN SPECIFIED BOLT TORQUE WHICH LEADS TO JOINT LOOSENESS, CAUSING BOLT FATIGUE AND EVENTUAL BOLT FAILURE.
Consequence & remedy
Consequence: IF BOLT FAILURE OCCURS TO THE DRIVER'S SEAT, IT WOULDALLOW THE SEAT BACK TO SUDDENLY RECLINE, AND COULD RESULT IN LOSS OF VEHICLECONTROL AND A VEHICLE CRASH WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REMOVE THE FOAM AND/OR VINYL FROM BETWEEN THE RECLINER MECHANISM AND THE SEAT FRAME "SOFT" JOINT AND REPLACE THE RECLINER BOLTS.
91V164000 · Seat Belts:front:anchorage
Sep 20, 1991
SEAT BELT ANCHORAGE BAR FOR REAR SOFA FAILED TO SUSTAIN LOADS REQUIRED BY FMVSS 210.
Consequence & remedy
Consequence: VEHICLES WOULD NOT COMPLY WITH FMVSS 210.
Remedy: REPLACE NONCOMPLYING SOFA BAR WITH BAR THAT MEETS REQUIREMENTS.
91V102000 · Seat Belts:front:anchorage
Jun 14, 1991
THE SEAT BELTS FOR THE FRONT AND MID-SHIP SEATS DID NOT REST ON PELVIS AS REQUIRED BY FMVSS 209.
Consequence & remedy
Consequence: SEAT BELTS MAY NOT RESTRAIN SEAT OCCUPANT, AND COULDINJURE THE SEAT OCCUPANT IN THE EVENT OF A SUDDEN STOP OR ACCIDENT.
Remedy: RELOCATE SEAT BELT ANCHOR BOLTS TO ADJUST BELTS FOR SEAT LOCATIONS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5PE97025 · Instrument Panel/dash Electrical Fire
Opened Jun 12, 1997 · Closed Nov 26, 1997
Status: closed (inferred from source dates) · Electrical System
ALLEGED ELECTRICAL FIRES MAY OCCUR IN THE DASH AREA WHILE THE SUBJECT VEHICLES ARE BEING OPERATED OR WHILE PARKED.
EA92022 · Seat Back Bolt Breakage
Opened Jun 24, 1992 · Closed Nov 19, 1993
Status: closed (inferred from source dates) · Seats
There is no summary currently available
DP92012 · Apv Fires
Opened Jun 9, 1992 · Closed Jun 25, 1992
Status: closed (inferred from source dates) · Engine And Engine Cooling:engine:gasoline
APV FIRES
EA91028 · Brake Failure
Opened Jun 10, 1991 · Closed Jun 30, 1992
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
===
PE91052 · Brake Failure
Opened Feb 22, 1991 · Closed Jun 10, 1991
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available